Get Free 2008 FORD F350 V8, 5.4L; SOHC TSBs

Released 4/23/2018
2001-2015 - Vehicles With Modular 4.6L, 5.4L Or 6.8L Engines - Determining Root Cause Of Engine Damage Due To Oil Pressure Loss.

Released 4/23/2018
2003-2014 Multiple Vehicles with a Torqshift Transmission Intermittent Clunk When Shifting Between Reverse and Park and/or During 2-3 Shift

Released 4/23/2018
2008-2014 F-Super Duty, Econoline, F-53, and F-59 With a 5R110 Torqshift-Transmission Oil To Air Cooler Can Now Be Flushed After Some Repairs

Released 4/23/2018
Vehicle No Start After Instrument Cluster Replacement Due to Proper Programmable Module Installation (PMI) Programming Not Being Performed.

Released 4/23/2018
New Wiring Repair Job Aid is available on PTS under the Service Tips tab

Released 4/23/2018
2005-2017 F-Super Duty 4x4 – Front Hub Vacuum Seal Shield Kit Now Available – Extreme Dust, Mud Or Tar Sand Conditions

Released 4/23/2018
Dealer Installed Audio Upgrades

Released 4/23/2018
2004-2016 Econoline/F-Super Duty with Dana 70 or Dana 80 Trac-Loc® Limited-Slip Differential - Rear Axle Chatter On Turns

Released 4/23/2018
Various Vehicles - 4.6L/5.4L/6.8L 3 Valve - Engine Noise Upper End And/Or Rough Running - Camshaft Roller Follower Replacement - Built On Or Before 8-Jan-2016

Released 4/23/2018
2008-2017 Various Ford/Lincoln/Mercury Vehicles - Replacing/Upgrading Original Equipment SYNC/Navigation System Components Is Not Supported

Released 4/23/2018
1999-2011 F-SUPER DUTY EQUIPPED WITH ESOF 4X4 WITH DTC P1865 AND/OR P1867

Released 4/23/2018
2006-2009 F-SUPER DUTY - 4WD HUB USEAGE - SERVICE TIP

Released 4/23/2018
VEHICLES WITH P035X (OR P0351 - P0360) DTC CODES

Released 4/23/2018
2007-2008 CROWN VICTORIA/GRAND MARQUIS/TOWN CAR/E150/F150 - 4R75E TRANSMISSION INTERMEDIATE ONE WAY CLUTCH AND SNAP RING SERVICE TIP

Released 4/23/2018
2008 E-SERIES, SUPER DUTY OR RANGER - NO CRANK, CRANK/NO START WITH P1260 DTC NON-PATS AND PATS KEY EQUIPPED.

Released 4/23/2018
REPLACEMENT TRANSMISSION FLUID FOR SERVICING TORQSHIFT TRANSMISSIONS

Released 4/23/2018
2005-2008 Remanufactured 5.4L 3v and 6.8L 3v - Ignition Coil Boots Included with Engine Packaging.

Released 4/23/2018
2008-2010 F-SUPER DUTY EQUIPPED WITH 6.4L, AUTO TRANS, ADJUSTABLE PEDALS - BUCK/JERK, SURGE TOWING 5TH WHEEL AND GOOSENECK TRAILERS.

Released 4/23/2018
Accessory (Wireless) Keyless Entry Keypad Is Available With Remote Keyless Entry (RKE) Only And The Retrieval Of Master Code.

Released 4/23/2018
2008-2018 Various Ford/Lincoln/Mercury Vehicles - Replacing/Upgrading Original Equipment SYNC/Navigation System Components Is Not Supported

Released 4/23/2018
2008-2010 - F-Super Duty - 6.4L - Exhaust Odor - Exhaust Manifold Leak Service Tip

Released 11/28/2017
2000-2010 F-Super Duty/E-Series/Excursion - Diesel Remanufactured Component Identification

Released 9/25/2017
Various Vehicles - Module Programming and Reprogramming Procedures

Released 9/30/2016
Multiple Vehicles - SYNC Software Programming v1.1

Released 4/27/2016
Multiple Vehicles - No PCM/Network Communication

Released 1/27/2016
2004 And Newer Vehicles Equipped With Flex Fuel Capability - Flex Fuel General Service Bulletin (GSB)

Released 12/15/2015
Multiple Vehicles - Transmission Cooler Flush General Service Bulletin (GSB)

Released 12/9/2015
Multiple Vehicles - Tire Pressure Monitor System (TPMS) General Service Bulletin (GSB)

