Get Free 2008 GMC C4500 V8, 6.6L; Diesel; Turbo TSBs

Released 8/1/2015
Information for Identifying Non-GM ECM Calibration Use and Power-up Hardware Detection in Duramax Diesel Engines - Photograph Tech 2 Calibration IDs, Calibration Verification Numbers (CVNs) and Transmission Data Screen

Released 5/12/2015
Information on Higher Than Expected Oil Consumption

Released 8/26/2014
Information on Identifying Duramax Diesel Overpower Engine Breakdown/Non-Function Due to Aftermarket Power-Up Devices vs Non Overpower Engine Non-Function of Pistons, Cylinders, Valvetrain Components, DTC P003A or P111D Set

Released 8/15/2014
Duramax Diesel Airflow Leak Equivalency Ratio Or Induction System Leak Indication And P0101

Released 7/16/2014
Duramax Diesel Glow Plugs Difficult to Install Due to Carbon Buildup - New Glow Plug Bore Reamer Available

Released 6/19/2014
Radio Reprogramming Using Techline/Service Programming System (SPS) - Ensuring Correct Vehicle Selection

Released 2/6/2014
Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum Wheel Bead Seat Corrosion (Clean and Resurface Wheel Bead Seat)

Released 1/4/2014
Proper Wheel Installation and Wheel Torque Techniques

Released 6/19/2013
Repair Information for Reconnection of Rear Window Defroster (Defogger) Contact or Tab

Released 6/19/2013
Global Information for GM dexos 1 and dexos 2 Engine Oil Specifications, Licensed Brands, and Service Fill

Released 6/19/2013
Dealership Service Consultant Procedure as Vehicle Comes into Service Drive for Tire Pressure Monitor (TPM) System Message, Light and Customer Information

Released 6/19/2013
Information on Slight Vehicle Movement in Park at Start Up After Cold Soak

Released 4/23/2013
Odometer Servicing When The Odometer Cannot Be Set To The Actual Mileage

Released 4/12/2013
Information on Driveline Clunk Noise

Released 3/29/2013
Vehicle Software Enhancements

Released 3/22/2013
Vibration Analysis Worksheet

Released 3/1/2013
Paint-less Dent Repair Process

Released 2/15/2013
Information for Electrical Ground Repair - Use New Replacement Fasteners with Conductive Finish

Released 2/15/2013
Windshield Wiper Performance, Cleaning Instructions and Maintenance

Released 2/11/2013
Prior To Any Circuit Testing

Released 2/8/2013
HYDRA-MATIC Front Wheel Drive 4T80-E (MH1) Left Front Axle Seal Leak, Transmission Slips in Gear (Replace Third Clutch Housing with Revised Service Part)

Released 1/1/2013
Various Driveability Symptoms Due to Clogged Fuel Injectors, MIL/SES DTCs P0171, P0172, P0174, P0300, P1174, P1175 (Clean Fuel Injectors and/or Perform Injector Test With AFIT CH-47976)

Released 9/4/2012
IPC Odometer Programming Method Quick Reference Guide

Released 9/4/2012
Information on Normal Maintenance or Warranty Service for 4T40, 4T45, 4T65, 4L60 Automatic Transmission Oil Pan Magnet Upgrade

Released 3/19/2012
Hem Flange Rust Repair

Released 1/19/2012
Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability

Released 1/19/2012
Damaged, Disassembled or Improperly Packaged Turbochargers Returned to Warranty Parts Center

Released 1/13/2012
Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability

Released 1/12/2012
Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability

Released 10/24/2011
Use of Surface Conditioning Disks When Cleaning Engine Gasket Sealing Surfaces and/or Reused Engine Parts

Released 10/22/2011
Warranty Code Generated By EL-50313 Midtronics GR8 Battery Tester/Charger Required for Claim Processing On Labor Operation 4041510 and Battery Part Restriction (North America ONLY)

Released 10/17/2011
Safety Belt Locking Conditions (Normal Operating Characteristics)

Released 10/13/2011
Eliminating Unwanted Odors in Vehicles

Released 7/22/2011
Car and Truck Fix it Right the First Time Issues

Released 7/22/2011
Car and Truck Fix it Right the First Time Issues

Released 7/15/2011
Key Code Security Rules and Information on GM KeyCode Look-Up Application (Canada Only)

Released 6/7/2011
Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability

Released 2/21/2011
Windshield Wiper Performance, Cleaning Instructions and Maintenance

Released 2/2/2011
Seat Belt Buckle Latching Issues and/or Seat Belt Warning Lights Illuminated

Released 12/23/2010
Information on Passenger Presence Sensing System (PPS or PSS) Concerns with Custom Upholstery, Accessory Seat Heaters or Other Comfort Enhancing Devices

Released 12/21/2010
Warranty Information-Fascia Refinish Labor Operations

Released 11/22/2010
Diesel Engine Turbocharger Performance DTC P2563

Released 11/19/2010
Application of Anti-Corrosion Materials

Released 10/21/2010
Safety Belt Locking Conditions (Normal Operating Characteristics)

Released 10/14/2010
Warranty Administration-Warranty Claims Submission-Outside Rearview Mirrors

Released 9/14/2010
Car and Truck Fix It Right the First Time Issues

Released 9/10/2010
Distortion in Outer Surface of Vehicle Glass

Released 6/30/2010
Information on Hem Flange Sealer for Corrosion Protection

Released 6/30/2010
Squeeze Type Resistance Spot Welding/Equipment

Released 5/27/2010
Key Code Security Rules and Information on GM KeyCode Look-Up Application (Canada Only)

Released 5/27/2010
Key Code Security Rules and Information on GM KeyCode Look-Up Application (U.S. Only)

Released 4/28/2010
New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores

Released 4/27/2010
Interior Cleaning-Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer-Product Availability

Released 3/30/2010
Information on Proper Use of Floor Mats

Released 3/11/2010
Key Code Security Rules and Information on GM KeyCode Look-Up Application

Released 3/10/2010
Intermittent MIL/SES, DTC P2138 with Reduced Engine Power (Repair Instrument Panel (IP) to Body Harness Connector)

Released 3/8/2010
Information on Driver or Passenger Seat Head Restraint Concerns with Comfort, Custom Upholstery or Other Comfort Enhancing Devices

Released 3/4/2010
Car and Truck Fix It Right the First Time Issues

Released 2/25/2010
Information on Heated Electrochromatic Outside Rearview Mirror Performance

Released 2/24/2010
Information on Passenger Presence Sensing System (PPS or PSS) Concerns with Custom Upholstery, Accessory Seat Heaters or Other Comfort Enhancing Devices

Released 2/4/2010
Car and Truck Fix It Right the First Time Issues

Released 1/14/2010
Preventing Damage on Dealer Lots During Longer Periods in Dealer Inventory and Maintaining High CSI Scores

Released 11/24/2009
Service Engine Soon (SES) Light Illuminated, Reduced Engine Power Mode, DTCs P0101, P0106, P0107, P0108, P0299, P0652 or P0653 Set (Install Body to Frame Shims)

Released 11/12/2009
Preventing Damage on Dealer Lots During Longer Periods in Dealer Inventory and Maintaining High CSI Scores

