Get Free 1999 FORD MUSTANG V6, 3.8L TSBs

Released 2/23/2003
BODY—MIRROR—EXTERIOR MIRROR GLASS AND MOTOR REPLACEMENT—SERVICE TIPS

Released 4/23/2002
DIAGNOSTIC TROUBLE CODE (DTC)—P1635 AND/OR P1639 PRESENT AFTER POWERTRAIN CONTROL MODULE (PCM) OR INSTRUMENT CLUSTER REPLACEMENT—GASOLINE ENGINE VEHICLES ONLY *

Released 11/8/2001
BODY—HOOD SCOOP LOOSE OR DETACHED FROM HOOD

Released 2/21/2000
HOOD—HOOD REQUIRES EXCESSIVE EFFORT TO CLOSE—SERVICE TIPS

Released 12/8/1999
INTERIOR TRIM—DOOR TRIM PANEL REPLACEMENT—SERVICE TIP

Released 8/21/1999
BODY—“CREAKING” NOISE FROM LH REAR QUARTER AREA—CONVERTIBLES ONLY * NOISE—“CREAKING” FROM LH REAR QUARTER AREA—CONVERTIBLES ONLY

Released 6/22/1999
NOISE—“POPPING” OR “OIL CANNING” NOISE FROM DRIVER’S FOOTWELL AREA

Released 5/22/1999
CONVERTIBLE TOP—IMPROPER FIT OF CONVERTIBLE TOP BOOT

Released 3/15/1999
INTERIOR—CUP HOLDER NOT DEEP ENOUGH TO HOLD LARGE CUPS—VEHICLES BUILT THROUGH 5/3/1999

Released 3/4/1999
REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS)—OUT-OF-VEHICLE—EEC V VEHICLES ONLY

Released 2/24/1999
LOCKS—REPLACE AND/OR REPAIR ANY LOCK COMPONENT—AVAILABILITY OF INDIVIDUAL LOCKS

Released 2/3/1999
WATER LEAKS—WINDSHIELD SEALING—SERVICE TIP * WINDSHIELD—SEALING—SERVICE TIP

Released 1/10/1999
BODY—DUST INTRUSION INTO LUGGAGE COMPARTMENT * WATER LEAK—EVIDENCE OF WATER LEAK INTO LUGGAGE COMPARTMENT * NOISE—EXCESSIVE ROAD NOISE HEARD FROM REAR WHEEL AREA

Released 9/25/1998
INTERIOR TRIM—REPAIRS TO VINYL COVERED SURFACES—SERVICE TIP

Released 11/1/1996
LOCKS—INTRODUCTION OF NEW LOCK DESIGN—SERVICE TIP

Released 12/4/1994
PAINT—PRIMED SHEET METAL—PREP PROCEDURE AND MSDS INFORMATION

Released 12/23/2001
• ENGINE COOLANT—PROPYLENE GLYCOL—FORD MOTOR COMPANY POSITION ON ENGINE COOLANTS MADE FROM PROPYLENE GLYCOL • ENGINE COOLANT—PROPYLENE GLYCOL-BASED—FORD MOTOR COMPANY POSITION ON PROPYLENE GLYCOL-BASED ENGINE COOLANTS

Released 10/23/2000
TRANSMISSION—FLUID IN-LINE FILTER KIT—REPEAT REPAIRS OF TRANSMISSION—SERVICE TIPS

Released 3/13/2000
ENGINE—4.6L 2V OR 5.4L 2V COOLING SYSTEM-COOLANT LEAK FROM PASSENGER SIDE OF INTAKE MANIFOLD AT REAR CORNER OF HEAD—VEHICLES BUILT FROM 7/1/1998 THROUGH 6/30/2000—VEHICLES WITH 4.6L 2V OR 5.4L 2V ENGINE

Released 2/23/2003
BODY—MIRROR—EXTERIOR MIRROR GLASS AND MOTOR REPLACEMENT—SERVICE TIPS

Released 1/18/2003
ELECTRICAL—REMOTE KEYLESS ENTRY (RKE)— SERVICE TIPS

Released 6/17/2002
LAMP—BRAKE—INADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK

Released 2/2/2002
COOLANT—COOLANT SEEPAGE AT INTAKE MANIFOLD CROSS-OVER—VEHICLES EQUIPPED WITH 4.6L 2V ENGINE ONLY * ENGINE—4.6L 2V—COOLANT SEEPAGE AT INTAKE MANIFOLD CROSS-OVER

