Get Free 2004 FORD F450 V8, 6.0L; DI; Diesel; Turbo TSBs

Released 4/23/2018
2004-2016 Econoline/F-Super Duty with Dana 70 or Dana 80 Trac-Loc® Limited-Slip Differential - Rear Axle Chatter On Turns

Released 4/23/2018
2001-2015 - Vehicles With Modular 4.6L, 5.4L Or 6.8L Engines - Determining Root Cause Of Engine Damage Due To Oil Pressure Loss.

Released 4/23/2018
2003-2010 - Vehicles Equipped With 6.0L Or 4.5L Diesel Engines - Damage To The Injector Pressure Regulator (IPR) Screen

Released 4/23/2018
REPLACEMENT TRANSMISSION FLUID FOR SERVICING TORQSHIFT TRANSMISSIONS

Released 11/28/2017
2000-2010 F-Super Duty/E-Series/Excursion - Diesel Remanufactured Component Identification

Released 2/17/2016
Vehicles with 6.0L Diesel - Crank/No Start Supplement - General Service Bulletin (GSB)

Released 1/27/2016
2004 And Newer Vehicles Equipped With Flex Fuel Capability - Flex Fuel General Service Bulletin (GSB)

Released 12/15/2015
Multiple Vehicles - Transmission Cooler Flush General Service Bulletin (GSB)

Released 12/8/2015
Multiple Vehicles - Engine Failure Analysis General Service Bulletin (GSB)

Released 12/7/2015
Multiple Vehicles - Spark Plug Thread Repair - 4.6L/5.4L/6.8L Modular 2v Engines - General Service Bulletin (GSB)

Released 11/30/2007
TAILGATE STRIKER—NOISE/RATTLE

Released 2/13/2007
LEATHER-WRAPPED STEERING WHEEL—LEATHER COMING LOOSE

Released 7/17/2006
ADDING ADDITIONAL BULBS TO TURN INDICATOR OR HAZARD FLASHER CIRCUITS—SERVICE TIPS

Released 5/26/2006
KING RANCH CREW CAB MODEL ONLY—WHITE CORROSION ON RUNNING BOARDS

Released 5/20/2006
PARKING AID SPEAKER INOPERATIVE—DTCS C1742 AND C1743

Released 5/15/2006
SLIDING POWER WINDOW (BACK GLASS) SERVICE PROCEDURE

Released 11/16/2005
SAFETY BELT RETRACTION SPEED

Released 10/3/2005
SAFETY BELT WEB STOP BUTTON SERVICE

Released 7/5/2005
LOW BATTERY VOLTAGE—SNOW PLOW EQUIPPED VEHICLES—6.0L DIESEL WITH SINGLE GENERATOR

Released 4/17/2005
VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY—CLIMATE CONTROL DEFAULTS TO DEFROST MODE

Released 3/9/2005
INTERIOR PLASTIC TRIM—PAINT-TO-MATCH AND REPAIR—INTERIOR SPRAY PAINT AND ADHESION PROMOTER USAGE INSTRUCTIONS

Released 12/14/2004
FRONT END ACCESSORY DRIVE (FEAD) BELT NOISE—VEHICLES BUILT PRIOR TO 6/1/2004—6.0L ENGINE

Released 12/8/2004
6.0L ENGINE—LOW RPM, BUCK/JERK, MISS, STUMBLE—AFTER DECELERATION DOWN LONG GRADE WITH THE CRUISE CONTROL ENGAGED

