Get Free 2007 MERCURY MOUNTAINEER V6, 4.0L; SOHC TSBs

Released 4/23/2018
2001-2015 - Vehicles With Modular 4.6L, 5.4L Or 6.8L Engines - Determining Root Cause Of Engine Damage Due To Oil Pressure Loss.

Released 4/23/2018
Dealer Installed Audio Upgrades

Released 4/23/2018
Various Vehicles - 4.6L/5.4L/6.8L 3 Valve - Engine Noise Upper End And/Or Rough Running - Camshaft Roller Follower Replacement - Built On Or Before 8-Jan-2016

Released 4/23/2018
2003-2008 ELECTRONIC THROTTLE BODIES (ETB)EQUIPPED VEHICLES - HESITATION/LOSS OF RPM/DIFFICULTY STARTING/LOW IDLE RPM WITH OR WITHOUT MIL P0505 AND/OR P0506.

Released 4/23/2018
2005-2009 MULTIPLE VEHICLES - KEY HARD TO TURN IN THE IGNITION LOCK CYLINDER

Released 4/23/2018
HIGH PITCHED WHINE NOISE COMING FROM A GROUNDED OUT SHIFT CABLE ON THE 5R55S TRANSMISSION SPEED SENSOR(TSS) OR INPUT SHAFT SPEED SENSOR(ISS)

Released 9/25/2017
Various Vehicles - Module Programming and Reprogramming Procedures

Released 8/22/2017
2000 And Newer Ford, Lincoln And Mercury Vehicles - Aluminum Panel Corrosion

Released 4/27/2016
Multiple Vehicles - No PCM/Network Communication

Released 1/27/2016
2004 And Newer Vehicles Equipped With Flex Fuel Capability - Flex Fuel General Service Bulletin (GSB)

Released 12/15/2015
Multiple Vehicles - Transmission Cooler Flush General Service Bulletin (GSB)

Released 12/9/2015
Multiple Vehicles - Tire Pressure Monitor System (TPMS) General Service Bulletin (GSB)

Released 12/8/2015
Multiple Vehicles - Engine Failure Analysis General Service Bulletin (GSB)

Released 11/24/2015
2006-2010 Explorer/Mountaineer/Explorer Sport Trac - Service Part Warranty (SPW) Radiator Identification General Service Bulletin (GSB)

Released 10/14/2015
Multple Vehicles - Wiring Repair General Service Bulletin (GSB)

Released 8/31/2015
2006-2010 Explorer/Mountaineer/Explorer Sport Trac- Front Wheel Speed Sensor (WSS) Wire Harness Routing General Service Bulletin (GSB)

Released 5/3/2012
DRIVER OR PASSENGER POWER SEAT BINDING - GRINDING OR CLICKING NOISE DURING POWER SEAT OPERATION

Released 2/3/2010
ODOMETER DISPLAY READING MOMENTARILY FLIPS FROM BOTTOM TO TOP OF MESSAGE CENTER SCREEN

Released 10/20/2009
TRIP A/TRIP B ODOMETER AND/OR AVERAGE FUEL ECONOMY RESETS UNINTENTIONALLY

Released 1/26/2009
SUN VISOR MIRROR COVER CRACKING - BUILT BETWEEN 1/2/2007 AND 11/3/2008

Released 10/7/2008
REAR WINDOW DEFROSTER INOPERATIVE—GRID BUTTON TERMINAL REPAIR

Released 4/24/2008
4.0L/4.6L—HARD START/ROUGH RUNNING—AFTER LONG HOT SOAK / DIP IN RPM WHEN COMING TO A STOP—BUILT ON OR BEFORE 4/2/2008

Released 2/7/2008
COLD START FEAD HOOT—WHISTLE NOISE / BUILT BEFORE 1/28/2008

Released 1/7/2008
4.0L—PCM BRACKET BUZZ/HUM NOISE FROM CENTER/RIGHT SIDE DASH AREA

Released 12/6/2007
LOOSE OUTSIDE SEAT CUSHION SHIELD— VEHICLES BUILT BEFORE 7/1/2007

Released 9/24/2007
WATER LEAK IN HEADLINER/DOME LAMP AREA— TSB 07-20-6 VEHICLES EQUIPPED WITH ROOF OPENING PANEL AND SAFETY CANOPY AIR BAG SYSTEMS—BUILT BEFORE 3/27/2007

