Get Free 2004 TOYOTA RAV4 L4, 2.4L; DOHC; 16V TSBs

Released 10/27/2017
Replacement Certification Labels and VIN Plates

Released 12/20/2013
BO030-01: Windshield Wiper Blade Maintenance and Cleaning (Obsolete)

Released 12/19/2013
T-SB-0185-13: All '85-'14 Toyota Models: Wiper Blade Maintenance and Cleaning

Released 9/12/2013
T-SB-0142-13: '04-'14 Applicable Toyota Models: HVAC Odor Maintenance

Released 1/29/2013
T-SB-0012-13: '01-'14 Applicable Toyota Models: Techstream ECU Flash Reprogramming Procedure

Released 11/21/2012
T-SB-0229-12: '00-'13 Toyota Models: Flood Damaged Vehicle Inspection & Handling

Released 6/13/2012
T-SB-0087-12: '01-'13 Applicable Toyota Models: Accelerator Pedal Sensor Assembly Service Precaution

Released 9/6/2011
T-SB-0122-11: '98-'12 Applicable Toyota Models: Seat Cover Replacement For Side Airbag Equipped Vehicles

Released 8/17/2011
T-SB-0101-11: All '83-'12 Toyota Models: Interior Electrical Component Precautions

Released 3/4/2009
T-SB-0079-09: '98-'10 Applicable Toyota Models: Long Term Vehicle Storage Guidelines

Released 10/2/2008
Seat Belt Tongue Plate Stopper Replacement

Released 9/8/2008
T-SB-0288-08 Rev1: '04-'10 Applicable Toyota Models: Front Seat Squeak Noise

Released 7/31/2008
Replacement Certification Labels

Released 7/29/2008
Upper/Lower Windshield Tick Noise

Released 7/21/2008
T-SB-0138-08: 91-09 Applicable Vehicles: Permanent-Type Protective Wax Coatings

Released 11/20/2007
PG007-07: All Toyota Models: Replacement VIN Plates

Released 11/20/2007
REPLACEMENT CERTIFICATION LABELS

Released 4/6/2007
2AZ-FE ENGINE BLOCK

Released 9/18/2006
UPPER/LOWER WINDSHIELD TICK NOISE

Released 5/23/2006
FRONT SEAT SQUEAK NOISE

Released 12/9/2004
BO022-04: Seat Belt Extender: 03-05 All Toyota Models & 04-05 All Scion Models (Revised)

Released 11/16/2004
PA005-04: Iron Particle Rust Contamination Repair: 94 - Current Toyota & 04 - Current Scion (Revised)

Released 10/20/2004
LIO Transmitters

Released 9/8/2004
ACCESSORY DRIVE BELT SQUEAL/BELT TENSIONER RATTLE

Released 4/9/2004
ROOF RACK CROSS BAR INSTALLATION DURING PDS

Released 4/2/2004
PA002-04: 04 All Models: Exterior Color and Scratch Resistant and Anti-Acid Paint

Released 2/26/2004
2004 PAINT COLORS

Released 1/14/2004
COWL NOISE

Released 12/9/2003
SEAT BELT EXTENDER

Released 9/26/2003
PG006-03: Warranty Parts Marking Procedure: All Models

Released 9/9/2003
BO017-03: 91-07 All Models: Trim Garnish Loose (Revised)

Released 7/28/2003
BODY TRIM AND CLADDING COLORS

Released 7/21/2003
PA006-03: 2004 Paint Colors - All 04 Models

Released 6/4/2002
PA003-02: Refinishing Replacement Bumper Covers: All 83-05 Models (Revised)

Released 5/31/2002
PA002-02: Paint Stains Under Rapgard: All 02-06 Toyota & All 04-06 Scion Models (Revised)

Released 12/1/2000
PG026-00: 2001 RAV4 Front License Plate Installation

Released 3/25/2008
Disconnect Battery & Perform Zero Point Calibration After Wheel Alignment Adjustment

Released 2/7/2006
TIRE PRESSURE WARNING SYSTEM LIGHT ON

Released 7/16/2004
PD017-04: All Models: Wheel Film for Brake Rotor Rust Prevention

Released 2/4/2004
BR001-04: Zero Point Calibration: 04-05 Models with VSC (Revised)

