Get Free 2006 GMC C4500 V8 TSBs

Released 8/1/2015
Information for Identifying Non-GM ECM Calibration Use and Power-up Hardware Detection in Duramax Diesel Engines - Photograph Tech 2 Calibration IDs, Calibration Verification Numbers (CVNs) and Transmission Data Screen

Released 5/12/2015
Information on Higher Than Expected Oil Consumption

Released 8/26/2014
Information on Identifying Duramax Diesel Overpower Engine Breakdown/Non-Function Due to Aftermarket Power-Up Devices vs Non Overpower Engine Non-Function of Pistons, Cylinders, Valvetrain Components, DTC P003A or P111D Set

Released 7/16/2014
Duramax Diesel Glow Plugs Difficult to Install Due to Carbon Buildup - New Glow Plug Bore Reamer Available

Released 6/19/2014
Radio Reprogramming Using Techline/Service Programming System (SPS) - Ensuring Correct Vehicle Selection

Released 2/6/2014
Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum Wheel Bead Seat Corrosion (Clean and Resurface Wheel Bead Seat)

Released 1/4/2014
Proper Wheel Installation and Wheel Torque Techniques

Released 6/19/2013
Information on Slight Vehicle Movement in Park at Start Up After Cold Soak

Released 6/19/2013
Dealership Service Consultant Procedure as Vehicle Comes into Service Drive for Tire Pressure Monitor (TPM) System Message, Light and Customer Information

Released 6/19/2013
Global Information for GM dexos 1 and dexos 2 Engine Oil Specifications, Licensed Brands, and Service Fill

Released 6/19/2013
Repair Information for Reconnection of Rear Window Defroster (Defogger) Contact or Tab

Released 4/23/2013
Odometer Servicing When The Odometer Cannot Be Set To The Actual Mileage

Released 4/12/2013
Information on Driveline Clunk Noise

Released 3/29/2013
Vehicle Software Enhancements

Released 3/22/2013
Vibration Analysis Worksheet

Released 3/1/2013
Paint-less Dent Repair Process

Released 2/15/2013
Information for Electrical Ground Repair - Use New Replacement Fasteners with Conductive Finish

Released 2/15/2013
Windshield Wiper Performance, Cleaning Instructions and Maintenance

Released 2/11/2013
Prior To Any Circuit Testing

Released 2/8/2013
HYDRA-MATIC Front Wheel Drive 4T80-E (MH1) Left Front Axle Seal Leak, Transmission Slips in Gear (Replace Third Clutch Housing with Revised Service Part)

Released 1/1/2013
Various Driveability Symptoms Due to Clogged Fuel Injectors, MIL/SES DTCs P0171, P0172, P0174, P0300, P1174, P1175 (Clean Fuel Injectors and/or Perform Injector Test With AFIT CH-47976)

Released 9/4/2012
IPC Odometer Programming Method Quick Reference Guide

Released 9/4/2012
Information on Normal Maintenance or Warranty Service for 4T40, 4T45, 4T65, 4L60 Automatic Transmission Oil Pan Magnet Upgrade

Released 3/19/2012
Hem Flange Rust Repair

Released 1/19/2012
Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability

Released 1/13/2012
Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability

Released 1/12/2012
Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability

Released 10/24/2011
Use of Surface Conditioning Disks When Cleaning Engine Gasket Sealing Surfaces and/or Reused Engine Parts

Released 10/22/2011
Warranty Code Generated By EL-50313 Midtronics GR8 Battery Tester/Charger Required for Claim Processing On Labor Operation 4041510 and Battery Part Restriction (North America ONLY)

Released 10/17/2011
Safety Belt Locking Conditions (Normal Operating Characteristics)

Released 10/13/2011
Eliminating Unwanted Odors in Vehicles

Released 7/22/2011
Car and Truck Fix it Right the First Time Issues

Released 7/22/2011
Car and Truck Fix it Right the First Time Issues

Released 7/15/2011
Key Code Security Rules and Information on GM KeyCode Look-Up Application (Canada Only)

Released 6/7/2011
Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability

Released 2/21/2011
Windshield Wiper Performance, Cleaning Instructions and Maintenance

Released 2/2/2011
Seat Belt Buckle Latching Issues and/or Seat Belt Warning Lights Illuminated

Released 12/23/2010
Information on Passenger Presence Sensing System (PPS or PSS) Concerns with Custom Upholstery, Accessory Seat Heaters or Other Comfort Enhancing Devices

Released 12/21/2010
Warranty Information-Fascia Refinish Labor Operations

Released 11/19/2010
Application of Anti-Corrosion Materials

Released 10/21/2010
Safety Belt Locking Conditions (Normal Operating Characteristics)

Released 10/14/2010
Warranty Administration-Warranty Claims Submission-Outside Rearview Mirrors

Released 9/14/2010
Car and Truck Fix It Right the First Time Issues

Released 9/10/2010
Distortion in Outer Surface of Vehicle Glass

Released 6/30/2010
Information on Hem Flange Sealer for Corrosion Protection

Released 6/30/2010
Squeeze Type Resistance Spot Welding/Equipment

Released 5/27/2010
Key Code Security Rules and Information on GM KeyCode Look-Up Application (Canada Only)

Released 5/27/2010
Key Code Security Rules and Information on GM KeyCode Look-Up Application (U.S. Only)

Released 4/28/2010
New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores

Released 4/27/2010
Interior Cleaning-Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer-Product Availability

Released 3/30/2010
Information on Proper Use of Floor Mats

Released 3/11/2010
Key Code Security Rules and Information on GM KeyCode Look-Up Application

Released 3/10/2010
Intermittent MIL/SES, DTC P2138 with Reduced Engine Power (Repair Instrument Panel (IP) to Body Harness Connector)

Released 3/8/2010
Information on Driver or Passenger Seat Head Restraint Concerns with Comfort, Custom Upholstery or Other Comfort Enhancing Devices

Released 3/4/2010
Car and Truck Fix It Right the First Time Issues

Released 2/25/2010
Information on Heated Electrochromatic Outside Rearview Mirror Performance

Released 2/24/2010
Information on Passenger Presence Sensing System (PPS or PSS) Concerns with Custom Upholstery, Accessory Seat Heaters or Other Comfort Enhancing Devices

Released 2/4/2010
Car and Truck Fix It Right the First Time Issues

Released 11/24/2009
Service Engine Soon (SES) Light Illuminated, Reduced Engine Power Mode, DTCs P0101, P0106, P0107, P0108, P0299, P0652 or P0653 Set (Install Body to Frame Shims)

Released 11/4/2009
Safety Belt Locking Conditions (Normal Operating Characteristics)

Released 11/4/2009
Car and Truck Fix It Right the First Time Issues

Released 10/20/2009
Information on Side Door Window Glass Chipping Caused by Hanging Vehicle Key Lock Box

Released 10/6/2009
Information on Passenger Presence System (PPS or PSS) Concerns with Custom Upholstery, Accessory Seat Heaters or Other Comfort Enhancing Devices

Released 9/25/2009
Information on Discoloration, Blistering, Peeling or Erosion of Various Exterior Emblems Including Chevy Bowtie (Bulletin Canceled)

Released 9/18/2009
Clear Stain or Film on Inside Perimeter of Windshield Glass (Clean/Polish Glass)

Released 8/27/2009
Minor Wrinkles/Creases, Discoloration, Cigarette Burns and Customer Induced Cuts and Stains on Front and Rear Driver and Passenger Seats with Leather, Vinyl or Cloth Seat Covers

Released 8/13/2009
Information on Paint Stain Under Protective Shipping Film

Released 8/13/2009
Information on Body Control Module (BCM) Grounds

Released 7/29/2009
Information on Maintaining Exterior Weatherstrip Appearance

Released 6/4/2009
Seat Belt Latch Stop Button Available for Service

Released 5/26/2009
Repair Information for Reconnection of Rear Window Defroster Contact or Tab

Released 5/18/2009
Interior Cleaning-Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl. Fabric Cleaner, Stain Remover, Restorer - Product Availability

Released 5/12/2009
Negative Impact of Dealer-Installed Cloth/Viny Roofs on XM Radio and/or OnStar Systems

Released 5/11/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 5/6/2009
Car and Truck Fix It Right the First Time Issues

Released 4/23/2009
IPC Odometer Programming Method Quick Reference

Released 3/19/2009
Marks/Stains on Windshield When Wet (Clean Windshield)

Released 3/12/2009
08-08-51-002: New Primer For TPO Fascias and Affected Cleaning Process of Painting Operation - (Mar 12, 2008)

Released 3/9/2009
Warranty Administration - Guidelines for Claiming C0034 - Windshield Replacement

Released 3/9/2009
New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores

Released 3/9/2009
Car and Truck Fix It Right the First Time Issues

Released 2/17/2009
Seat Belt Buckle Latching Issues and/or Seat Belt Warning Lights Illuminated

Released 2/16/2009
Warranty Administration - Labor Operation Z1241 - Personal Property Damage

Released 2/3/2009
Hem Flange Rust Repair

Released 1/28/2009
Non-Approval of Clipping (Sectioning of Two Vehicles) for Collision Repair

Released 1/8/2009
Preventing Damage on Dealer Lots During Longer Periods in Dealer Inventory and Maintaining High CSI Scores

Released 1/6/2009
Information on Curb Park Assist and Memory Related Issues on Outside Rearview Mirrors

Released 12/12/2008
Information on Passenger Presence Sensing System (PPS or PSS) Concerns with Custom Upholstery, Accessory Seat Heaters or Other Comfort Enhancing Devices

Released 10/16/2008
08-00-89-037: CSO Surcharges Not Allowed on Warranty Claims - (Oct 16, 2008)

Released 10/6/2008
08-00-89-036: GM Training - GM STC Training Location Changes (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-035: GM Training - Login Prompts for My I-Car Page of GM/I-CAR Web Site (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-033: GM Training - October 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-034: GM Training - Accessing Hands-On Checklists (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 9/29/2008
00-00-89-027E: Eliminating Unwanted Odors in Vehicles - (Sep 29, 2008)

Released 9/18/2008
06-08-46-008C: Information on OnStar Dual-Mode (Analog/Digital) Systems - (Sep 18, 2008)

Released 9/15/2008
06-08-111-004A: Information on Discoloration, Blistering, Peeling or Erosion of Various Exterior Emblems Including the Chevy Bowtie - (Sep 15, 2008)

Released 8/27/2008
02-00-89-014E: New Labor Operation Codes for Dealer-Installed GM Accessories Replaced During Warranty Coverage Period - (Aug 27, 2008)

Released 8/25/2008
03-08-48-006E: Repair Information for Reconnection of Rear Window Defroster Contact or Tab - (Aug 25, 2008)

Released 8/14/2008
08-08-46-004: Information on Aftermarket Device Interference with OnStar Diagnostic Services - (Aug 14, 2008)

Released 6/27/2008
07-00-89-047B: Technical Assistance Center (TAC) Coverage Available for Current and Last Nine Model Year Vehicles (U.S. Only) - (Jun 27, 2008)

Released 6/10/2008
08-00-89-021: Servicing Medium Duty Trucks, Including Conventional and Crew Cabs, Motorhome Cutaway Cab, Commercial Cutaway Cab (Ambulance, School Bus, Shuttle Bus) and Tilt Cabs - (Jun 10, School Bus, Shuttle Bus) and Tilt Cabs - (Jun 10, 2008)

Released 6/5/2008
07-08-64-022A: Information on Curb Park Assist and Memory Related Issues on Outside Rear View Mirrors - (Jun 5, 2008)

Released 5/22/2008
07-08-49-020B: IPC Odometer Programming Method Quick Reference Guide - (May 22, 2008)

Released 5/2/2008
03-08-46-004D: Parts Restriction on Ordering OnStar Generation 6 and 7 Vehicle Communication Interface Modules (VCIM) - (May 2, 2008)

Released 4/30/2008
06-00-89-050B: Diagnostic Trouble Codes (DTCs) Required on Repair Orders - (Apr 30, 2008)

Released 4/29/2008
04-00-89-018C: Processing GM Accessories - Initial Quality Issues - (Apr 29, 2008)

Released 4/28/2008
07-00-89-031A: Warranty System Changes - Medium Duty Trucks - (Apr 28, 2008)

Released 4/28/2008
05-08-51-001C: Information on Paint Stain Under Protective Shipping Film - (Apr 28, 2008)

Released 4/24/2008
03-08-44-022E: Parts Restriction on Ordering XM Digital Radio Receiver - (Apr 24, 2008)

Released 4/17/2008
99-00-89-011C: Key Code Information - (Apr 17, 2008)

Released 4/16/2008
05-08-44-024A: Return or Reimbursement of Customer Owned CDs, DVDs, Cassette Tapes and/or CD Magazines - (Apr 16, 2008)

Released 4/14/2008
04-03-08-011D: Unnecessary Leaf Spring Clip Replacement - (Apr 14, 2008)

Released 4/7/2008
08-08-64-005: Passenger Side Front Outside Door Handle Inoperative (Replace Outside Door Handle) - (Apr 7, 2008)

Released 2/19/2008
08-00-89-006: GM Training: February 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Feb 19, 2008)

Released 2/5/2008
06-06-04-035A: Use of E85 Fuels in Vehicles Not Certified by GM as being FlexFuel Compatible/Aftermarket Conversion of Vehicles to Operate on E85 Fuels - (Feb 5, 2008)

Released 2/5/2008
04-06-01-029B: Unnecessary Engine Crankcase and Subsystems Flushing Services, Additive Recommendations and Proper Utilization of GM Simplified Maintenance Schedule to Enhance Customer Service Experience - (Feb 5, 2008)

Released 2/1/2008
00-08-48-005C: Distortion in Outer Surface of Vehicle Glass - (Feb 1, 2008)

