Get Free 2001 FORD MUSTANG V8, 4.6L; DOHC; 32V TSBs

Released 3/7/2007
SPARK KNOCK UNDER LIGHT LOAD AND ACCELERATION—3.8L, 3.9L, AND 4.2L—SPLIT PORT INTAKE MANIFOLD RUNNER CONTROL (IMRC)

Released 2/13/2007
LEATHER-WRAPPED STEERING WHEEL—LEATHER COMING LOOSE

Released 11/16/2005
SAFETY BELT RETRACTION SPEED

Released 10/3/2005
SAFETY BELT WEB STOP BUTTON SERVICE

Released 5/24/2004
REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR—TERMINAL TAB REPAIR

Released 3/5/2004
CLIMATE CONTROL—RATTLE NOISE FROM INSTRUMENT PANEL VENTS—DIFFICULT TO ADJUST * NOISE—CLIMATE CONTROL—RATTLE NOISE FROM INSTRUMENT PANEL VENTS—DIFFICULT TO ADJUST

Released 2/1/2004
BODY—INTERIOR TRIM—HEADLINER SAGGING REAR

Released 1/11/2004
DRIVEABILITY—STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MIL ON AND DTCS P0401, P0402, P1400 OR P1401—ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY

Released 5/25/2003
PAINT—PIN HOLES AND/OR PAINT DELAMINATION ON VEHICLE HOOD—VEHICLES BUILT 6/1/2001 THROUGH 3/1/2003 ONLY

Released 5/1/2003
TRIM—PASSENGER SEAT RUBS AGAINST DOOR PANEL

Released 2/23/2003
BODY—MIRROR—EXTERIOR MIRROR GLASS AND MOTOR REPLACEMENT—SERVICE TIPS

Released 8/17/2002
NOISE—WINDNOISE FROM THE “A” PILLAR AREA

Released 8/9/2002
BODY—CONVERTIBLE TOP BOOT FIT

Released 4/23/2002
DIAGNOSTIC TROUBLE CODE (DTC)—P1635 AND/OR P1639 PRESENT AFTER POWERTRAIN CONTROL MODULE (PCM) OR INSTRUMENT CLUSTER REPLACEMENT—GASOLINE ENGINE VEHICLES ONLY *

Released 11/1/1996
LOCKS—INTRODUCTION OF NEW LOCK DESIGN—SERVICE TIP

Released 12/4/1994
PAINT—PRIMED SHEET METAL—PREP PROCEDURE AND MSDS INFORMATION

Released 2/6/2003
ENGINE—CYLINDER HEAD DECK LEAK—4.6 AND 5.4L ENGINES—NEW “SERVICE-ONLY” GASKET AND CYLINDER HEAD KITS AVAILABILITY

Released 4/5/2002
ENGINE—4.6L—FRONT END ACCESSORY DRIVE (FEAD) BELT SLIPS OFF WATER PUMP PULLEY WHEN SPLASHED WITH WATER

Released 12/23/2001
• ENGINE COOLANT—PROPYLENE GLYCOL—FORD MOTOR COMPANY POSITION ON ENGINE COOLANTS MADE FROM PROPYLENE GLYCOL • ENGINE COOLANT—PROPYLENE GLYCOL-BASED—FORD MOTOR COMPANY POSITION ON PROPYLENE GLYCOL-BASED ENGINE COOLANTS

Released 10/23/2000
TRANSMISSION—FLUID IN-LINE FILTER KIT—REPEAT REPAIRS OF TRANSMISSION—SERVICE TIPS

Released 5/8/2006
SPEED CONTROL DIAGNOSTICS—W/O SCP

Released 7/18/2005
WIRING—SOLDERING AND CRIMPING REPAIRS— SOLDERING TIPS

Released 5/24/2004
REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR—TERMINAL TAB REPAIR