Released 11/4/2009
Car and Truck Fix It Right the First Time Issues

Released 11/4/2009
Safety Belt Locking Conditions (Normal Operating Characteristics)

Released 10/20/2009
Information on Side Door Window Glass Chipping Caused by Hanging Vehicle Key Lock Box

Released 10/6/2009
Information on Passenger Presence System (PPS or PSS) Concerns with Custom Upholstery, Accessory Seat Heaters or Other Comfort Enhancing Devices

Released 9/25/2009
Information on Discoloration, Blistering, Peeling or Erosion of Various Exterior Emblems Including Chevy Bowtie (Bulletin Canceled)

Released 9/18/2009
Clear Stain or Film on Inside Perimeter of Windshield Glass (Clean/Polish Glass)

Released 8/27/2009
Minor Wrinkles/Creases, Discoloration, Cigarette Burns and Customer Induced Cuts and Stains on Front and Rear Driver and Passenger Seats with Leather, Vinyl or Cloth Seat Covers

Released 8/13/2009
Information on Paint Stain Under Protective Shipping Film

Released 8/13/2009
Information on Body Control Module (BCM) Grounds

Released 7/29/2009
Information on Maintaining Exterior Weatherstrip Appearance

Released 6/22/2009
Bumps or Rust Colored Spots in Paint Due to Rail or Iron Dust (Remove Rail Dust)

Released 6/8/2009
New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores

Released 6/4/2009
Seat Belt Latch Stop Button Available for Service

Released 5/26/2009
Repair Information for Reconnection of Rear Window Defroster Contact or Tab

Released 5/18/2009
Interior Cleaning-Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl. Fabric Cleaner, Stain Remover, Restorer - Product Availability

Released 5/12/2009
Negative Impact of Dealer-Installed Cloth/Viny Roofs on XM Radio and/or OnStar Systems

Released 5/11/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 5/6/2009
Car and Truck Fix It Right the First Time Issues

Released 4/23/2009
IPC Odometer Programming Method Quick Reference

Released 3/19/2009
Marks/Stains on Windshield When Wet (Clean Windshield)

Released 3/9/2009
New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores

Released 3/9/2009
Warranty Administration - Guidelines for Claiming C0034 - Windshield Replacement

Released 3/9/2009
Car and Truck Fix It Right the First Time Issues

Released 2/24/2009
GM Accessories VPO/LPO Programs - Reimbursement for Dealer Labor

Released 2/17/2009
Seat Belt Buckle Latching Issues and/or Seat Belt Warning Lights Illuminated

Released 2/16/2009
Warranty Administration - Labor Operation Z1241 - Personal Property Damage

Released 2/3/2009
Hem Flange Rust Repair

Released 1/28/2009
Non-Approval of Clipping (Sectioning of Two Vehicles) for Collision Repair

Released 1/8/2009
Preventing Damage on Dealer Lots During Longer Periods in Dealer Inventory and Maintaining High CSI Scores

Released 1/6/2009
Information on Curb Park Assist and Memory Related Issues on Outside Rearview Mirrors

Released 12/12/2008
Information on Passenger Presence Sensing System (PPS or PSS) Concerns with Custom Upholstery, Accessory Seat Heaters or Other Comfort Enhancing Devices

Released 8/25/2008
Chrome Front Bumper Revised Procedure to Install Washers Behind Bumper to Aid in Installation Without Damage to Bumper

Released 1/17/1997
Car and Truck Fix it Right the First Time Issues

Released 7/22/2011
Car and Truck Fix it Right the First Time Issues

Released 4/19/2011
Disc Brake Warranty Service and Procedures

Released 1/14/2010
Preventing Damage on Dealer Lots During Longer Periods in Dealer Inventory and Maintaining High CSI Scores

Released 11/12/2009
Preventing Damage on Dealer Lots During Longer Periods in Dealer Inventory and Maintaining High CSI Scores

Released 5/11/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 5/6/2009
Car and Truck Fix It Right the First Time Issues

Released 3/26/2009
Disc Brake Warranty Service and Procedures

Released 3/9/2009
Car and Truck Fix It Right the First Time Issues

Released 1/8/2009
Preventing Damage on Dealer Lots During Longer Periods in Dealer Inventory and Maintaining High CSI Scores

Released 1/17/1997
Car and Truck Fix it Right the First Time Issues

Released 4/18/2011
New Tool Availability - EN-48974 - EGR Cooler Pressure Tester Adapter Set to Diagnose Duramax Diesel Engine EGR Cooler Engine Coolant Leaks into Combustion Chamber

Released 3/2/2011
Automatic Transmission Oil Cooler Flush and Flow Test Essential Tool J-45096 TransFlow

Released 4/29/2010
Unnecessary Flushing Services, Additive Recommendations and Proper Utilization of GM Simplified Maintenance Schedule to Enhance Customer Service Experience

Released 9/9/2009
Automatic Transmission Oil Cooler Flush and Flow Test Essential Tool J 45096 TransFlow

Released 5/11/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 5/5/2009
Engine Oil Leaks from Charge Air Cooler and Turbocharger Air Inlet Adapter (Replace Clamp and/or Turbo Inlet Duct/Pipe)

Released 3/20/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 1/27/2009
Check Engine Light On, Possible Crank/No Start, DTCs P0526 and/or P0642 (Follow SI Diagnostics/Replace Fan Clutch)

Released 9/14/2013
OnStar Will Not Power Up

Released 6/19/2013
Repair Information for Reconnection of Rear Window Defroster (Defogger) Contact or Tab

Released 6/19/2013
Global Information for GM dexos 1 and dexos 2 Engine Oil Specifications, Licensed Brands, and Service Fill

Released 6/19/2013
Information on Slight Vehicle Movement in Park at Start Up After Cold Soak

Released 4/23/2013
Odometer Servicing When The Odometer Cannot Be Set To The Actual Mileage

Released 4/12/2013
Information on Driveline Clunk Noise

Released 3/29/2013
Vehicle Software Enhancements

Released 3/29/2013
Powertrain and Various Electrical/Electronic Control Issues

Released 3/22/2013
Aftermarket ALDL or DLC Interface Devices Causing Multiple Issues

Released 3/22/2013
Vibration Analysis Worksheet

Released 3/22/2013
OnStar Will Not Power Up

Released 3/1/2013
Paint-less Dent Repair Process

Released 3/1/2013
DVD Navigation Update Program, Navigation Disc Diagnostic Aid, AVN Software Update Discs and Ordering Information

Released 2/15/2013
Information for Electrical Ground Repair - Use New Replacement Fasteners with Conductive Finish

Released 2/15/2013
Windshield Wiper Performance, Cleaning Instructions and Maintenance

Released 2/11/2013
Prior To Any Circuit Testing

Released 1/1/2013
IPC Odometer Programming Method Quick Reference Guide

Released 3/3/2012
Warranty, SPS, Control Module Diagnostics and Configuration Information, Programming, Set-Up

Released 2/10/2012
Service Programming System (SPS) Errors (E4398, E4399, E4403, E4404 E4413, E4414, E4423 or E4491, E4494)

Released 10/22/2011
Warranty Code Generated By EL-50313 Midtronics GR8 Battery Tester/Charger Required for Claim Processing On Labor Operation 4041510 and Battery Part Restriction (North America ONLY)