Released 1/30/2008
99-08-52-005C: Remote Keyless Entry Operational Characteristics - (Jan 30, 2008)

Released 1/18/2008
04-08-44-005C: Utilizing Tech 2 to Retrieve Part Numbers for Radios, Compact Disc (CD) Changers and Instrument Panel Clusters (IPC) - (Jan 18, 2008)

Released 1/17/2008
04-00-89-053B: Engineering Information (EI) Process - (Jan 17, 2008)

Released 1/17/2008
08-00-89-003: GM Training: January 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Jan 17, 2008)

Released 1/10/2008
06-00-89-029D: Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability - (Jan 10, 2008)

Released 1/9/2008
99-09-40-005E: Seat Belt Extender Availability - (Jan 9, 2008)

Released 1/8/2008
05-08-46-004B: OnStar Phone Number Concerns (Phone Number Incorrect/Assigned to Another Vehicle/Phone) That Occur During Diagnosis of OnStar System - (Jan 8, 2008)

Released 1/8/2008
02-08-44-007C: Negative Impact of Dealer-Installed Cloth/Vinyl Roofs on XM Radio and/or OnStar Systems - (Jan 8, 2008)

Released 1/8/2008
02-08-46-006C: Incorrect OnStar Global Positioning System (GPS) Location Reported During OnStar Call - (Jan 8, 2008)

Released 1/8/2008
06-00-89-016A: Cataloging of Electronic Service Center Parts - (Jan 8, 2008)

Released 12/17/2007
07-00-89-062: GM Training: December 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Dec 17, 2007)

Released 12/4/2007
07-08-64-020: Driver/Passenger Outside Rearview Mirror Shake/Vibration (Apply Sealant and Retighten Mirror Pivot Bolt and Shaft Screws) - (Dec 4, 2007)

Released 11/13/2007
07-00-89-056: GM Training: November 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Nov 13, 2007)

Released 11/2/2007
03-00-89-008D: Corrosion Protection for Metal Panels With Dealer Installed Accessories Fastened By Drilled Holes - (Nov 2, 2007)

Released 10/15/2007
07-00-89-051: GM Training: I-CAR Offers Various Resources to Help Dealers Achieve Training Goals (U.S. Dealers) - (Oct 15, 2007)

Released 10/15/2007
07-00-89-052: GM Training: October 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Oct 15, 2007)

Released 9/5/2007
07-08-45-002: Service Alert: Concerns With Aftermarket Fuses in GM Vehicles - (Sep 5, 2007)

Released 8/27/2007
07-08-49-003A: Information on Engine Hourmeter Reading Not Being Transferred to New IPCs - (Aug 27, 2007)

Released 8/23/2007
07-00-89-043: Warranty Admin. - Use of Parts and Components (Including Control Module Calibrations) Not Issued Through General Motors - (Aug 23, 2007)

Released 8/17/2007
07-00-89-039: GM Training: August 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Aug 17, 2007)

Released 7/25/2007
07-00-89-033: GM Training - June 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Jul 25, 2007)

Released 7/20/2007
07-08-64-016: Left or Right Front Door Trim Panel Armrest/Pull Handle Cover Pulls Off of Door (Replace Armrest/Handle with New Fasteners) - (Jul 20, 2007)

Released 7/19/2007
06-08-50-009B: Information on Passenger Presence Sensing System (PPS or PSS) Concerns with Custom Upholstery, Accessory Seat Heaters or Other Comfort Enhancing Devices) - (Jul 19, 2007)

Released 6/27/2007
07-00-89-028: GM Training: May 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Jun 27, 2007)

Released 6/26/2007
07-00-89-025: GM Training: April 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Jun 26, 2007)

Released 6/26/2007
07-00-89-024: GM Training: Service Training Standard (STS) Effective Date for Two Required Technology Close-ups (TCUs) was 04/14/07 (U.S. Dealers) - (Jun 26, 2007)

Released 6/26/2007
07-00-89-011: GM Training: Course Information (For U.S. Dealers and Aftermarket) - (Jun 26, 2007)

Released 6/22/2007
99-08-64-016B: Use of Silicone for Weatherstrip Maintenance - (Jun 22, 2007)

Released 4/23/2007
05-08-51-008B: Bumps or Rust Colored Spots in Paint Due to Rail or Iron Dust (Remove Rail Dust) - (Apr 23, 2007)

Released 4/17/2007
07-08-63-001: Information on Repair of Polypropylene Energy Absorbers - (Apr 17, 2007)

Released 4/2/2007
07-08-98-001: Info - Non-approval of Clipping (Sectioning of Two Vehicles) for Collision Repair - (Apr 2, 2007)

Released 3/7/2007
07-06-01-003: LBZ LB7 LLY 6.6L Duramax Diesel Engine Accessory Drive Belt Chirp, Squeal or Squeak Type Noise at Cold Start Idle (Replace Accessory Drive Belt) - (Mar 7, 2007)

Released 1/17/2007
02-08-98-002B: Info - Hem Flange Rust Repair - (Jan 17, 2007)

Released 10/9/2006
02-08-98-001C: Info - Metal Panel Bonding - (Oct 9, 2006)

Released 8/7/2006
06-00-89-038: Information on Radio and Instrument Panel Cluster (IPC) Part Restrictions (U.S. Only) - (Aug 7, 2006)

Released 6/21/2006
06-00-89-036: Owner Manual and Warranty Information in Service Information (SI) Website/Distributed on CD - (Jul 21, 2006)

Released 5/2/2006
06-08-45-004: Info - Instrument Panel (I/P), Body and General Wiring Harness Repair - (May 2, 2006)

Released 4/28/2006
05-08-57-004A: Water Intrusion into Cab (Inspect/Replace Roof Marker Lamp Lens/Bolts) - (Apr 28, 2006)

Released 4/27/2006
05-08-133-001A: Diagnostic Information for Inoperative Air Seats, Air Horn and/or Exhaust Brake and Release of New Auxiliary Air Compressor Relay and Pressure Switch on RPO K16 Vehicles - (Apr 27, 2006)

Released 4/3/2006
05-08-64-002B: Door Latch Freezing in Cold Temperatures (Apply Super Lube) - (Apr 3, 2006)

Released 3/29/2006
02-08-48-001B: Info - Urethane Adhesives for Stationary Glass and Other Applications - (Mar 29, 2006)

Released 11/23/2005
05-00-89-082: Info - Elimination of Front License Plate Bracket (Canada Only) - (Nov 23, 2005)

Released 11/21/2005
99-08-51-001A: Info - Paint-less Dent Repair Process - (Nov 21, 2005)

Released 11/2/2005
05-00-89-075: Warranty Admin. - Servicing Medium Duty Trucks, Including Conventional and Crew Cabs, Motorhome Cutaway Cab, Commercial Cutaway Cab (Ambulance, School Bus, Shuttle Bus), and Tilt Cabs - (Nov 2, 2005)

Released 1/17/1997
Car and Truck Fix it Right the First Time Issues

Released 7/22/2011
Car and Truck Fix it Right the First Time Issues

Released 4/19/2011
Disc Brake Warranty Service and Procedures

Released 6/8/2009
EI06060 - Hydraulic Brake Booster Master Cylinder Diagnostics - Hydra Max System (Engineering Information Closed)

Released 5/11/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 5/6/2009
Car and Truck Fix It Right the First Time Issues

Released 3/26/2009
Disc Brake Warranty Service and Procedures

Released 3/9/2009
Car and Truck Fix It Right the First Time Issues

Released 1/8/2009
Preventing Damage on Dealer Lots During Longer Periods in Dealer Inventory and Maintaining High CSI Scores

Released 10/6/2008
08-00-89-036: GM Training - GM STC Training Location Changes (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-033: GM Training - October 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-034: GM Training - Accessing Hands-On Checklists (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 7/15/2008
08-05-23-007: Rear Caliper Piston Boot Becomes Brittle on Vehicles Operating in High Temperatures and Extreme Driving Cycles (Install New Silicone Based Piston Boot) - (Jul 15, 2008)

Released 6/27/2008
07-00-89-047B: Technical Assistance Center (TAC) Coverage Available for Current and Last Nine Model Year Vehicles (U.S. Only) - (Jun 27, 2008)

Released 10/17/2007
06-04-21-004A: Information on Driveline Vibration Analysis and Correction - (Oct 17, 2007)

Released 8/23/2007
07-00-89-043: Warranty Admin. - Use of Parts and Components (Including Control Module Calibrations) Not Issued Through General Motors - (Aug 23, 2007)

Released 8/17/2007
07-00-89-039: GM Training: August 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Aug 17, 2007)

Released 7/25/2007
07-00-89-033: GM Training - June 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Jul 25, 2007)

Released 6/26/2007
07-00-89-011: GM Training: Course Information (For U.S. Dealers and Aftermarket) - (Jun 26, 2007)

Released 2/22/2007
07-05-22-001: Brake Light Switch Inoperative, Brake Warning Buzzer Sounding and Brake Warning Light On, DTCs C0164, C0272 Set (Remove and Splice Wire/Remove CHMSL Fuse/Replace Stop Lamp Switch) - (Feb 22, 2007)

Released 11/30/2006
06-05-22-005A: EI06060 - Hydraulic Brake Booster Master Cylinder Diagnostics - Hydra Max System - (Nov 30, 2006)

Released 11/2/2005
05-00-89-075: Warranty Admin. - Servicing Medium Duty Trucks, Including Conventional and Crew Cabs, Motorhome Cutaway Cab, Commercial Cutaway Cab (Ambulance, School Bus, Shuttle Bus), and Tilt Cabs - (Nov 2, 2005)

Released 6/8/2005
05-05-22-001: Info - On-Car Brake Lathe Specifications and Maintenance Requirements - (Jun 8, 2005)

Released 1/17/1997
Car and Truck Fix it Right the First Time Issues

Released 4/18/2011
New Tool Availability - EN-48974 - EGR Cooler Pressure Tester Adapter Set to Diagnose Duramax Diesel Engine EGR Cooler Engine Coolant Leaks into Combustion Chamber

Released 3/2/2011
Automatic Transmission Oil Cooler Flush and Flow Test Essential Tool J-45096 TransFlow

Released 4/29/2010
Unnecessary Flushing Services, Additive Recommendations and Proper Utilization of GM Simplified Maintenance Schedule to Enhance Customer Service Experience

Released 9/9/2009
Automatic Transmission Oil Cooler Flush and Flow Test Essential Tool J 45096 TransFlow

Released 5/11/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 5/5/2009
Engine Oil Leaks from Charge Air Cooler and Turbocharger Air Inlet Adapter (Replace Clamp and/or Turbo Inlet Duct/Pipe)

Released 3/20/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 10/6/2008
08-00-89-036: GM Training - GM STC Training Location Changes (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-033: GM Training - October 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-034: GM Training - Accessing Hands-On Checklists (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 6/27/2008
07-00-89-047B: Technical Assistance Center (TAC) Coverage Available for Current and Last Nine Model Year Vehicles (U.S. Only) - (Jun 27, 2008)

Released 2/22/2008
02-07-30-052E: Automatic Transmission Oil Cooler Flush and Flow Test Essential Tool J 45096 TransFlow - (Feb 22, 2008)

Released 1/18/2008
05-06-02-002B: DEX-COOL Coolant - New Leak Detection Dye J 46366 Replaces J 29545-6 - (Jan 18, 2008)

Released 1/10/2008
08-06-04-003: New Tool Availability - EN-48974 - EGR Cooler Pressure Tester Adapter Set to Diagnose Duramax Diesel Engine EGR Cooler Leaks into Combustion Chamber - (Jan 10, 2008)

Released 8/17/2007
07-00-89-039: GM Training: August 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Aug 17, 2007)

Released 8/15/2006
00-06-02-006D: Engine Coolant Recycling and Warranty Information - (Aug 15, 2006)

Released 11/2/2005
05-00-89-075: Warranty Admin. - Servicing Medium Duty Trucks, Including Conventional and Crew Cabs, Motorhome Cutaway Cab, Commercial Cutaway Cab (Ambulance, School Bus, Shuttle Bus), and Tilt Cabs - (Nov 2, 2005)

Released 9/14/2013
OnStar Will Not Power Up

Released 6/19/2013
Information on Slight Vehicle Movement in Park at Start Up After Cold Soak

Released 6/19/2013
Global Information for GM dexos 1 and dexos 2 Engine Oil Specifications, Licensed Brands, and Service Fill

Released 6/19/2013
Repair Information for Reconnection of Rear Window Defroster (Defogger) Contact or Tab

Released 4/23/2013
Odometer Servicing When The Odometer Cannot Be Set To The Actual Mileage

Released 4/12/2013
Information on Driveline Clunk Noise

Released 3/29/2013
Vehicle Software Enhancements

Released 3/22/2013
Aftermarket ALDL or DLC Interface Devices Causing Multiple Issues

Released 3/22/2013
Vibration Analysis Worksheet

Released 3/22/2013
OnStar Will Not Power Up

Released 3/1/2013
Paint-less Dent Repair Process

Released 3/1/2013
DVD Navigation Update Program, Navigation Disc Diagnostic Aid, AVN Software Update Discs and Ordering Information

Released 2/15/2013
Information for Electrical Ground Repair - Use New Replacement Fasteners with Conductive Finish

Released 2/15/2013
Windshield Wiper Performance, Cleaning Instructions and Maintenance

Released 2/11/2013
Prior To Any Circuit Testing

Released 1/1/2013
IPC Odometer Programming Method Quick Reference Guide

Released 3/3/2012
Warranty, SPS, Control Module Diagnostics and Configuration Information, Programming, Set-Up

Released 2/10/2012
Service Programming System (SPS) Errors (E4398, E4399, E4403, E4404 E4413, E4414, E4423 or E4491, E4494)