Released 9/23/2004
WATER LEAK—ROOF FLANGE AREA—WATER ACCUMULATION IN HEADLINER AND/OR LEAK AT THE CAB FLOOR PAN AREA

Released 6/9/2004
BODY—PAINT—IRON PARTICLE REMOVAL - INDUSTRIAL FALLOUT—ACID RAIN NEUTRALIZATION

Released 5/16/2004
HIGH ENGINE RPM BETWEEN DOWNSHIFTS—LACK OF ENGINE BRAKING—5.4L ENGINE AND MANUAL TRANSMISSION

Released 2/23/2003
BODY—MIRROR—EXTERIOR MIRROR GLASS AND MOTOR REPLACEMENT—SERVICE TIPS

Released 4/23/2006
DRIVE-AWAY SHUDDER OR VIBRATION

Released 5/18/2004
AXLE—FRONT HUBS NOT ENGAGING, NOT STAYING ENGAGED AND/OR UNLOCKING

Released 9/8/2009
COOLING SYSTEM DIAGNOSTICS - OIL IN ENGINE COOLANT - 6.0L

Released 4/14/2009
DIESEL COOLANT MAINTENANCE - SERVICE TIPS

Released 4/13/2009
COOLANT LOSS - 6.0L

Released 11/5/2008
6.0L DIESEL FUEL IN ENGINE COOLANT DIAGNOSTICS

Released 6/19/2008
LACK OF A/C COOLING DUE TO DESICCANT MATERIAL CLOGGING THE ORIFICE TUBE

Released 5/16/2008
COOLANT LOSS—6.0L

Released 11/13/2007
COOLING SYSTEM DIAGNOSTICS—OIL IN ENGINE COOLANT—6.0L

Released 5/18/2007
DIESEL ENGINE—OVERHEATING WITH A SNOW PLOW INSTALLED ON VEHICLES WITHOUT THE FACTORY INSTALLED SNOW PLOW PACKAGE

Released 2/2/2007
LACK OF COOLING FAN OPERATION—6.0L

Released 12/21/2006
HEATER CORE LEAKAGE AND ELECTROLYSIS (INFORMATION ONLY)

Released 12/13/2005
FEAD BELT FRAYED/SHREDDED/BROKEN—6.0L DIESEL ENGINE—VEHICLES BUILT THROUGH 1/1/2005

Released 8/3/2011
Compliance Recall - Certain 2011 Model Year Ranger Vehicles Built with a Suspect Multifunction Switch and Certain Vehicles Serviced with a Suspect Multifunction Switch - Multifunction Switch Inspection and Replacement - Owner Letter

Released 7/7/2011
Compliance Recall - Certain 2011 Model Year Ranger Vehicles Built with a Suspect Multifunction Switch and Certain Vehicles Serviced with a Suspect Multifunction Switch - Multifunction Switch Inspection and Replacement - Technical Info

Released 7/7/2011
Compliance Recall - Certain 2011 Model Year Ranger Vehicles Built with a Suspect Multifunction Switch and Certain Vehicles Serviced with a Suspect Multifunction Switch - Multifunction Switch Inspection and Replacement - Dealer Bulletin

Released 7/7/2011
Compliance Recall - Certain 2011 Model Year Ranger Vehicles Built with a Suspect Multifunction Switch and Certain Vehicles Serviced with a Suspect Multifunction Switch - Multifunction Switch Inspection and Replacement - Additional Information - Background Summary