Released 7/22/2011
Car and Truck Fix it Right the First Time Issues

Released 6/6/2011
Information for Electrical Ground Repair - Use New Replacement Fasteners with Conductive Finish

Released 5/19/2011
IPC Odometer Programming Method Quick Reference Guide

Released 5/13/2011
Headlamp, Tail Lamp or Fog/Driving Lamp Damage

Released 2/2/2011
Seat Belt Buckle Latching Issues and/or Seat Belt Warning Lights Illuminated

Released 1/5/2011
Exterior Lamp Condensation and Replacement Guidelines

Released 12/23/2010
OnStar Phone Number Concerns (Phone Number Incorrect/Assigned to Another Vehicle/Phone) That Occur During Diagnosis of OnStar System

Released 12/8/2010
Intermittent No Crank/No Start, No Module Communication, MIL, Warning Lights, Messages or DTCs Set by Various Control Modules-Diagnosing and Repairing Fretting Corrosion

Released 12/6/2010
IPC Odometer Programming Method Quick Reference Guide

Released 10/25/2010
Information for Electrical Ground Repair - Use New Replacement Fasteners with Conductive Finish

Released 10/18/2010
Warranty Code Generated by El-50313/Charger Required for N0110, Battery Parts Rest

Released 9/14/2010
Car and Truck Fix It Right the First Time Issues

Released 6/28/2010
Intermittent Malfunction Indicator Lamp (MIL) Illuminated, DTC P2138 with Reduced Engine Power (Repair Instrument Panel (IP) to Body Harness Connector)

Released 6/11/2010
Information on Inappropriate Warranty Claims Submitted for Damaged Radios and Instrument Panel Clusters (IPCs)

Released 6/4/2010
Information for Electrical Ground Repair - Use New Replacement Fasteners with Conductive Finish

Released 4/28/2010
New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores

Released 3/10/2010
Intermittent MIL/SES, DTC P2138 with Reduced Engine Power (Repair Instrument Panel (IP) to Body Harness Connector)

Released 3/9/2010
Battery Part Restriction Program Effective March 1, 2008

Released 3/5/2010
Information for Electrical Ground Repair-Use New Replacement Fasteners with Conductive Finish

Released 3/4/2010
Car and Truck Fix It Right the First Time Issues

Released 2/11/2010
DVD Navigation Update Program, Navigation Disc Diagnostic Aid, AVN Software Update Discs and Ordering Information

Released 2/4/2010
Car and Truck Fix It Right the First Time Issues

Released 1/14/2010
Preventing Damage on Dealer Lots During Longer Periods in Dealer Inventory and Maintaining High CSI Scores

Released 11/24/2009
Intermittent No Crank/No Start, No Module Communication, MIL, Warning Lights, Vehicle Messages or DTCs Set by Various Control Modules-Diagnosing and Repairing Fretting Corrosion

Released 11/24/2009
Service Engine Soon (SES) Light Illuminated, Reduced Engine Power Mode, DTCs P0101, P0106, P0107, P0108, P0299, P0652 or P0653 Set (Install Body to Frame Shims)

Released 11/12/2009
Preventing Damage on Dealer Lots During Longer Periods in Dealer Inventory and Maintaining High CSI Scores

Released 11/10/2009
Air Compressor Belt/Serpentine Belt Noise (Replace Air Compressor Belt Tensioner)

Released 11/4/2009
Car and Truck Fix It Right the First Time Issues

Released 10/6/2009
Information on Passenger Presence System (PPS or PSS) Concerns with Custom Upholstery, Accessory Seat Heaters or Other Comfort Enhancing Devices

Released 9/1/2009
Intermittent No Crank/No Start, No Module Communication, MIL, Warning Lights, Vehicle Messages or DTCs Set by Various Control Modules (Disconnect Affected Connector and Apply Dielectric Lubricant)

Released 8/27/2009
Minor Wrinkles/Creases, Discoloration, Cigarette Burns and Customer Induced Cuts and Stains on Front and Rear Driver and Passenger Seats with Leather, Vinyl or Cloth Seat Covers

Released 8/13/2009
Information on Body Control Module (BCM) Grounds

Released 7/27/2009
Diagnosing Accessory Drive Belt/Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool-Drive Belt

Released 6/11/2009
Replacement of Headlamp Assemblies Under Warranty and Use of GM vs. Non-GM Headlamp Assemblies

Released 6/8/2009
New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores

Released 5/12/2009
Negative Impact of Dealer-Installed Cloth/Viny Roofs on XM Radio and/or OnStar Systems

Released 5/11/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 5/6/2009
Car and Truck Fix It Right the First Time Issues

Released 5/4/2009
Exterior Lamp Condensation and Replacement Guidelines

Released 4/29/2009
Malfunction Indicator Lamp (MIL) Illuminated, Intermittent DTC P0191, Slow Fuel Rail Pressure (FRP) Decay, Wiring Harness Connections, Voltage Fluctuations/Interruptions (Follow Correction Info Below)

Released 4/23/2009
IPC Odometer Programming Method Quick Reference

Released 4/14/2009
Part Restriction on Ordering OnStar Generation 7 and 8 Vehicle Communication Interface Modules (VCIM)

Released 3/20/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 3/9/2009
New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores

Released 3/9/2009
Navigation Radio Diagnostic Tips

Released 3/9/2009
Car and Truck Fix It Right the First Time Issues

Released 2/17/2009
Seat Belt Buckle Latching Issues and/or Seat Belt Warning Lights Illuminated

Released 2/11/2009
Key Code Security Rules and Information on GM KeyCode Look-Up Application

Released 2/6/2009
GM Training - February 2009 New Course Information (For U.S. Dealers and Aftermarket)

Released 1/20/2009
Information on Verifying OnStar System Function During Pre-Delivery Inspection (PDI)

Released 1/8/2009
Preventing Damage on Dealer Lots During Longer Periods in Dealer Inventory and Maintaining High CSI Scores

Released 1/6/2009
Information on Curb Park Assist and Memory Related Issues on Outside Rearview Mirrors

Released 12/17/2008
Replacement of Headlamp Assemblies Under Warranty and Use of GM vs. Non-GM Headlamp Assemblies

Released 12/12/2008
Information on Passenger Presence Sensing System (PPS or PSS) Concerns with Custom Upholstery, Accessory Seat Heaters or Other Comfort Enhancing Devices

Released 11/26/2008
GM Training - December 2008 New Course Information (For U.S. Dealers and Aftermarket)

Released 11/6/2008
Intermittent MIL/SES, DTC P2138 with Reduced Engine Power (Repair Instrument Panel (IP) to Body Harness Connector)

Released 10/29/2008
Reducing Electrical Intermittents-Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Misc. DTCs, Intermittent Driveability Concerns, Hard/No

Released 1/17/1997
Car and Truck Fix it Right the First Time Issues

Released 3/22/2013
Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V6 and V8 Gasoline Engines Using Tech 2 or Global Diagnostic System 2 (GDS 2)

Released 2/1/2013
Aftermarket ALDL or DLC Interface Devices Causing Multiple Issues

Released 9/4/2012
Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V8 Gasoline Engines Using Tech 2 or Global Diagnostic System 2 (GDS 2)