Released 2/1/2004
BODY—INTERIOR TRIM—HEADLINER SAGGING REAR

Released 2/23/2003
BODY—MIRROR—EXTERIOR MIRROR GLASS AND MOTOR REPLACEMENT—SERVICE TIPS

Released 1/18/2003
ELECTRICAL—REMOTE KEYLESS ENTRY (RKE)— SERVICE TIPS

Released 8/9/2002
BODY—CONVERTIBLE TOP BOOT FIT

Released 6/17/2002
LAMP—BRAKE—INADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK

Released 4/5/2002
ENGINE—4.6L—FRONT END ACCESSORY DRIVE (FEAD) BELT SLIPS OFF WATER PUMP PULLEY WHEN SPLASHED WITH WATER

Released 2/2/2002
COOLANT—COOLANT SEEPAGE AT INTAKE MANIFOLD CROSS-OVER—VEHICLES EQUIPPED WITH 4.6L 2V ENGINE ONLY * ENGINE—4.6L 2V—COOLANT SEEPAGE AT INTAKE MANIFOLD CROSS-OVER

Released 12/8/2001
• DRIVEABILITY—DIAGNOSTIC TROUBLE CODES (DTC) P0500, P1502 AND/OR U1039 CONTINENTAL MODELS ONLY—STICKING OR BINDING IGNITION LOCK CYLINDER—HIGH EFFORT WHEN TURNING IGNITION SWITCH • ELECTRICAL—STICKING OR BINDING IGNITION LOCK CYLINDER

Released 11/8/2001
· DRIVEABILITY—DETONATION OR SPARK KNOCK ON HEAVY ACCELERATION—MUSTANG BUILT GT VEHICLES ONLY · ENGINE—4.6L 2 VALVE—DETONATION OR SPARK KNOCK ON HEAVY ACCELERATION—MUSTANG BULLITT GT VEHICLES ONLY

Released 10/11/2001
WIRING—WIRE HARNESS TERMINAL REPAIR KIT AND WIRE SPLICE PROCEDURE

Released 6/2/2001
PASSIVE ANTI THEFT SYSTEM (PATS)—DIAGNOSTIC SERVICE TIPS

Released 11/1/1996
LOCKS—INTRODUCTION OF NEW LOCK DESIGN—SERVICE TIP

Released 3/20/2003
DRIVEABILITY—MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH DTC’S P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457

Released 4/23/2002
DIAGNOSTIC TROUBLE CODE (DTC)—P1635 AND/OR P1639 PRESENT AFTER POWERTRAIN CONTROL MODULE (PCM) OR INSTRUMENT CLUSTER REPLACEMENT—GASOLINE ENGINE VEHICLES ONLY *

Released 11/8/2001
· DRIVEABILITY—DETONATION OR SPARK KNOCK ON HEAVY ACCELERATION—MUSTANG BUILT GT VEHICLES ONLY · ENGINE—4.6L 2 VALVE—DETONATION OR SPARK KNOCK ON HEAVY ACCELERATION—MUSTANG BULLITT GT VEHICLES ONLY

Released 9/7/2001
DRIVEABILITY—HO2S (HEATED OXYGEN SENSOR), CATALYST, AND FUEL SYSTEM MONITORS—SERVICE TIPS—OBD II VEHICLES ONLY

Released 1/2/2001
DRIVEABILITY/ELECTRICAL -LAMP/TRANSMISSION-4R70W-SLIP/BUMP ON 1-2 SHIFT-HARSH 2-3 SHIFT—MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE (DTC) P0442

Released 5/16/2008
Customer Satisfaction Program - Certain 1999-2001 Model Year Vehicles up to 6000-lb GVWR Registered in the State of New York, and Certain 2001 Model Year Vehicles up to 6000-lb GVWR Registered in the State of Maine, Certified for Sale in California - Federal Emission Warranty Refund__THIS FIELD SERVICE ACTION EXPIRED ON NOVEMBER 30, 2008. - Dealer Bulletin