Released 4/3/2009
DIAGNOSTIC PROCEDURE FOR TRAILER TOW LIGHTS - SERVICE TIP

Released 2/27/2008
BATTERY SERVICE—OPERATION OF BATTERY EYE—CHARGING SERVICE TIPS

Released 12/14/2006
NO CRANK / STARTER TERMINAL FATIGUE

Released 8/15/2006
KEYPAD DIAGNOSTICS—DEALER INSTALLED ACCESSORY

Released 7/17/2006
ADDING ADDITIONAL BULBS TO TURN INDICATOR OR HAZARD FLASHER CIRCUITS—SERVICE TIPS

Released 5/8/2006
SPEED CONTROL DIAGNOSTICS—W/O SCP

Released 1/6/2006
DIAGNOSTIC PROCEDURE FOR TRAILER TOW LIGHTS—SERVICE TIP

Released 12/13/2005
FEAD BELT FRAYED/SHREDDED/BROKEN—6.0L DIESEL ENGINE—VEHICLES BUILT THROUGH 1/1/2005

Released 10/26/2005
CLUNK OR BUMP WHEN STARTING FROM A STOP

Released 8/18/2005
SERVICE KIT AVAILABLE FOR WIPER MOTOR WIRING

Released 7/18/2005
WIRING—SOLDERING AND CRIMPING REPAIRS— SOLDERING TIPS

Released 7/5/2005
LOW BATTERY VOLTAGE—SNOW PLOW EQUIPPED VEHICLES—6.0L DIESEL WITH SINGLE GENERATOR

Released 4/6/2005
FALSE PARKING AID WARNINGS

Released 1/20/2005
BROKEN OR CORRODED BOLT ON BATTERY TERMINAL

Released 12/17/2004
HARD START OR NO START—GPCM CONNECTOR SERVICE KIT AVAILABLE—6.0L ENGINE

Released 12/14/2004
FRONT END ACCESSORY DRIVE (FEAD) BELT NOISE—VEHICLES BUILT PRIOR TO 6/1/2004—6.0L ENGINE

Released 12/8/2004
6.0L ENGINE—LOW RPM, BUCK/JERK, MISS, STUMBLE—AFTER DECELERATION DOWN LONG GRADE WITH THE CRUISE CONTROL ENGAGED

Released 10/15/2004
OVERHEAD TRIP COMPUTER (OTC) DISTANCE TO EMPTY (DTE) INCORRECT

Released 9/23/2004
WATER LEAK—ROOF FLANGE AREA—WATER ACCUMULATION IN HEADLINER AND/OR LEAK AT THE CAB FLOOR PAN AREA

Released 6/18/2004
DRIVEABILITY—NO START OR CONSTANT ENGINE MISFIRE—FUEL INJECTION CONTROL MODULE (FICM) DIAGNOSIS—6.0L DIESEL

Released 6/9/2004
BODY—PAINT—IRON PARTICLE REMOVAL - INDUSTRIAL FALLOUT—ACID RAIN NEUTRALIZATION

Released 2/23/2003
BODY—MIRROR—EXTERIOR MIRROR GLASS AND MOTOR REPLACEMENT—SERVICE TIPS

Released 1/18/2003
ELECTRICAL—REMOTE KEYLESS ENTRY (RKE)— SERVICE TIPS

Released 11/19/2009
6.0L DIESEL CALIBRATION UPDATE - VARIOUS ISSUES

Released 4/3/2009
6.0L DIESEL CALIBRATION UPDATE - VARIOUS ISSUES

Released 12/22/2008
6.0L - COKING DEPOSITS DIAGNOSTIC - EGR DTCS P0401, P0402, P0404, P1335

Released 5/16/2008
COOLANT LOSS—6.0L

Released 11/13/2007
COOLING SYSTEM DIAGNOSTICS—OIL IN ENGINE COOLANT—6.0L

Released 10/12/2007
6.0L—MIL ON—P0401, P0402, P0404, P1335—LACK OF POWER OR SURGE

Released 7/6/2007
ERRATIC SHIFTS—SPEEDS ABOVE 50 MPH (80 TSB 07-14-8 KM/H) AND/OR ENGAGEMENT SHUDDER

Released 12/22/2006
WATER-IN-FUEL (WIF) LAMP ON / FLICKERING

Released 6/24/2006
6.0L—BUILT ON OR BEFORE 9/29/2003—DTCS P006A OR P132B—LACKS POWER, SURGE, OR FLUTTERAFTER FIELD SERVICE ACTION 06E17

Released 12/19/2005
TURBO-INDUCED EXHAUST MOAN/DRONE AT 1500-2000 RPM—6.0L BUILT AFTER 9/29/2003

Released 12/4/2005
INTERMITTENT ROUGH IDLE—NON-COMMANDED INTERMITTENT ROUGH IDLE—NON-COMMANDED

Released 9/21/2005
WHINE/WHISTLE NOISE—6.0L

Released 12/8/2004
6.0L ENGINE—LOW RPM, BUCK/JERK, MISS, STUMBLE—AFTER DECELERATION DOWN LONG GRADE WITH THE CRUISE CONTROL ENGAGED