Released 3/3/2012
Warranty, SPS, Control Module Diagnostics and Configuration Information, Programming, Set-Up

Released 2/10/2012
Service Programming System (SPS) Errors (E4398, E4399, E4403, E4404 E4413, E4414, E4423 or E4491, E4494)

Released 7/22/2011
Car and Truck Fix it Right the First Time Issues

Released 8/6/2010
Information on Drilling High Strength Steel Related to Collision Repair

Released 3/4/2010
Clean Exhaust Filter See Owners Manual Now Message Displayed on Driver Information Center (DIC), DTC P2463 May Be Set-Inform Customer on Driving Conditions Required for Self Cleaning of Diesel

Released 11/13/2009
Information on Diesel Particulate Filter Regeneration

Released 6/19/2009
Procedure to Take Snapshot Data with Tech 2 and Upload Data to Computer Using TIS Software

Released 5/18/2009
Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V8 Gas Engines

Released 5/11/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 5/6/2009
Car and Truck Fix It Right the First Time Issues

Released 4/29/2009
Malfunction Indicator Lamp (MIL) Illuminated, Intermittent DTC P0191, Slow Fuel Rail Pressure (FRP) Decay, Wiring Harness Connections, Voltage Fluctuations/Interruptions (Follow Correction Info Below)

Released 3/9/2009
Car and Truck Fix It Right the First Time Issues

Released 1/9/2009
Warranty, SPS, Control Module Diagnostics and Configuration Information, Programming, Set-Up

Released 10/30/2008
Procedure to Take Snapshot Data with a Tech 2 and Upload Data to Computer Using TIS Software

Released 10/29/2008
Information on Identifying Non-GM Calibration Usages for LBZ, LLY, LMM Duramax Diesel Engines

Released 1/17/1997
Car and Truck Fix it Right the First Time Issues

Released 2/1/2013
Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V6 and V8 Gasoline Engines Using Tech 2 or Global Diagnostic System 2 (GDS 2)

Released 1/1/2013
Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V8 Gasoline Engines Using Tech 2 or Global Diagnostic System 2 (GDS 2)

Released 9/14/2010
Car and Truck Fix It Right the First Time Issues

Released 10/28/2009
Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V8 Gas Engines

Released 5/11/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 5/6/2009
Car and Truck Fix It Right the First Time Issues

Released 3/20/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 1/30/2009
Information on Sulfur Odor from Exhaust

Released 1/22/2016
DTCs P003A and P2563 Setting After Turbocharger Replacement

Released 10/31/2015
Cleaning Diesel Engine Fuel Injectors

Released 7/16/2014
Duramax Diesel Glow Plugs Difficult to Install Due to Carbon Buildup - New Glow Plug Bore Reamer Available

Released 1/1/2013
Various Driveability Symptoms Due to Clogged Fuel Injectors, MIL/SES DTCs P0171, P0172, P0174, P0300, P1174, P1175 (Clean Fuel Injectors and/or Perform Injector Test With AFIT CH-47976)

Released 1/19/2012
Damaged, Disassembled or Improperly Packaged Turbochargers Returned to Warranty Parts Center

Released 7/22/2011
Car and Truck Fix it Right the First Time Issues

Released 7/15/2011
Key Code Security Rules and Information on GM KeyCode Look-Up Application (Canada Only)

Released 12/8/2010
General Motors Position Regarding the Environmental Protection Agencys Partial Waiver Announcement Allowing the Use of E 15 in MY 2007 and Newer Vehicles

Released 11/22/2010
Diesel Engine Turbocharger Performance DTC P2563

Released 10/27/2010
TOP TIER Detergent Gasoline Information and Available Brands (Deposits, Fuel Economy, No Start, Stall Concerns) Canada Only

Released 4/29/2010
Unnecessary Flushing Services, Additive Recommendations and Proper Utilization of GM Simplified Maintenance Schedule to Enhance Customer Service Experience

Released 3/4/2010
Car and Truck Fix It Right the First Time Issues

Released 2/12/2010
Engine Oil Leaks from Charge Air Cooler and Turbocharger Air Inlet Adapter (Replace Clamp and/or Turbo Inlet Duct/Pipe)

Released 2/4/2010
Car and Truck Fix It Right the First Time Issues

Released 1/28/2010
Malfunction Indicator Lamp (MIL) Illuminated, Intermittent DTC P0191, Slow Fuel Rail Pressure (FRP) Decay, Wiring Harness Connections, Voltage Fluctuations/Interruptions (Follow Correction Information

Released 1/22/2010
Rear In-Frame Fuel Tank Strap Bolts Appear Not To Be Tightened Completely

Released 1/14/2010
Preventing Damage on Dealer Lots During Longer Periods in Dealer Inventory and Maintaining High CSI Scores

Released 11/17/2009
Paint Peeling on Saddle Type Fuel Tanks (Refinish Tanks)

Released 11/10/2009
Information on Servicing Duramax Diesel Fuel Injectors to Avoid and Remove Contamination

Released 9/2/2009
Paint Peeling on Saddle Type Fuel Tanks (Refinish Tanks)

Released 8/17/2009
TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - Canada ONLY

Released 8/17/2009
TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only

Released 5/11/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 5/6/2009
Car and Truck Fix It Right the First Time Issues

Released 5/5/2009
Engine Oil Leaks from Charge Air Cooler and Turbocharger Air Inlet Adapter (Replace Clamp and/or Turbo Inlet Duct/Pipe)

Released 4/29/2009
Malfunction Indicator Lamp (MIL) Illuminated, Intermittent DTC P0191, Slow Fuel Rail Pressure (FRP) Decay, Wiring Harness Connections, Voltage Fluctuations/Interruptions (Follow Correction Info Below)

Released 4/22/2009
Various Driveability Symptoms Due to Clogged Fuel Injectors, MIL/SES DTCs P0171, P0172, P0174, P0300, P1174, P1175 (Clean Fuel Injectors and/or Perform Injector Test with AFIT CH-47976)

Released 3/20/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 3/9/2009
Car and Truck Fix It Right the First Time Issues

Released 3/2/2009
Information on Improved Fuel Filter for 6.6L Duramax Diesel Engine

Released 1/30/2009
Information on Sulfur Odor from Exhaust

Released 1/13/2009
Information on Diesel Fuel Additives

Released 11/6/2008
GM Training - November 2008 New Course Information (For U.S. Dealers and Aftermarket)

Released 8/10/2011
Air Conditioning Odor (Install Evaporator Core Dryer Kit and Apply Cooling Coil Coating)

Released 7/22/2011
Car and Truck Fix it Right the First Time Issues

Released 4/11/2011
Repair Information for Reconnection of Rear Window Defroster Contact or Tab

Released 12/23/2010
Information on Passenger Presence Sensing System (PPS or PSS) Concerns with Custom Upholstery, Accessory Seat Heaters or Other Comfort Enhancing Devices

Released 4/29/2010
Unnecessary Flushing Services, Additive Recommendations and Proper Utilization of GM Simplified Maintenance Schedule to Enhance Customer Service Experience

Released 3/4/2010
Car and Truck Fix It Right the First Time Issues

Released 2/25/2010
Repair Information for Reconnection of Rear Window Defroster Contact or Tab