Released 5/16/2008
Customer Satisfaction Program - Certain 1999-2001 Model Year Vehicles up to 6000-lb GVWR Registered in the State of New York, and Certain 2001 Model Year Vehicles up to 6000-lb GVWR Registered in the State of Maine, Certified for Sale in California - Federal Emission Warranty Refund__THIS FIELD SERVICE ACTION EXPIRED ON NOVEMBER 30, 2008. - New York Customer Letter

Released 5/16/2008
Customer Satisfaction Program - Certain 1999-2001 Model Year Vehicles up to 6000-lb GVWR Registered in the State of New York, and Certain 2001 Model Year Vehicles up to 6000-lb GVWR Registered in the State of Maine, Certified for Sale in California - Federal Emission Warranty Refund__THIS FIELD SERVICE ACTION EXPIRED ON NOVEMBER 30, 2008. - Maine Customer Letter

Released 6/21/2004
EXHAUST LEAK—CRACKED OR SEPARATED RIGHT SIDE EXHAUST PIPE—3.8L AND 3.9L ENGINES

Released 6/25/2003
ENGINE—ROMEO BUILT 4.6L 2V—TICK NOISE FROM ENGINE—ENGINES BUILT BEFORE 9/17/2003

Released 2/2/2002
COOLANT—COOLANT SEEPAGE AT INTAKE MANIFOLD CROSS-OVER—VEHICLES EQUIPPED WITH 4.6L 2V ENGINE ONLY * ENGINE—4.6L 2V—COOLANT SEEPAGE AT INTAKE MANIFOLD CROSS-OVER

Released 1/22/2002
DRIVEABILITY—SURGE/ROLLING IDLE—GEAR DRIVEN SYNCHRONIZERS—INCORRECT INSTALLATION—CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION *

Released 12/8/2001
• DRIVEABILITY—DIAGNOSTIC TROUBLE CODES (DTC) P0500, P1502 AND/OR U1039 CONTINENTAL MODELS ONLY—STICKING OR BINDING IGNITION LOCK CYLINDER—HIGH EFFORT WHEN TURNING IGNITION SWITCH • ELECTRICAL—STICKING OR BINDING IGNITION LOCK CYLINDER

Released 12/7/1996
AIR CONDITIONING—NEW O-RING AVAILABILITY AND APPLICATIONS—SERVICE TIP

Released 12/15/2015
Multiple Vehicles - Transmission Cooler Flush General Service Bulletin (GSB)

Released 10/3/2008
Customer Satisfaction Program - Certain 1999-2001 Model Year Vehicles Registered in the States of California, Massachusetts or Vermont and Certified for Sale in California - Federal Emissions Warranty Refund__THIS FIELD SERVICE ACTION EXPIRED ON MARCH 31, 2009. - Dealer Bulletin

Released 10/3/2008
Customer Satisfaction Program - Certain 1999-2001 Model Year Vehicles Registered in the States of California, Massachusetts or Vermont and Certified for Sale in California - Federal Emissions Warranty Refund__THIS FIELD SERVICE ACTION EXPIRED ON MARCH 31, 2009. - Owner Letter

Released 5/16/2008
Customer Satisfaction Program - Certain 1999-2001 Model Year Vehicles up to 6000-lb GVWR Registered in the State of New York, and Certain 2001 Model Year Vehicles up to 6000-lb GVWR Registered in the State of Maine, Certified for Sale in California - Federal Emission Warranty Refund__THIS FIELD SERVICE ACTION EXPIRED ON NOVEMBER 30, 2008. - Dealer Bulletin

Released 5/16/2008
Customer Satisfaction Program - Certain 1999-2001 Model Year Vehicles up to 6000-lb GVWR Registered in the State of New York, and Certain 2001 Model Year Vehicles up to 6000-lb GVWR Registered in the State of Maine, Certified for Sale in California - Federal Emission Warranty Refund__THIS FIELD SERVICE ACTION EXPIRED ON NOVEMBER 30, 2008. - New York Customer Letter

