A free CarMD service

Get Free 1999 SUZUKI VITARA L4, 1.6L TSBs

Technical Service Bulletins

Released 3/3/2009
Monthly Technical Service Information Fee

Released 1/1/2008
WATER PUMP LEAK

Get all TSBs for 5 vehicles for only $25

TSB Description
Released 1/1/2004 SERVICE MANUAL UPDATE FOR RESEALING FRONT TIMING CHAIN COVER.
Released 1/1/2003 REAR MAIN OIL SEAL INSTALLATION TOOLS
Released 1/1/2003 CORRECT AMOUNT OF ENGINE OIL NEEDED TO RAISE OIL LEVEL FROM LOW MARK TO FULL MARK ON OIL LEVEL DIPSTICK
Released 1/1/1999 CORRECT COOLANT USAGE

Released 9/30/2010
TS 03 07210 Technician/Vehicle Owner “Best Practices”: Inspecting, Removing, and installing floor mats in Suzuki vehicles.

Released 12/19/2008
Special Coverage Adjustment "PQ": Corrosion Inspection of Front Suspension Frame

Get all TSBs for 5 vehicles for only $25

TSB Description
Released 1/1/2008 TECH 2 PCMCIA CARD RE FLASH UPDATE
Released 1/1/2008 SLOW AND/OR INCOMPLETE RETRACTION OF SEAT BELTS
Released 1/1/2008 ERROR CODE 7156 WHEN ATTEMPTING TO PROGRAM OR REPROGRAM WITH PASS-THRU REPROGRAMMING SOFTWARE VERSION 1.9.0.2
Released 1/1/2008 REPLACEMENT BOLTS ARE NOT THE SAME COLOR AS THE ORIGINAL BOLTS
Released 1/1/2007 ELECTRONIC CONTROL UNIT (ECU) REPROGRAMMING VERIFICATION PROCEDURE USING THE SUZUKI SDS TOOL
Released 1/1/2002 FRONT DOOR WINDOW GLASS TIPS FORWARD WHEN CLOSING
Released 1/1/2001 SERVICE MANUAL UPDATE CORRECTION - DTC, B1026 FLOW TABLE
Released 1/1/2001 TECHNICAL SERVICE BULLETIN SYSTEM REVISION
Released 1/1/1999 SPECIAL SERVICE CAMPAIGN: SE, HARNESS PINCHED BY REAR SPEAKER RETAINING PLATE AND FRONT SEAT BELT LOWER ANCHOR BOLTTORQUE CHECK.
Released 1/1/1998 DEAD BATTERIES IN KEYLESS ENTRY REMOTE “FOBS”
Released 1/1/1995 AIR BAG ON/OFF SWITCH INSTALLATION INSTRUCTIONS

Released 1/1/2008
BRAKE NOISE CHARACTERISTICS DURING NORMAL OPERATION

Released 1/1/2001
TECHNICAL SERVICE BULLETIN SYSTEM REVISION

Get all TSBs for 5 vehicles for only $25

TSB Description
Released 1/1/1999 SPECIAL SERVICE CAMPAIGN: V7, SERVICE STOP LAMP SWITCH FAILURE

Released 1/1/2008
WATER PUMP LEAK

Released 1/1/1999
CORRECT COOLANT USAGE

Get all TSBs for 5 vehicles for only $25

TSB Description

Released 9/30/2010
SERVICE MANUAL UPDATE CORRECTION - DTC, B1026 FLOW TABLE

Released 9/30/2010
IGNITION KEY BINDS IN ACCESSORY POSITION

Get all TSBs for 5 vehicles for only $25

TSB Description
Released 9/30/2010 SPECIAL SERVICE CAMPAIGN: SE, HARNESS PINCHED BY REAR SPEAKER RETAINING PLATE AND FRONT SEAT BELT LOWER ANCHOR
Released 1/1/2008 TECH 2 PCMCIA CARD RE FLASH UPDATE
Released 1/1/2008 SLOW AND/OR INCOMPLETE RETRACTION OF SEAT BELTS
Released 1/1/2008 ERROR CODE 7156 WHEN ATTEMPTING TO PROGRAM OR REPROGRAM WITH PASS-THRU REPROGRAMMING SOFTWARE VERSION 1.9.0.2
Released 1/1/2008 PASS-THRU REPROGRAMMING SOFTWARE VERSION 1.8.3.0
Released 1/1/2007 ELECTRONIC CONTROL UNIT (ECU) REPROGRAMMING VERIFICATION PROCEDURE USING THE SUZUKI SDS TOOL
Released 1/1/2001 SERVICE MANUAL UPDATE CORRECTION - DTC, B1026 FLOW TABLE
Released 1/1/2001 TECHNICAL SERVICE BULLETIN SYSTEM REVISION
Released 1/1/1999 SPECIAL SERVICE CAMPAIGN: V7, SERVICE STOP LAMP SWITCH FAILURE
Released 1/1/1999 POSSIBLE NO-START CONDITION IN 5O F. OR COLDER TEMPERATURES
Released 1/1/1999 SPECIAL SERVICE CAMPAIGN: SE, HARNESS PINCHED BY REAR SPEAKER RETAINING PLATE AND FRONT SEAT BELT LOWER ANCHOR BOLTTORQUE CHECK.
Released 1/1/1998 DEAD BATTERIES IN KEYLESS ENTRY REMOTE “FOBS”
Released 1/1/1995 AIR BAG ON/OFF SWITCH INSTALLATION INSTRUCTIONS