Released 6/6/2007
RCM FAULT REPORTING USING DTCS AND BIT-MAPPED PARAMETER IDENTIFIERS (PIDS)— SERVICE TIPS

Released 3/27/2007
FRONT SEAT MANUAL LUMBAR INOPERATIVE

Released 2/13/2007
LEATHER-WRAPPED STEERING WHEEL—LEATHER COMING LOOSE

Released 12/21/2006
WATER NOISE—WATER ACCUMULATION INSIDE DOORS

Released 12/17/2006
CALIBRATION UPDATE 4.0L—VARIOUS SYMPTOMS—SURGE, HESITATION, TORQUE CONVERTER CYCLING, NO UP SHIFT AFTER A CONVERTER CYCLING, NO UP SHIFT AFTER A/C PERFORMANCE

Released 3/25/2006
PIONEER NAVIGATION RADIO—SEEK FUNCTION INOPERATIVE—SERVICE TIP

Released 1/18/2008
IMPROVED BRAKE PEDAL FEEL AND FIRMNESS

Released 1/7/2008
4.0L—PCM BRACKET BUZZ/HUM NOISE FROM CENTER/RIGHT SIDE DASH AREA

Released 11/21/2007
REAR BRAKE RATTLE OVER BUMPS

Released 8/16/2007
PARKING BRAKE RELEASE HANDLE BREAKS— VEHICLES BUILT BEFORE 12/1/2006

Released 12/21/2006
HEATER CORE LEAKAGE AND ELECTROLYSIS (INFORMATION ONLY)

Released 4/23/2018
2003-2008 ELECTRONIC THROTTLE BODIES (ETB)EQUIPPED VEHICLES - HESITATION/LOSS OF RPM/DIFFICULTY STARTING/LOW IDLE RPM WITH OR WITHOUT MIL P0505 AND/OR P0506.

Released 4/23/2018
2005-2009 MULTIPLE VEHICLES - KEY HARD TO TURN IN THE IGNITION LOCK CYLINDER

Released 4/27/2016
Multiple Vehicles - No PCM/Network Communication

Released 10/14/2015
Multple Vehicles - Wiring Repair General Service Bulletin (GSB)

Released 10/20/2009
TRIP A/TRIP B ODOMETER AND/OR AVERAGE FUEL ECONOMY RESETS UNINTENTIONALLY

Released 5/1/2009
COLD START FEAD HOOT - WHISTLE NOISE

Released 4/2/2009
4.0L ENGINE BELT SQUEAL OR CHIRP NOISE ON COLD STARTUP

Released 1/26/2009
SUN VISOR MIRROR COVER CRACKING - BUILT BETWEEN 1/2/2007 AND 11/3/2008

Released 10/7/2008
REAR WINDOW DEFROSTER INOPERATIVE—GRID BUTTON TERMINAL REPAIR

Released 8/21/2008
MIL ON—P0506 AND/OR P0505—HESITATION/LOSS OF RPM/DIFFICULTY STARTING/LOW IDLE RPM

Released 3/5/2008
DISCHARGED BATTERIES—VEHICLES IN STORAGE/LIMITED USAGE

Released 2/27/2008
BATTERY SERVICE—OPERATION OF BATTERY EYE—CHARGING SERVICE TIPS

Released 12/21/2006
WATER NOISE—WATER ACCUMULATION INSIDE DOORS

Released 7/21/2006
AUDIO / NAVIGATION SERVICE AND ORDERING PROCEDURES

Released 1/8/2009
MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0456 - BUILT ON OR BEFORE 4/14/2008

Released 11/20/2008
DRIVELINE BUMP WHILE BRAKING - BELOW 10 MPH (16 KM/H)

Released 8/21/2008
MIL ON—P0506 AND/OR P0505—HESITATION/LOSS OF RPM/DIFFICULTY STARTING/LOW IDLE RPM

Released 8/1/2008
MALFUNCTION INDICATOR LAMP (MIL) ON WITH TSB 08-16-10 DIAGNOSTIC TROUBLE CODE (DTC) P0456

Released 4/24/2008
4.0L/4.6L—HARD START/ROUGH RUNNING—AFTER LONG HOT SOAK / DIP IN RPM WHEN COMING TO A STOP—BUILT ON OR BEFORE 4/2/2008