Released 12/8/2015
Multiple Vehicles - Engine Failure Analysis General Service Bulletin (GSB)

Released 12/7/2015
Multiple Vehicles - Spark Plug Thread Repair - 4.6L/5.4L/6.8L Modular 2v Engines - General Service Bulletin (GSB)

Released 10/14/2015
Multple Vehicles - Wiring Repair General Service Bulletin (GSB)

Released 9/30/2015
6.4L Diesel - High Pressure Fuel System Contamination - Water In Fuel General Service Bulletin (GSB)

Released 8/25/2015
6.4L Diesel - Oil Cooler Service Tips General Service Bulletin (GSB)

Released 8/20/2015
Multiple Vehicles - 4.6L 3v And 5.4L 3v Engines - 3v Cam Phaser Installation General Service Bulletin (GSB)

Released 6/7/2013
2008-2012 F-Super Duty - Clunk Or Pop-Type Noise And/Or Bump Felt From Floor Pan While Turning Left Or Right - Built On Or Before 5/1/2012

Released 10/13/2010
6.4L - FRONT END SHEET METAL BODY BOLT REMOVAL - SPUN CAGE NUT

Released 5/24/2010
Multiple Vehicles - Brake Disc Service Tips General Service Bulletin (GSB)

Released 4/7/2010
CLUNK/POP NOISE HEARD/FELT UNDER FLOOR PAN WHILE TURNING

Released 7/29/2009
SLIDING POWER WINDOW (BACK GLASS) INOPERATIVE OR BINDING - BUILT BEFORE 6/20/2009

Released 6/3/2009
EXTERIOR DOOR HANDLE LOOSE - BUILT BEFORE 11/1/2008

Released 6/2/2009
SEAT SIDE TRIM PANEL - LOOSE / BROKEN / CRACKED - BUILT BEFORE 8/1/2008

Released 2/25/2009
SHUDDER OR VIBRATION ON ACCELERATION - ESPECIALLY WHEN LOADED

Released 11/25/2008
WATER LEAKS - ROOF OPENING PANEL DURING HIGH PRESSURE CAR WASH

Released 9/10/2008
A/C SLOW TO COOL—DUAL AUTOMATIC TEMPERATURE CONTROL (DATC)—BUILD DATE BEFORE 6/28/2007

Released 6/3/2008
RUST STAINS ON THE EDGES OF THE FRONT BUMPER CENTER VENT AND FOG LAMP OPENINGS

Released 5/23/2008
4X4 ONLY—BANGING/CLUNKING NOISE WHEN DRIVING—CONTACT WITH JOUNCE BUMPER—COLD TEMPERATURES

Released 5/16/2008
POWER WINDOW NOISE—BUILT BEFORE 7/31/2007

Released 2/21/2008
SATELLITE DIGITAL AUDIO RECEIVER SYSTEM (SDARS), MAY NOT SEEK ALL SIRIUS SATELLITE RADIO CHANNELS

Released 2/12/2008
ASH TRAY BROKEN OR LOOSE—BUILT BEFORE 09/17/2007

Released 2/12/2008
6.4L AIR INDUCTION SYSTEM RESTRICTION— SNOW—BUILT BEFORE 9/18/2007

Released 11/30/2007
TAILGATE STRIKER—NOISE/RATTLE

Released 11/9/2007
6.4L DIESEL—COLD WEATHER BELT CHIRP

Released 7/30/2007
LIGHTING ON AMBULANCE PACKAGES (US ONLY)