Released 12/8/2001
• DRIVEABILITY—DIAGNOSTIC TROUBLE CODES (DTC) P0500, P1502 AND/OR U1039 CONTINENTAL MODELS ONLY—STICKING OR BINDING IGNITION LOCK CYLINDER—HIGH EFFORT WHEN TURNING IGNITION SWITCH • ELECTRICAL—STICKING OR BINDING IGNITION LOCK CYLINDER

Released 11/8/2001
BODY—HOOD SCOOP LOOSE OR DETACHED FROM HOOD

Released 10/11/2001
WIRING—WIRE HARNESS TERMINAL REPAIR KIT AND WIRE SPLICE PROCEDURE

Released 6/2/2001
PASSIVE ANTI THEFT SYSTEM (PATS)—DIAGNOSTIC SERVICE TIPS

Released 2/24/1999
LOCKS—REPLACE AND/OR REPAIR ANY LOCK COMPONENT—AVAILABILITY OF INDIVIDUAL LOCKS

Released 2/3/1999
WATER LEAKS—WINDSHIELD SEALING—SERVICE TIP * WINDSHIELD—SEALING—SERVICE TIP

Released 9/25/1998
INTERIOR TRIM—REPAIRS TO VINYL COVERED SURFACES—SERVICE TIP

Released 6/24/1998
ELECTRICAL—NEW TERMINAL GREASE RELEASED FOR SERVICE

Released 11/1/1996
LOCKS—INTRODUCTION OF NEW LOCK DESIGN—SERVICE TIP

Released 9/7/2001
DRIVEABILITY—HO2S (HEATED OXYGEN SENSOR), CATALYST, AND FUEL SYSTEM MONITORS—SERVICE TIPS—OBD II VEHICLES ONLY

Released 1/9/2001
DRIVEABILITY—HESITATION WHEN COLD—WITH NO DIAGNOSTIC TROUBLE CODES (DTC) PRESENT—VEHICLES EQUIPPED WITH 4.6L ENGINE AND MANUAL TRANSMISSION

Released 7/14/1999
CALIBRATION INFORMATION—VEHICLES BUILT THROUGH 1/29/1999—APPLICABLE ENGINES ARE 2.0L, 2.5L, 3.0L, 3.4L, 3.8L, 4.0L, 4.2L, 4.6L, 5.0L, 5.4L, 6.8L, AND 7.3L—SERVICE TIP

Released 4/23/1999
MALFUNCTION INDICATOR LAMP (MIL)— DIAGNOSTIC TROUBLE CODES (DTCS) P0442 AND P0455—NO DRIVEABILITY CONCERNS

Released 10/23/1998
MASS AIR FLOW (MAF)—SENSOR CONTAMINATION—SERVICE TIP

Released 10/3/2008
Customer Satisfaction Program - Certain 1999-2001 Model Year Vehicles Registered in the States of California, Massachusetts or Vermont and Certified for Sale in California - Federal Emissions Warranty Refund__THIS FIELD SERVICE ACTION EXPIRED ON MARCH 31, 2009. - Owner Letter

Released 5/16/2008
Customer Satisfaction Program - Certain 1999-2001 Model Year Vehicles up to 6000-lb GVWR Registered in the State of New York, and Certain 2001 Model Year Vehicles up to 6000-lb GVWR Registered in the State of Maine, Certified for Sale in California - Federal Emission Warranty Refund__THIS FIELD SERVICE ACTION EXPIRED ON NOVEMBER 30, 2008. - Dealer Bulletin

Released 5/16/2008
Customer Satisfaction Program - Certain 1999-2001 Model Year Vehicles up to 6000-lb GVWR Registered in the State of New York, and Certain 2001 Model Year Vehicles up to 6000-lb GVWR Registered in the State of Maine, Certified for Sale in California - Federal Emission Warranty Refund__THIS FIELD SERVICE ACTION EXPIRED ON NOVEMBER 30, 2008. - New York Customer Letter

Released 5/16/2008
Customer Satisfaction Program - Certain 1999-2001 Model Year Vehicles up to 6000-lb GVWR Registered in the State of New York, and Certain 2001 Model Year Vehicles up to 6000-lb GVWR Registered in the State of Maine, Certified for Sale in California - Federal Emission Warranty Refund__THIS FIELD SERVICE ACTION EXPIRED ON NOVEMBER 30, 2008. - Maine Customer Letter