Released 10/22/2011
Warranty Code Generated By EL-50313 Midtronics GR8 Battery Tester/Charger Required for Claim Processing On Labor Operation 4041510 and Battery Part Restriction (North America ONLY)

Released 7/22/2011
Car and Truck Fix it Right the First Time Issues

Released 6/6/2011
Information for Electrical Ground Repair - Use New Replacement Fasteners with Conductive Finish

Released 5/19/2011
IPC Odometer Programming Method Quick Reference Guide

Released 5/13/2011
Headlamp, Tail Lamp or Fog/Driving Lamp Damage

Released 2/2/2011
Seat Belt Buckle Latching Issues and/or Seat Belt Warning Lights Illuminated

Released 1/5/2011
Exterior Lamp Condensation and Replacement Guidelines

Released 12/23/2010
OnStar Phone Number Concerns (Phone Number Incorrect/Assigned to Another Vehicle/Phone) That Occur During Diagnosis of OnStar System

Released 12/8/2010
Intermittent No Crank/No Start, No Module Communication, MIL, Warning Lights, Messages or DTCs Set by Various Control Modules-Diagnosing and Repairing Fretting Corrosion

Released 12/6/2010
IPC Odometer Programming Method Quick Reference Guide

Released 10/25/2010
Information for Electrical Ground Repair - Use New Replacement Fasteners with Conductive Finish

Released 10/18/2010
Warranty Code Generated by El-50313/Charger Required for N0110, Battery Parts Rest

Released 9/14/2010
Car and Truck Fix It Right the First Time Issues

Released 6/28/2010
Intermittent Malfunction Indicator Lamp (MIL) Illuminated, DTC P2138 with Reduced Engine Power (Repair Instrument Panel (IP) to Body Harness Connector)

Released 6/11/2010
Information on Inappropriate Warranty Claims Submitted for Damaged Radios and Instrument Panel Clusters (IPCs)

Released 6/4/2010
Information for Electrical Ground Repair - Use New Replacement Fasteners with Conductive Finish

Released 4/28/2010
New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores

Released 3/10/2010
Intermittent MIL/SES, DTC P2138 with Reduced Engine Power (Repair Instrument Panel (IP) to Body Harness Connector)

Released 3/9/2010
Battery Part Restriction Program Effective March 1, 2008

Released 3/5/2010
Information for Electrical Ground Repair-Use New Replacement Fasteners with Conductive Finish

Released 3/4/2010
Car and Truck Fix It Right the First Time Issues

Released 2/11/2010
DVD Navigation Update Program, Navigation Disc Diagnostic Aid, AVN Software Update Discs and Ordering Information

Released 2/4/2010
Car and Truck Fix It Right the First Time Issues

Released 11/24/2009
Intermittent No Crank/No Start, No Module Communication, MIL, Warning Lights, Vehicle Messages or DTCs Set by Various Control Modules-Diagnosing and Repairing Fretting Corrosion

Released 11/24/2009
Service Engine Soon (SES) Light Illuminated, Reduced Engine Power Mode, DTCs P0101, P0106, P0107, P0108, P0299, P0652 or P0653 Set (Install Body to Frame Shims)

Released 11/10/2009
Air Compressor Belt/Serpentine Belt Noise (Replace Air Compressor Belt Tensioner)

Released 11/4/2009
Car and Truck Fix It Right the First Time Issues

Released 10/6/2009
Information on Passenger Presence System (PPS or PSS) Concerns with Custom Upholstery, Accessory Seat Heaters or Other Comfort Enhancing Devices

Released 9/9/2009
Diagnostic Information for Inoperative Air Seats, Air Horn and/or Exhaust Brake and Release of New Auxiliary Air Compressor Relay and Pressure Switch on RPO K16 Vehicles

Released 9/1/2009
Intermittent No Crank/No Start, No Module Communication, MIL, Warning Lights, Vehicle Messages or DTCs Set by Various Control Modules (Disconnect Affected Connector and Apply Dielectric Lubricant)

Released 8/27/2009
Minor Wrinkles/Creases, Discoloration, Cigarette Burns and Customer Induced Cuts and Stains on Front and Rear Driver and Passenger Seats with Leather, Vinyl or Cloth Seat Covers

Released 8/13/2009
Information on Body Control Module (BCM) Grounds

Released 7/27/2009
Diagnosing Accessory Drive Belt/Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool-Drive Belt

Released 6/11/2009
Replacement of Headlamp Assemblies Under Warranty and Use of GM vs. Non-GM Headlamp Assemblies

Released 5/12/2009
Negative Impact of Dealer-Installed Cloth/Viny Roofs on XM Radio and/or OnStar Systems

Released 5/11/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 5/6/2009
Car and Truck Fix It Right the First Time Issues

Released 5/4/2009
Exterior Lamp Condensation and Replacement Guidelines

Released 4/29/2009
Malfunction Indicator Lamp (MIL) Illuminated, Intermittent DTC P0191, Slow Fuel Rail Pressure (FRP) Decay, Wiring Harness Connections, Voltage Fluctuations/Interruptions (Follow Correction Info Below)

Released 4/23/2009
IPC Odometer Programming Method Quick Reference

Released 3/20/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 3/9/2009
New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores

Released 3/9/2009
Navigation Radio Diagnostic Tips

Released 3/9/2009
Car and Truck Fix It Right the First Time Issues

Released 2/17/2009
Seat Belt Buckle Latching Issues and/or Seat Belt Warning Lights Illuminated

Released 2/11/2009
Key Code Security Rules and Information on GM KeyCode Look-Up Application

Released 2/6/2009
GM Training - February 2009 New Course Information (For U.S. Dealers and Aftermarket)

Released 1/20/2009
Information on Verifying OnStar System Function During Pre-Delivery Inspection (PDI)

Released 1/8/2009
Preventing Damage on Dealer Lots During Longer Periods in Dealer Inventory and Maintaining High CSI Scores

Released 1/6/2009
Information on Curb Park Assist and Memory Related Issues on Outside Rearview Mirrors

Released 12/17/2008
Replacement of Headlamp Assemblies Under Warranty and Use of GM vs. Non-GM Headlamp Assemblies

Released 12/12/2008
Information on Passenger Presence Sensing System (PPS or PSS) Concerns with Custom Upholstery, Accessory Seat Heaters or Other Comfort Enhancing Devices

Released 11/26/2008
GM Training - December 2008 New Course Information (For U.S. Dealers and Aftermarket)

Released 11/6/2008
Intermittent MIL/SES, DTC P2138 with Reduced Engine Power (Repair Instrument Panel (IP) to Body Harness Connector)

Released 10/29/2008
Reducing Electrical Intermittents-Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Misc. DTCs, Intermittent Driveability Concerns, Hard/No

Released 10/6/2008
08-00-89-036: GM Training - GM STC Training Location Changes (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-033: GM Training - October 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-034: GM Training - Accessing Hands-On Checklists (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 9/5/2008
02-08-42-001C: Headlamp Lens Overheating When Covered and Chemical Damage to Exterior Polycarbonate Headlamp Lenses - (Sep 5, 2008)

Released 8/28/2008
08-08-44-028: Information on Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies) - (Aug 28, 2008)

Released 8/25/2008
03-08-48-006E: Repair Information for Reconnection of Rear Window Defroster Contact or Tab - (Aug 25, 2008)

Released 6/27/2008
07-00-89-047B: Technical Assistance Center (TAC) Coverage Available for Current and Last Nine Model Year Vehicles (U.S. Only) - (Jun 27, 2008)

Released 6/18/2008
08-08-44-023: Information on Navigation Radio Not Displaying Accurate Vehicle Location After Radio Replacement, Power Loss or Battery Replacement - (Jun 18, 2008)

Released 6/5/2008
07-08-64-022A: Information on Curb Park Assist and Memory Related Issues on Outside Rear View Mirrors - (Jun 5, 2008)

Released 5/29/2008
08-06-03-005: GM Dealer Visits: Proper Management of Batteries in Dealer Parts Stock/Vehicle Inventory - (May 29, 2008)

Released 5/22/2008
07-08-49-020B: IPC Odometer Programming Method Quick Reference Guide - (May 22, 2008)

Released 5/8/2008
04-06-04-036E: Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) - (May 8, 2008)

Released 5/2/2008
01-08-42-001F: Exterior Lamp Condensation and Replacement Guidelines - (May 2, 2008)

Released 5/2/2008
05-08-45-002D: Required Return Criteria of Complete Electrical Centers (EC) and Body Control Modules (IBCMs) with Integrated Electrical Centers to Warranty Parts Center (WPC) - (May 2, 2008)

Released 4/30/2008
03-06-03-003B: ACDelco Replacement Battery Warranty Procedures - (Apr 30, 2008)

Released 4/28/2008
07-00-89-031A: Warranty System Changes - Medium Duty Trucks - (Apr 28, 2008)

Released 4/28/2008
05-08-51-001C: Information on Paint Stain Under Protective Shipping Film - (Apr 28, 2008)

Released 4/17/2008
05-06-03-002C: Battery and Charging System Electrical Diagnostics - (Apr 17, 2008)

Released 4/17/2008
05-00-89-045A: Electronic Exchange Program Goodwill Procedures - (Apr 17, 2008)

Released 4/17/2008
99-00-89-011C: Key Code Information - (Apr 17, 2008)

Released 3/27/2008
08-06-01-008: Diagnosing Accessory Drive Belt/Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt - (Mar 27, 2008)

Released 2/19/2008
08-00-89-006: GM Training: February 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Feb 19, 2008)

Released 2/1/2008
06-08-44-015A: Information on Eliminating Noise in Audio System When Using Portable Playback Device - (Feb 1, 2008)

Released 1/30/2008
99-08-52-005C: Remote Keyless Entry Operational Characteristics - (Jan 30, 2008)

Released 1/17/2008
08-00-89-003: GM Training: January 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Jan 17, 2008)

Released 1/9/2008
06-08-46-006A: Information on Verifying OnStar System Function During Pre-Delivery Inspection(PDI) - (Jan 9, 2008)

Released 1/9/2008
99-09-40-005E: Seat Belt Extender Availability - (Jan 9, 2008)

Released 1/8/2008
06-00-89-016A: Cataloging of Electronic Service Center Parts - (Jan 8, 2008)

Released 12/17/2007
07-00-89-062: GM Training: December 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Dec 17, 2007)

Released 11/13/2007
07-00-89-056: GM Training: November 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Nov 13, 2007)

Released 10/15/2007
07-00-89-052: GM Training: October 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Oct 15, 2007)

Released 9/5/2007
07-08-45-002: Service Alert: Concerns With Aftermarket Fuses in GM Vehicles - (Sep 5, 2007)

Released 8/27/2007
07-08-49-003A: Information on Engine Hourmeter Reading Not Being Transferred to New IPCs - (Aug 27, 2007)

Released 8/23/2007
07-00-89-043: Warranty Admin. - Use of Parts and Components (Including Control Module Calibrations) Not Issued Through General Motors - (Aug 23, 2007)

Released 8/17/2007
07-00-89-039: GM Training: August 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Aug 17, 2007)

Released 8/2/2007
03-06-03-001D: Starter Cranks After Key Is Released (Normal Condition) - (Aug 2, 2007)

Released 7/25/2007
07-00-89-033: GM Training - June 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Jul 25, 2007)

Released 7/19/2007
06-08-50-009B: Information on Passenger Presence Sensing System (PPS or PSS) Concerns with Custom Upholstery, Accessory Seat Heaters or Other Comfort Enhancing Devices) - (Jul 19, 2007)

Released 6/27/2007
07-00-89-028: GM Training: May 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Jun 27, 2007)

Released 6/26/2007
07-00-89-025: GM Training: April 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Jun 26, 2007)

Released 6/8/2007
06-08-43-003A: Windshield Wiper Performance, Cleaning Instructions and Maintenance - (Jun 8, 2007)

Released 4/17/2007
07-08-44-007: Information on Obtaining Replacement Navigation Discs When Radios are Exchanged - Order Replacement Navigation Disc Through Navigation Disc Center - (Apr 17, 2007)

Released 3/30/2007
02-08-42-004A: Info - PRNDL Display Reduced Visibility for Approximately One Minute - (Mar 30, 2007)

Released 3/7/2007
07-06-01-003: LBZ LB7 LLY 6.6L Duramax Diesel Engine Accessory Drive Belt Chirp, Squeal or Squeak Type Noise at Cold Start Idle (Replace Accessory Drive Belt) - (Mar 7, 2007)

Released 2/22/2007
07-05-22-001: Brake Light Switch Inoperative, Brake Warning Buzzer Sounding and Brake Warning Light On, DTCs C0164, C0272 Set (Remove and Splice Wire/Remove CHMSL Fuse/Replace Stop Lamp Switch) - (Feb 22, 2007)

Released 1/24/2007
06-00-89-051A: KeyCode Security Rules and Information on GM KeyCode Look-Up Application - (Jan 24, 2007)

Released 11/28/2006
04-06-04-001C: LB7/LBZ/LLY/LMM - Intermittent Driveability Conditions-No Crank, Crank No Start, Hard to Start, MIL/SES, HEsitation, Lack of Power, Surge, Misfire, Fuel Knock, IPC Indicates No Oil Pressure, DTCs Set - (Nov 28, 2006)

Released 8/4/2006
06-06-04-037: Info - Normal Characteristics of Malfunction Indicator Lamp (MIL) During On-Board Diagnostic (OBD) Inspection/Maintenance (I/M) Testing - (Aug 4, 2006)

Released 5/8/2006
06-08-131-001A: Power Take-Off (PTO) Inoperative or Not Operating Properly (Check TCM Feedback Signal, Modify Wiring If Necessary) - (May 8, 2006)

