Get Free 2004 FORD FOCUS L4, 2.0L TSBs

Released 4/23/2018
1997-2002 ESCORT / 2000-2004 FOCUS - 2.0L SPI REPLACEMENT ENGINE SERVICE TIP

Released 1/27/2016
2004 And Newer Vehicles Equipped With Flex Fuel Capability - Flex Fuel General Service Bulletin (GSB)

Released 12/15/2015
Multiple Vehicles - Transmission Cooler Flush General Service Bulletin (GSB)

Released 12/8/2015
Multiple Vehicles - Engine Failure Analysis General Service Bulletin (GSB)

Released 9/8/2014
2000-2005 Focus - Safety Recall 05S27 - Rear Door Latch Corrosion - Requests For Recall Service Action - Built On or Before 1/26/2005

Released 3/12/2008
CENTER CONSOLE ARM REST PIVOT LOOSE

Released 2/26/2008
ENGINE VIBRATION AT IDLE

Released 6/6/2007
RCM FAULT REPORTING USING DTCS AND BIT-MAPPED PARAMETER IDENTIFIERS (PIDS)— SERVICE TIPS

Released 2/13/2007
PULL/DRIFT

Released 2/13/2007
LEATHER-WRAPPED STEERING WHEEL—LEATHER COMING LOOSE

Released 5/9/2006
SQUEAKING NOISE FROM 9 SPOKE WHEEL COVERS

Released 12/10/2005
POWER DOOR LOCKS CYCLING OR SELF LOCKING

Released 12/10/2005
MIL ON WITH DTC P0172—2.3L ENGINE

Released 10/3/2005
SAFETY BELT WEB STOP BUTTON SERVICE

Released 9/9/2005
INTERIOR TRIM—CARPET PULLING FROM UNDER RIGHT FRONT COWL SIDE KICK PANEL

Released 6/21/2005
LONG CRANK/HARD START—2.3L PZEV

Released 3/9/2005
INTERIOR PLASTIC TRIM—PAINT-TO-MATCH AND REPAIR—INTERIOR SPRAY PAINT AND ADHESION PROMOTER USAGE INSTRUCTIONS

Released 12/21/2004
DTC P2195—STALL AFTER COLD START IN EXTREME LOW AMBIENT TEMPERATURE

Released 6/9/2004
BODY—PAINT—IRON PARTICLE REMOVAL - INDUSTRIAL FALLOUT—ACID RAIN NEUTRALIZATION

Released 5/24/2004
REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR—TERMINAL TAB REPAIR

Released 5/21/2004
DIFFICULTY CHANGING GEARS—UNABLE TO ENGAGE GEARS

Released 2/23/2003
BODY—MIRROR—EXTERIOR MIRROR GLASS AND MOTOR REPLACEMENT—SERVICE TIPS

Released 2/27/2008
BATTERY SERVICE—OPERATION OF BATTERY EYE—CHARGING SERVICE TIPS

Released 8/15/2006
KEYPAD DIAGNOSTICS—DEALER INSTALLED ACCESSORY

Released 5/8/2006
SPEED CONTROL DIAGNOSTICS—W/O SCP

Released 1/7/2006
NEUTRAL TOW CAPABILITY—SERVICE KIT REQUIREMENTS

Released 12/21/2005
IGNITION KEY DIFFICULT OR UNABLE TO BE TURNED OR REMOVED—KEY-IN-IGNITION WARNING CHIME SOUNDING WITH KEY REMOVED

Released 7/18/2005
WIRING—SOLDERING AND CRIMPING REPAIRS— SOLDERING TIPS

Released 6/9/2004
BODY—PAINT—IRON PARTICLE REMOVAL - INDUSTRIAL FALLOUT—ACID RAIN NEUTRALIZATION

Released 5/24/2004
REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR—TERMINAL TAB REPAIR

Released 5/21/2004
DIFFICULTY CHANGING GEARS—UNABLE TO ENGAGE GEARS

Released 2/15/2004
issue date namingLOSS OF INTERMITTENT WIPER OR WIPER PARK FUNCTION

Released 2/23/2003
BODY—MIRROR—EXTERIOR MIRROR GLASS AND MOTOR REPLACEMENT—SERVICE TIPS

Released 1/18/2003
ELECTRICAL—REMOTE KEYLESS ENTRY (RKE)— SERVICE TIPS

Released 10/4/2006
SURGE AT STEADY STATE CRUISE 25-75 MPH (40-121 KM/H)

Released 1/8/2006
2.3L PZEV WITH 4F27E AUTOMATIC TRANSMISSION—LOSS OF PATS KEY PROGRAMMING

Released 12/21/2004
DTC P2195—STALL AFTER COLD START IN EXTREME LOW AMBIENT TEMPERATURE

Released 4/17/2004
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED—SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC’S)—SERVICE TIPS