Released 6/21/2004
EXHAUST LEAK—CRACKED OR SEPARATED RIGHT SIDE EXHAUST PIPE—3.8L AND 3.9L ENGINES

Released 12/11/1999
TECHNICAL SERVICE BULLETIN INDEX

Released 10/20/1998
EXHAUST SYSTEM—LOOSE CATALYST OR MUFFLER HEAT SHIELDS * NOISE—“BUZZING” OR “RATTLING”—LOOSE CATALYST OR MUFFLER HEAT SHIELDS

Released 1/22/2002
DRIVEABILITY—SURGE/ROLLING IDLE—GEAR DRIVEN SYNCHRONIZERS—INCORRECT INSTALLATION—CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION *

Released 12/8/2001
• DRIVEABILITY—DIAGNOSTIC TROUBLE CODES (DTC) P0500, P1502 AND/OR U1039 CONTINENTAL MODELS ONLY—STICKING OR BINDING IGNITION LOCK CYLINDER—HIGH EFFORT WHEN TURNING IGNITION SWITCH • ELECTRICAL—STICKING OR BINDING IGNITION LOCK CYLINDER

Released 2/24/1999
LOCKS—REPLACE AND/OR REPAIR ANY LOCK COMPONENT—AVAILABILITY OF INDIVIDUAL LOCKS

Released 10/23/1998
MASS AIR FLOW (MAF)—SENSOR CONTAMINATION—SERVICE TIP

Released 2/26/1998
FUEL—INFORMATION ON GASOLINE—TIPS TO RESOLVE VOLATILITY RELATED DRIVEABILITY CONCERNS

Released 10/3/2008
Customer Satisfaction Program - Certain 1999-2001 Model Year Vehicles Registered in the States of California, Massachusetts or Vermont and Certified for Sale in California - Federal Emissions Warranty Refund__THIS FIELD SERVICE ACTION EXPIRED ON MARCH 31, 2009. - Owner Letter

Released 5/16/2008
Customer Satisfaction Program - Certain 1999-2001 Model Year Vehicles up to 6000-lb GVWR Registered in the State of New York, and Certain 2001 Model Year Vehicles up to 6000-lb GVWR Registered in the State of Maine, Certified for Sale in California - Federal Emission Warranty Refund__THIS FIELD SERVICE ACTION EXPIRED ON NOVEMBER 30, 2008. - Dealer Bulletin

Released 5/16/2008
Customer Satisfaction Program - Certain 1999-2001 Model Year Vehicles up to 6000-lb GVWR Registered in the State of New York, and Certain 2001 Model Year Vehicles up to 6000-lb GVWR Registered in the State of Maine, Certified for Sale in California - Federal Emission Warranty Refund__THIS FIELD SERVICE ACTION EXPIRED ON NOVEMBER 30, 2008. - New York Customer Letter

Released 5/16/2008
Customer Satisfaction Program - Certain 1999-2001 Model Year Vehicles up to 6000-lb GVWR Registered in the State of New York, and Certain 2001 Model Year Vehicles up to 6000-lb GVWR Registered in the State of Maine, Certified for Sale in California - Federal Emission Warranty Refund__THIS FIELD SERVICE ACTION EXPIRED ON NOVEMBER 30, 2008. - Maine Customer Letter

Released 10/17/2007
4.6L 2V, 5.4L 2V, OR 6.8L 2V—SPARK PLUG THREAD REPAIR PROCEDURE—NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY

Released 1/9/2007
MERCONâ ATF REPLACED BY MERCON (R) V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS

Released 12/18/2006
IDENTIFYING THE CORRECT REPLACEMENT HEAD GASKET FOR CERTAIN REMANUFACTURED ENGINES—SERVICE TIP

Released 1/26/2006
MERCON ATF IS BEING REPLACED BY MERCON V AS A SERVICE FLUID FOR SOME MANUAL TRANSMISSIONS

Released 8/22/2005
WDS COP KIT DIAGNOSTIC TIPS—COIL ON PLUG (COP) IGNITION SYSTEMS—ENGINE MISFIRE OR ROUGH RUNNING

Released 8/19/2004
MANUAL TRANSMISSION HARD TO SHIFT INTO FIRST/REVERSE FROM A STOP

Released 6/21/2004
EXHAUST LEAK—CRACKED OR SEPARATED RIGHT SIDE EXHAUST PIPE—3.8L AND 3.9L ENGINES

Released 2/6/2003
ENGINE—CYLINDER HEAD DECK LEAK—4.6 AND 5.4L ENGINES—NEW “SERVICE-ONLY” GASKET AND CYLINDER HEAD KITS AVAILABILITY