Released 5/16/2008
Customer Satisfaction Program - Certain 1999-2001 Model Year Vehicles up to 6000-lb GVWR Registered in the State of New York, and Certain 2001 Model Year Vehicles up to 6000-lb GVWR Registered in the State of Maine, Certified for Sale in California - Federal Emission Warranty Refund__THIS FIELD SERVICE ACTION EXPIRED ON NOVEMBER 30, 2008. - Maine Customer Letter

Released 10/17/2007
4.6L 2V, 5.4L 2V, OR 6.8L 2V—SPARK PLUG THREAD REPAIR PROCEDURE—NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY

Released 1/9/2007
MERCONâ ATF REPLACED BY MERCON (R) V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS

Released 12/18/2006
IDENTIFYING THE CORRECT REPLACEMENT HEAD GASKET FOR CERTAIN REMANUFACTURED ENGINES—SERVICE TIP

Released 1/26/2006
MERCON ATF IS BEING REPLACED BY MERCON V AS A SERVICE FLUID FOR SOME MANUAL TRANSMISSIONS

Released 8/22/2005
WDS COP KIT DIAGNOSTIC TIPS—COIL ON PLUG (COP) IGNITION SYSTEMS—ENGINE MISFIRE OR ROUGH RUNNING

Released 8/19/2004
MANUAL TRANSMISSION HARD TO SHIFT INTO FIRST/REVERSE FROM A STOP

Released 6/21/2004
EXHAUST LEAK—CRACKED OR SEPARATED RIGHT SIDE EXHAUST PIPE—3.8L AND 3.9L ENGINES

Released 6/15/2004
TR3650 MANUAL TRANSMISSION—JUMPS OUT OF GEAR 2ND AND/OR 3RD—CLASH NOISE AND/OR RASPY FEEL ON GEAR ENGAGEMENT

Released 8/14/2003
TRANSMISSION—NEW TRANSMISSION COOLER FLUSHER SERVICE TIPS

Released 6/25/2003
ENGINE—ROMEO BUILT 4.6L 2V—TICK NOISE FROM ENGINE—ENGINES BUILT BEFORE 9/17/2003

Released 2/6/2003
ENGINE—CYLINDER HEAD DECK LEAK—4.6 AND 5.4L ENGINES—NEW “SERVICE-ONLY” GASKET AND CYLINDER HEAD KITS AVAILABILITY

Released 12/21/2002
OSCILLATION/BOUNCE—HIGHWAY SPEEDS—4X2 CHECKING CYLINDER HEAD AND BLOCK FLATNESS

Released 9/1/2002
ENGINE—ENGINE OIL—RECOMMENDED APPLICATIONS FOR SAE 5W-20 AND SAE 5W-30 MOTOR OILS—GASOLINE AND FLEXIBLE FUEL VEHICLES ONLY

Released 4/23/2002
DIAGNOSTIC TROUBLE CODE (DTC)—P1635 AND/OR P1639 PRESENT AFTER POWERTRAIN CONTROL MODULE (PCM) OR INSTRUMENT CLUSTER REPLACEMENT—GASOLINE ENGINE VEHICLES ONLY *

Released 4/11/2002
ENGINE—NEW GASKET REMOVER/CLEANER AND SERVICE TIPS FOR ALUMINUM HEADS AND BLOCKS

Released 4/5/2002
ENGINE—4.6L—FRONT END ACCESSORY DRIVE (FEAD) BELT SLIPS OFF WATER PUMP PULLEY WHEN SPLASHED WITH WATER

Released 2/2/2002
COOLANT—COOLANT SEEPAGE AT INTAKE MANIFOLD CROSS-OVER—VEHICLES EQUIPPED WITH 4.6L 2V ENGINE ONLY * ENGINE—4.6L 2V—COOLANT SEEPAGE AT INTAKE MANIFOLD CROSS-OVER

