Get Free 2004 LINCOLN NAVIGATOR V8, 5.4L; DOHC TSBs

Released 4/23/2018
Multiple Vehicles - Powerfold And/Or Telescoping Trailer Tow Mirrors- Shakes/Vibrates And/Or Changes Position While Driving

Released 8/22/2017
2000 And Newer Ford, Lincoln And Mercury Vehicles - Aluminum Panel Corrosion

Released 1/27/2016
2004 And Newer Vehicles Equipped With Flex Fuel Capability - Flex Fuel General Service Bulletin (GSB)

Released 12/15/2015
Multiple Vehicles - Transmission Cooler Flush General Service Bulletin (GSB)

Released 12/8/2015
Multiple Vehicles - Engine Failure Analysis General Service Bulletin (GSB)

Released 12/7/2015
Multiple Vehicles - Spark Plug Thread Repair - 4.6L/5.4L/6.8L Modular 2v Engines - General Service Bulletin (GSB)

Released 6/6/2007
RCM FAULT REPORTING USING DTCS AND BIT-MAPPED PARAMETER IDENTIFIERS (PIDS)— SERVICE TIPS

Released 5/14/2007
REAR WIPER INOPERATIVE

Released 2/13/2007
LEATHER-WRAPPED STEERING WHEEL—LEATHER COMING LOOSE

Released 1/23/2007
PAINT BUBBLES AROUND LIFTGATE TRIM

Released 12/25/2006
PARKING AID SYSTEM INOPERATIVE—DTC C1983

Released 12/25/2006
ALUMINUM BODY PANELS—CORROSION—SERVICE TIP

Released 12/14/2006
LOWER DOOR CLADDING RUBBING ON FRONT FENDER

Released 5/2/2006
POWER FOLDING MIRROR OPERATION

Released 4/13/2006
WIND / WHISTLE NOISE AROUND OUTSIDE MIRRORS

Released 1/2/2006
STATIC RUNNING BOARD STEP PADS WARPED OR LOOSE

Released 12/18/2005
DRIVERS FRONT POWER SEAT WILL NOT MOVE FORWARD OR REARWARD

Released 12/9/2005
WATER LEAKS AT MOONROOF—VEHICLES BUILT BEFORE 12/08/2004

Released 11/16/2005
SAFETY BELT RETRACTION SPEED

Released 10/3/2005
SAFETY BELT WEB STOP BUTTON SERVICE

Released 9/23/2005
INCORRECT COMPASS HEADINGS

Released 3/9/2005
INTERIOR PLASTIC TRIM—PAINT-TO-MATCH AND REPAIR—INTERIOR SPRAY PAINT AND ADHESION PROMOTER USAGE INSTRUCTIONS

Released 1/7/2005
RATTLE/RUBBING/TICKING NOISE FROM DOORS

Released 12/26/2004
CLIMATE CONTROLLED SEAT DIAGNOSIS—SERVICE TIPS

Released 12/24/2004
DEPLOYABLE RUNNING BOARDS (DRB) INTERMITTENTLY INOPERATIVE

Released 12/21/2004
REVERSE TILT MIRROR SYSTEM DIAGNOSTICS AND REPAIR

Released 9/15/2004
MOONROOF WATER LEAKS

Released 7/18/2004
FRONT END ACCESSORY DRIVE NOISE

Released 7/5/2004
BODY—FRONT WINDOW(S)—POP/THUMP NOISE END OF WINDOW TRAVEL AND/OR DRIVER’S WINDOW BOUNCE BACK AND REVERSE TO MID-POSITION

Released 6/9/2004
BODY—PAINT—IRON PARTICLE REMOVAL - INDUSTRIAL FALLOUT—ACID RAIN NEUTRALIZATION

Released 5/24/2004
REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR—TERMINAL TAB REPAIR

Released 4/11/2004
BODY—LIFTGATE REVERSING DIRECTION WHEN CLOSING IN HOT AMBIENT TEMPERATURES ABOVE 90 F (32 C)—DTC B2825 PRESENT DURING SELF TEST *