Released 10/15/2004
OVERHEAD TRIP COMPUTER (OTC) DISTANCE TO EMPTY (DTE) INCORRECT

Released 5/16/2004
HIGH ENGINE RPM BETWEEN DOWNSHIFTS—LACK OF ENGINE BRAKING—5.4L ENGINE AND MANUAL TRANSMISSION

Released 4/17/2004
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED—SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC’S)—SERVICE TIPS

Released 4/9/2004
ENGINE—EXHAUST—TURBO-INDUCED EXHAUST MOAN/DRONE AT 1600-1800 RPM—6.0L BUILT PRIOR TO 9/29/2003 * NOISE—VIBRATION—TURBO-INDUCED EXHAUST MOAN/DRONE AT 1600-1800 RPM—6.0L BUILT PRIOR TO 9/29/2003

Released 12/20/2003
DRIVEABILITY—VARIOUS DRIVEABILITY CONDITIONS—6.0L DIT ENGINE—VEHICLES BUILT BEFORE 9/29/03—CALIBRATION UPDATE—RUNNING CHANGE

Released 2/23/2008
COLD START DRIVEABILITY—WHITE SMOKE, LACKS POWER, EXHAUST ODOR, SURGES, RUNS ROUGH, OR NO START—6.0L

Released 12/19/2005
TURBO-INDUCED EXHAUST MOAN/DRONE AT 1500-2000 RPM—6.0L BUILT AFTER 9/29/2003

Released 9/13/2005
DIESEL EXHAUST SMELL IN CAB—6.0L ENGINE

Released 4/5/2005
USE OF STAINLESS STEEL EXHAUST STUDS IN SERVICE FOR 5.4L 2V ENGINE

Released 4/9/2004
ENGINE—EXHAUST—TURBO-INDUCED EXHAUST MOAN/DRONE AT 1600-1800 RPM—6.0L BUILT PRIOR TO 9/29/2003 * NOISE—VIBRATION—TURBO-INDUCED EXHAUST MOAN/DRONE AT 1600-1800 RPM—6.0L BUILT PRIOR TO 9/29/2003

Released 7/9/2012
DTCS P0505, P0506 AND/OR ENGINE IDLE RPM FLUCTUATION - HARD START

Released 6/11/2010
6.0L - RUNS ROUGH, LACKS POWER, HARD START, NO START

Released 8/5/2009
6.0L TURBOCHARGER CARBON DEPOSIT DIAGNOSTICS AND SERVICE TIPS

Released 12/12/2008
6.0L DIESEL - DRIVEABILITY - NO START, HARD START, RUNS ROUGH - FUEL INJECTION CONTROL MODULE DIAGNOSIS

Released 11/5/2008
6.0L DIESEL FUEL IN ENGINE COOLANT DIAGNOSTICS

Released 9/12/2008
6.0L ENGINE—MISFIRE, LACK OF POWER, BUCK / TSB 08-20-1 JERK, EXCESSIVE SMOKE, CRANK / NO START— DIAGNOSTICS FOR FUEL SYSTEM—SERVICE TIPS