Released 1/22/2002
DRIVEABILITY—SURGE/ROLLING IDLE—GEAR DRIVEN SYNCHRONIZERS—INCORRECT INSTALLATION—CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION *

Released 12/23/2001
TRANSMISSION—T-45 MANUAL TRANSMISSION— STUCK IN REVERSE—DIFFICULT TO SHIFT INTO REVERSE—POPS OUT OF REVERSE

Released 12/23/2001
• ENGINE COOLANT—PROPYLENE GLYCOL—FORD MOTOR COMPANY POSITION ON ENGINE COOLANTS MADE FROM PROPYLENE GLYCOL • ENGINE COOLANT—PROPYLENE GLYCOL-BASED—FORD MOTOR COMPANY POSITION ON PROPYLENE GLYCOL-BASED ENGINE COOLANTS

Released 11/8/2001
· DRIVEABILITY—DETONATION OR SPARK KNOCK ON HEAVY ACCELERATION—MUSTANG BUILT GT VEHICLES ONLY · ENGINE—4.6L 2 VALVE—DETONATION OR SPARK KNOCK ON HEAVY ACCELERATION—MUSTANG BULLITT GT VEHICLES ONLY

Released 11/8/2001
• NOISE—“CLUNK” NOISE HEARD ON 2-1 DOWNSHIFT VEHICLES EQUIPPED WITH 4R70W AUTOMATIC TRANSMISSION • TRANSMISSION—4R70W—“CLUNK” NOISE HEARD FROM TRANSMISSION ON 2-1 DOWNSHIFT

Released 6/2/2001
PASSIVE ANTI THEFT SYSTEM (PATS)—DIAGNOSTIC SERVICE TIPS

Released 5/8/2001
NOISE/TRANSMISSION—4R70W—“TICKING” OR “CLICKING” NOISE FROM TRANSMISSION—HEARD IN 1ST GEAR ONLY—VEHICLES EQUIPPED WITH 4R70W AUTOMATIC TRANSMISSION ONLY

Released 4/1/2001
ENGINE—3.8L—OIL PUMP LIQUID INJECTION SEAL (LIS) GASKET SERVICE PROCEDURE—MUSTANG VEHICLES EQUIPPED WITH 3.8L ENGINE—VEHICLES PRODUCED 11/27/2000 THROUGH 6/30/2001—SERVICE TIPS

Released 1/2/2001
DRIVEABILITY/ELECTRICAL -LAMP/TRANSMISSION-4R70W-SLIP/BUMP ON 1-2 SHIFT-HARSH 2-3 SHIFT—MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE (DTC) P0442

Released 10/23/2000
TRANSMISSION—FLUID IN-LINE FILTER KIT—REPEAT REPAIRS OF TRANSMISSION—SERVICE TIPS

Released 5/9/2003
SUSPENSION—CLUNK OR POP NOISE FROM REAR SUSPENSION—MUSTANG COBRA ONLY-SERVICE TIPS * NOISE—CLUNK OR POP NOISE FROM REAR SUSPENSION—MUSTANG COBRA ONLY—SERVICE TIPS

Released 11/1/1996
LOCKS—INTRODUCTION OF NEW LOCK DESIGN—SERVICE TIP

Released 8/22/2005
WDS COP KIT DIAGNOSTIC TIPS—COIL ON PLUG (COP) IGNITION SYSTEMS—ENGINE MISFIRE OR ROUGH RUNNING

Released 7/18/2005
WIRING—SOLDERING AND CRIMPING REPAIRS— SOLDERING TIPS

Released 10/11/2001
WIRING—WIRE HARNESS TERMINAL REPAIR KIT AND WIRE SPLICE PROCEDURE

Released 12/4/1994
PAINT—PRIMED SHEET METAL—PREP PROCEDURE AND MSDS INFORMATION