Released 2/4/2010
Car and Truck Fix It Right the First Time Issues

Released 6/12/2009
Air Conditioning Odor (Install Evaporator Core Dryer Kit and Apply Cooling Coil Coating)

Released 5/26/2009
Repair Information for Reconnection of Rear Window Defroster Contact or Tab

Released 5/11/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 5/6/2009
Car and Truck Fix It Right the First Time Issues

Released 3/20/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 10/31/2015
Allison LCT1000 Clunk When Shifting Into Or Out Of Park or On Start Up In Park

Released 8/1/2015
Information for Identifying Non-GM ECM Calibration Use and Power-up Hardware Detection in Duramax Diesel Engines - Photograph Tech 2 Calibration IDs, Calibration Verification Numbers (CVNs) and Transmission Data Screen

Released 5/12/2015
Information on Higher Than Expected Oil Consumption

Released 8/26/2014
Information on Identifying Duramax Diesel Overpower Engine Breakdown/Non-Function Due to Aftermarket Power-Up Devices vs Non Overpower Engine Non-Function of Pistons, Cylinders, Valvetrain Components, DTC P003A or P111D Set

Released 7/17/2014
Alleged Cylinders Out Of Round

Released 6/19/2013
Global Information for GM dexos 1 and dexos 2 Engine Oil Specifications, Licensed Brands, and Service Fill

Released 6/19/2013
Information on Slight Vehicle Movement in Park at Start Up After Cold Soak

Released 4/12/2013
Information on Driveline Clunk Noise

Released 3/22/2013
Aftermarket ALDL or DLC Interface Devices Causing Multiple Issues

Released 3/22/2013
Vibration Analysis Worksheet

Released 3/22/2013
Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V6 and V8 Gasoline Engines Using Tech 2 or Global Diagnostic System 2 (GDS 2)

Released 2/8/2013
HYDRA-MATIC Front Wheel Drive 4T80-E (MH1) Left Front Axle Seal Leak, Transmission Slips in Gear (Replace Third Clutch Housing with Revised Service Part)

Released 2/1/2013
Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V6 and V8 Gasoline Engines Using Tech 2 or Global Diagnostic System 2 (GDS 2)

Released 1/1/2013
Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V8 Gasoline Engines Using Tech 2 or Global Diagnostic System 2 (GDS 2)

Released 9/4/2012
Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V8 Gasoline Engines Using Tech 2 or Global Diagnostic System 2 (GDS 2)

Released 9/4/2012
Information on Normal Maintenance or Warranty Service for 4T40, 4T45, 4T65, 4L60 Automatic Transmission Oil Pan Magnet Upgrade

Released 5/23/2012
Guidelines for Usage of Transmission K Labor Operation Recondition Add Time (Bulletin Canceled)

Released 3/27/2012
Information on Diesel Engine Ticking Noise

Released 3/5/2012
Warranty, SPS, Control Module Diagnostics and Configuration Information, Programming, Set-Up

Released 3/3/2012
Warranty, SPS, Control Module Diagnostics and Configuration Information, Programming, Set-Up

Released 10/24/2011
Use of Surface Conditioning Disks When Cleaning Engine Gasket Sealing Surfaces and/or Reused Engine Parts

Released 7/22/2011
Car and Truck Fix it Right the First Time Issues

Released 5/17/2011
Information on Slight Vehicle Movement in Park at Start Up After Cold Soak

Released 5/6/2011
Information on Driveline Clunk Noise when Shifting Between PARK and DRIVE, PARK and REVERSE or DRIVE and REVERSE

Released 4/28/2011
Information on Diesel Engine Ticking Noise

Released 4/7/2011
Release of DEXRON-VI Automatic Transmission Fluid (ATF)

Released 3/28/2011
Engine and Automatic Transmission/Transaxle Identification

Released 2/7/2011
Identifying Non-GM ECM Calibration Usages for Duramax Diesel Engines and Power-up Hardware Detection

Released 12/15/2010
Manual Transmission Operating Characteristics

Released 11/18/2010
Information - Non-GM Parts and Accessories (Aftermarket)

Released 11/1/2010
Information on Water or Ethylene Glycol in Transmission Fluid

Released 10/6/2010
Information on Duramax Valve Guide and Valve Stem Oil Seal Change

Released 9/14/2010
Car and Truck Fix It Right the First Time Issues

Released 8/6/2010
Information on Drilling High Strength Steel Related to Collision Repair

Released 7/23/2010
Information on Engine Ticking Noise

Released 5/12/2010
Warranty Administration - Change in Automatic Transmission Add Condition Documentation and Claim Submission

Released 5/7/2010
Identifying Aftermarket Engine and Transmission Calibrations-GasPowered Engines Only and Automatic Transmission

Released 4/29/2010
Unnecessary Flushing Services, Additive Recommendations and Proper Utilization of GM Simplified Maintenance Schedule to Enhance Customer Service Experience

Released 3/31/2010
Information on Identifying Duramax Diesel LB7, LLY, LMM, LBZ Overpower Engine Breakdown/Non-Function Due to Aftermarket Power-Up Devices vs Non Overpower Engine Non-Function of Pistons, Cylinders

Released 3/4/2010
Car and Truck Fix It Right the First Time Issues

Released 2/24/2010
Information on Identifying Duramax Diesel LB7, LLY, LMM, LBZ Overpower Engine Breakdown or Non-Function Due to Aftermarket Power-Up Devices vs Non-Overpower Engine Non-Function of Pistons, Cylinders

Released 2/23/2010
Current Model Year Goodwrench Transmission Replacement Assembly Program

Released 2/5/2010
Information on 2-3 Upshift or 3-2 Downshift Clunk Noise

Released 2/4/2010
Car and Truck Fix It Right the First Time Issues

Released 2/3/2010
Intake Manifold Inspection/Replacement After Severe Internal Engine Damage

Released 1/12/2010
Guidelines for Usage of Transmission K Labor Operation Recondition Add Time

Released 12/17/2009
Warranty Administration - Change in Automatic Transmission Add Condition Documentation and Claim Submission

Released 12/11/2009
Unnecessary Engine Crankcase and Subsystems Flushing Services, Additive Recommendations and Proper Utilization of GM Simplified Maintenance Schedule to Enhance Customer Service Experience

Released 12/1/2009
Information on Water or Ethylene Glycol in Transmission Oil

Released 11/13/2009
Current Model Year Goodwrench Transmission Replacement Assembly Program

Released 11/9/2009
Identifying Non-GM ECM Calibration Usages and Power-Up Hardware Detection for Duramax Diesel Engines-Photograph Tech 2 Calibration IDs and CVNs and Trans Data Screen Before Removing Engine/Trans

Released 11/4/2009
Car and Truck Fix It Right the First Time Issues

Released 11/2/2009
Information on Driveline Clunk Noise When Shifting Between PARK and DRIVE, PARK and REVERSE or DRIVE and REVERSE

Released 10/28/2009
Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V8 Gas Engines

Released 10/6/2009
Product Quality Center (PQC) for Engine, Transmission Assembly and Transfer Case Replacement