Released 8/4/2008
6.0L TURBOCHARGER CARBON DEPOSIT DIAGNOSTICS AND SERVICE TIPS

Released 3/7/2008
6.0L—OIL SEEP OR BOOST PRESSURE LEAK AT HOT SIDE CHARGE AIR COOLER DUCT

Released 2/23/2008
COLD START DRIVEABILITY—WHITE SMOKE, LACKS POWER, EXHAUST ODOR, SURGES, RUNS ROUGH, OR NO START—6.0L

Released 1/18/2008
6.0L—COKING DEPOSIT DIAGNOSTICS—SERVICE TIP

Released 11/21/2007
WATER IN THE FUEL TANK BEHIND REAR AXLE— 6.4L, 6.0L, AND 7.3L DIESEL ENGINE

Released 12/22/2006
WATER-IN-FUEL (WIF) LAMP ON / FLICKERING

Released 12/19/2005
LONG CRANK OR RUNS ROUGH AT FACTORY DELIVERY OR AFTER HIGH PRESSURE OIL SYSTEM REPAIR—6.0L

Released 12/19/2005
TURBO-INDUCED EXHAUST MOAN/DRONE AT 1500-2000 RPM—6.0L BUILT AFTER 9/29/2003

Released 9/21/2005
WHINE/WHISTLE NOISE—6.0L

Released 8/22/2005
WDS COP KIT DIAGNOSTIC TIPS—COIL ON PLUG (COP) IGNITION SYSTEMS—ENGINE MISFIRE OR ROUGH RUNNING

Released 4/17/2005
VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY—CLIMATE CONTROL DEFAULTS TO DEFROST MODE

Released 3/22/2005
LOW POWER—COLD SIDE CHARGE AIR COOLER CAC) DISCONNECTED—OIL LEAK AT CAC CONNECTIONS—6.0L ENGINE—VEHICLES BUILT 4/1/2004 THROUGH 2/20/2005

Released 12/24/2004
LOSS OF POWER OR STUMBLE WHILE DRIVING IN RAIN—6.8L ENGINE

Released 10/15/2004
OVERHEAD TRIP COMPUTER (OTC) DISTANCE TO EMPTY (DTE) INCORRECT

Released 6/18/2004
DRIVEABILITY—NO START OR CONSTANT ENGINE MISFIRE—FUEL INJECTION CONTROL MODULE (FICM) DIAGNOSIS—6.0L DIESEL

Released 4/9/2004
ENGINE—EXHAUST—TURBO-INDUCED EXHAUST MOAN/DRONE AT 1600-1800 RPM—6.0L BUILT PRIOR TO 9/29/2003 * NOISE—VIBRATION—TURBO-INDUCED EXHAUST MOAN/DRONE AT 1600-1800 RPM—6.0L BUILT PRIOR TO 9/29/2003

Released 3/9/2004
DRIVEABILITY—RUNS ROUGH AND/OR LOW POWER—6.0L DIESEL ENGINE ONLY * ENGINE—FUEL IN OIL—6.0L DIESEL—INJECTOR DIAGNOSTICS

Released 10/20/2003
DRIVEABILITY—FUEL SYSTEM—INJECTOR COMBUSTION SEAL—INSTALLATION PROCEDURE—SERVICE TIP—6.0L ENGINE *

Released 12/22/2006
HEATER CORE LEAKS—6.0L ENGINE

Released 12/21/2006
HEATER CORE LEAKAGE AND ELECTROLYSIS (INFORMATION ONLY)

Released 9/4/2006
A/C COMPRESSOR NOT OPERATIONAL / LOW FREON—SHAFT SEAL LEAKS

Released 5/22/2018
2000-2010 F-Super Duty/E-Series/Excursion - Diesel Remanufactured Component Identification

Released 4/23/2018
2003-2014 Multiple Vehicles with a Torqshift Transmission Intermittent Clunk When Shifting Between Reverse and Park and/or During 2-3 Shift

Released 4/23/2018
1999-2011 F-SUPER DUTY EQUIPPED WITH ESOF 4X4 WITH DTC P1865 AND/OR P1867

Released 4/23/2018
2004-2016 Econoline/F-Super Duty with Dana 70 or Dana 80 Trac-Loc® Limited-Slip Differential - Rear Axle Chatter On Turns

Released 4/23/2018
2001-2015 - Vehicles With Modular 4.6L, 5.4L Or 6.8L Engines - Determining Root Cause Of Engine Damage Due To Oil Pressure Loss.