Released 2/19/2008
4.6L AND 6R60 TRANSMISSION EQUIPPED VEHICLES ONLY—BUMP WHILE BRAKING—VARIOUS TRANSMISSION SHIFT QUALITY SYMPTOMS— VEHICLES BUILT BEFORE 11/28/2007

Released 6/6/2007
RCM FAULT REPORTING USING DTCS AND BIT-MAPPED PARAMETER IDENTIFIERS (PIDS)— SERVICE TIPS

Released 5/14/2007
VARIOUS DRIVEABILITY AND A/C PERFORMANCE QUALITY SYMPTOMS—4.6L 3V 6R60 EQUIPPED VEHICLES ONLY

Released 12/18/2006
IGNITION DIAGNOSTICS

Released 10/7/2008
REAR WINDOW DEFROSTER INOPERATIVE—GRID BUTTON TERMINAL REPAIR

Released 4/1/2008
SPARK PLUG REMOVAL INSTRUCTIONS—4.6L 3V/5.4L 3V/6.8L 3V

Released 2/29/2008
THUMPING/LOUD FLUTTER—BEHIND DASH IN DEFROST MODE—LACK OF AIRFLOW TO FLOOR— MANUAL A/C ONLY

Released 11/30/2007
FUEL FILL—SLOW OR EARLY SHUT OFF—BUILT BEFORE 11/28/2007

Released 9/24/2007
WATER LEAK IN HEADLINER/DOME LAMP AREA— TSB 07-20-6 VEHICLES EQUIPPED WITH ROOF OPENING PANEL AND SAFETY CANOPY AIR BAG SYSTEMS—BUILT BEFORE 3/27/2007

Released 12/18/2006
IGNITION DIAGNOSTICS

Released 10/17/2006
MIL ON WITH DTC P0463 OR ERRATIC FUEL GAUGE OPERATION

Released 2/29/2008
THUMPING/LOUD FLUTTER—BEHIND DASH IN DEFROST MODE—LACK OF AIRFLOW TO FLOOR— MANUAL A/C ONLY

Released 6/8/2007
FRONT BLOWER MOTOR WHISTLE NOISE— TSB 07-12-6 VEHICLES BUILT ON OR BEFORE 06/7/2007

Released 12/21/2006
HEATER CORE LEAKAGE AND ELECTROLYSIS (INFORMATION ONLY)

Released 6/7/2018
Various Vehicles - Engine Failure Analysis General Service Bulletin (GSB)

Released 4/23/2018
2001-2015 - Vehicles With Modular 4.6L, 5.4L Or 6.8L Engines - Determining Root Cause Of Engine Damage Due To Oil Pressure Loss.

Released 4/23/2018
Various Vehicles - 4.6L/5.4L/6.8L 3 Valve - Engine Noise Upper End And/Or Rough Running - Camshaft Roller Follower Replacement - Built On Or Before 8-Jan-2016

Released 4/23/2018
HIGH PITCHED WHINE NOISE COMING FROM A GROUNDED OUT SHIFT CABLE ON THE 5R55S TRANSMISSION SPEED SENSOR(TSS) OR INPUT SHAFT SPEED SENSOR(ISS)

Released 12/15/2015
Multiple Vehicles - Transmission Cooler Flush General Service Bulletin (GSB)

Released 12/8/2015
Multiple Vehicles - Engine Failure Analysis General Service Bulletin (GSB)

Released 11/24/2015
2006-2010 Explorer/Mountaineer/Explorer Sport Trac - Service Part Warranty (SPW) Radiator Identification General Service Bulletin (GSB)

Released 8/31/2015
2006-2010 Explorer/Mountaineer/Explorer Sport Trac- Front Wheel Speed Sensor (WSS) Wire Harness Routing General Service Bulletin (GSB)

Released 11/2/2009
5R55S TRANSMISSION - CHECK ENGINE LIGHT ON - VARIOUS DTC'S - WATER INTRUSION FROM A/C DRAIN INTO TRANSMISSION SOLENOID BODY CONNECTOR - BUILT ON OR BEFORE 8/12/2009

