Get Free 2006 MERCURY MARINER L4, 2.3L; DOHC TSBs

Released 4/23/2018
Dealer Installed Audio Upgrades

Released 4/23/2018
2005-2012 Escape Hybrid and 2006-2011 Mariner Hybrid - Malfunction Indicator Lamp (MIL) With DTC P0A7E:00 - Hybrid Battery Pack Over Temperature

Released 4/23/2018
2002-2008 ESCAPE / 2005-2008 MARINER - CRACKED WELD DETECTION PROCEDURE FOR 7G120, CYLINDER AND HUB ASSEMBLY, FORWARD, COAST AND DIRECT CLUTCH

Released 4/23/2018
2005-2008 VEHICLES EQUIPPED WITH 2.0L/2.3L I4 ENGINE LEAN CODES DUE TO VACUUM LEAK

Released 4/23/2018
2005-2008 Escape/Mariner Hybrid - Anti-Lock Brake System (ABS) Warning Indicator Illuminated with DTC(s) C1478, C1479, C1480 And/Or C1481

Released 9/25/2017
Various Vehicles - Module Programming and Reprogramming Procedures

Released 9/25/2017
Hybrid and Electric Vehicle Battery Recycling Information General Service Bulletin (GSB)

Released 9/7/2016
2005-2012 Escape Hybrid, 2006-2011 Mariner Hybrid - Diagnostic Trouble Codes (DTCs) P0A81 And/Or P0A96

Released 4/27/2016
Multiple Vehicles - No PCM/Network Communication

Released 1/27/2016
2004 And Newer Vehicles Equipped With Flex Fuel Capability - Flex Fuel General Service Bulletin (GSB)

Released 12/15/2015
Multiple Vehicles - Transmission Cooler Flush General Service Bulletin (GSB)

Released 12/9/2015
Multiple Vehicles - Tire Pressure Monitor System (TPMS) General Service Bulletin (GSB)

Released 12/8/2015
Multiple Vehicles - Engine Failure Analysis General Service Bulletin (GSB)

Released 10/14/2015
Multple Vehicles - Wiring Repair General Service Bulletin (GSB)

Released 11/9/2010
FRONT AND/OR REAR CREAK/SQUEAK NOISE DUE TO SUBFRAME LOCATING PINS CONTACTING VEHICLE BODY

Released 1/15/2010
FRONT AND/OR REAR CREAK/SQUEAK NOISE

Released 6/6/2007
RCM FAULT REPORTING USING DTCS AND BIT-MAPPED PARAMETER IDENTIFIERS (PIDS)— SERVICE TIPS

Released 2/13/2007
LEATHER-WRAPPED STEERING WHEEL—LEATHER COMING LOOSE

Released 1/12/2007
HYBRID—SPILL IN CARGO AREA

Released 12/16/2006
SPARK KNOCK, HARD START AND/OR HESITATION—VEHICLES BUILT AFTER 8/2/2004 WITH A 3.0L ENGINE

Released 7/6/2006
TURN SIGNALS—RAPID FLASHING

Released 5/20/2006
PARKING AID SPEAKER INOPERATIVE—DTCS C1742 AND C1743

Released 3/5/2006
INTERIOR ODOR—FOAM INSULATOR SLEEVE ON SHIFTER CABLE NOT FULLY CURED

Released 2/9/2006
SPEAKER BUZZ—FRONT DOOR SPEAKERS ONLY

Released 2/7/2006
COOLANT LEAK—3.0L ENGINE—VEHICLES BUILT FROM 09/10/2005 TO 10/15/2005

Released 1/19/2006
REAR CARGO AREA CARPET COMING LOOSE

Released 11/16/2005
SAFETY BELT RETRACTION SPEED

Released 3/9/2005
INTERIOR PLASTIC TRIM—PAINT-TO-MATCH AND REPAIR—INTERIOR SPRAY PAINT AND ADHESION PROMOTER USAGE INSTRUCTIONS

Released 1/26/2005
LONG CRANK/HARD START—3.0L

Released 2/20/2008
BRAKE GRAB—DAMP CONDITIONS

Released 1/28/2008
MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) U2062

Released 1/22/2006
ABS LIGHT ON AND DTC C1475—HYBRID VEHICLES BUILT FROM 8/2/2004—3/30/2006

Released 7/17/2009
DTC P0A81 AND/OR P0A96

Released 11/20/2008
OVERHEATING - ALL HYBRID APPLICATIONS

Released 7/2/2008
OVERHEATING—COMMERCIAL APPLICATIONS

Released 12/21/2006
HEATER CORE LEAKAGE AND ELECTROLYSIS (INFORMATION ONLY)

Released 2/7/2006
COOLANT LEAK—3.0L ENGINE—VEHICLES BUILT FROM 09/10/2005 TO 10/15/2005

Released 4/23/2018
2005-2012 Escape Hybrid and 2006-2011 Mariner Hybrid - Malfunction Indicator Lamp (MIL) With DTC P0A7E:00 - Hybrid Battery Pack Over Temperature