Released 5/2/2006
06-08-45-004: Info - Instrument Panel (I/P), Body and General Wiring Harness Repair - (May 2, 2006)

Released 4/28/2006
05-08-57-004A: Water Intrusion into Cab (Inspect/Replace Roof Marker Lamp Lens/Bolts) - (Apr 28, 2006)

Released 2/17/2006
06-08-45-001: Information on Changes to the SI Table of Contents, Electrical Connectors, Terminal Testing/Repair and the Importance of J-38125 Terminal Repair Kit Maintenance - (Feb 17, 2006)

Released 12/22/2005
05-09-41-010: Info - New SIR System Disabling and Enabling Procedure - (Dec 22, 2005)

Released 11/2/2005
05-00-89-075: Warranty Admin. - Servicing Medium Duty Trucks, Including Conventional and Crew Cabs, Motorhome Cutaway Cab, Commercial Cutaway Cab (Ambulance, School Bus, Shuttle Bus), and Tilt Cabs - (Nov 2, 2005)

Released 1/17/1997
Car and Truck Fix it Right the First Time Issues

Released 3/22/2013
Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V6 and V8 Gasoline Engines Using Tech 2 or Global Diagnostic System 2 (GDS 2)

Released 2/1/2013
Aftermarket ALDL or DLC Interface Devices Causing Multiple Issues

Released 9/4/2012
Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V8 Gasoline Engines Using Tech 2 or Global Diagnostic System 2 (GDS 2)

Released 3/3/2012
Warranty, SPS, Control Module Diagnostics and Configuration Information, Programming, Set-Up

Released 2/10/2012
Service Programming System (SPS) Errors (E4398, E4399, E4403, E4404 E4413, E4414, E4423 or E4491, E4494)

Released 7/22/2011
Car and Truck Fix it Right the First Time Issues

Released 8/6/2010
Information on Drilling High Strength Steel Related to Collision Repair

Released 6/19/2009
Procedure to Take Snapshot Data with Tech 2 and Upload Data to Computer Using TIS Software

Released 5/18/2009
Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V8 Gas Engines

Released 5/11/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 5/6/2009
Car and Truck Fix It Right the First Time Issues

Released 4/29/2009
Malfunction Indicator Lamp (MIL) Illuminated, Intermittent DTC P0191, Slow Fuel Rail Pressure (FRP) Decay, Wiring Harness Connections, Voltage Fluctuations/Interruptions (Follow Correction Info Below)

Released 3/9/2009
Car and Truck Fix It Right the First Time Issues

Released 2/6/2009
Check Engine Light On, DTC P0403 Set (Check/Reprogram ECM and Perform EGR Valve Motor Cleaning Procedure)

Released 1/9/2009
Warranty, SPS, Control Module Diagnostics and Configuration Information, Programming, Set-Up

Released 10/30/2008
Procedure to Take Snapshot Data with a Tech 2 and Upload Data to Computer Using TIS Software

Released 10/29/2008
Information on Identifying Non-GM Calibration Usages for LBZ, LLY, LMM Duramax Diesel Engines

Released 10/6/2008
08-00-89-036: GM Training - GM STC Training Location Changes (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-033: GM Training - October 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-034: GM Training - Accessing Hands-On Checklists (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 8/6/2008
05-06-04-022E: TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - Canada ONLY - (Aug 6, 2008)

Released 7/31/2008
06-06-04-066C: LBZ, LLY Engine MIL/SES Light On With DTC P0403 Set (Check/Reprogram ECM and Perform EGR Valve Motor Cleaning Procedure) - (Jul 31, 2008)

Released 6/27/2008
07-00-89-047B: Technical Assistance Center (TAC) Coverage Available for Current and Last Nine Model Year Vehicles (U.S. Only) - (Jun 27, 2008)

Released 6/27/2008
08-06-04-006B: Information on Identifying Non-GM Calibration Usages for LMM Duramax Diesel Engine - (Jun 27, 2008)

Released 6/17/2008
05-00-89-072B: Fuel and Oil Additives - Facts and Myths/Maximizing Fuel Economy - (Jun 17, 2008)

Released 5/8/2008
04-06-04-036E: Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) - (May 8, 2008)

Released 5/1/2008
PIP4403: Control Module Ignition On Timer Performance DTC P2610 - keywords 6.6 cal calibration ECM engine LBZ LLY MIL replace replacement - (May 1, 2008)

Released 4/30/2008
06-00-89-050B: Diagnostic Trouble Codes (DTCs) Required on Repair Orders - (Apr 30, 2008)

Released 2/19/2008
08-00-89-006: GM Training: February 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Feb 19, 2008)

Released 1/17/2008
04-00-89-053B: Engineering Information (EI) Process - (Jan 17, 2008)

Released 1/10/2008
08-06-04-003: New Tool Availability - EN-48974 - EGR Cooler Pressure Tester Adapter Set to Diagnose Duramax Diesel Engine EGR Cooler Leaks into Combustion Chamber - (Jan 10, 2008)

Released 12/17/2007
07-00-89-062: GM Training: December 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Dec 17, 2007)

Released 10/22/2007
06-06-04-063C: 6.6L Duramax LBZ, LLY, LMM Diesel Engine EGR Valve Motor is Now Serviceable Separately from EGR Valve Assembly - (Oct 22, 2007)

Released 10/15/2007
07-00-89-052: GM Training: October 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Oct 15, 2007)

Released 8/23/2007
07-00-89-043: Warranty Admin. - Use of Parts and Components (Including Control Module Calibrations) Not Issued Through General Motors - (Aug 23, 2007)

Released 8/17/2007
07-00-89-039: GM Training: August 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Aug 17, 2007)

Released 6/26/2007
07-00-89-025: GM Training: April 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Jun 26, 2007)

Released 6/26/2007
07-00-89-024: GM Training: Service Training Standard (STS) Effective Date for Two Required Technology Close-ups (TCUs) was 04/14/07 (U.S. Dealers) - (Jun 26, 2007)

Released 6/26/2007
07-00-89-011: GM Training: Course Information (For U.S. Dealers and Aftermarket) - (Jun 26, 2007)

Released 1/11/2007
07-06-04-002: Reduced Engine Power, SES Light Illuminated, DTCs P0107 or P0108 Set Due to MAP Sensor Disconnection (Replace Air Cleaner Assembly and Reconnect MAP Sensor Connector) - (Jan 11, 2007)

Released 10/24/2006
06-06-04-057: Warranty Admin. - Revised Mass Air Flow Core Return Requirements - (Oct 24, 2006)

Released 8/4/2006
06-06-04-037: Info - Normal Characteristics of Malfunction Indicator Lamp (MIL) During On-Board Diagnostic (OBD) Inspection/Maintenance (I/M) Testing - (Aug 4, 2006)

Released 4/27/2006
05-08-133-001A: Diagnostic Information for Inoperative Air Seats, Air Horn and/or Exhaust Brake and Release of New Auxiliary Air Compressor Relay and Pressure Switch on RPO K16 Vehicles - (Apr 27, 2006)

Released 11/2/2005
05-00-89-075: Warranty Admin. - Servicing Medium Duty Trucks, Including Conventional and Crew Cabs, Motorhome Cutaway Cab, Commercial Cutaway Cab (Ambulance, School Bus, Shuttle Bus), and Tilt Cabs - (Nov 2, 2005)

Released 1/17/1997
Car and Truck Fix it Right the First Time Issues

Released 9/14/2010
Car and Truck Fix It Right the First Time Issues

Released 10/28/2009
Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V8 Gas Engines

Released 9/9/2009
Diagnostic Information for Inoperative Air Seats, Air Horn and/or Exhaust Brake and Release of New Auxiliary Air Compressor Relay and Pressure Switch on RPO K16 Vehicles

Released 5/11/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 5/6/2009
Car and Truck Fix It Right the First Time Issues

Released 3/20/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 10/6/2008
08-00-89-036: GM Training - GM STC Training Location Changes (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-033: GM Training - October 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-034: GM Training - Accessing Hands-On Checklists (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 6/27/2008
07-00-89-047B: Technical Assistance Center (TAC) Coverage Available for Current and Last Nine Model Year Vehicles (U.S. Only) - (Jun 27, 2008)

Released 2/4/2008
06-06-01-010A: Info on Close-Coupled Converter, Engine Breakdown or Non-Function Due to Severe Overheat/Lack of Oil Causing Pistons, Rods, Crankshaft, Cylinders/Heads, Camshaft, Intake/Exhaust Valves, Bearing Damage - (Feb 4, 2008)

Released 8/17/2007
07-00-89-039: GM Training: August 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Aug 17, 2007)

Released 12/22/2005
02-00-89-006C: Warranty Admin. - New Add Time for Labor Operation L2300 - Converter, Oxidation Catalytic-Replace - (Dec 22, 2005)

Released 11/2/2005
05-00-89-075: Warranty Admin. - Servicing Medium Duty Trucks, Including Conventional and Crew Cabs, Motorhome Cutaway Cab, Commercial Cutaway Cab (Ambulance, School Bus, Shuttle Bus), and Tilt Cabs - (Nov 2, 2005)

Released 7/16/2014
Duramax Diesel Glow Plugs Difficult to Install Due to Carbon Buildup - New Glow Plug Bore Reamer Available

Released 1/1/2013
Various Driveability Symptoms Due to Clogged Fuel Injectors, MIL/SES DTCs P0171, P0172, P0174, P0300, P1174, P1175 (Clean Fuel Injectors and/or Perform Injector Test With AFIT CH-47976)

Released 7/22/2011
Car and Truck Fix it Right the First Time Issues

Released 7/15/2011
Key Code Security Rules and Information on GM KeyCode Look-Up Application (Canada Only)

Released 10/27/2010
TOP TIER Detergent Gasoline Information and Available Brands (Deposits, Fuel Economy, No Start, Stall Concerns) Canada Only

Released 4/29/2010
Unnecessary Flushing Services, Additive Recommendations and Proper Utilization of GM Simplified Maintenance Schedule to Enhance Customer Service Experience

Released 3/4/2010
Car and Truck Fix It Right the First Time Issues

Released 2/4/2010
Car and Truck Fix It Right the First Time Issues

Released 1/28/2010
Malfunction Indicator Lamp (MIL) Illuminated, Intermittent DTC P0191, Slow Fuel Rail Pressure (FRP) Decay, Wiring Harness Connections, Voltage Fluctuations/Interruptions (Follow Correction Information

Released 11/17/2009
Paint Peeling on Saddle Type Fuel Tanks (Refinish Tanks)

Released 11/10/2009
Information on Servicing Duramax Diesel Fuel Injectors to Avoid and Remove Contamination

Released 9/2/2009
Paint Peeling on Saddle Type Fuel Tanks (Refinish Tanks)

Released 8/17/2009
TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - Canada ONLY

Released 8/17/2009
TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only

Released 7/20/2009
LBZ, LLY, LMM MIL/SES Light On, DTC P0087-Fuel Rail Pressure (FRP) Too Low, Lack of Performance, No Power, Engine Runs Rough, No Start (Diagnose Fuel System Components)

Released 5/11/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 5/6/2009
Car and Truck Fix It Right the First Time Issues

Released 5/5/2009
Engine Oil Leaks from Charge Air Cooler and Turbocharger Air Inlet Adapter (Replace Clamp and/or Turbo Inlet Duct/Pipe)

Released 4/29/2009
Malfunction Indicator Lamp (MIL) Illuminated, Intermittent DTC P0191, Slow Fuel Rail Pressure (FRP) Decay, Wiring Harness Connections, Voltage Fluctuations/Interruptions (Follow Correction Info Below)

Released 4/22/2009
Various Driveability Symptoms Due to Clogged Fuel Injectors, MIL/SES DTCs P0171, P0172, P0174, P0300, P1174, P1175 (Clean Fuel Injectors and/or Perform Injector Test with AFIT CH-47976)

Released 4/3/2009
LBZ, LLY, LMM MIL/SES Light, DTC P0087 - Fuel Rail Pressure (FRP) Too Low, Lack of Performance, No Power, Engine Runs Rough, No Start (Diagnose Fuel System Components)

Released 3/20/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 3/9/2009
Car and Truck Fix It Right the First Time Issues

Released 3/2/2009
Information on Improved Fuel Filter for 6.6L Duramax Diesel Engine

Released 1/13/2009
Information on Diesel Fuel Additives

Released 11/6/2008
GM Training - November 2008 New Course Information (For U.S. Dealers and Aftermarket)

Released 10/9/2008
03-06-93-001D: Diagnostic Information on Turbocharger Malfunction Due to Lack of Engine Oil for LBZ, LB7, LLY and LMM Duramax Diesel Engine - (Oct 9, 2008)

Released 10/6/2008
08-00-89-036: GM Training - GM STC Training Location Changes (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-033: GM Training - October 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-034: GM Training - Accessing Hands-On Checklists (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/1/2008
08-06-04-029A: LBZ, LLY, LMM MIL/SES Light On DTC P0087 - Fuel Rail Pressure (FRP) Too Low, Lack of Performance, No Power, Engine Runs Rough, No Start (Diagnose Fuel System Components) - (Oct 1, 2008)

Released 8/6/2008
05-06-04-022E: TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - Canada ONLY - (Aug 6, 2008)

Released 6/27/2008
07-00-89-047B: Technical Assistance Center (TAC) Coverage Available for Current and Last Nine Model Year Vehicles (U.S. Only) - (Jun 27, 2008)

Released 6/24/2008
04-06-04-047H: TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only - (Jun 24, 2008)

Released 6/17/2008
05-00-89-072B: Fuel and Oil Additives - Facts and Myths/Maximizing Fuel Economy - (Jun 17, 2008)

Released 5/1/2008
PIP4403: Control Module Ignition On Timer Performance DTC P2610 - keywords 6.6 cal calibration ECM engine LBZ LLY MIL replace replacement - (May 1, 2008)