Released 1/6/2017
Interior Electrical Component Precautions

Released 9/29/2015
Safety Recall F0L - Phase 2: 2004-2005 RAV4; Front Driver Airbag Inflator Module (Technical Instructions)

Released 5/13/2015
Safety Recall F0L - Phase 2: 2004-2005 RAV4; Front Driver Airbag Inflator Module (Dealer Letter)

Released 5/13/2015
Safety Recall R06 (X06) (Canadian Equivalent to F0L): 2004-2005 RAV4; Driver Front Airbag Inflator Module - Canadian Market Vehicles (Dealer Letter)

Released 11/21/2012
T-SB-0229-12: '00-'13 Toyota Models: Flood Damaged Vehicle Inspection & Handling

Released 8/17/2011
T-SB-0101-11: All '83-'12 Toyota Models: Interior Electrical Component Precautions

Released 3/4/2009
T-SB-0079-09: '98-'10 Applicable Toyota Models: Long Term Vehicle Storage Guidelines

Released 7/29/2008
Upper/Lower Windshield Tick Noise

Released 3/25/2008
Disconnect Battery & Perform Zero Point Calibration After Wheel Alignment Adjustment

Released 11/9/2007
EL010-07: 90-08 Applicable Models: Wireless Transmitter & Programming Guide (Revised)

Released 11/9/2007
EL009-07: 00-08 Applicable Models: Programming OEM Wireless Door Lock Remote Transmitters

Released 8/6/2007
SS004-07: 98-08 Toyota (SRS-Equipped): SRS Component Disposal as Hazardous Material Treatment

Released 4/26/2007
SS002-07: 01-08 Applicable Toyota: Techstream ECU Flash Reprogramming Procedure

Released 2/6/2007
EL003-07: 04-07 Applicable Toyota & Scion: Repair Manual Supplement: Supplemental Restraint

Released 12/8/2006
BLUETOOTH COMPATIBLE CELLULAR PHONES

Released 2/7/2006
TIRE PRESSURE WARNING SYSTEM LIGHT ON

Released 1/26/2006
PG001-06: Battery Maintenance for In-Stock Vehicles & Pre-Delivery: All Models & Model Years - OBSOLETE

Released 11/10/2005
BO014-05: 98-06 All Models: Seat Cover Replacement for Side Airbag Equipped Vehicles

Released 8/2/2005
PARASITIC DRAW FROM JBL AMPLIFIER

Released 3/31/2005
DIFFICULTY REMOVING IGNITION KEY

Released 2/18/2005
PG001-05: All Models: Repair Manual Corrections Index

Released 10/20/2004
LIO Transmitters

Released 9/8/2004
ACCESSORY DRIVE BELT SQUEAL/BELT TENSIONER RATTLE

Released 9/1/2004
PD005-03: Check Sheet: 2004 MY Pre-Delivery Service (PDS) - All 04 Except Prius (Revised)

Released 8/25/2004
M.I.L. "ON" DTC P0031 AND/OR P2238

Released 5/18/2004
PG003-04: All Models: Repair Manual Corrections Index

Released 8/4/2003
PD005-03: 2004 Model Year Pre-Delivery Service (PDS) - All 04 Models Except Prius (Revised)

Released 8/30/2002
SS003-01: 2000 & Later Applicable Models: Immobilizer Key Code Reset (Revised)

Released 7/19/2002
PROGRAMMING OEM WIRELESS DOOR LOCK REMOTE TRANSMITTERS

Released 5/25/2001
SS004-01: ECU Flash Reprogramming Error Message - Applicable 01 & Later Models (Revised)

Released 3/9/2001
SS002-01: 2001 & Later Applicable Models: ECU Flash Reprogramming Process (Revised)

Released 8/18/2000
PG013-00: 2001 RAV4: Cut Fuse Installation during PDS

Released 1/29/2013
T-SB-0012-13: '01-'14 Applicable Toyota Models: Techstream ECU Flash Reprogramming Procedure

Released 11/21/2012
T-SB-0229-12: '00-'13 Toyota Models: Flood Damaged Vehicle Inspection & Handling

Released 2/4/2010
T-SB-0064-10: 01-11 Applicable Toyota Models: Techstream ECU Flash Reprogramming Procedure

Released 12/23/2009
T-SB-0398-09: 93-10 Applicable Toyota Models: Engine Bank 1 and Bank 2 A/F and O2 Identification