Released 10/1/2009
Engine and Automatic Transmission/Transaxle Identification

Released 9/14/2009
Info on Identifying Duramax Diesel LB7, LLY, LMM, LBZ Overpower Engine Breakdown or Non-Function Due to Aftermarket Power-Up Devices vs Non-Overpower Engine Non-Function of Pistons, Cylinders, Valve

Released 9/9/2009
Automatic Transmission Oil Cooler Flush and Flow Test Essential Tool J 45096 TransFlow

Released 7/29/2009
Manual Transmission Operating Characteristics

Released 7/27/2009
Information on Internal Engine Noise or Damage After Oil Filter Replacement

Released 7/22/2009
Guidelines for Usage of Transmission K Labor Operation Recondition Add Time

Released 6/24/2009
Allison Transmission Service Repairs

Released 6/15/2009
GM Training - June 2009 New Course Information (For U.S. Dealers and Aftermarket)

Released 6/3/2009
New Ordering Process for Propeller Shafts or Prop-Shaft Systems Through GMSPO

Released 5/18/2009
Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V8 Gas Engines

Released 5/11/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 5/6/2009
Car and Truck Fix It Right the First Time Issues

Released 5/5/2009
Engine Oil Leaks from Charge Air Cooler and Turbocharger Air Inlet Adapter (Replace Clamp and/or Turbo Inlet Duct/Pipe)

Released 5/5/2009
Information on Normal Maintenance or Warranty Service for 4T40, 4T45, 4T65, 4L60 Automatic Transmission Oil Pan Magnet Upgrade

Released 5/1/2009
Vibration Analysis Worksheet

Released 4/29/2009
Ticking Noise Coming From Engine Compartment (Inspect/Replace Rocker Arms, Rocker Arm Balls)

Released 4/24/2009
Information on Engine Ticking Noise

Released 3/20/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 3/9/2009
Car and Truck Fix It Right the First Time Issues

Released 2/6/2009
GM Training - February 2009 New Course Information (For U.S. Dealers and Aftermarket)

Released 1/29/2009
Diagnostic Tips for Automatic Transmission DTC P0756, Second, Third, Fourth Gear Start

Released 1/12/2009
GM Training - January 2009 New Course Information (For U.S. Dealers and Aftermarket)

Released 1/12/2009
Information on Higher Than Expected Oil Consumption

Released 1/12/2009
Warranty Administration - Labor Op T2020 - Tow, Add Time to Reconnect Prop Shaft

Released 1/9/2009
Information on Engine Ticking Noise

Released 1/8/2009
Preventing Damage on Dealer Lots During Longer Periods in Dealer Inventory and Maintaining High CSI Scores

Released 12/18/2008
Identifying Aftermarket Engine and Transmission Calibrations 2.0L, 2.2L, 2.4L, 2.8L, 2.9L, 3.0L, 3.1L, 3.2L, 3.4L 3.5L, 3.6L, 3.8L, 3.9L, 4.2L, 4.3L, 4.4L, 4.6L, 5.0L, 5.3L, 5.7L 6.0L, 6.2L 7.0L, 7.4L

Released 12/17/2008
Higher Than Expected Oil Consumption at 8600 GVW and Above

Released 11/26/2008
GM Training - December 2008 New Course Information (For U.S. Dealers and Aftermarket)

Released 11/6/2008
GM Training - November 2008 New Course Information (For U.S. Dealers and Aftermarket)

Released 1/17/1997
Car and Truck Fix it Right the First Time Issues

Released 2/17/2017
Product Emission - Emission Label Visibility

Released 6/21/2013
Product Safety - Recall of Master Cylinders (used with Hydro-Max Booster)

Released 2/6/2014
Vibration Shortly After Tires are Mounted/Preventing Vibration from Wheel Slip (Tire Sliding on Wheel)

Released 1/4/2014
Proper Wheel Installation and Wheel Torque Techniques

Released 6/19/2013
Dealership Service Consultant Procedure as Vehicle Comes into Service Drive for Tire Pressure Monitor (TPM) System Message, Light and Customer Information

Released 3/22/2013
Aftermarket ALDL or DLC Interface Devices Causing Multiple Issues

Released 3/22/2013
Vibration Analysis Worksheet

Released 1/1/2013
Proper Wheel Installation and Wheel Torque Techniques

Released 5/17/2012
Information on Slight or Mild Tire Feathering and Recommended Practices (Normal Tire Wear Condition)

Released 3/27/2012
Hydraulic Power Steering System Leak - Required Diagnostic Actions

Released 12/3/2011
Information on Diagnosis and Replacement of Shock Absorber and Strut Due to Fluid Leak

Released 7/22/2011
Car and Truck Fix it Right the First Time Issues

Released 4/21/2011
Chemical Staining, Pitting, Corrosion and/or Spotted Appearance of Chromed Aluminum Wheels

Released 3/17/2011
Refinishing Aluminum Wheels

Released 12/13/2010
Guidelines for Using Labor Operations E0200, E0201, E0203, E0204 - Wheel Balance

Released 12/9/2010
Wheel Alignment Specifications, Requirements and Recommendations for GM Vehicles

Released 9/14/2010
Car and Truck Fix It Right the First Time Issues

Released 6/9/2010
Information on Proper Wheel Changing Procedures and Cautions

Released 6/7/2010
Guidelines for Using Labor Operations E2020 - Wheel Alignments, E2000 - Toe Adjust and E0200, E0201, E0203, E0204 - Wheel Balance

Released 5/19/2010
Warranty Administration - Labor Operation Z1111 - Suspected Tampering or Vehicle Modifications

Released 5/4/2010
Information on Tire Radial Force Variation (RFV)

Released 4/29/2010
Unnecessary Flushing Services, Additive Recommendations and Proper Utilization of GM Simplified Maintenance Schedule to Enhance Customer Service Experience

Released 4/28/2010
New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores

Released 4/27/2010
Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum Wheel Bead Seat Corrosion (Clean and Resurface Wheel Bead Seat)

Released 4/27/2010
Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant)

Released 4/27/2010
Dealership Service Consultant Procedure as Vehicle Comes into Service Drive for Tire Pressure Monitor (TPM) System Message, Light and Customer Information

Released 4/27/2010
Use of Nitrogen Gas in Tires

Released 4/26/2010
TPM System Overview, Diagnosing Tire Pressure Monitor System (TPM) Concerns and TPM Frequently Asked Questions (FAQ)

Released 4/13/2010
Revised GM of Canada New Vehicle Limited Warranty Tire Program and Global Warranty Management (GWM) Submission Rollout Information

Released 3/29/2010
Revised General Motors New Vehicle Tire Warranty Program and Global Warranty Management (GWM) Submission Rollout Information (U.S. Dealers Only)

Released 3/15/2010
Chemical Staining, Pitting, Corrosion and/or Spotted Appearance of Chromed Aluminum Wheels

Released 3/4/2010
Car and Truck Fix It Right the First Time Issues

Released 2/4/2010
Car and Truck Fix It Right the First Time Issues

Released 1/14/2010
Refinishing Aluminum Wheels

Released 1/14/2010
Preventing Damage on Dealer Lots During Longer Periods in Dealer Inventory and Maintaining High CSI Scores