Released 3/19/2004
RETRACTABLE RUNNING BOARD DEPLOYMENT CONCERNS

Released 2/8/2004
BODY—BODY JOINT REINFORCEMENT MATERIAL (STRUCTURAL FOAM)—UPDATED REPAIR PROCEDURE

Released 2/23/2003
BODY—MIRROR—EXTERIOR MIRROR GLASS AND MOTOR REPLACEMENT—SERVICE TIPS

Released 5/12/2006
BRAKE SHUDDER

Released 3/8/2006
SPEED CONTROL DIAGNOSTIC TIPS—PCM

Released 12/26/2005
UNINTENDED BRAKE ASSIST

Released 12/21/2004
REVERSE TILT MIRROR SYSTEM DIAGNOSTICS AND REPAIR

Released 2/5/2004
BRAKES—BRAKE DUST—REVISED BRAKE LININGS—VEHICLES BUILT PRIOR TO 12/18/2003

Released 2/27/2008
BATTERY SERVICE—OPERATION OF BATTERY EYE—CHARGING SERVICE TIPS

Released 2/16/2008
HIGH INTENSITY DISCHARGE (HID) HEADLAMPS—SERVICE FIX

Released 12/25/2006
ALUMINUM BODY PANELS—CORROSION—SERVICE TIP

Released 12/14/2006
NO CRANK / STARTER TERMINAL FATIGUE

Released 12/8/2006
BATTERY DRAIN—VEHICLES BUILT PRIOR TO 3/24/2006

Released 8/15/2006
KEYPAD DIAGNOSTICS—DEALER INSTALLED ACCESSORY

Released 3/8/2006
SPEED CONTROL DIAGNOSTIC TIPS—PCM

Released 12/18/2005
DRIVERS FRONT POWER SEAT WILL NOT MOVE FORWARD OR REARWARD

Released 12/13/2005
DEPLOYABLE RUNNING BOARDS DIAGNOSTIC JUMPER HARNESS

Released 8/19/2005
REAR WINDOW WIPER INOPERATIVE

Released 7/18/2005
WIRING—SOLDERING AND CRIMPING REPAIRS— SOLDERING TIPS

Released 12/24/2004
DEPLOYABLE RUNNING BOARDS (DRB) INTERMITTENTLY INOPERATIVE

Released 9/15/2004
MOONROOF WATER LEAKS

Released 9/14/2004
DIAGNOSTIC TROUBLE CODE (DTC) P0320 WITH POSSIBLE DRIVEABILITY CONCERNS AND/OR CHARGING SYSTEM WARNING INDICATOR ON WITH POSSIBLE DTC P0620

Released 7/18/2004
FRONT END ACCESSORY DRIVE NOISE

Released 7/5/2004
BODY—FRONT WINDOW(S)—POP/THUMP NOISE END OF WINDOW TRAVEL AND/OR DRIVER’S WINDOW BOUNCE BACK AND REVERSE TO MID-POSITION

Released 6/9/2004
BODY—PAINT—IRON PARTICLE REMOVAL - INDUSTRIAL FALLOUT—ACID RAIN NEUTRALIZATION

Released 5/24/2004
REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR—TERMINAL TAB REPAIR

Released 4/11/2004
BODY—LIFTGATE REVERSING DIRECTION WHEN CLOSING IN HOT AMBIENT TEMPERATURES ABOVE 90 F (32 C)—DTC B2825 PRESENT DURING SELF TEST *

Released 2/8/2004
BODY—BODY JOINT REINFORCEMENT MATERIAL (STRUCTURAL FOAM)—UPDATED REPAIR PROCEDURE

Released 2/23/2003
BODY—MIRROR—EXTERIOR MIRROR GLASS AND MOTOR REPLACEMENT—SERVICE TIPS

Released 1/18/2003
ELECTRICAL—REMOTE KEYLESS ENTRY (RKE)— SERVICE TIPS

Released 4/17/2004
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED—SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC’S)—SERVICE TIPS

Released 12/26/2005
AIR SUSPENSION COMPRESSOR NOISE

Released 8/22/2005
WDS COP KIT DIAGNOSTIC TIPS—COIL ON PLUG (COP) IGNITION SYSTEMS—ENGINE MISFIRE OR ROUGH RUNNING

Released 12/21/2004
REVERSE TILT MIRROR SYSTEM DIAGNOSTICS AND REPAIR

Released 9/5/2004
CLIMATE CONTROL—INTERMITTENT LOSS OF COOLING OR AIRFLOW FROM A/C SYSTEM AT HIGHWAY DRIVES—VEHICLES BUILT PRIOR TO 3/16/2004

Released 6/16/2009
WHITE FLAKES COMING FROM A/C VENTS

Released 12/15/2008
WHITE FLAKES COMING FROM A/C VENTS

Released 12/21/2006
HEATER CORE LEAKAGE AND ELECTROLYSIS (INFORMATION ONLY)