Released 7/31/2008
Replacement Certification Labels

Released 6/28/2007
EG034-07: 93-08 Applicable Toyota Models: Engine Bank 1 and Bank 2 A/F and O2 Identification (Obsolete)

Released 4/26/2007
SS002-07: 01-08 Applicable Toyota: Techstream ECU Flash Reprogramming Procedure (Obsolete)

Released 10/14/2004
EG045-04: All 04-06 Models: Entering VIN During ECM (PCM) Replacement and/or DTC P0630 (Revised)

Released 8/25/2004
M.I.L. "ON" DTC P0031 AND/OR P2238

Released 9/26/2003
PG006-03: Warranty Parts Marking Procedure: All Models

Released 6/10/2003
TC002-03: ECM Reset Memory Function: All 00-05 Toyota & 04-05 Scion (Revised)

Released 12/17/2003
SS002-03: O2S Test Results (Mode 05): All 96-03 & 04 Corolla, Matrix, Scion xA & xB

Released 11/9/2007
EL010-07: 90-08 Applicable Models: Wireless Transmitter & Programming Guide (Revised)

Released 10/13/2005
PG011-05: 90-06 Toyota & Scion models w/ Port Electronic Fuel Injection: Fuel Injector Cleaning (Revised)

Released 3/31/2005
DIFFICULTY REMOVING IGNITION KEY

Released 8/25/2004
M.I.L. "ON" DTC P0031 AND/OR P2238

Released 9/26/2003
PG006-03: Warranty Parts Marking Procedure: All Models

Released 8/30/2002
SS003-01: 00-Later Applicable 4Runner, Camry, Highlander, Land Cruiser, MR2 Spyder, RAV4, Sequoia, & Solara: Immobilizer Key Code Reset (Obsolete)

Released 12/16/2004
AC009-04: Sensor Inspection for Air Conditioning System: 1989 - Current All Models

Released 7/16/2004
PD017-04: All Models: Wheel Film for Brake Rotor Rust Prevention

Released 3/1/2004
A/C COMPRESSOR INSTALLATION PROCEDURE

Released 9/30/2014
T-SB-0134-14: '90-'15 Applicable Toyota Models: Automatic/Continuously Variable Transmission Replacement Precautions

Released 7/24/2013
CSP ELT: Economic Loss Class Action Settlement (Dealer Letter)

Released 1/29/2013
T-SB-0012-13: '01-'14 Applicable Toyota Models: Techstream ECU Flash Reprogramming Procedure

Released 11/21/2012
T-SB-0229-12: '00-'13 Toyota Models: Flood Damaged Vehicle Inspection & Handling

Released 10/6/2011
T-SB-0153-11: '02-'06 Camry, Solara, '04-'05 RAV4: 2AZ-FE Engine Block

Released 7/13/2011
T-SB-0071-11: Automatic Transmission Replacement Precautions

Released 3/2/2011
T-SB-0015-11: 02-06 Camry & Solara, 01-07 Highlander, 04-05 RAV4: Cylinder Head Bolt Threads Damaged (2AZ-FE)

Released 2/17/2011
T-SB-0014-11: All ATM Equipped Toyota Models: Torque Converter Bolt Installation

Released 2/4/2010
T-SB-0064-10: 01-11 Applicable Toyota Models: Techstream ECU Flash Reprogramming Procedure

Released 9/19/2008
T-SB-0301-08: 00-09 Applicable Models: Engine Serial Number Location

Released 5/8/2008
Alignment Pin Installation during Transmission/Transaxle Assembly Installation

Released 4/16/2008
Cylinder Head Cover Baffle Precautions

Released 7/31/2007
TC012-07: 91-08 Toyota (w/ATM): Automatic Transmission Shipping Bag for Warranty Recovery

Released 6/28/2007
TC010-07: 04-08 Toyota: World Standard Automatic Transmission Fluid

Released 6/28/2007
ENGINE BANK 1 AND BANK 2 A/F AND O2 IDENTIFICATION

Released 4/6/2007
EG015-07: 02-07 Camry, Solara, & 04-07 RAV4: 2AZ-FE Engine Block (Obsolete)

Released 4/6/2007
2AZ-FE ENGINE BLOCK

Released 3/6/2007
TC003-07: 90-07 Toyota: Driveshaft Assembly Replacement

Released 3/6/2007
TC004-07: 04-07 Scion: Driveshaft Assembly Replacement

Released 8/1/2005
TC008-05: U140F Transmission Solenoid Identification: 01-05 Highlander & RAV4