Released 12/17/2009
Information on Replacement Wheel Weights

Released 12/4/2009
Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum Wheel Bead Seat Corrosion (Clean and Resurface Wheel Bead Seat)

Released 12/4/2009
Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant)

Released 12/1/2009
Wheel Balancing Machine Finish Damage to Chrome Clad or ChromeTech Wheels

Released 11/30/2009
GM of Canada New Vehicle Limited Warranty Tire Program

Released 11/12/2009
Preventing Damage on Dealer Lots During Longer Periods in Dealer Inventory and Maintaining High CSI Scores

Released 11/4/2009
Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum Wheel Bead Seat Corrosion (Clean and Resurface Wheel Bead Seat)

Released 11/4/2009
Car and Truck Fix It Right the First Time Issues

Released 11/3/2009
Guidelines for Using Labor Operation E2020-Wheel Alignments, E2000-Toe Adjust and E0200, E0201, E0203, E0204-Wheel Balance

Released 11/3/2009
Information on Tire Radial Force Variation (RFV)

Released 10/30/2009
GM of Canada New Vehicle Limited Warranty Tire Program

Released 10/30/2009
Revised General Motors New Vehicle Tire Warranty Program

Released 10/16/2009
Information on Replacement of Shock Absorbers and Struts Due to Fluid Leaks

Released 10/8/2009
Statement on Tire Sealant Included in GM Inflator Kits (Supplied with New Vehicles or as GM Accessory)

Released 8/20/2009
Diagnostic Tips for Tire Vibration or Steering Wheel Shake (Oscillation) Concerns

Released 8/13/2009
Information on Slight or Mild Tire Feathering and Recommended Practices (Normal Tire Wear Condition)

Released 8/7/2009
Diagnostic Tips/Recommendations When Power Steering Pump Replacement Is Necessary

Released 8/5/2009
Information on Tire/Wheel Characteristics (Vibration, Balance, Shake, Flat Spotting) of GM Original Equipment Tires

Released 7/24/2009
Mounting, Balancing and Installation of Accessory Wheels and Tires Available Through GM Accessories

Released 6/8/2009
New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores

Released 5/11/2009
Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant)

Released 5/11/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 5/4/2009
Dealership Service Consultant Procedure as Vehicle Comes Into Service Drive for Tire Pressure Monitor (TPM) System Message, Light and Customer Information

Released 4/16/2009
Guidelines for Using E2020-Wheel Alignments, E2000-Toe Adjust and E0200, E0201, E0203, E0204-Wheel Balance

Released 4/2/2009
GM Tire Warranty Program Goodwill Guidelines (U.S. Only)

Released 3/31/2009
Use of Chrome or Chrome Plated Steel Valve Caps on Aluminum Valve Stems

Released 3/26/2009
TPM System Overview, Diagnosing Tire Pressure Monitor System (TPM) Concerns and TPM Frequently Asked Questions (FAQ)

Released 3/9/2009
Car and Truck Fix It Right the First Time Issues

Released 2/24/2009
GM Accessories VPO/LPO Programs - Reimbursement for Dealer Labor

Released 1/28/2009
Information on Proper Tire Pressure

Released 1/22/2009
Use of Nitrogen Gas in Tires

Released 1/8/2009
Preventing Damage on Dealer Lots During Longer Periods in Dealer Inventory and Maintaining High CSI Scores

Released 11/26/2008
Information on Tire Radial Force Variation (RFV)

Released 11/26/2008
Information on Slight or Mild Tire Feathering and Recommended Practices (Normal Tire Wear Condition)

Released 11/24/2008
EI07266 - Vehicle/Tire Vibration, P275/55R20, LT245/75R16, P265/70R17, P245/70R17, P285/45R22, LT265/75R17 -- Diagnostic Information to Reduce Vibration Concerns

Released 11/24/2008
Information on Tire/Wheel Characteristics (Vibration, Balance, Shake, Flat Spotting) of GM Original Equipment Tires

Released 1/21/2016
Light and Medium Duty Truck Warranty, Crossline Warranty Eligibility and Guidelines for Chevrolet/GMC Dealers

Released 12/5/2014
New Tool Availability - EN-48974 - EGR Cooler Pressure Tester Adapter Set to Diagnose Duramax Diesel Engine EGR Cooler Engine Coolant Leaks into Combustion Chamber

Released 12/5/2014
Information for Dealers on How to Submit a Product Information Report (PIR) (Canada Only)

Released 7/16/2014
Duramax Diesel Glow Plugs Difficult to Install Due to Carbon Buildup - New Glow Plug Bore Reamer Available

Released 2/6/2014
Information on Slight or Mild Tire Feathering and Recommended Practices (Normal Tire Wear Condition)

Released 6/7/2013
IPC Odometer Programming Method Quick Reference Guide

Released 3/22/2013
Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V6 and V8 Gasoline Engines Using Tech 2 or Global Diagnostic System 2 (GDS 2)

Released 3/1/2013
Paint-less Dent Repair Process

Released 1/1/2013
IPC Odometer Programming Method Quick Reference Guide

Released 3/19/2012
Hem Flange Rust Repair

Released 3/5/2012
Warranty, SPS, Control Module Diagnostics and Configuration Information, Programming, Set-Up

Released 1/13/2012
Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability

Released 10/24/2011
Use of Surface Conditioning Disks When Cleaning Engine Gasket Sealing Surfaces and/or Reused Engine Parts

Released 10/22/2011
Information for Dealers/Technicians on When and How to Submit a Field Product Report (FPR) (U.S. Dealers Only)

Released 10/22/2011
Warranty Code Generated By EL-50313 Midtronics GR8 Battery Tester/Charger Required for Claim Processing On Labor Operation 4041510 and Battery Part Restriction (North America ONLY)

Released 8/10/2011
Comeback Prevention Information and Using Customer Concern Verification Sheets (CCVS)

Released 7/22/2011
Clarification of Use - Dealer Empowerment Labor Operations and Customer Enthusiasm

Released 7/22/2011
Enhancing Field Product Reports with Digital Pictures

Released 6/17/2011
Improperly Formatted SI Screen Characters

Released 6/9/2011
Warranty Administration-Revised Customer Concern Not Duplicated (CCND)/Verified Labor Operation Numbers/How to Submit CCND Transactions in GWM / Elimination of E9995, J9993, J9994 and J9995

Released 5/23/2011
Global Warranty Management (GWM) Warranty Parts Center (WPC) Parts Return Program Information

Released 5/19/2011
IPC Odometer Programming Method Quick Reference Guide

Released 5/9/2011
Information for Dealers on How to Submit a Product Information Report (PIR) (Canada Only)

Released 5/5/2011
Change in Product Field Action Customer Reimbursement Procedure (U.S. Dealers Only)

Released 4/18/2011
New Tool Availability - EN-48974 - EGR Cooler Pressure Tester Adapter Set to Diagnose Duramax Diesel Engine EGR Cooler Engine Coolant Leaks into Combustion Chamber

Released 4/18/2011
Warranty Administration - Courtesy Transportation and Roadside Assistance Programs

Released 4/13/2011
Warranty Parts Center (WPC) Special Part Request Enhancement - New Expedited Overnight Shipping Process and Form Information

Released 4/7/2011
Expediting Warranty Parts

Released 3/2/2011
Automatic Transmission Oil Cooler Flush and Flow Test Essential Tool J-45096 TransFlow