Released 9/30/2010
SERVICE MANUAL UPDATE

Released 1/1/2003
SERVICE MANUAL UPDATE

Get all TSBs for 5 vehicles for only $25

TSB Description

Released 9/30/2010
IGNITION KEY BINDS IN ACCESSORY POSITION

Released 9/30/2010
SAFETY RECALL CAMPAIGN: ER, FUEL PRESSURE REGULATOR REPLACEMENT AND VACUUM LINE REROUTING

Get all TSBs for 5 vehicles for only $25

TSB Description
Released 1/1/2005 SERVICE MANUAL UPDATE FOR DTC P0420 AND/OR (P0430 V6) INSPECTION AND TROUBLESHOOTING
Released 1/1/2004 ER, FUEL PRESSURE REGULATOR REPLACEMENT AND VACUUM LINE REROUTING
Released 1/1/2003 SERVICE MANUAL UPDATE
Released 1/1/2001 IGNITION KEY BINDS IN ACCESSORY POSITION

Released 9/30/2010
HVAC VENT REGISTERS LOOSE IN HOUSING

Released 1/1/1999
HVAC VENT REGISTERS LOOSE IN HOUSING

Get all TSBs for 5 vehicles for only $25

TSB Description

Released 4/1/2011
TS 01 12200 Torque converter bolt tightening specs

Released 9/30/2010
CORRECT AMOUNT OF ENGINE OIL NEEDED TO RAISE OIL LEVEL FROM LOW MARK TO FULL MARK ON OIL LEVEL DIPSTICK

Get all TSBs for 5 vehicles for only $25

TSB Description
Released 9/30/2010 SERVICE MANUAL UPDATE ON SELECTION METHOD OF THE STANDARD SIZE CONNECTING ROD BEARING
Released 9/30/2010 SERVICE MANUAL UPDATE FOR RESEALING FRONT TIMING CHAIN COVER.
Released 9/30/2010 Oil leakage from the Front Differential Right Side Seal
Released 9/30/2010 FRONT DIFFERENTIAL OIL SEAL REPLACEMENT
Released 9/30/2010 SERVICING AND REPLACEMENT OF AUTOMATIC TRANSMISSION FLUID PIPE UNION BOLT AND GASKET.
Released 9/30/2010 MODIFICATION OF MAIN BEARING OIL CLEARANCE AND THE BEARING SELECTION PROCEDURE
Released 7/1/2008 Oil Leak Identification
Released 1/1/2008 WATER PUMP LEAK
Released 1/1/2008 SERVICE MANUAL UPDATE ON SELECTION METHOD OF THE STANDARD SIZE CONNECTING ROD BEARING STANDARD SIZE CONNECTING ROD BEARING
Released 1/1/2008 PASS-THRU REPROGRAMMING SOFTWARE VERSION 1.8.3.0
Released 1/1/2006 SERVICING AND REPLACEMENT OF AUTOMATIC TRANSMISSION FLUID PIPE UNION BOLT AND GASKET
Released 1/1/2005 SERVICE MANUAL UPDATE FOR DTC P0420 AND/OR (P0430 V6) INSPECTION AND TROUBLESHOOTING
Released 1/1/2005 FRONT DIFFERENTIAL OIL SEAL REPLACEMENT
Released 1/1/2005 MODIFICATION OF MAIN BEARING OIL CLEARANCE AND THE BEARING SELECTION PROCEDURE
Released 1/1/2004 ER, FUEL PRESSURE REGULATOR REPLACEMENT AND VACUUM LINE REROUTING
Released 1/1/2004 SERVICE MANUAL UPDATE FOR RESEALING FRONT TIMING CHAIN COVER.
Released 11/1/2003 BEVEL PINION MOUNTING DISTANCE
Released 1/1/2003 REAR MAIN OIL SEAL INSTALLATION TOOLS
Released 1/1/2003 ENGINE TICK NOISE
Released 1/1/2003 SERVICE MANUAL UPDATE
Released 1/1/2003 CORRECT AMOUNT OF ENGINE OIL NEEDED TO RAISE OIL LEVEL FROM LOW MARK TO FULL MARK ON OIL LEVEL DIPSTICK
Released 1/1/2001 Oil leakage from the Front Differential Right Side Seal
Released 1/1/2001 TECHNICAL SERVICE BULLETIN SYSTEM REVISION
Released 1/1/1999 CORRECT COOLANT USAGE
Released 1/1/1999 POSSIBLE NO-START CONDITION IN 5O F. OR COLDER TEMPERATURES