Released 12/21/2002
OSCILLATION/BOUNCE—HIGHWAY SPEEDS—4X2 CHECKING CYLINDER HEAD AND BLOCK FLATNESS

Released 9/1/2002
ENGINE—ENGINE OIL—RECOMMENDED APPLICATIONS FOR SAE 5W-20 AND SAE 5W-30 MOTOR OILS—GASOLINE AND FLEXIBLE FUEL VEHICLES ONLY

Released 4/23/2002
DIAGNOSTIC TROUBLE CODE (DTC)—P1635 AND/OR P1639 PRESENT AFTER POWERTRAIN CONTROL MODULE (PCM) OR INSTRUMENT CLUSTER REPLACEMENT—GASOLINE ENGINE VEHICLES ONLY *

Released 4/11/2002
ENGINE—NEW GASKET REMOVER/CLEANER AND SERVICE TIPS FOR ALUMINUM HEADS AND BLOCKS

Released 2/2/2002
COOLANT—COOLANT SEEPAGE AT INTAKE MANIFOLD CROSS-OVER—VEHICLES EQUIPPED WITH 4.6L 2V ENGINE ONLY * ENGINE—4.6L 2V—COOLANT SEEPAGE AT INTAKE MANIFOLD CROSS-OVER

Released 1/22/2002
DRIVEABILITY—SURGE/ROLLING IDLE—GEAR DRIVEN SYNCHRONIZERS—INCORRECT INSTALLATION—CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION *

Released 12/23/2001
• ENGINE COOLANT—PROPYLENE GLYCOL—FORD MOTOR COMPANY POSITION ON ENGINE COOLANTS MADE FROM PROPYLENE GLYCOL • ENGINE COOLANT—PROPYLENE GLYCOL-BASED—FORD MOTOR COMPANY POSITION ON PROPYLENE GLYCOL-BASED ENGINE COOLANTS

Released 12/23/2001
TRANSMISSION—T-45 MANUAL TRANSMISSION— STUCK IN REVERSE—DIFFICULT TO SHIFT INTO REVERSE—POPS OUT OF REVERSE

Released 11/8/2001
• NOISE—“CLUNK” NOISE HEARD ON 2-1 DOWNSHIFT VEHICLES EQUIPPED WITH 4R70W AUTOMATIC TRANSMISSION • TRANSMISSION—4R70W—“CLUNK” NOISE HEARD FROM TRANSMISSION ON 2-1 DOWNSHIFT

Released 8/3/2001
VIBRATION—FELT THROUGH SEAT, FLOOR AND/OR STEERING WHEEL AT HIGHWAY SPEEDS WHILE IN 4TH OR 5TH GEAR—COBRA MODEL ONLY

Released 6/2/2001
PASSIVE ANTI THEFT SYSTEM (PATS)—DIAGNOSTIC SERVICE TIPS

Released 1/9/2001
DRIVEABILITY—HESITATION WHEN COLD—WITH NO DIAGNOSTIC TROUBLE CODES (DTC) PRESENT—VEHICLES EQUIPPED WITH 4.6L ENGINE AND MANUAL TRANSMISSION

Released 10/23/2000
TRANSMISSION—FLUID IN-LINE FILTER KIT—REPEAT REPAIRS OF TRANSMISSION—SERVICE TIPS

Released 9/1/2000
LEAK—TRANSMISSION FLUID LEAKS AT RADIATOR—VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSION AND TRANSMISSION OIL COOLER IN RADIATOR END TANK

Released 3/13/2000
ENGINE—4.6L 2V OR 5.4L 2V COOLING SYSTEM-COOLANT LEAK FROM PASSENGER SIDE OF INTAKE MANIFOLD AT REAR CORNER OF HEAD—VEHICLES BUILT FROM 7/1/1998 THROUGH 6/30/2000—VEHICLES WITH 4.6L 2V OR 5.4L 2V ENGINE