Released 2/3/2011
Expanded Customer Concern Not Duplicated (CCND)/Verified Labor Operation Numbers/How to Submit CCND Transactions in Global Warranty Management

Released 11/19/2010
Application of Anti-Corrosion Materials

Released 10/18/2010
Warranty Code Generated by El-50313/Charger Required for N0110, Battery Parts Rest

Released 10/13/2010
General Motors Dealership Critical Equipment Requirements and Recommendations

Released 9/2/2010
Engineering Information (EI) Process

Released 8/6/2010
Information on Drilling High Strength Steel Related to Collision Repair

Released 7/30/2010
Electronic Exchange Program Changes

Released 7/1/2010
Out-of-Warranty Parts for Engineering Analysis

Released 6/30/2010
Squeeze Type Resistance Spot Welding/Equipment

Released 6/17/2010
Free Agent Best Practices for HUMMER, Pontiac, Saab and Saturn Customers or Those Affected by Dealership Consolidation (U.S. Only) (SB10168)

Released 6/9/2010
Warranty Admin - Expanded Customer Concern Not Duplicated (CCND)/Verified Labor Operation Numbers/How to Submit CCND Transactions in Global Warranty Management

Released 5/28/2010
Expediting Warranty Parts

Released 5/27/2010
Key Code Security Rules and Information on GM KeyCode Look-Up Application (Canada Only)

Released 5/26/2010
Warranty Admin - Warranty Claims Submission-Importance of GM Part Numbers and Parts with Date Codes

Released 5/24/2010
Technical Assistance Center (TAC) Coverage Available for Current and Last Nine Model Year Vehicles (U.S. Only)

Released 5/21/2010
Improperly Formatted SI Screen Characters

Released 5/20/2010
Global Warranty Management (GWM) Warranty Parts Center (WPC) Parts Return Program Information

Released 5/20/2010
Warranty Administration - Courtesy Transportation and Roadside Assistance Programs

Released 5/19/2010
Warranty Administration - Labor Operation Z1111 - Suspected Tampering or Vehicle Modifications

Released 5/18/2010
Information for Dealers on How to Submit a Field Product Report (FPR) (U.S. Dealers Only)

Released 5/17/2010
Information for Dealers on How to Submit a Product Information Report (PIR) (Canada Only)

Released 5/4/2010
Enhancing Field Product Reports with Digital Pictures

Released 5/4/2010
Information on Tire Radial Force Variation (RFV)

Released 4/29/2010
Unnecessary Flushing Services, Additive Recommendations and Proper Utilization of GM Simplified Maintenance Schedule to Enhance Customer Service Experience

Released 4/26/2010
Required Return Criteria of Complete Electrical Center (EC) and Body Control Module (BCM) with Integrated Electrical Center to Warranty Parts Center (WPC)

Released 3/29/2010
Revised General Motors New Vehicle Tire Warranty Program and Global Warranty Management (GWM) Submission Rollout Information (U.S. Dealers Only)

Released 3/5/2010
Information for Electrical Ground Repair-Use New Replacement Fasteners with Conductive Finish

Released 2/15/2010
Warranty, SPS, Control Module Diagnostics and Configuration Information, Programming, Set-Up

Released 2/4/2010
Car and Truck Fix It Right the First Time Issues

Released 12/18/2009
New Tool Availability - EN-48974-EGR Cooler Pressure Tester Adapter Set to Diagnose Duramax Diesel Engine EGR Cooler Engine Coolant Leaks into Combustion Chamber

Released 12/11/2009
Unnecessary Engine Crankcase and Subsystems Flushing Services, Additive Recommendations and Proper Utilization of GM Simplified Maintenance Schedule to Enhance Customer Service Experience

Released 11/13/2009
Light and Medium Duty Truck Warranty, Crossline Warranty Eligibility and Guidelines for Chevrolet/GMC Dealers

Released 11/11/2009
New Labor Operation Codes for Dealer-Installed GM Accessories Replaced During Warranty Coverage Period

Released 9/24/2009
Discontinuation of Printed GM VIN Cards

Released 9/22/2009
Warranty Administration - Warranty System Changes-Medium Duty Trucks

Released 9/11/2009
GM Training - September 2009 New Course Information (For U.S. Dealers and Aftermarket)

Released 9/2/2009
Paint Peeling on Saddle Type Fuel Tanks (Refinish Tanks)

Released 8/13/2009
Information on Paint Stain Under Protective Shipping Film

Released 8/10/2009
GM Training - August 2009 New Course Information (For U.S. Dealers and Aftermarket)

Released 7/22/2009
GM Training - July 2009 New Course Information (For U.S. Dealers and Aftermarket)

Released 7/16/2009
Technical Assistance Center (TAC) Coverage Available for Current and Last Nine Model Year Vehicles (U.S. Only)

Released 7/6/2009
Electric Air Compressor (K16) Runs Continuously or Is Inoperative (Install Signal Filter Jumper Harness/Replace Necessary Components)

Released 6/22/2009
Bumps or Rust Colored Spots in Paint Due to Rail or Iron Dust (Remove Rail Dust)

Released 6/16/2009
Information Required Before Contacting GM Technical Assistance or When Ordering Replacement OnStar VCIM

Released 6/15/2009
GM Training - June 2009 New Course Information (For U.S. Dealers and Aftermarket)

Released 6/15/2009
Engineering Information (EI) Process

Released 5/18/2009
Interior Cleaning-Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl. Fabric Cleaner, Stain Remover, Restorer - Product Availability

Released 5/11/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 5/7/2009
GM Training - May 2009 New Course Information (For U.S. Dealers and Aftermarket)

Released 4/20/2009
GM Training - April 2009 New Course Information (For U.S. Dealers and Aftermarket)

Released 4/2/2009
Warranty Administration - GM Dealer Empowerment Program and Goodwill Procedures

Released 4/1/2009
Warranty Administration - Policies for Used Vehicles Purchased Through GM-Sponsored Auctions (SB 09074)

Released 3/31/2009
Warranty Administration - Labor Operation Z1111 - Suspected Tampering or Vehicle Modifications

Released 3/23/2009
Enhancing Field Product Reports with Digital Pictures

Released 2/3/2009
Hem Flange Rust Repair

Released 12/10/2008
General Motors Dealership Critical Equipment Requirements and Recommendations

Released 10/30/2008
Procedure to Take Snapshot Data with a Tech 2 and Upload Data to Computer Using TIS Software

Released 10/29/2008
Reducing Electrical Intermittents-Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Misc. DTCs, Intermittent Driveability Concerns, Hard/No

Released 9/14/2010
Car and Truck Fix It Right the First Time Issues

Released 4/28/2010
New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores

Released 1/14/2010
Preventing Damage on Dealer Lots During Longer Periods in Dealer Inventory and Maintaining High CSI Scores

Released 11/12/2009
Preventing Damage on Dealer Lots During Longer Periods in Dealer Inventory and Maintaining High CSI Scores

Released 6/8/2009
New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores

Released 5/11/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 1/8/2009
Preventing Damage on Dealer Lots During Longer Periods in Dealer Inventory and Maintaining High CSI Scores