Released 10/26/2009
4.6L ENGINE - CHECK ENGINE LIGHT ON - DTC P0196 - COLD WEATHER DRIVING CONDITIONS - CALIBRATION UPDATE

Released 1/8/2009
MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0456 - BUILT ON OR BEFORE 4/14/2008

Released 11/20/2008
DRIVELINE BUMP WHILE BRAKING - BELOW 10 MPH (16 KM/H)

Released 10/10/2008
4 WHEEL DRIVE/ALL WHEEL DRIVE—WITH CONTROL TRAC —SHUDDER ON ACCELERATION/DECELERATION OR BINDING ON SLOW TURNS

Released 9/9/2008
HIGH PITCHED SQUEAL NOISE FROM THE REAR TSB 08-19-6 AXLE AREA—BUILT ON OR BEFORE 7/28/2008

Released 9/5/2008
UNITIZED SEAL DIAGNOSIS—LEAK / GREASE OIL TSB 08-19-3 SEPARATION—AXLE BEARING SEAL 8.8 IFS, 8.8 IRS, AND 9.75 IRS AXLES

Released 8/21/2008
MIL ON—P0506 AND/OR P0505—HESITATION/LOSS OF RPM/DIFFICULTY STARTING/LOW IDLE RPM

Released 8/1/2008
MALFUNCTION INDICATOR LAMP (MIL) ON WITH TSB 08-16-10 DIAGNOSTIC TROUBLE CODE (DTC) P0456

Released 3/7/2008
6R60/75—DTC-MECHATRONIC ASSEMBLY / POSSIBLE WRENCH LIGHT ON

Released 2/19/2008
4.6L AND 6R60 TRANSMISSION EQUIPPED VEHICLES ONLY—BUMP WHILE BRAKING—VARIOUS TRANSMISSION SHIFT QUALITY SYMPTOMS— VEHICLES BUILT BEFORE 11/28/2007

Released 2/7/2008
COLD START FEAD HOOT—WHISTLE NOISE / BUILT BEFORE 1/28/2008

Released 11/30/2007
FUEL FILL—SLOW OR EARLY SHUT OFF—BUILT BEFORE 11/28/2007

Released 6/8/2007
INTERMITTENT CONDITION—SHIFTER REQUIRES MANUAL OVERRIDE TO GET VEHICLE OUT OF PARK—VEHICLES BUILT ON OR BEFORE 11/14/2006

Released 5/14/2007
VARIOUS DRIVEABILITY AND A/C PERFORMANCE QUALITY SYMPTOMS—4.6L 3V 6R60 EQUIPPED VEHICLES ONLY

Released 1/9/2007
MERCONâ ATF REPLACED BY MERCON (R) V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS

Released 12/17/2006
CALIBRATION UPDATE 4.0L—VARIOUS SYMPTOMS—SURGE, HESITATION, TORQUE CONVERTER CYCLING, NO UP SHIFT AFTER A CONVERTER CYCLING, NO UP SHIFT AFTER A/C PERFORMANCE

Released 2/17/2009
POPPING/SNAPPING NOISE - FRONT OR REAR 18 INCH WHEELS - TURNING AT SLOW SPEED BELOW 10 MPH (16 KM/H)

Released 11/17/2008
VIBRATION DIAGNOSTICS - STEERING WHEEL NIBBLE - TIRE WHEEL RUNOUT AND BALANCE

Released 10/10/2008
4 WHEEL DRIVE/ALL WHEEL DRIVE—WITH CONTROL TRAC —SHUDDER ON ACCELERATION/DECELERATION OR BINDING ON SLOW TURNS

Released 8/28/2008
POPPING/SNAPPING NOISE—FRONT OR REAR 18 TSB 08-18-5 INCH WHEELS—TURNING AT SLOW SPEED BELOW 10 MPH (16KM/H)

Released 2/14/2007
VIBRATION DIAGNOSIS—TIRE/WHEEL RUNOUT

Released 2/13/2007
LEATHER-WRAPPED STEERING WHEEL—LEATHER COMING LOOSE

Released 1/9/2007
MERCONâ ATF REPLACED BY MERCON (R) V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS

Released 12/24/2006
LOWER STEERING COLUMN SHAFT POP / CLUNK NOISE