Released 4/30/2008
06-00-89-050B: Diagnostic Trouble Codes (DTCs) Required on Repair Orders - (Apr 30, 2008)

Released 2/19/2008
08-00-89-006: GM Training: February 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Feb 19, 2008)

Released 2/6/2008
05-00-89-078B: GM Fuel System Treatment PLUS, Fuel Sending Unit Corrosion and Fuel System Deposits - (Feb 6, 2008)

Released 2/5/2008
06-06-04-035A: Use of E85 Fuels in Vehicles Not Certified by GM as being FlexFuel Compatible/Aftermarket Conversion of Vehicles to Operate on E85 Fuels - (Feb 5, 2008)

Released 12/17/2007
07-00-89-062: GM Training: December 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Dec 17, 2007)

Released 11/13/2007
07-00-89-056: GM Training: November 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Nov 13, 2007)

Released 8/17/2007
07-00-89-039: GM Training: August 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Aug 17, 2007)

Released 8/13/2007
02-07-30-042C: Allison Transmission Service Repairs - (Aug 13, 2007)

Released 7/30/2007
05-06-04-035C: Usage of E85 Fuels in GM Vehicles - (Jul 30, 2007)

Released 6/26/2007
07-00-89-025: GM Training: April 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Jun 26, 2007)

Released 6/26/2007
07-00-89-011: GM Training: Course Information (For U.S. Dealers and Aftermarket) - (Jun 26, 2007)

Released 6/21/2007
00-06-01-026B: Intake Manifold Inspection/Replacement After Severe Internal Engine Damage - (Jun 21, 2007)

Released 2/20/2007
03-06-04-017D: Information on Diesel Fuel Additives - (Feb 20, 2007)

Released 1/24/2007
06-00-89-051A: KeyCode Security Rules and Information on GM KeyCode Look-Up Application - (Jan 24, 2007)

Released 1/11/2007
07-06-04-002: Reduced Engine Power, SES Light Illuminated, DTCs P0107 or P0108 Set Due to MAP Sensor Disconnection (Replace Air Cleaner Assembly and Reconnect MAP Sensor Connector) - (Jan 11, 2007)

Released 12/19/2006
06-06-04-067: LLY Diesel Engine SES/MIL MAP Sensor DTCs P0106, P0107 Reduced Engine Power and/or Lack of Performance (Replace AIr Cleaner Outlet Duct) - (Dec 19, 2006)

Released 11/6/2006
06-06-04-060: SMU - Discontinue Use of Sealer on Fuel Injection Line Fittings - (Nov 6, 2006)

Released 10/24/2006
06-06-04-057: Warranty Admin. - Revised Mass Air Flow Core Return Requirements - (Oct 24, 2006)

Released 10/17/2006
03-06-04-036A: Information on Servicing Fuel Injectors to Avoid Contamination - (Oct 17, 2006)

Released 8/11/2006
06-06-04-041: Info on Utra Low Sulfur Diesel Fuel and Warning Labels on Fuel Station Pumps -This Info Applies to Diesel Engines w/RPOs LBZ, LB7, LH6, LLY, LMM, LL4, LQM, LQN, L49, L56, L57, L65, LG4, 1C3, 1C2, 1L5 - (Aug 11, 2006)

Released 5/15/2006
06-06-04-030: Locations of E85 Refueling Stations and Expanded E85 Information - (May 15, 2006)

Released 4/27/2006
05-08-133-001A: Diagnostic Information for Inoperative Air Seats, Air Horn and/or Exhaust Brake and Release of New Auxiliary Air Compressor Relay and Pressure Switch on RPO K16 Vehicles - (Apr 27, 2006)

Released 4/3/2006
05-08-64-002B: Door Latch Freezing in Cold Temperatures (Apply Super Lube) - (Apr 3, 2006)

Released 1/4/2006
04-06-04-051B: Info - Maintenance Cleaning of Fuel Injectors - (Jan 4, 2006)

Released 11/2/2005
05-00-89-075: Warranty Admin. - Servicing Medium Duty Trucks, Including Conventional and Crew Cabs, Motorhome Cutaway Cab, Commercial Cutaway Cab (Ambulance, School Bus, Shuttle Bus), and Tilt Cabs - (Nov 2, 2005)

Released 7/29/2005
#04-06-04-070A: Information on a Revised Fuel Filter for 6.6L LLY and LB7 Duramax Diesel Engine - (Jul 29, 2005)

Released 8/10/2011
Air Conditioning Odor (Install Evaporator Core Dryer Kit and Apply Cooling Coil Coating)

Released 7/22/2011
Car and Truck Fix it Right the First Time Issues

Released 12/23/2010
Information on Passenger Presence Sensing System (PPS or PSS) Concerns with Custom Upholstery, Accessory Seat Heaters or Other Comfort Enhancing Devices

Released 4/29/2010
Unnecessary Flushing Services, Additive Recommendations and Proper Utilization of GM Simplified Maintenance Schedule to Enhance Customer Service Experience

Released 3/4/2010
Car and Truck Fix It Right the First Time Issues

Released 2/25/2010
Repair Information for Reconnection of Rear Window Defroster Contact or Tab

Released 2/4/2010
Car and Truck Fix It Right the First Time Issues

Released 6/12/2009
Air Conditioning Odor (Install Evaporator Core Dryer Kit and Apply Cooling Coil Coating)

Released 5/26/2009
Repair Information for Reconnection of Rear Window Defroster Contact or Tab

Released 5/11/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 5/6/2009
Car and Truck Fix It Right the First Time Issues

Released 3/20/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 10/6/2008
08-00-89-036: GM Training - GM STC Training Location Changes (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-033: GM Training - October 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-034: GM Training - Accessing Hands-On Checklists (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 9/29/2008
00-00-89-027E: Eliminating Unwanted Odors in Vehicles - (Sep 29, 2008)

Released 6/27/2008
07-00-89-047B: Technical Assistance Center (TAC) Coverage Available for Current and Last Nine Model Year Vehicles (U.S. Only) - (Jun 27, 2008)

Released 4/30/2008
06-00-89-050B: Diagnostic Trouble Codes (DTCs) Required on Repair Orders - (Apr 30, 2008)

Released 12/17/2007
07-00-89-062: GM Training: December 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Dec 17, 2007)

Released 11/12/2007
06-00-89-026A: Customer Concern Not Duplicated/Verified Labor Operations - (Nov 12, 2007)

Released 10/15/2007
07-00-89-052: GM Training: October 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Oct 15, 2007)

Released 8/23/2007
07-00-89-043: Warranty Admin. - Use of Parts and Components (Including Control Module Calibrations) Not Issued Through General Motors - (Aug 23, 2007)

Released 8/17/2007
07-00-89-039: GM Training: August 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Aug 17, 2007)

Released 6/26/2007
07-00-89-011: GM Training: Course Information (For U.S. Dealers and Aftermarket) - (Jun 26, 2007)

Released 5/29/2007
99-01-39-004B: Air Conditioning Odor (Install Evaporator Core Dryer Kit and Apply Cooling Coil Coating) - (May 29, 2007)

Released 12/19/2006
06-06-04-067: LLY Diesel Engine SES/MIL MAP Sensor DTCs P0106, P0107 Reduced Engine Power and/or Lack of Performance (Replace AIr Cleaner Outlet Duct) - (Dec 19, 2006)

Released 7/25/2006
06-01-39-007: Info - Contaminated R134a Refrigerant Found on Market for Automotive Air-Conditioning Systems - (Jul 25, 2006)

Released 4/27/2006
05-08-133-001A: Diagnostic Information for Inoperative Air Seats, Air Horn and/or Exhaust Brake and Release of New Auxiliary Air Compressor Relay and Pressure Switch on RPO K16 Vehicles - (Apr 27, 2006)

Released 11/16/2005
02-01-39-004B: Info - New PAG Oil Released - (Nov 16, 2005)

Released 11/2/2005
05-00-89-075: Warranty Admin. - Servicing Medium Duty Trucks, Including Conventional and Crew Cabs, Motorhome Cutaway Cab, Commercial Cutaway Cab (Ambulance, School Bus, Shuttle Bus), and Tilt Cabs - (Nov 2, 2005)

Released 10/31/2015
Allison LCT1000 Clunk When Shifting Into Or Out Of Park or On Start Up In Park

Released 8/1/2015
Information for Identifying Non-GM ECM Calibration Use and Power-up Hardware Detection in Duramax Diesel Engines - Photograph Tech 2 Calibration IDs, Calibration Verification Numbers (CVNs) and Transmission Data Screen

Released 5/12/2015
Information on Higher Than Expected Oil Consumption

Released 8/26/2014
Information on Identifying Duramax Diesel Overpower Engine Breakdown/Non-Function Due to Aftermarket Power-Up Devices vs Non Overpower Engine Non-Function of Pistons, Cylinders, Valvetrain Components, DTC P003A or P111D Set

Released 7/17/2014
Alleged Cylinders Out Of Round

Released 6/19/2013
Information on Slight Vehicle Movement in Park at Start Up After Cold Soak

Released 6/19/2013
Global Information for GM dexos 1 and dexos 2 Engine Oil Specifications, Licensed Brands, and Service Fill

Released 4/12/2013
Information on Driveline Clunk Noise

Released 3/22/2013
Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V6 and V8 Gasoline Engines Using Tech 2 or Global Diagnostic System 2 (GDS 2)

Released 3/22/2013
Aftermarket ALDL or DLC Interface Devices Causing Multiple Issues

Released 3/22/2013
Vibration Analysis Worksheet

Released 2/8/2013
HYDRA-MATIC Front Wheel Drive 4T80-E (MH1) Left Front Axle Seal Leak, Transmission Slips in Gear (Replace Third Clutch Housing with Revised Service Part)

Released 2/1/2013
Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V6 and V8 Gasoline Engines Using Tech 2 or Global Diagnostic System 2 (GDS 2)

Released 1/1/2013
Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V8 Gasoline Engines Using Tech 2 or Global Diagnostic System 2 (GDS 2)

Released 9/4/2012
Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V8 Gasoline Engines Using Tech 2 or Global Diagnostic System 2 (GDS 2)

Released 9/4/2012
Information on Normal Maintenance or Warranty Service for 4T40, 4T45, 4T65, 4L60 Automatic Transmission Oil Pan Magnet Upgrade

Released 5/23/2012
Guidelines for Usage of Transmission K Labor Operation Recondition Add Time (Bulletin Canceled)

Released 3/27/2012
Information on Diesel Engine Ticking Noise

Released 3/5/2012
Warranty, SPS, Control Module Diagnostics and Configuration Information, Programming, Set-Up

Released 3/3/2012
Warranty, SPS, Control Module Diagnostics and Configuration Information, Programming, Set-Up

Released 10/24/2011
Use of Surface Conditioning Disks When Cleaning Engine Gasket Sealing Surfaces and/or Reused Engine Parts

Released 7/22/2011
Car and Truck Fix it Right the First Time Issues

Released 5/17/2011
Information on Slight Vehicle Movement in Park at Start Up After Cold Soak

Released 5/6/2011
Information on Driveline Clunk Noise when Shifting Between PARK and DRIVE, PARK and REVERSE or DRIVE and REVERSE

Released 4/28/2011
Information on Diesel Engine Ticking Noise

Released 4/7/2011
Release of DEXRON-VI Automatic Transmission Fluid (ATF)

Released 3/28/2011
Engine and Automatic Transmission/Transaxle Identification

Released 2/7/2011
Identifying Non-GM ECM Calibration Usages for Duramax Diesel Engines and Power-up Hardware Detection

Released 12/15/2010
Manual Transmission Operating Characteristics

Released 11/18/2010
Information - Non-GM Parts and Accessories (Aftermarket)

Released 11/1/2010
Information on Water or Ethylene Glycol in Transmission Fluid

Released 9/14/2010
Car and Truck Fix It Right the First Time Issues

Released 8/6/2010
Information on Drilling High Strength Steel Related to Collision Repair

Released 7/23/2010
Information on Engine Ticking Noise

Released 5/12/2010
Warranty Administration - Change in Automatic Transmission Add Condition Documentation and Claim Submission

Released 5/7/2010
Identifying Aftermarket Engine and Transmission Calibrations-GasPowered Engines Only and Automatic Transmission

Released 4/29/2010
Unnecessary Flushing Services, Additive Recommendations and Proper Utilization of GM Simplified Maintenance Schedule to Enhance Customer Service Experience

Released 3/31/2010
Information on Identifying Duramax Diesel LB7, LLY, LMM, LBZ Overpower Engine Breakdown/Non-Function Due to Aftermarket Power-Up Devices vs Non Overpower Engine Non-Function of Pistons, Cylinders

Released 3/4/2010
Car and Truck Fix It Right the First Time Issues

Released 2/24/2010
Information on Identifying Duramax Diesel LB7, LLY, LMM, LBZ Overpower Engine Breakdown or Non-Function Due to Aftermarket Power-Up Devices vs Non-Overpower Engine Non-Function of Pistons, Cylinders

Released 2/23/2010
Current Model Year Goodwrench Transmission Replacement Assembly Program

Released 2/5/2010
Information on 2-3 Upshift or 3-2 Downshift Clunk Noise

Released 2/4/2010
Car and Truck Fix It Right the First Time Issues

Released 2/3/2010
Intake Manifold Inspection/Replacement After Severe Internal Engine Damage

Released 1/12/2010
Guidelines for Usage of Transmission K Labor Operation Recondition Add Time

Released 12/17/2009
Warranty Administration - Change in Automatic Transmission Add Condition Documentation and Claim Submission

Released 12/11/2009
Unnecessary Engine Crankcase and Subsystems Flushing Services, Additive Recommendations and Proper Utilization of GM Simplified Maintenance Schedule to Enhance Customer Service Experience