Released 7/19/1999
LAMP—INTERMITTENT MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION—DIAGNOSTIC TROUBLE CODES (DTCS) P0741, P0750, P0755, AND P1746 MAY BE STORED IN MEMORY— VEHICLES BUILT FROM 8/1/1998 THROUGH 5/1/1999 WITH 4R70W TRANSMISSION

Released 7/14/1999
CALIBRATION INFORMATION—VEHICLES BUILT THROUGH 1/29/1999—APPLICABLE ENGINES ARE 2.0L, 2.5L, 3.0L, 3.4L, 3.8L, 4.0L, 4.2L, 4.6L, 5.0L, 5.4L, 6.8L, AND 7.3L—SERVICE TIP

Released 6/22/1999
NOISE—“POPPING” OR “OIL CANNING” NOISE FROM DRIVER’S FOOTWELL AREA

Released 5/18/1999
TRANSMISSION CONTROL INDICATOR LAMP (TCIL)—TCIL ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE (DTC) P0782 STORED IN MEMORY—VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSION * TRANSMISSION—4R70W—DELAYED OR NO 2-3 UPSHIFT

Released 4/26/1999
MOTOR OIL - SAE VISCOSITY GRADE RECOMMENDATION - SERVICE TIP

Released 3/5/1999
TRANSMISSION—CHECKING TRANSMISSION FLUID LEVEL COLD—SERVICE TIP

Released 10/20/1998
EXHAUST SYSTEM—LOOSE CATALYST OR MUFFLER HEAT SHIELDS * NOISE—“BUZZING” OR “RATTLING”—LOOSE CATALYST OR MUFFLER HEAT SHIELDS

Released 10/20/2009
Safety Recall - Certain 1999 and 2000 Model Year SVT Mustang Cobra and Certain 2000 Model Year SVT Mustang Cobra R Vehicles - Rear Knuckle Replacement - Background Summary

Released 4/12/2001
Safety Recall - Certain 1999 and 2000 Model Year SVT Mustang Cobra and Certain 2000 Model Year SVT Mustang Cobra R Vehicles - Rear Knuckle Replacement - Administrative Information

Released 4/4/2001
Safety Recall - Certain 1999 and 2000 Model Year SVT Mustang Cobra and Certain 2000 Model Year SVT Mustang Cobra R Vehicles - Rear Knuckle Replacement - Technical Information

Released 8/3/2001
VIBRATION—FELT THROUGH SEAT, FLOOR AND/OR STEERING WHEEL AT HIGHWAY SPEEDS WHILE IN 4TH OR 5TH GEAR—COBRA MODEL ONLY

Released 7/1/2001
SUSPENSION—NOISE—“SQUEAK” FROM REAR SUSPENSION OVER BUMPS—COBRA MODELS ONLY, NOISE—“SQUEAK” FROM REAR SUSPENSION OVER BUMPS—COBRA MODELS ONLY

Released 1/9/2001
DRIVEABILITY—HESITATION WHEN COLD—WITH NO DIAGNOSTIC TROUBLE CODES (DTC) PRESENT—VEHICLES EQUIPPED WITH 4.6L ENGINE AND MANUAL TRANSMISSION

Released 9/4/2000
NOISE—“POPPING/CLUNKING” HEARD WHILE PERFORMING A QUICK LANE CHANGE AT HIGHWAY SPEEDS AND/OR GOING UP AN INCLINE AT LOW SPEEDS—COBRA VEHICLES ONLY (DOES NOT INCLUDE COBRA R VEHICLES)

Released 1/10/1999
BODY—DUST INTRUSION INTO LUGGAGE COMPARTMENT * WATER LEAK—EVIDENCE OF WATER LEAK INTO LUGGAGE COMPARTMENT * NOISE—EXCESSIVE ROAD NOISE HEARD FROM REAR WHEEL AREA

Released 11/1/1996
LOCKS—INTRODUCTION OF NEW LOCK DESIGN—SERVICE TIP

Released 10/11/2001
WIRING—WIRE HARNESS TERMINAL REPAIR KIT AND WIRE SPLICE PROCEDURE

Released 12/4/1994
PAINT—PRIMED SHEET METAL—PREP PROCEDURE AND MSDS INFORMATION