Released 4/23/2018
2003-2010 - Vehicles Equipped With 6.0L Or 4.5L Diesel Engines - Damage To The Injector Pressure Regulator (IPR) Screen

Released 4/23/2018
REPLACEMENT TRANSMISSION FLUID FOR SERVICING TORQSHIFT TRANSMISSIONS

Released 11/28/2017
2000-2010 F-Super Duty/E-Series/Excursion - Diesel Remanufactured Component Identification

Released 2/17/2016
Vehicles with 6.0L Diesel - Crank/No Start Supplement - General Service Bulletin (GSB)

Released 12/15/2015
Multiple Vehicles - Transmission Cooler Flush General Service Bulletin (GSB)

Released 12/8/2015
Multiple Vehicles - Engine Failure Analysis General Service Bulletin (GSB)

Released 12/7/2015
Multiple Vehicles - Spark Plug Thread Repair - 4.6L/5.4L/6.8L Modular 2v Engines - General Service Bulletin (GSB)

Released 12/16/2009
6.0L DIESEL FUEL IN ENGINE COOLANT DIAGNOSTICS - BUILT ON OR BEFORE 9/30/2008

Released 10/22/2009
4.5L, 6.0L AND 6.4L DIESEL HEAD GASKET CLEANING AND CYLINDER HEAD INSPECTION PROCEDURES

Released 8/3/2009
6.0L - BUILT ON OR BEFORE 9/29/2003 DTCS P006A, P132B, P0401 OR P0402 - LACKS POWER, SURGE, OR FLUTTER AFTER FIELD SERVICE ACTION 06E17

Released 6/17/2009
4.5L, 6.0L AND 6.4L DIESEL HEAD GASKET CLEANING AND CYLINDER HEAD INSPECTION PROCEDURES

Released 11/5/2008
6.0L DIESEL FUEL IN ENGINE COOLANT DIAGNOSTICS

Released 9/12/2008
6.0L ENGINE—MISFIRE, LACK OF POWER, BUCK / TSB 08-20-1 JERK, EXCESSIVE SMOKE, CRANK / NO START— DIAGNOSTICS FOR FUEL SYSTEM—SERVICE TIPS

Released 5/16/2008
COOLANT LOSS—6.0L

Released 3/7/2008
6.0L—OIL SEEP OR BOOST PRESSURE LEAK AT HOT SIDE CHARGE AIR COOLER DUCT

Released 1/18/2008
6.0L—COKING DEPOSIT DIAGNOSTICS—SERVICE TIP

Released 11/21/2007
WATER IN THE FUEL TANK BEHIND REAR AXLE— 6.4L, 6.0L, AND 7.3L DIESEL ENGINE

Released 11/13/2007
COOLING SYSTEM DIAGNOSTICS—OIL IN ENGINE COOLANT—6.0L

Released 10/17/2007
4.6L 2V, 5.4L 2V, OR 6.8L 2V—SPARK PLUG THREAD REPAIR PROCEDURE—NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY

Released 7/6/2007
ERRATIC SHIFTS—SPEEDS ABOVE 50 MPH (80 TSB 07-14-8 KM/H) AND/OR ENGAGEMENT SHUDDER

Released 5/18/2007
DIESEL ENGINE—OVERHEATING WITH A SNOW PLOW INSTALLED ON VEHICLES WITHOUT THE FACTORY INSTALLED SNOW PLOW PACKAGE

Released 5/4/2007
6.0L—SERVICE REMANUFACTURED ENGINE, CYLINDER BLOCK, AND CYLINDER HEAD IDENTIFICATION

Released 2/15/2007
SOME 1997-2007 VEHICLES WITH 5.4L 2V AND 6.8L 2V MODULAR ENGINE SPARK PLUG THREAD OUT OF WARRANTY REPAIR PROCEDURE FOR ALUMINUM HEADS

Released 1/9/2007
MERCONâ ATF REPLACED BY MERCON (R) V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS

Released 12/22/2006
HEATER CORE LEAKS—6.0L ENGINE

Released 12/22/2006
WATER-IN-FUEL (WIF) LAMP ON / FLICKERING

Released 12/18/2006
IDENTIFYING THE CORRECT REPLACEMENT HEAD GASKET FOR CERTAIN REMANUFACTURED ENGINES—SERVICE TIP

Released 10/21/2006
6.0L—REVISED CYLINDER HEAD FLATNESS CHECK PROCEDURE AND SPECIFICATION

Released 4/23/2006
DRIVE-AWAY SHUDDER OR VIBRATION

Released 4/14/2006
MERCON ATF IS BEING REPLACED BY MERCON V ATF AS A SERVICE FLUID.