Released 4/23/2018
2005-2008 VEHICLES EQUIPPED WITH 2.0L/2.3L I4 ENGINE LEAN CODES DUE TO VACUUM LEAK

Released 4/23/2018
2005-2008 Escape/Mariner Hybrid - Anti-Lock Brake System (ABS) Warning Indicator Illuminated with DTC(s) C1478, C1479, C1480 And/Or C1481

Released 9/25/2017
Hybrid and Electric Vehicle Battery Recycling Information General Service Bulletin (GSB)

Released 9/7/2016
2005-2012 Escape Hybrid, 2006-2011 Mariner Hybrid - Diagnostic Trouble Codes (DTCs) P0A81 And/Or P0A96

Released 4/27/2016
Multiple Vehicles - No PCM/Network Communication

Released 10/14/2015
Multple Vehicles - Wiring Repair General Service Bulletin (GSB)

Released 11/4/2011
HYBRID - POSSIBLE MISDIAGNOSIS OF START/STALL WITH OR WITHOUT DTCS P0A7D, P1A0C

Released 9/2/2009
DTC P0A27 - INSTRUMENTATION WARNINGS - REDUCED ENGINE POWER

Released 8/27/2009
DTC P0A81 AND/OR P0A96

Released 2/27/2008
BATTERY SERVICE—OPERATION OF BATTERY EYE—CHARGING SERVICE TIPS

Released 12/7/2007
WRENCH LIGHT/CHECK ENGINE LIGHT ON-DTCS TSB 07-25-11 P2110, P2111, P2112, AND/OR P2135-WITH/WITHOUT DRIVEABILITY SYMPTOMS

Released 12/7/2007
WRENCH LIGHT ON—DTC B1239

Released 1/12/2007
HYBRID—SPILL IN CARGO AREA

Released 12/23/2006
SERVICE TIPS FOR OPTIONAL NAVIGATION SYSTEM RADIO

Released 8/15/2006
KEYPAD DIAGNOSTICS—DEALER INSTALLED ACCESSORY

Released 7/21/2006
AUDIO / NAVIGATION SERVICE AND ORDERING PROCEDURES

Released 7/6/2006
TURN SIGNALS—RAPID FLASHING

Released 6/25/2006
RED ELECTRICAL HAZARD WARNING LAMP AND DTC P0A95—HYBRID VEHICLE

Released 3/23/2006
SQUEAK—STEERING COLUMN / RACK

Released 1/7/2006
NEUTRAL TOW CAPABILITY—SERVICE KIT REQUIREMENTS

Released 7/18/2005
WIRING—SOLDERING AND CRIMPING REPAIRS— SOLDERING TIPS

Released 12/7/2007
WRENCH LIGHT/CHECK ENGINE LIGHT ON-DTCS TSB 07-25-11 P2110, P2111, P2112, AND/OR P2135-WITH/WITHOUT DRIVEABILITY SYMPTOMS

Released 6/6/2007
RCM FAULT REPORTING USING DTCS AND BIT-MAPPED PARAMETER IDENTIFIERS (PIDS)— SERVICE TIPS

Released 12/16/2006
SPARK KNOCK, HARD START AND/OR HESITATION—VEHICLES BUILT AFTER 8/2/2004 WITH A 3.0L ENGINE

Released 1/26/2005
LONG CRANK/HARD START—3.0L

Released 4/15/2009
RED TRIANGLE ON AND STOP SAFELY NOW MESSAGE - DTC P1A0C

Released 1/23/2009
3.0L ENGINE MIL ON WITH DTCS P0351 THROUGH P0356 - MULTIPLE COIL PRIMARY CIRCUIT

Released 2/26/2008
SLOW FUEL FILL AND/OR DTC P0451

Released 8/22/2005
WDS COP KIT DIAGNOSTIC TIPS—COIL ON PLUG (COP) IGNITION SYSTEMS—ENGINE MISFIRE OR ROUGH RUNNING

Released 4/18/2005
SLOW FUEL FILL—REPEAT FILLING STATION PUMP SHUT-OFF

Released 9/4/2006
A/C COMPRESSOR NOT OPERATIONAL / LOW FREON—SHAFT SEAL LEAKS

Released 6/7/2018
Various Vehicles - Engine Failure Analysis General Service Bulletin (GSB)

Released 4/23/2018
2002-2008 ESCAPE / 2005-2008 MARINER - CRACKED WELD DETECTION PROCEDURE FOR 7G120, CYLINDER AND HUB ASSEMBLY, FORWARD, COAST AND DIRECT CLUTCH

Released 12/15/2015
Multiple Vehicles - Transmission Cooler Flush General Service Bulletin (GSB)