Released 12/1/2009
Information on Water or Ethylene Glycol in Transmission Oil

Released 11/13/2009
Current Model Year Goodwrench Transmission Replacement Assembly Program

Released 11/9/2009
Identifying Non-GM ECM Calibration Usages and Power-Up Hardware Detection for Duramax Diesel Engines-Photograph Tech 2 Calibration IDs and CVNs and Trans Data Screen Before Removing Engine/Trans

Released 11/4/2009
Car and Truck Fix It Right the First Time Issues

Released 11/2/2009
Information on Driveline Clunk Noise When Shifting Between PARK and DRIVE, PARK and REVERSE or DRIVE and REVERSE

Released 10/30/2009
Information on 6.6L LBZ, LB7, LLY Duramax Diesel Engine Cylinder Head Gasket Design Change-New Head Gasket Part Numbers and Head Bolt Torque Specifications

Released 10/28/2009
Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V8 Gas Engines

Released 10/6/2009
Product Quality Center (PQC) for Engine, Transmission Assembly and Transfer Case Replacement

Released 10/1/2009
Engine and Automatic Transmission/Transaxle Identification

Released 9/14/2009
Info on Identifying Duramax Diesel LB7, LLY, LMM, LBZ Overpower Engine Breakdown or Non-Function Due to Aftermarket Power-Up Devices vs Non-Overpower Engine Non-Function of Pistons, Cylinders, Valve

Released 9/9/2009
Automatic Transmission Oil Cooler Flush and Flow Test Essential Tool J 45096 TransFlow

Released 7/29/2009
Manual Transmission Operating Characteristics

Released 7/27/2009
Information on Internal Engine Noise or Damage After Oil Filter Replacement

Released 7/22/2009
Guidelines for Usage of Transmission K Labor Operation Recondition Add Time

Released 6/24/2009
Allison Transmission Service Repairs

Released 6/15/2009
GM Training - June 2009 New Course Information (For U.S. Dealers and Aftermarket)

Released 6/3/2009
New Ordering Process for Propeller Shafts or Prop-Shaft Systems Through GMSPO

Released 5/18/2009
Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V8 Gas Engines

Released 5/11/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 5/6/2009
Car and Truck Fix It Right the First Time Issues

Released 5/5/2009
Information on Normal Maintenance or Warranty Service for 4T40, 4T45, 4T65, 4L60 Automatic Transmission Oil Pan Magnet Upgrade

Released 5/5/2009
Engine Oil Leaks from Charge Air Cooler and Turbocharger Air Inlet Adapter (Replace Clamp and/or Turbo Inlet Duct/Pipe)

Released 5/1/2009
Vibration Analysis Worksheet

Released 4/24/2009
Information on Engine Ticking Noise

Released 3/20/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 3/9/2009
Car and Truck Fix It Right the First Time Issues

Released 2/6/2009
GM Training - February 2009 New Course Information (For U.S. Dealers and Aftermarket)

Released 1/29/2009
Diagnostic Tips for Automatic Transmission DTC P0756, Second, Third, Fourth Gear Start

Released 1/12/2009
Warranty Administration - Labor Op T2020 - Tow, Add Time to Reconnect Prop Shaft

Released 1/12/2009
Information on Higher Than Expected Oil Consumption

Released 1/12/2009
GM Training - January 2009 New Course Information (For U.S. Dealers and Aftermarket)

Released 1/9/2009
Information on Engine Ticking Noise

Released 1/8/2009
Preventing Damage on Dealer Lots During Longer Periods in Dealer Inventory and Maintaining High CSI Scores

Released 12/18/2008
Identifying Aftermarket Engine and Transmission Calibrations 2.0L, 2.2L, 2.4L, 2.8L, 2.9L, 3.0L, 3.1L, 3.2L, 3.4L 3.5L, 3.6L, 3.8L, 3.9L, 4.2L, 4.3L, 4.4L, 4.6L, 5.0L, 5.3L, 5.7L 6.0L, 6.2L 7.0L, 7.4L

Released 12/17/2008
Higher Than Expected Oil Consumption at 8600 GVW and Above

Released 11/26/2008
GM Training - December 2008 New Course Information (For U.S. Dealers and Aftermarket)

Released 11/6/2008
GM Training - November 2008 New Course Information (For U.S. Dealers and Aftermarket)

Released 11/6/2008
Information on 6.6L Duramax LLY Diesel Engine Fire Truck Application Power Take-Off (PTO) Modification to Add-On 3rd Gear Drive for Split Shaft Pump

Released 10/16/2008
06-06-01-007C: Identifying Duramax DIesel LB7, LLY, LMM, LBZ Overpower Engine Breakdown or Non-Function Due to Aftermarket Power-Up Devices vs. Non-Overpower Engine Non-Function of Pistons, Cylinders, Valvetrain Com - (Oct 16, 2008)

Released 10/9/2008
03-06-93-001D: Diagnostic Information on Turbocharger Malfunction Due to Lack of Engine Oil for LBZ, LB7, LLY and LMM Duramax Diesel Engine - (Oct 9, 2008)

Released 10/6/2008
08-00-89-036: GM Training - GM STC Training Location Changes (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-033: GM Training - October 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-034: GM Training - Accessing Hands-On Checklists (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/1/2008
08-06-04-029A: LBZ, LLY, LMM MIL/SES Light On DTC P0087 - Fuel Rail Pressure (FRP) Too Low, Lack of Performance, No Power, Engine Runs Rough, No Start (Diagnose Fuel System Components) - (Oct 1, 2008)

Released 8/18/2008
02-06-01-022H: Information on Engine Ticking Noise - (Aug 18, 2008)

Released 8/6/2008
05-06-04-022E: TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - Canada ONLY - (Aug 6, 2008)

Released 7/31/2008
06-06-04-066C: LBZ, LLY Engine MIL/SES Light On With DTC P0403 Set (Check/Reprogram ECM and Perform EGR Valve Motor Cleaning Procedure) - (Jul 31, 2008)

Released 6/27/2008
07-00-89-047B: Technical Assistance Center (TAC) Coverage Available for Current and Last Nine Model Year Vehicles (U.S. Only) - (Jun 27, 2008)

Released 6/27/2008
08-06-04-006B: Information on Identifying Non-GM Calibration Usages for LMM Duramax Diesel Engine - (Jun 27, 2008)

Released 6/24/2008
04-06-04-047H: TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only - (Jun 24, 2008)

Released 6/17/2008
05-00-89-072B: Fuel and Oil Additives - Facts and Myths/Maximizing Fuel Economy - (Jun 17, 2008)

Released 6/10/2008
08-00-89-021: Servicing Medium Duty Trucks, Including Conventional and Crew Cabs, Motorhome Cutaway Cab, Commercial Cutaway Cab (Ambulance, School Bus, Shuttle Bus) and Tilt Cabs - (Jun 10, School Bus, Shuttle Bus) and Tilt Cabs - (Jun 10, 2008)

Released 5/12/2008
01-07-30-010C: Automatic Transmission/Transaxle Torque Converter Replacement - (May 12, 2008)

Released 5/2/2008
03-07-29-004E: Manual Transmission Operating Characteristics - (May 2, 2008)

Released 5/1/2008
PIP4403: Control Module Ignition On Timer Performance DTC P2610 - keywords 6.6 cal calibration ECM engine LBZ LLY MIL replace replacement - (May 1, 2008)

Released 4/30/2008
06-00-89-050B: Diagnostic Trouble Codes (DTCs) Required on Repair Orders - (Apr 30, 2008)

Released 4/28/2008
07-00-89-031A: Warranty System Changes - Medium Duty Trucks - (Apr 28, 2008)

Released 4/14/2008
00-06-01-012C: Use of Surface Conditioning Disks When Cleaning Engine Gasket Sealing Surfaces and/or Reused Engine Parts - (Apr 14, 2008)

Released 4/2/2008
06-06-01-006B: Information on 6.6L LBZ, LB7, LLY Duramax Diesel Engine Cylinder Head Gasket Design Change - New Head Gasket Part Numbers and Head Bolt Torque Specifications - (Apr 2, 2008)

Released 2/22/2008
02-07-30-052E: Automatic Transmission Oil Cooler Flush and Flow Test Essential Tool J 45096 TransFlow - (Feb 22, 2008)

Released 2/5/2008
04-06-01-029B: Unnecessary Engine Crankcase and Subsystems Flushing Services, Additive Recommendations and Proper Utilization of GM Simplified Maintenance Schedule to Enhance Customer Service Experience - (Feb 5, 2008)

Released 2/4/2008
06-06-01-010A: Info on Close-Coupled Converter, Engine Breakdown or Non-Function Due to Severe Overheat/Lack of Oil Causing Pistons, Rods, Crankshaft, Cylinders/Heads, Camshaft, Intake/Exhaust Valves, Bearing Damage - (Feb 4, 2008)

Released 1/17/2008
04-00-89-053B: Engineering Information (EI) Process - (Jan 17, 2008)

Released 1/17/2008
08-00-89-003: GM Training: January 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Jan 17, 2008)

Released 1/10/2008
08-06-04-003: New Tool Availability - EN-48974 - EGR Cooler Pressure Tester Adapter Set to Diagnose Duramax Diesel Engine EGR Cooler Leaks into Combustion Chamber - (Jan 10, 2008)

Released 12/17/2007
07-00-89-062: GM Training: December 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Dec 17, 2007)

Released 11/21/2007
04-07-30-037D: Release of DEXRON-VI Automatic Transmission Fluid (ATF) - (Nov 21, 2007)

Released 11/13/2007
07-00-89-056: GM Training: November 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Nov 13, 2007)

Released 11/12/2007
06-00-89-026A: Customer Concern Not Duplicated/Verified Labor Operations - (Nov 12, 2007)

Released 10/22/2007
06-06-04-063C: 6.6L Duramax LBZ, LLY, LMM Diesel Engine EGR Valve Motor is Now Serviceable Separately from EGR Valve Assembly - (Oct 22, 2007)

Released 10/17/2007
06-04-21-004A: Information on Driveline Vibration Analysis and Correction - (Oct 17, 2007)

Released 10/15/2007
07-00-89-052: GM Training: October 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Oct 15, 2007)

Released 9/28/2007
05-06-01-010B: Service Information Update on Consolidating Use of GM Liquid Gasket/Engine Sealants and New Sealant Dispenser GE-48326 Essential Tool - (Sep 28, 2007)

Released 9/17/2007
07-06-01-016A: Information on Internal Engine Noise or Damage After Oil Filter Replacement - (Sep 17, 2007)

Released 8/27/2007
07-08-49-003A: Information on Engine Hourmeter Reading Not Being Transferred to New IPCs - (Aug 27, 2007)

Released 8/23/2007
07-00-89-043: Warranty Admin. - Use of Parts and Components (Including Control Module Calibrations) Not Issued Through General Motors - (Aug 23, 2007)

Released 8/17/2007
07-00-89-039: GM Training: August 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Aug 17, 2007)

Released 8/13/2007
02-07-30-042C: Allison Transmission Service Repairs - (Aug 13, 2007)

Released 7/30/2007
05-06-04-035C: Usage of E85 Fuels in GM Vehicles - (Jul 30, 2007)

Released 7/25/2007
07-00-89-033: GM Training - June 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Jul 25, 2007)

Released 6/27/2007
07-00-89-028: GM Training: May 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Jun 27, 2007)

Released 6/22/2007
99-08-64-016B: Use of Silicone for Weatherstrip Maintenance - (Jun 22, 2007)

Released 6/21/2007
00-06-01-026B: Intake Manifold Inspection/Replacement After Severe Internal Engine Damage - (Jun 21, 2007)

Released 6/12/2007
07-07-30-017: Allison 1000 and 2000 Series Six Speed Automatic Transmission Fluid Loss Out of Main Housing Rear Breather in Cold Ambient Conditions During Engine Start Up (Vent Transmission Fluid Fill Tube) - (Jun 12, 2007)

Released 6/5/2007
04-06-01-019A: GM Performance Parts Engine Warranty Q and A - (Jun 5, 2007)

Released 4/3/2007
07-00-89-009: Warranty Administration - Labor Op T2020 - Tow, Add Time to Reconnect Prop Shaft - (Apr 3, 2007)

Released 3/30/2007
02-08-42-004A: Info - PRNDL Display Reduced Visibility for Approximately One Minute - (Mar 30, 2007)

Released 3/7/2007
07-06-01-003: LBZ LB7 LLY 6.6L Duramax Diesel Engine Accessory Drive Belt Chirp, Squeal or Squeak Type Noise at Cold Start Idle (Replace Accessory Drive Belt) - (Mar 7, 2007)

Released 1/11/2007
04-06-04-054A: Info - Non-GM Parts and Accessories (Aftermarket) - (Jan 11, 2007)

Released 1/11/2007
07-06-04-002: Reduced Engine Power, SES Light Illuminated, DTCs P0107 or P0108 Set Due to MAP Sensor Disconnection (Replace Air Cleaner Assembly and Reconnect MAP Sensor Connector) - (Jan 11, 2007)

Released 11/28/2006
04-06-04-001C: LB7/LBZ/LLY/LMM - Intermittent Driveability Conditions-No Crank, Crank No Start, Hard to Start, MIL/SES, HEsitation, Lack of Power, Surge, Misfire, Fuel Knock, IPC Indicates No Oil Pressure, DTCs Set - (Nov 28, 2006)

Released 11/9/2006
04-04-20-005A: Axle Lubricant Present at Rear Wheel Hubs (Install New Rear Wheel Bearing Seal) - (Nov 9, 2006)

Released 10/24/2006
06-06-04-057: Warranty Admin. - Revised Mass Air Flow Core Return Requirements - (Oct 24, 2006)