Released 3/31/2005
DIFFICULTY REMOVING IGNITION KEY

Released 3/28/2005
EG014-05: All Toyota & Scion Models: Radiator Cap Inspection

Released 10/14/2004
EG045-04: All 04-06 Models: Entering VIN During ECM (PCM) Replacement and/or DTC P0630 (Revised)

Released 9/8/2004
ACCESSORY DRIVE BELT SQUEAL/BELT TENSIONER RATTLE

Released 8/25/2004
M.I.L. "ON" DTC P0031 AND/OR P2238

Released 5/7/2004
EXCESSIVE SULFUR DIOXIDE ODORN

Released 9/26/2003
PG006-03: Warranty Parts Marking Procedure: All Models

Released 6/10/2003
TC002-03: ECM Reset Memory Function: All 00-05 Toyota & 04-05 Scion (Revised)

Released 5/13/2015
Safety Recall R06 (X06) (Canadian Equivalent to F0L): 2004-2005 RAV4; Driver Front Airbag Inflator Module - Canadian Market Vehicles (Dealer Letter)

Released 10/4/2012
T-SB-0187-12: 2004-2012 Applicable Models: Tire Repair Resources

Released 12/24/2008
T-SB-0391-08: 02-09 Toyota Models: Repair Manual Supplement: Vehicle Pulling to One Side

Released 3/25/2008
Disconnect Battery & Perform Zero Point Calibration After Wheel Alignment Adjustment

Released 2/7/2006
TIRE PRESSURE WARNING SYSTEM LIGHT ON

Released 10/7/2004
PG005-04:04-05 Highlander,RAV4, Sienna & Solara w/VSC, 05 Scion tC w/ABS: Tire Pressure Warning System Information & Re-Initialization (Revised)

Released 9/9/2004
ST005-04: VSC Steering Angle Sensor Initialization During PDS or After Repair: RAV4, Scion xA & xB, Tacoma & Tundra

Released 7/16/2004
PD017-04: All Models: Wheel Film for Brake Rotor Rust Prevention

Released 2/4/2004
BR001-04: Zero Point Calibration: 04-05 Models with VSC (Revised)

Released 9/26/2003
PG006-03: Warranty Parts Marking Procedure: All Models

Released 9/8/2003
INITIALIZATION OF TIRE PRESSURE WARNING SYSTEM DURING PDS

Released 4/26/2007
SS002-07: 01-08 Applicable Toyota: Techstream ECU Flash Reprogramming Procedure

Released 11/28/2005
SS003-05: All 01-06 Toyota & 04-06 Scion: CD Skip Verification Using Toyota Master CD

Released 3/11/2005
SS001-05: 04-05 Applicable Models: Failure to Initialize CAN Interface Module (Revised)

Released 11/16/2004
PA005-04: Iron Particle Rust Contamination Repair: 94 - Current Toyota & 04 - Current Scion (Revised)

Released 4/2/2004
PA002-04: 04 All Models: Exterior Color and Scratch Resistant and Anti-Acid Paint

Released 12/17/2003
SS002-03: O2S Test Results (Mode 05): All 96-03 & 04 Corolla, Matrix, Scion xA & xB

Released 9/8/2003
SS001-03: Diagnostic Tester Controller Area Network (CAN) Interface Module: All Models

Released 7/21/2003
PA006-03: 2004 Paint Colors - All 04 Models

Released 12/11/2002
SS003-02: 2001 & Later Applicable Models: Diagnostic Tester Immobilizer Functions (Revised)

Released 8/30/2002
SS003-01: 2000 & Later Applicable Models: Immobilizer Key Code Reset (Revised)

Released 5/31/2002
PA002-02: Paint Stains Under Rapgard: All 02-06 Toyota & All 04-06 Scion Models (Revised)

Released 5/25/2001
SS004-01: ECU Flash Reprogramming Error Message - Applicable 01 & Later Models (Revised)

Released 3/9/2001
SS002-01: 2001 & Later Applicable Models: ECU Flash Reprogramming Process (Revised)

Released 1/14/2004
COWL NOISE

Released 12/7/2001
BO030-01: Windshield Wiper Blade Maintenance and Cleaning (Revised)