Released 1/26/2006
MERCON ATF IS BEING REPLACED BY MERCON V AS A SERVICE FLUID FOR SOME MANUAL TRANSMISSIONS

Released 12/19/2005
LONG CRANK OR RUNS ROUGH AT FACTORY DELIVERY OR AFTER HIGH PRESSURE OIL SYSTEM REPAIR—6.0L

Released 12/17/2005
DTC P0488 AND/OR P1334 WITH NO DRIVEABILITY SYMPTOMS, HARSH SHIFT AND/OR TRANSMISSION ENGAGEMENTS

Released 12/13/2005
FEAD BELT FRAYED/SHREDDED/BROKEN—6.0L DIESEL ENGINE—VEHICLES BUILT THROUGH 1/1/2005

Released 12/4/2005
INTERMITTENT ROUGH IDLE—NON-COMMANDED INTERMITTENT ROUGH IDLE—NON-COMMANDED

Released 10/26/2005
CLUNK OR BUMP WHEN STARTING FROM A STOP

Released 10/11/2005
BUCK/JERK, SURGE, HESITATION—5.4L OR 6.8L ENGINES—MANUAL TRANSMISSION ONLY

Released 9/21/2005
WHINE/WHISTLE NOISE—6.0L

Released 9/13/2005
DIESEL EXHAUST SMELL IN CAB—6.0L ENGINE

Released 8/22/2005
WDS COP KIT DIAGNOSTIC TIPS—COIL ON PLUG (COP) IGNITION SYSTEMS—ENGINE MISFIRE OR ROUGH RUNNING

Released 6/16/2005
MISFIRE, LACK OF POWER, SMOKE, SLOW CRANK IN COLD WEATHER ON INITIAL START UP—6.0L ENGINE

Released 6/3/2005
4X4 TRANSFER CASE JUMP OUT OF 4H OR 4L— MANUAL SHIFT TRANSFER CASE

Released 4/17/2005
VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY—CLIMATE CONTROL DEFAULTS TO DEFROST MODE

Released 4/5/2005
USE OF STAINLESS STEEL EXHAUST STUDS IN SERVICE FOR 5.4L 2V ENGINE

Released 3/22/2005
LOW POWER—COLD SIDE CHARGE AIR COOLER CAC) DISCONNECTED—OIL LEAK AT CAC CONNECTIONS—6.0L ENGINE—VEHICLES BUILT 4/1/2004 THROUGH 2/20/2005

Released 3/20/2005
OIL PAN CORROSION—7.3L OR 6.0L

Released 12/25/2004
MIL ILLUMINATED WITH DTC P0756, P0761 OR P0771 AFTER OVERHAUL OR INSTALLATION OF 2005 TORQSHIFT TRANSMISSION

Released 12/24/2004
LOSS OF POWER OR STUMBLE WHILE DRIVING IN RAIN—6.8L ENGINE

Released 12/17/2004
HARD START OR NO START—GPCM CONNECTOR SERVICE KIT AVAILABLE—6.0L ENGINE

Released 12/14/2004
FRONT END ACCESSORY DRIVE (FEAD) BELT NOISE—VEHICLES BUILT PRIOR TO 6/1/2004—6.0L ENGINE

Released 12/8/2004
6.0L ENGINE—LOW RPM, BUCK/JERK, MISS, STUMBLE—AFTER DECELERATION DOWN LONG GRADE WITH THE CRUISE CONTROL ENGAGED

Released 8/23/2004
STEERING GEAR NOISE—6.0L DIESEL ENGINE

Released 6/18/2004
DRIVEABILITY—NO START OR CONSTANT ENGINE MISFIRE—FUEL INJECTION CONTROL MODULE (FICM) DIAGNOSIS—6.0L DIESEL