Released 10/17/2006
03-06-04-036A: Information on Servicing Fuel Injectors to Avoid Contamination - (Oct 17, 2006)

Released 9/19/2006
06-07-29-003: ML6 Manual Transmisison - Shift Lever May Unintentionally Move to the Neutral Position (Replace Shift Shaft Detent Plunger) - (Sep 19, 2006)

Released 9/12/2006
06-04-17-001A: Info - New Ordering Process for Propeller Shafts or Prop-Shaft Systems Through GMSPO - (Sep 12, 2006)

Released 8/17/2006
06-08-131-002: Information on 6.6L Duramax LLYDiesel Engine Fire Truck Application Power Take-Off (PTO) Modification to Add-On 3rd Gear Drive for Split Shaft Pump - (Aug 17, 2006)

Released 8/15/2006
00-06-02-006D: Engine Coolant Recycling and Warranty Information - (Aug 15, 2006)

Released 8/11/2006
06-06-04-041: Info on Utra Low Sulfur Diesel Fuel and Warning Labels on Fuel Station Pumps -This Info Applies to Diesel Engines w/RPOs LBZ, LB7, LH6, LLY, LMM, LL4, LQM, LQN, L49, L56, L57, L65, LG4, 1C3, 1C2, 1L5 - (Aug 11, 2006)

Released 8/4/2006
02-00-89-007A: Light and Medium Duty Truck Warranty and Crossline Warranty Eligibility and Guidelines for Chevrolet and GMC Dealers - (Aug 4, 2006)

Released 6/12/2006
06-00-89-031: Info - Engine and Automatic Transmission/Transaxle Identification - (Jun 12, 2006)

Released 5/25/2006
03-07-30-043A: Information Regarding Automatic Transmission Shift Lock Control Function - (May 25, 2006)

Released 5/8/2006
06-08-131-001A: Power Take-Off (PTO) Inoperative or Not Operating Properly (Check TCM Feedback Signal, Modify Wiring If Necessary) - (May 8, 2006)

Released 4/27/2006
05-08-133-001A: Diagnostic Information for Inoperative Air Seats, Air Horn and/or Exhaust Brake and Release of New Auxiliary Air Compressor Relay and Pressure Switch on RPO K16 Vehicles - (Apr 27, 2006)

Released 12/22/2005
02-00-89-006C: Warranty Admin. - New Add Time for Labor Operation L2300 - Converter, Oxidation Catalytic-Replace - (Dec 22, 2005)

Released 11/2/2005
05-00-89-075: Warranty Admin. - Servicing Medium Duty Trucks, Including Conventional and Crew Cabs, Motorhome Cutaway Cab, Commercial Cutaway Cab (Ambulance, School Bus, Shuttle Bus), and Tilt Cabs - (Nov 2, 2005)

Released 10/21/2005
05-06-04-067: Information on New Essential Tool EN-47909 Injector Bore Cleaning Kit for 6.6L Duramax Diesel Engine (RPOs LB7, LBZ, LLY) - (Oct 21, 2005)

Released 8/2/2005
05-04-21-004: Info - Guidelines for Proper Use of Labor Operation Numbers when Servicing Transfer Case - (Aug 2, 2005)

Released 7/29/2005
#04-06-04-070A: Information on a Revised Fuel Filter for 6.6L LLY and LB7 Duramax Diesel Engine - (Jul 29, 2005)

Released 5/17/2005
02-06-01-027A: Information on Higher Than Expected Oil Consumption - (May 17, 2005)

Released 1/17/1997
Car and Truck Fix it Right the First Time Issues

Released 6/21/2013
Product Safety - Recall of Master Cylinders (used with Hydro-Max Booster)

Released 2/6/2014
Information on Slight or Mild Tire Feathering and Recommended Practices (Normal Tire Wear Condition)

Released 1/4/2014
Proper Wheel Installation and Wheel Torque Techniques

Released 6/19/2013
Dealership Service Consultant Procedure as Vehicle Comes into Service Drive for Tire Pressure Monitor (TPM) System Message, Light and Customer Information

Released 3/22/2013
Aftermarket ALDL or DLC Interface Devices Causing Multiple Issues

Released 3/22/2013
Vibration Analysis Worksheet

Released 1/1/2013
Proper Wheel Installation and Wheel Torque Techniques

Released 5/17/2012
Information on Slight or Mild Tire Feathering and Recommended Practices (Normal Tire Wear Condition)

Released 3/27/2012
Hydraulic Power Steering System Leak - Required Diagnostic Actions

Released 12/3/2011
Information on Diagnosis and Replacement of Shock Absorber and Strut Due to Fluid Leak

Released 7/22/2011
Car and Truck Fix it Right the First Time Issues

Released 4/21/2011
Chemical Staining, Pitting, Corrosion and/or Spotted Appearance of Chromed Aluminum Wheels

Released 3/17/2011
Refinishing Aluminum Wheels

Released 12/13/2010
Guidelines for Using Labor Operations E0200, E0201, E0203, E0204 - Wheel Balance

Released 12/9/2010
Wheel Alignment Specifications, Requirements and Recommendations for GM Vehicles

Released 9/14/2010
Car and Truck Fix It Right the First Time Issues

Released 6/9/2010
Information on Proper Wheel Changing Procedures and Cautions

Released 6/7/2010
Guidelines for Using Labor Operations E2020 - Wheel Alignments, E2000 - Toe Adjust and E0200, E0201, E0203, E0204 - Wheel Balance

Released 5/19/2010
Warranty Administration - Labor Operation Z1111 - Suspected Tampering or Vehicle Modifications

Released 5/4/2010
Information on Tire Radial Force Variation (RFV)

Released 4/29/2010
Unnecessary Flushing Services, Additive Recommendations and Proper Utilization of GM Simplified Maintenance Schedule to Enhance Customer Service Experience

Released 4/28/2010
New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores

Released 4/27/2010
Use of Nitrogen Gas in Tires

Released 4/27/2010
Dealership Service Consultant Procedure as Vehicle Comes into Service Drive for Tire Pressure Monitor (TPM) System Message, Light and Customer Information

Released 4/27/2010
Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant)

Released 4/27/2010
Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum Wheel Bead Seat Corrosion (Clean and Resurface Wheel Bead Seat)

Released 4/13/2010
Revised GM of Canada New Vehicle Limited Warranty Tire Program and Global Warranty Management (GWM) Submission Rollout Information

Released 3/29/2010
Revised General Motors New Vehicle Tire Warranty Program and Global Warranty Management (GWM) Submission Rollout Information (U.S. Dealers Only)

Released 3/15/2010
Chemical Staining, Pitting, Corrosion and/or Spotted Appearance of Chromed Aluminum Wheels

Released 3/4/2010
Car and Truck Fix It Right the First Time Issues

Released 2/4/2010
Car and Truck Fix It Right the First Time Issues

Released 1/14/2010
Refinishing Aluminum Wheels

Released 12/17/2009
Information on Replacement Wheel Weights

Released 12/4/2009
Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant)

Released 12/4/2009
Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum Wheel Bead Seat Corrosion (Clean and Resurface Wheel Bead Seat)

Released 11/30/2009
GM of Canada New Vehicle Limited Warranty Tire Program

Released 11/4/2009
Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum Wheel Bead Seat Corrosion (Clean and Resurface Wheel Bead Seat)

Released 11/4/2009
Car and Truck Fix It Right the First Time Issues

Released 11/3/2009
Guidelines for Using Labor Operation E2020-Wheel Alignments, E2000-Toe Adjust and E0200, E0201, E0203, E0204-Wheel Balance

Released 11/3/2009
Information on Tire Radial Force Variation (RFV)

Released 10/30/2009
GM of Canada New Vehicle Limited Warranty Tire Program

Released 10/30/2009
Revised General Motors New Vehicle Tire Warranty Program

Released 10/16/2009
Information on Replacement of Shock Absorbers and Struts Due to Fluid Leaks

Released 10/8/2009
Statement on Tire Sealant Included in GM Inflator Kits (Supplied with New Vehicles or as GM Accessory)

Released 8/20/2009
Diagnostic Tips for Tire Vibration or Steering Wheel Shake (Oscillation) Concerns

Released 8/13/2009
Information on Slight or Mild Tire Feathering and Recommended Practices (Normal Tire Wear Condition)

Released 8/7/2009
Diagnostic Tips/Recommendations When Power Steering Pump Replacement Is Necessary

Released 8/5/2009
Information on Tire/Wheel Characteristics (Vibration, Balance, Shake, Flat Spotting) of GM Original Equipment Tires

Released 7/24/2009
Mounting, Balancing and Installation of Accessory Wheels and Tires Available Through GM Accessories

Released 5/11/2009
Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant)

Released 5/11/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 5/4/2009
Dealership Service Consultant Procedure as Vehicle Comes Into Service Drive for Tire Pressure Monitor (TPM) System Message, Light and Customer Information

Released 4/16/2009
Guidelines for Using E2020-Wheel Alignments, E2000-Toe Adjust and E0200, E0201, E0203, E0204-Wheel Balance

Released 4/2/2009
GM Tire Warranty Program Goodwill Guidelines (U.S. Only)

Released 3/31/2009
Use of Chrome or Chrome Plated Steel Valve Caps on Aluminum Valve Stems

Released 3/9/2009
Car and Truck Fix It Right the First Time Issues

Released 1/28/2009
Information on Proper Tire Pressure

Released 1/22/2009
Use of Nitrogen Gas in Tires

Released 1/8/2009
Preventing Damage on Dealer Lots During Longer Periods in Dealer Inventory and Maintaining High CSI Scores

Released 11/26/2008
Information on Slight or Mild Tire Feathering and Recommended Practices (Normal Tire Wear Condition)

Released 11/26/2008
Information on Tire Radial Force Variation (RFV)

Released 11/24/2008
Information on Tire/Wheel Characteristics (Vibration, Balance, Shake, Flat Spotting) of GM Original Equipment Tires

Released 10/6/2008
08-00-89-036: GM Training - GM STC Training Location Changes (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-033: GM Training - October 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-034: GM Training - Accessing Hands-On Checklists (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 8/29/2008
07-03-10-016C: Requirements for Changing Tire and Wheel Assemblies - New Vehicle Placard (U.S. and Canada Only) - (Aug 29, 2008)

Released 8/28/2008
08-08-44-028: Information on Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies) - (Aug 28, 2008)

Released 7/25/2008
05-03-08-002B: Replacement of Shock Absorbers and Struts and Use of Labor Operations E3800, E3801, E3807, E5800, E5801, E5807, E3850, E3857, E5750, E5751 and E5757 - (Jul 25, 2008)

Released 6/27/2008
07-00-89-047B: Technical Assistance Center (TAC) Coverage Available for Current and Last Nine Model Year Vehicles (U.S. Only) - (Jun 27, 2008)

Released 6/10/2008
08-00-89-021: Servicing Medium Duty Trucks, Including Conventional and Crew Cabs, Motorhome Cutaway Cab, Commercial Cutaway Cab (Ambulance, School Bus, Shuttle Bus) and Tilt Cabs - (Jun 10, School Bus, Shuttle Bus) and Tilt Cabs - (Jun 10, 2008)

Released 6/5/2008
07-08-64-022A: Information on Curb Park Assist and Memory Related Issues on Outside Rear View Mirrors - (Jun 5, 2008)

Released 4/30/2008
06-00-89-050B: Diagnostic Trouble Codes (DTCs) Required on Repair Orders - (Apr 30, 2008)

Released 4/14/2008
04-03-08-011D: Unnecessary Leaf Spring Clip Replacement - (Apr 14, 2008)

Released 2/1/2008
04-03-10-012B: Pitting and Brake Dust on Chrome Wheels - (Feb 1, 2008)

Released 1/3/2008
05-03-10-020A: Use of Nitrogen Gas in Tires - (Jan 3, 2008)

Released 11/6/2007
02-03-10-005B: Diagnostic Tips for Tire Vibration or Steering Wheel Shake (Oscillation) Concerns - (Nov 6, 2007)

Released 8/23/2007
07-00-89-043: Warranty Admin. - Use of Parts and Components (Including Control Module Calibrations) Not Issued Through General Motors - (Aug 23, 2007)

Released 8/17/2007
07-00-89-039: GM Training: August 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Aug 17, 2007)

Released 7/25/2007
07-00-89-033: GM Training - June 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Jul 25, 2007)

Released 6/26/2007
07-00-89-011: GM Training: Course Information (For U.S. Dealers and Aftermarket) - (Jun 26, 2007)

Released 11/9/2006
04-04-20-005A: Axle Lubricant Present at Rear Wheel Hubs (Install New Rear Wheel Bearing Seal) - (Nov 9, 2006)

Released 9/26/2006
06-03-08-012: Front Shock Absorber Crack/Breakage After Extreme Rough Road Driving or from High Road Impacts (Replace Shock Absorber) - (Sep 26, 2006)

Released 9/7/2006
06-03-10-010: Information on Proper Wheel Changing Procedures and Cautions - (Sep 7, 2006)

Released 8/1/2006
00-03-10-002D: Info - Chemical Staining, Pitting, Corrosion and/or Spotted Appearance of Chromed Aluminum Wheels - (Aug 1, 2006)

Released 6/19/2006
99-08-51-007C: Info - Refinishing Aluminum Wheels - (Jun 19, 2006)

Released 12/22/2005
05-09-41-010: Info - New SIR System Disabling and Enabling Procedure - (Dec 22, 2005)

Released 11/2/2005
05-00-89-075: Warranty Admin. - Servicing Medium Duty Trucks, Including Conventional and Crew Cabs, Motorhome Cutaway Cab, Commercial Cutaway Cab (Ambulance, School Bus, Shuttle Bus), and Tilt Cabs - (Nov 2, 2005)