Released 12/21/2005
IGNITION KEY DIFFICULT OR UNABLE TO BE TURNED OR REMOVED—KEY-IN-IGNITION WARNING CHIME SOUNDING WITH KEY REMOVED

Released 8/22/2005
WDS COP KIT DIAGNOSTIC TIPS—COIL ON PLUG (COP) IGNITION SYSTEMS—ENGINE MISFIRE OR ROUGH RUNNING

Released 3/13/2005
WATER LEAKS AND/OR A/C CONDENSATION LEAKS AT FRONT FLOOR AREA—SERVICE TIPS

Released 6/7/2018
Various Vehicles - Engine Failure Analysis General Service Bulletin (GSB)

Released 12/15/2015
Multiple Vehicles - Transmission Cooler Flush General Service Bulletin (GSB)

Released 12/8/2015
Multiple Vehicles - Engine Failure Analysis General Service Bulletin (GSB)

Released 3/18/2011
ENGINE VIBRATION AT IDLE

Released 3/16/2010
ENGINE VIBRATION AT IDLE - VEHICLES BUILT ON OR BEFORE 1/13/2010

Released 7/24/2009
ENGINE VIBRATION AT IDLE

Released 11/25/2008
ENGINE VIBRATION AT IDLE

Released 11/11/2008
CLUTCH PEDAL RETURN SPRING NOISE AND/OR FREE PLAY

Released 6/23/2008
CLUTCH PEDAL RETURN SPRING NOISE AND/OR FREE PLAY

Released 2/26/2008
ENGINE VIBRATION AT IDLE

Released 5/8/2007
ROUGH, ROLLING OR HIGH IDLE OR INDUCTION BACKFIRE—MAINLY AFTER COLD START—SVT MODELS ONLY

Released 2/13/2007
PULL/DRIFT

Released 1/9/2007
MERCONâ ATF REPLACED BY MERCON (R) V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS

Released 10/24/2006
MTX-75 PREMATURE CLUTCH FAILURE

Released 10/4/2006
SURGE AT STEADY STATE CRUISE 25-75 MPH (40-121 KM/H)

Released 4/21/2006
2.3L/2.0L DURATEC—NO START/POSSIBLE ENGINE DAMAGE—INSTALL SPECIAL SERVICE TOOLS PRIOR TO REMOVING CRANKSHAFT PULLEY BOLT

Released 1/8/2006
2.3L PZEV WITH 4F27E AUTOMATIC TRANSMISSION—LOSS OF PATS KEY PROGRAMMING

Released 12/21/2005
IGNITION KEY DIFFICULT OR UNABLE TO BE TURNED OR REMOVED—KEY-IN-IGNITION WARNING CHIME SOUNDING WITH KEY REMOVED

Released 12/14/2005
CATALYTIC CONVERTER MOUNTING BRACKET BROKEN

Released 12/10/2005
MIL ON WITH DTC P0172—2.3L ENGINE

Released 8/22/2005
WDS COP KIT DIAGNOSTIC TIPS—COIL ON PLUG (COP) IGNITION SYSTEMS—ENGINE MISFIRE OR ROUGH RUNNING

Released 6/21/2005
LONG CRANK/HARD START—2.3L PZEV

Released 1/8/2005
DIFFICULT OR UNABLE TO SHIFT INTO 5TH GEAR

Released 12/21/2004
TRANSAXLE NOISE AT IDLE IN NEUTRAL WITH CLUTCH PEDAL RELEASED—PREMATURE CLUTCH WEAR

Released 5/21/2004
DIFFICULTY CHANGING GEARS—UNABLE TO ENGAGE GEARS

Released 1/9/2007
MERCONâ ATF REPLACED BY MERCON (R) V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS

Released 5/9/2006
SQUEAKING NOISE FROM 9 SPOKE WHEEL COVERS

Released 12/10/2005
POWER DOOR LOCKS CYCLING OR SELF LOCKING

Released 1/6/2004
SUSPENSION—CREAKING, CRUNCHING, GRINDING OR RATTLE NOISE FROM FRONT SUSPENSION AT SLOW SPEEDS OVER BUMPS AND/OR WHILE TURNING *

Released 5/13/2003
SUSPENSION—REAR TIRE INNER EDGE WEAR

Released 4/21/2006
2.3L/2.0L DURATEC—NO START/POSSIBLE ENGINE DAMAGE—INSTALL SPECIAL SERVICE TOOLS PRIOR TO REMOVING CRANKSHAFT PULLEY BOLT

Released 8/22/2005
WDS COP KIT DIAGNOSTIC TIPS—COIL ON PLUG (COP) IGNITION SYSTEMS—ENGINE MISFIRE OR ROUGH RUNNING

Released 7/18/2005
WIRING—SOLDERING AND CRIMPING REPAIRS— SOLDERING TIPS

Released 3/9/2005
INTERIOR PLASTIC TRIM—PAINT-TO-MATCH AND REPAIR—INTERIOR SPRAY PAINT AND ADHESION PROMOTER USAGE INSTRUCTIONS