Get Free 2005 JEEP WRANGLER L6, 4.0L TSBs

Released 1/11/2013
Overspray Removal

Released 8/14/2012
Welded Sheet Metal Repairs and Replacements

Released 7/26/2012
Front Fascia Repair When License Plate Bracket Has Been Removed

Released 11/10/2011
Repair Parts Used For Structural Repairs

Released 11/10/2011
Replacement Seat Covers And Seat Cover Repairs

Released 11/10/2011
Use of Heat To Straighten Damaged Components

Released 8/22/2007
Low Gloss Interior Trim

Released 7/26/2006
Soft Top Center Bow

Released 2/15/2006
Primary Door Weatherstrip Water Leak At A-Pillar Belt Line

Released 12/6/2005
Hardtop Sagging

Released 8/3/2005
Buzz Or Rattle-Like Sound From Sound Bar Radio Speaker Housing And/Or Harness

Released 7/26/2005
Circular/Ring Marks On Glass

Released 4/27/2005
Hard Top Rear Wiper Blade - Contacts CHMSL Housing

Released 2/15/2005
Sunrider Soft Top - Side Rail Pivot Link And Sleeve Repair

Released 2/4/2005
Soft Top - Seam Sealer Tape Repair

Released 10/15/2004
Seam Sealing Tape May Not Have Fully Fused To Soft Top

Released 7/30/2004
Safety Systems - Vehicle Modifications/Repair

Released 6/15/2004
Rear Window Lift Glass Seal/Carrier Replacement

Released 3/30/2007
Fluid Flushing Requirements

Released 7/30/2004
Safety Systems - Vehicle Modifications/Repair

Released 8/25/2006
Powertrain Control Module Initialization

Released 2/15/2006
2.4L Engine - Chirp-Like Sound From Accessory Drive Belt

Released 2/4/2005
HVAC Drain Water Leaks Inside Vehicle And Under Passenger Side Front Carpet

Released 7/30/2004
Safety Systems - Vehicle Modifications/Repair

Released 11/14/2009
Flash: 42RLE - Improved Hill Climb Capability In Reverse Or DTC's P1713 / P1776

Released 5/9/2009
Flash: MIL Illumination Due To Diagnostic Trouble Code P0340 Or P0344

Released 2/19/2008
FLASH: DTC P2074 - 2.4L - MAP/TPS Correlation

Released 11/6/2007
DTC P0420 / P0430 - Catalyst Efficiency

Released 4/26/2007
Generic Powertrain Control Module (PCM) Procedure

Released 3/20/2007
Flash: 42RLE - Improved Hill Climb Capability In Reverse Or DTC's P1713 / P1776

Released 2/9/2007
I/M Readiness Check Continues To Indicate OBD System Is Not Ready For I/M Testing

Released 9/15/2006
Flash: MIL Activation For Downstream Fuel Trim - DTC's P2096 or P2098

Released 10/20/2005
Flash Programming Failure Recovery Using DRBIII®

Released 5/13/2005
Flash: MIL Illumination With Diagnostic Trouble Code P0339

Released 1/13/2005
FLASH: Off-Roading In 4WD Low Range - Axle Lockers May Unlock When Ignition Key Is Cycled

Released 1/1/2005
Reprogram PCM - OBD Fuel System Monitor

Released 1/1/2005
OBD Fuel System Monitor

Released 11/22/2004
Evaporative Systems Service

Released 11/18/2004
Flash: Driveability Improvements Or MIL Illumination with Diagnostic Trouble Codes P2074

Released 7/30/2004
Safety Systems - Vehicle Modifications/Repair

Released 6/10/1994
Flash: Intermittent 4WD Lamp Or DTC P0573 - Brake Switch #1 Circuit High

Released 8/9/2006
A/C Cooling Coil Odor

Released 2/4/2005
HVAC Drain Water Leaks Inside Vehicle And Under Passenger Side Front Carpet

Released 9/17/2008
Automatic Transmission Diagnostic Tear Down Procedure

Released 2/19/2008
FLASH: DTC P2074 - 2.4L - MAP/TPS Correlation

Released 11/6/2007
DTC P0420 / P0430 - Catalyst Efficiency

Released 3/30/2007
Fluid Flushing Requirements

Released 3/20/2007
Flash: 42RLE - Improved Hill Climb Capability In Reverse Or DTC's P1713 / P1776

Released 2/9/2007
Automatic Transmission Diagnostic Tear Down Procedure

Released 9/15/2006
Flash: MIL Activation For Downstream Fuel Trim - DTC's P2096 or P2098

Released 12/10/2005
Cylinder Head Bolt Re-torque Procedure

Released 11/1/2005
Transmission Cup Plug Bracket

Released 11/1/2005
Transmission Cup Plug Bracket

Released 8/3/2005
NSG370 - Correct Shift Tower Sealer Application To Prevent Restriction Of Vent

Released 6/30/2005
Co-Pilot Support and Correct Cable Usage

Released 6/1/2005
Oil Pump Drive Gear

Released 5/13/2005
Flash: MIL Illumination With Diagnostic Trouble Code P0339

Released 3/22/2005
MIL Illumination For DTC's P0750, P0755, P0760, P0765, P0846, P0871 or P0841

Released 3/1/2005
Oil Pump Drive Gear

Released 2/24/2005
NSG370 6-Spd Transmission - May Not Remain In Reverse Gear When Selected

Released 1/13/2005
FLASH: Off-Roading In 4WD Low Range - Axle Lockers May Unlock When Ignition Key Is Cycled

Released 11/18/2004
Flash: Driveability Improvements Or MIL Illumination with Diagnostic Trouble Codes P2074

Released 10/1/2004
4.0L Engine - Dirt And Debris Accumulation At Rear Main Seal

Released 8/26/2004
NSG-370 Manual Transmission - Lubricant Level

Released 8/6/2004
Gasoline Engine Oil Quality And Viscosity Grades

Released 6/10/1994
Flash: Intermittent 4WD Lamp Or DTC P0573 - Brake Switch #1 Circuit High

Released 1/1/2005
Reprogram PCM - OBD Fuel System Monitor

Released 1/1/2005
OBD Fuel System Monitor

Released 7/12/2012
A Self-Sustaining Vibration (Shimmy) Of The Vehicle And Steering Wheel While Driving At Speeds Typically Above 50 MPH (80 KMH)

Released 9/24/2009
Fluid Flushing Requirements

Released 7/29/2009
Chrome Clad Wheel Adapters For Proper Balancing

Released 3/30/2007
Fluid Flushing Requirements

Released 8/30/2006
Steering Shimmy

Released 2/15/2006
2.4L Engine - Chirp-Like Sound From Accessory Drive Belt

Released 12/1/2005
Chrome Wheel Care

Released 4/9/2005
Owner Manual Addendum - Maintenance Schedule - Export Models Only

Released 11/29/2004
Power Steering Fluid Contamination

Released 8/20/2004
Special Offset Ball Joint - Allows Adjustment To Caster And Camber Angles

Released 9/17/2008
Automatic Transmission Diagnostic Tear Down Procedure

Released 2/9/2007
Automatic Transmission Diagnostic Tear Down Procedure

Released 10/20/2005
Flash Programming Failure Recovery Using DRBIII®

Released 6/30/2005
Co-Pilot Support and Correct Cable Usage