Released 1/21/2016
Light and Medium Duty Truck Warranty, Crossline Warranty Eligibility and Guidelines for Chevrolet/GMC Dealers

Released 12/5/2014
Information for Dealers on How to Submit a Product Information Report (PIR) (Canada Only)

Released 12/5/2014
New Tool Availability - EN-48974 - EGR Cooler Pressure Tester Adapter Set to Diagnose Duramax Diesel Engine EGR Cooler Engine Coolant Leaks into Combustion Chamber

Released 7/16/2014
Duramax Diesel Glow Plugs Difficult to Install Due to Carbon Buildup - New Glow Plug Bore Reamer Available

Released 2/6/2014
Information on Slight or Mild Tire Feathering and Recommended Practices (Normal Tire Wear Condition)

Released 6/7/2013
IPC Odometer Programming Method Quick Reference Guide

Released 3/22/2013
Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V6 and V8 Gasoline Engines Using Tech 2 or Global Diagnostic System 2 (GDS 2)

Released 3/1/2013
Paint-less Dent Repair Process

Released 1/1/2013
IPC Odometer Programming Method Quick Reference Guide

Released 3/19/2012
Hem Flange Rust Repair

Released 3/5/2012
Warranty, SPS, Control Module Diagnostics and Configuration Information, Programming, Set-Up

Released 1/13/2012
Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability

Released 10/24/2011
Use of Surface Conditioning Disks When Cleaning Engine Gasket Sealing Surfaces and/or Reused Engine Parts

Released 10/22/2011
Warranty Code Generated By EL-50313 Midtronics GR8 Battery Tester/Charger Required for Claim Processing On Labor Operation 4041510 and Battery Part Restriction (North America ONLY)

Released 10/22/2011
Information for Dealers/Technicians on When and How to Submit a Field Product Report (FPR) (U.S. Dealers Only)

Released 8/10/2011
Comeback Prevention Information and Using Customer Concern Verification Sheets (CCVS)

Released 7/22/2011
Clarification of Use - Dealer Empowerment Labor Operations and Customer Enthusiasm

Released 7/22/2011
Enhancing Field Product Reports with Digital Pictures

Released 6/17/2011
Improperly Formatted SI Screen Characters

Released 6/9/2011
Warranty Administration-Revised Customer Concern Not Duplicated (CCND)/Verified Labor Operation Numbers/How to Submit CCND Transactions in GWM / Elimination of E9995, J9993, J9994 and J9995

Released 5/23/2011
Global Warranty Management (GWM) Warranty Parts Center (WPC) Parts Return Program Information

Released 5/19/2011
IPC Odometer Programming Method Quick Reference Guide

Released 5/9/2011
Information for Dealers on How to Submit a Product Information Report (PIR) (Canada Only)

Released 5/5/2011
Change in Product Field Action Customer Reimbursement Procedure (U.S. Dealers Only)

Released 4/18/2011
New Tool Availability - EN-48974 - EGR Cooler Pressure Tester Adapter Set to Diagnose Duramax Diesel Engine EGR Cooler Engine Coolant Leaks into Combustion Chamber

Released 4/18/2011
Warranty Administration - Courtesy Transportation and Roadside Assistance Programs

Released 4/13/2011
Warranty Parts Center (WPC) Special Part Request Enhancement - New Expedited Overnight Shipping Process and Form Information

Released 4/7/2011
Expediting Warranty Parts

Released 3/2/2011
Automatic Transmission Oil Cooler Flush and Flow Test Essential Tool J-45096 TransFlow

Released 2/3/2011
Expanded Customer Concern Not Duplicated (CCND)/Verified Labor Operation Numbers/How to Submit CCND Transactions in Global Warranty Management

Released 11/19/2010
Application of Anti-Corrosion Materials

Released 10/18/2010
Warranty Code Generated by El-50313/Charger Required for N0110, Battery Parts Rest

Released 10/13/2010
General Motors Dealership Critical Equipment Requirements and Recommendations

Released 9/2/2010
Engineering Information (EI) Process

Released 8/6/2010
Information on Drilling High Strength Steel Related to Collision Repair

Released 7/30/2010
Electronic Exchange Program Changes

Released 7/1/2010
Out-of-Warranty Parts for Engineering Analysis

Released 6/30/2010
Squeeze Type Resistance Spot Welding/Equipment

Released 6/17/2010
Free Agent Best Practices for HUMMER, Pontiac, Saab and Saturn Customers or Those Affected by Dealership Consolidation (U.S. Only) (SB10168)

Released 6/9/2010
Warranty Admin - Expanded Customer Concern Not Duplicated (CCND)/Verified Labor Operation Numbers/How to Submit CCND Transactions in Global Warranty Management

Released 5/28/2010
Expediting Warranty Parts

Released 5/27/2010
Key Code Security Rules and Information on GM KeyCode Look-Up Application (Canada Only)

Released 5/26/2010
Warranty Admin - Warranty Claims Submission-Importance of GM Part Numbers and Parts with Date Codes

Released 5/24/2010
Technical Assistance Center (TAC) Coverage Available for Current and Last Nine Model Year Vehicles (U.S. Only)

Released 5/21/2010
Improperly Formatted SI Screen Characters

Released 5/20/2010
Global Warranty Management (GWM) Warranty Parts Center (WPC) Parts Return Program Information

Released 5/20/2010
Warranty Administration - Courtesy Transportation and Roadside Assistance Programs

Released 5/19/2010
Warranty Administration - Labor Operation Z1111 - Suspected Tampering or Vehicle Modifications

Released 5/18/2010
Information for Dealers on How to Submit a Field Product Report (FPR) (U.S. Dealers Only)

Released 5/17/2010
Information for Dealers on How to Submit a Product Information Report (PIR) (Canada Only)

Released 5/4/2010
Information on Tire Radial Force Variation (RFV)

Released 5/4/2010
Enhancing Field Product Reports with Digital Pictures

Released 4/29/2010
Unnecessary Flushing Services, Additive Recommendations and Proper Utilization of GM Simplified Maintenance Schedule to Enhance Customer Service Experience

Released 4/26/2010
Required Return Criteria of Complete Electrical Center (EC) and Body Control Module (BCM) with Integrated Electrical Center to Warranty Parts Center (WPC)

Released 3/29/2010
Revised General Motors New Vehicle Tire Warranty Program and Global Warranty Management (GWM) Submission Rollout Information (U.S. Dealers Only)

Released 3/5/2010
Information for Electrical Ground Repair-Use New Replacement Fasteners with Conductive Finish

Released 2/15/2010
Warranty, SPS, Control Module Diagnostics and Configuration Information, Programming, Set-Up

Released 2/4/2010
Car and Truck Fix It Right the First Time Issues

Released 12/18/2009
New Tool Availability - EN-48974-EGR Cooler Pressure Tester Adapter Set to Diagnose Duramax Diesel Engine EGR Cooler Engine Coolant Leaks into Combustion Chamber

Released 12/11/2009
Unnecessary Engine Crankcase and Subsystems Flushing Services, Additive Recommendations and Proper Utilization of GM Simplified Maintenance Schedule to Enhance Customer Service Experience

Released 11/13/2009
Light and Medium Duty Truck Warranty, Crossline Warranty Eligibility and Guidelines for Chevrolet/GMC Dealers

Released 11/11/2009
New Labor Operation Codes for Dealer-Installed GM Accessories Replaced During Warranty Coverage Period

Released 9/24/2009
Discontinuation of Printed GM VIN Cards

Released 9/22/2009
Warranty Administration - Warranty System Changes-Medium Duty Trucks

Released 9/11/2009
GM Training - September 2009 New Course Information (For U.S. Dealers and Aftermarket)

Released 9/2/2009
Paint Peeling on Saddle Type Fuel Tanks (Refinish Tanks)

Released 8/13/2009
Information on Paint Stain Under Protective Shipping Film

Released 8/10/2009
GM Training - August 2009 New Course Information (For U.S. Dealers and Aftermarket)

Released 7/22/2009
GM Training - July 2009 New Course Information (For U.S. Dealers and Aftermarket)

Released 7/16/2009
Technical Assistance Center (TAC) Coverage Available for Current and Last Nine Model Year Vehicles (U.S. Only)

Released 7/6/2009
Electric Air Compressor (K16) Runs Continuously or Is Inoperative (Install Signal Filter Jumper Harness/Replace Necessary Components)

Released 6/16/2009
Information Required Before Contacting GM Technical Assistance or When Ordering Replacement OnStar VCIM

Released 6/15/2009
Engineering Information (EI) Process

Released 6/15/2009
GM Training - June 2009 New Course Information (For U.S. Dealers and Aftermarket)

Released 5/18/2009
Interior Cleaning-Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl. Fabric Cleaner, Stain Remover, Restorer - Product Availability

Released 5/11/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 5/7/2009
GM Training - May 2009 New Course Information (For U.S. Dealers and Aftermarket)

Released 4/20/2009
GM Training - April 2009 New Course Information (For U.S. Dealers and Aftermarket)

Released 4/2/2009
Warranty Administration - GM Dealer Empowerment Program and Goodwill Procedures

Released 4/1/2009
Warranty Administration - Policies for Used Vehicles Purchased Through GM-Sponsored Auctions (SB 09074)

Released 3/31/2009
Warranty Administration - Labor Operation Z1111 - Suspected Tampering or Vehicle Modifications

Released 3/23/2009
Enhancing Field Product Reports with Digital Pictures

Released 3/12/2009
08-08-51-002: New Primer For TPO Fascias and Affected Cleaning Process of Painting Operation - (Mar 12, 2008)

Released 2/3/2009
Hem Flange Rust Repair

Released 12/10/2008
General Motors Dealership Critical Equipment Requirements and Recommendations

Released 10/30/2008
Procedure to Take Snapshot Data with a Tech 2 and Upload Data to Computer Using TIS Software

Released 10/29/2008
Reducing Electrical Intermittents-Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Misc. DTCs, Intermittent Driveability Concerns, Hard/No

Released 10/16/2008
08-00-89-037: CSO Surcharges Not Allowed on Warranty Claims - (Oct 16, 2008)

Released 10/6/2008
08-00-89-036: GM Training - GM STC Training Location Changes (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-033: GM Training - October 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-034: GM Training - Accessing Hands-On Checklists (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 3/27/2008
08-06-01-008: Diagnosing Accessory Drive Belt/Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt - (Mar 27, 2008)

Released 2/22/2008
02-07-30-052E: Automatic Transmission Oil Cooler Flush and Flow Test Essential Tool J 45096 TransFlow - (Feb 22, 2008)

Released 1/18/2008
04-08-44-005C: Utilizing Tech 2 to Retrieve Part Numbers for Radios, Compact Disc (CD) Changers and Instrument Panel Clusters (IPC) - (Jan 18, 2008)

Released 1/10/2008
08-06-04-003: New Tool Availability - EN-48974 - EGR Cooler Pressure Tester Adapter Set to Diagnose Duramax Diesel Engine EGR Cooler Leaks into Combustion Chamber - (Jan 10, 2008)

Released 8/17/2007
07-00-89-039: GM Training: August 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Aug 17, 2007)

Released 6/26/2007
07-00-89-025: GM Training: April 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Jun 26, 2007)

Released 4/23/2007
05-08-51-008B: Bumps or Rust Colored Spots in Paint Due to Rail or Iron Dust (Remove Rail Dust) - (Apr 23, 2007)

Released 2/17/2006
06-08-45-001: Information on Changes to the SI Table of Contents, Electrical Connectors, Terminal Testing/Repair and the Importance of J-38125 Terminal Repair Kit Maintenance - (Feb 17, 2006)

Released 11/21/2005
99-08-51-001A: Info - Paint-less Dent Repair Process - (Nov 21, 2005)

Released 11/2/2005
05-00-89-075: Warranty Admin. - Servicing Medium Duty Trucks, Including Conventional and Crew Cabs, Motorhome Cutaway Cab, Commercial Cutaway Cab (Ambulance, School Bus, Shuttle Bus), and Tilt Cabs - (Nov 2, 2005)

Released 10/21/2005
05-06-04-067: Information on New Essential Tool EN-47909 Injector Bore Cleaning Kit for 6.6L Duramax Diesel Engine (RPOs LB7, LBZ, LLY) - (Oct 21, 2005)

Released 6/8/2005
05-05-22-001: Info - On-Car Brake Lathe Specifications and Maintenance Requirements - (Jun 8, 2005)

Released 9/14/2010
Car and Truck Fix It Right the First Time Issues

Released 4/28/2010
New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores

Released 5/11/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 1/8/2009
Preventing Damage on Dealer Lots During Longer Periods in Dealer Inventory and Maintaining High CSI Scores

Released 10/6/2008
08-00-89-036: GM Training - GM STC Training Location Changes (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-033: GM Training - October 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-034: GM Training - Accessing Hands-On Checklists (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 6/27/2008
07-00-89-047B: Technical Assistance Center (TAC) Coverage Available for Current and Last Nine Model Year Vehicles (U.S. Only) - (Jun 27, 2008)

Released 8/17/2007
07-00-89-039: GM Training: August 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Aug 17, 2007)

Released 6/8/2007
06-08-43-003A: Windshield Wiper Performance, Cleaning Instructions and Maintenance - (Jun 8, 2007)

Released 10/27/2006
06-08-43-006: Windshield Wiper Arm Loose and Making Noise, Wiper Flops Across Windshield, Inconsistent Wiper Operation (Replace Wiper Pivot Screws) - (Oct 27, 2006)

Released 11/2/2005
05-00-89-075: Warranty Admin. - Servicing Medium Duty Trucks, Including Conventional and Crew Cabs, Motorhome Cutaway Cab, Commercial Cutaway Cab (Ambulance, School Bus, Shuttle Bus), and Tilt Cabs - (Nov 2, 2005)