Released 12/8/2015
Multiple Vehicles - Engine Failure Analysis General Service Bulletin (GSB)

Released 12/7/2009
CD4E TRANSMISSION FAILURE - REPLACE OR INSTALL TRANSMISSION FLUID COOLER COLD WEATHER BYPASS KIT

Released 2/17/2009
PTU VENT BOLT LEAK - MISDIAGNOSED AS PTU SHAFT SEAL LEAK

Released 3/1/2008
CD4E—ENGINE STALLING ON ENGAGEMENT/STOPPING

Released 2/5/2008
CAMSHAFT TICK NOISE—3.0L 4V ENGINE ONLY WITH EXHAUST CAMSHAFT DRIVEN WATER PUMPS

Released 12/7/2007
WRENCH LIGHT/CHECK ENGINE LIGHT ON-DTCS TSB 07-25-11 P2110, P2111, P2112, AND/OR P2135-WITH/WITHOUT DRIVEABILITY SYMPTOMS

Released 1/9/2007
MERCONâ ATF REPLACED BY MERCON (R) V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS

Released 12/16/2006
SPARK KNOCK, HARD START AND/OR HESITATION—VEHICLES BUILT AFTER 8/2/2004 WITH A 3.0L ENGINE

Released 5/3/2006
CAMSHAFT TICK NOISE—3.0L 4V ENGINE ONLY

Released 4/21/2006
2.3L/2.0L DURATEC—NO START/POSSIBLE ENGINE DAMAGE—INSTALL SPECIAL SERVICE TOOLS PRIOR TO REMOVING CRANKSHAFT PULLEY BOLT

Released 3/5/2006
INTERIOR ODOR—FOAM INSULATOR SLEEVE ON SHIFTER CABLE NOT FULLY CURED

Released 2/7/2006
COOLANT LEAK—3.0L ENGINE—VEHICLES BUILT FROM 09/10/2005 TO 10/15/2005

Released 8/22/2005
WDS COP KIT DIAGNOSTIC TIPS—COIL ON PLUG (COP) IGNITION SYSTEMS—ENGINE MISFIRE OR ROUGH RUNNING

Released 7/10/2005
DRIVELINE WHINE 20-45 MPH (32-72 KM/H)

Released 4/18/2005
SLOW FUEL FILL—REPEAT FILLING STATION PUMP SHUT-OFF

Released 11/9/2010
FRONT AND/OR REAR CREAK/SQUEAK NOISE DUE TO SUBFRAME LOCATING PINS CONTACTING VEHICLE BODY

Released 1/15/2010
FRONT AND/OR REAR CREAK/SQUEAK NOISE

Released 11/18/2009
CLICK/POP NOISE FROM FRONT STABILIZER BAR END LINK AREA WHEN DRIVING OVER BUMPS - BUILT ON OR BEFORE 10/9/2009

Released 3/17/2009
NOISE - FRONT STRUT AREA

Released 2/26/2009
LOWER CONTROL ARM BUSHING INSPECTION PROCEDURE

Released 11/17/2008
VIBRATION DIAGNOSTICS - STEERING WHEEL NIBBLE - TIRE WHEEL RUNOUT AND BALANCE

Released 2/14/2007
VIBRATION DIAGNOSIS—TIRE/WHEEL RUNOUT

Released 2/13/2007
LEATHER-WRAPPED STEERING WHEEL—LEATHER COMING LOOSE

Released 1/9/2007
MERCONâ ATF REPLACED BY MERCON (R) V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS

Released 12/20/2006
SQUEAK / CREAK NOISE FROM REAR—VEHICLES BUILT BEFORE 9/5/2006

Released 7/3/2006
LOW TIRE INDICATOR ON—TPMS SYSTEM SENSOR WAKE UP

Released 3/23/2006
SQUEAK—STEERING COLUMN / RACK

Released 3/17/2006
STEERING NOISE—CLUNK/RATTLE

Released 6/20/2005
HIGHWAY SPEED VIBRATION—VEHICLES BUILT BEFORE 7/1/2005 EQUIPPED WITH CONTITRAC P235/70R16 104T TIRES

Released 4/21/2006
2.3L/2.0L DURATEC—NO START/POSSIBLE ENGINE DAMAGE—INSTALL SPECIAL SERVICE TOOLS PRIOR TO REMOVING CRANKSHAFT PULLEY BOLT

Released 8/22/2005
WDS COP KIT DIAGNOSTIC TIPS—COIL ON PLUG (COP) IGNITION SYSTEMS—ENGINE MISFIRE OR ROUGH RUNNING

Released 7/18/2005
WIRING—SOLDERING AND CRIMPING REPAIRS— SOLDERING TIPS

Released 3/9/2005
INTERIOR PLASTIC TRIM—PAINT-TO-MATCH AND REPAIR—INTERIOR SPRAY PAINT AND ADHESION PROMOTER USAGE INSTRUCTIONS