Released 5/18/2004
AXLE—FRONT HUBS NOT ENGAGING, NOT STAYING ENGAGED AND/OR UNLOCKING

Released 5/16/2004
HIGH ENGINE RPM BETWEEN DOWNSHIFTS—LACK OF ENGINE BRAKING—5.4L ENGINE AND MANUAL TRANSMISSION

Released 3/9/2004
DRIVEABILITY—RUNS ROUGH AND/OR LOW POWER—6.0L DIESEL ENGINE ONLY * ENGINE—FUEL IN OIL—6.0L DIESEL—INJECTOR DIAGNOSTICS

Released 2/11/2004
SUSPENSION—VEHICLE SWAY/LEAN DURING LOW SPEED TURNING MANEUVERS * NOISE—SUSPENSION—POPPING NOISE IN FRONT END

Released 12/20/2003
DRIVEABILITY—VARIOUS DRIVEABILITY CONDITIONS—6.0L DIT ENGINE—VEHICLES BUILT BEFORE 9/29/03—CALIBRATION UPDATE—RUNNING CHANGE

Released 10/20/2003
DRIVEABILITY—FUEL SYSTEM—INJECTOR COMBUSTION SEAL—INSTALLATION PROCEDURE—SERVICE TIP—6.0L ENGINE *

Released 2/11/2003
SUSPENSION—ON-VEHICLE FRONT INTEGRATED HUB/BEARING ROCKING END-PLAY MEASUREMENT * AXLE—ON-VEHICLE FRONT INTEGRATED HUB/BEARING ROCKING END-PLAY MEASUREMENT

Released 7/7/2011
Compliance Recall - Certain 2011 Model Year Ranger Vehicles Built with a Suspect Multifunction Switch and Certain Vehicles Serviced with a Suspect Multifunction Switch - Multifunction Switch Inspection and Replacement - Dealer Bulletin

Released 7/7/2011
Compliance Recall - Certain 2011 Model Year Ranger Vehicles Built with a Suspect Multifunction Switch and Certain Vehicles Serviced with a Suspect Multifunction Switch - Multifunction Switch Inspection and Replacement - Additional Information - Background Summary

Released 2/13/2007
LEATHER-WRAPPED STEERING WHEEL—LEATHER COMING LOOSE

Released 1/9/2007
MERCONâ ATF REPLACED BY MERCON (R) V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS

Released 1/9/2005
STEERING GEAR NOISE—5.4L AND 6.8L ENGINE-SINGLE REAR WHEEL

Released 8/23/2004
STEERING GEAR NOISE—6.0L DIESEL ENGINE

Released 6/23/2004
VEHICLE LEAN/SAG WHEN OBSERVED FROM REAR OF VEHICLE

Released 2/11/2004
SUSPENSION—VEHICLE SWAY/LEAN DURING LOW SPEED TURNING MANEUVERS * NOISE—SUSPENSION—POPPING NOISE IN FRONT END

Released 4/17/2003
STEERING—STEERING WHEEL FIGHT AFTER RIDING OVER BUMPS/RUTS

Released 2/11/2003
SUSPENSION—ON-VEHICLE FRONT INTEGRATED HUB/BEARING ROCKING END-PLAY MEASUREMENT * AXLE—ON-VEHICLE FRONT INTEGRATED HUB/BEARING ROCKING END-PLAY MEASUREMENT

Released 8/22/2005
WDS COP KIT DIAGNOSTIC TIPS—COIL ON PLUG (COP) IGNITION SYSTEMS—ENGINE MISFIRE OR ROUGH RUNNING

Released 7/18/2005
WIRING—SOLDERING AND CRIMPING REPAIRS— SOLDERING TIPS

Released 3/9/2005
INTERIOR PLASTIC TRIM—PAINT-TO-MATCH AND REPAIR—INTERIOR SPRAY PAINT AND ADHESION PROMOTER USAGE INSTRUCTIONS