Released 3/10/2006
INSUFFICIENT A/C COOLING

Released 11/10/2005
WHITE FLAKES COMING FROM A/C VENTS

Released 12/26/2004
CLIMATE CONTROLLED SEAT DIAGNOSIS—SERVICE TIPS

Released 12/24/2004
HEATER HOSE LEAK

Released 9/5/2004
CLIMATE CONTROL—INTERMITTENT LOSS OF COOLING OR AIRFLOW FROM A/C SYSTEM AT HIGHWAY DRIVES—VEHICLES BUILT PRIOR TO 3/16/2004

Released 4/23/2018
2001-2015 - Vehicles With Modular 4.6L, 5.4L Or 6.8L Engines - Determining Root Cause Of Engine Damage Due To Oil Pressure Loss.

Released 12/15/2015
Multiple Vehicles - Transmission Cooler Flush General Service Bulletin (GSB)

Released 12/8/2015
Multiple Vehicles - Engine Failure Analysis General Service Bulletin (GSB)

Released 12/7/2015
Multiple Vehicles - Spark Plug Thread Repair - 4.6L/5.4L/6.8L Modular 2v Engines - General Service Bulletin (GSB)

Released 10/10/2008
4 WHEEL DRIVE/ALL WHEEL DRIVE—WITH CONTROL TRAC —SHUDDER ON ACCELERATION/DECELERATION OR BINDING ON SLOW TURNS

Released 9/5/2008
UNITIZED SEAL DIAGNOSIS—LEAK / GREASE OIL TSB 08-19-3 SEPARATION—AXLE BEARING SEAL 8.8 IFS, 8.8 IRS, AND 9.75 IRS AXLES

Released 1/9/2007
MERCONâ ATF REPLACED BY MERCON (R) V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS

Released 12/18/2006
IDENTIFYING THE CORRECT REPLACEMENT HEAD GASKET FOR CERTAIN REMANUFACTURED ENGINES—SERVICE TIP

Released 12/5/2006
ENGINE MISFIRE WITH DIAGNOSTIC TROUBLE CODE (DTC) P0301, P0302, P0303, P0304, P0305, P0306, P0307, P0308, AND P0316

Released 4/14/2006
MERCON ATF IS BEING REPLACED BY MERCON V ATF AS A SERVICE FLUID.

Released 8/22/2005
WDS COP KIT DIAGNOSTIC TIPS—COIL ON PLUG (COP) IGNITION SYSTEMS—ENGINE MISFIRE OR ROUGH RUNNING

Released 3/23/2005
REAR AXLE NOISE REPAIR

Released 3/19/2004
RETRACTABLE RUNNING BOARD DEPLOYMENT CONCERNS

Released 2/13/2007
LEATHER-WRAPPED STEERING WHEEL—LEATHER COMING LOOSE

Released 1/9/2007
MERCONâ ATF REPLACED BY MERCON (R) V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS

Released 10/15/2006
AIR SUSPENSION PERFORMANCE—HEIGHT SENSOR LINKAGE ARM DISENGAGING

Released 7/3/2006
LOW TIRE INDICATOR ON—TPMS SYSTEM SENSOR WAKE UP

Released 12/26/2005
AIR SUSPENSION COMPRESSOR NOISE

Released 2/7/2005
STEERING WHEEL NIBBLE AT 65 MPH (105 KM/H) OR HIGHER

Released 12/26/2004
CLUNK, POP, CREAK OR TICK NOISE FROM STEERING COLUMN

Released 4/11/2004
BODY—LIFTGATE REVERSING DIRECTION WHEN CLOSING IN HOT AMBIENT TEMPERATURES ABOVE 90 F (32 C)—DTC B2825 PRESENT DURING SELF TEST *

Released 4/22/2003
WHEEL—CORRECT LUG NUT TORQUE SPECIFICATIONS—INCREASED WHEEL NUT AND STUD SIZE—SERVICE TIP

Released 8/22/2005
WDS COP KIT DIAGNOSTIC TIPS—COIL ON PLUG (COP) IGNITION SYSTEMS—ENGINE MISFIRE OR ROUGH RUNNING

Released 7/18/2005
WIRING—SOLDERING AND CRIMPING REPAIRS— SOLDERING TIPS

Released 3/9/2005
INTERIOR PLASTIC TRIM—PAINT-TO-MATCH AND REPAIR—INTERIOR SPRAY PAINT AND ADHESION PROMOTER USAGE INSTRUCTIONS