Released 6/8/2007
SERVICE TIP—CAGE NUT SPINNING—CAB OFF SERVICE PROCEDURE

Released 5/4/2007
FRONT DOOR SIDE GLASS SCRATCHED DUE TO COLLECTION OF DIRT/DEBRIS IN WARPED OUTER WINDOW MOLDING

Released 4/19/2007
2008 F-SUPER DUTY- LIGHTING ON SNOW PLOW EQUIPPED VEHICLES—BUILT BEFORE 04/18/2007

Released 2/13/2007
LEATHER-WRAPPED STEERING WHEEL—LEATHER COMING LOOSE

Released 11/1/1996
LOCKS—INTRODUCTION OF NEW LOCK DESIGN—SERVICE TIP

Released 6/2/1991
PAINT—CODES—REVISED 1991 FLEET COLOR PAINT CODE NUMBERS

Released 2/1/2011
6.4L DIESEL - WHITE SMOKE IN DAMP WEATHER CONDITIONS WHEN ACCELERATING

Released 1/19/2011
6.4L DIESEL ENGINES - RADIATOR LEAK DUE TO HYPER-EXTENDED BYPASS THERMOSTAT

Released 8/30/2010
6.4L DIESEL ENGINES - RADIATOR LEAK DUE TO HYPER-EXTENDED BYPASS THERMOSTAT

Released 4/14/2010
6.4L DIESEL COOLING SYSTEM CONTAMINATION FLUSH PROCEDURE

Released 3/5/2010
6.4L DIESEL ENGINES - REPEAT RADIATOR LEAK - BUILT ON OR BEFORE 9/14/2009

Released 2/23/2010
6.4L DIESEL ENGINES - REPEAT RADIATOR LEAK - BUILT ON OR BEFORE 9/14/2009

Released 11/9/2009
6.4L DIESEL ENGINES - REPEAT RADIATOR LEAK - BUILT ON OR BEFORE 9/14/2009

Released 4/14/2009
DIESEL COOLANT MAINTENANCE - SERVICE TIPS

Released 3/4/2008
6.4L—DTC P0528 AND/OR P0529

Released 5/18/2007
DIESEL ENGINE—OVERHEATING WITH A SNOW PLOW INSTALLED ON VEHICLES WITHOUT THE FACTORY INSTALLED SNOW PLOW PACKAGE

Released 4/23/2018
Vehicle No Start After Instrument Cluster Replacement Due to Proper Programmable Module Installation (PMI) Programming Not Being Performed.

Released 4/23/2018
New Wiring Repair Job Aid is available on PTS under the Service Tips tab

Released 4/23/2018
Dealer Installed Audio Upgrades

Released 4/23/2018
2008-2017 Various Ford/Lincoln/Mercury Vehicles - Replacing/Upgrading Original Equipment SYNC/Navigation System Components Is Not Supported

Released 4/23/2018
VEHICLES WITH P035X (OR P0351 - P0360) DTC CODES

Released 4/23/2018
2008 E-SERIES, SUPER DUTY OR RANGER - NO CRANK, CRANK/NO START WITH P1260 DTC NON-PATS AND PATS KEY EQUIPPED.

Released 4/23/2018
2005-2008 Remanufactured 5.4L 3v and 6.8L 3v - Ignition Coil Boots Included with Engine Packaging.

Released 4/23/2018
2008-2010 F-SUPER DUTY EQUIPPED WITH 6.4L, AUTO TRANS, ADJUSTABLE PEDALS - BUCK/JERK, SURGE TOWING 5TH WHEEL AND GOOSENECK TRAILERS.

Released 4/23/2018
Accessory (Wireless) Keyless Entry Keypad Is Available With Remote Keyless Entry (RKE) Only And The Retrieval Of Master Code.

Released 11/28/2017
2000-2010 F-Super Duty/E-Series/Excursion - Diesel Remanufactured Component Identification

Released 9/30/2016
Multiple Vehicles - SYNC Software Programming v1.1

Released 4/27/2016
Multiple Vehicles - No PCM/Network Communication

Released 12/7/2015
Multiple Vehicles - Spark Plug Thread Repair - 4.6L/5.4L/6.8L Modular 2v Engines - General Service Bulletin (GSB)

Released 10/14/2015
Multple Vehicles - Wiring Repair General Service Bulletin (GSB)

Released 9/30/2009
SPEAKER POP AND/OR RADIO INOPERATIVE/BLANK/LOCKED UP

Released 5/5/2009
6.4L DIESEL - COLD WEATHER BELT CHIRP

Released 4/22/2009
WIRING FAULT ON TRAILER DISPLAYED IN MESSAGE CENTER - DTC C2806

Released 4/2/2009
COMPASS INTERMITTENTLY LOSES CALIBRATION - BUILD BEFORE 3/1/2009

Released 11/7/2008
DUAL REAR WHEEL (DRW) REAR FENDER SIDE MARKER LAMPS LOOSE

Released 6/5/2008
INOPERATIVE RKE TRANSMITTER (KEY FOB)— DISCHARGED KEY FOB BATTERY

Released 6/3/2008
RUST STAINS ON THE EDGES OF THE FRONT BUMPER CENTER VENT AND FOG LAMP OPENINGS

Released 2/21/2008
SATELLITE DIGITAL AUDIO RECEIVER SYSTEM (SDARS), MAY NOT SEEK ALL SIRIUS SATELLITE RADIO CHANNELS

Released 11/9/2007
6.4L DIESEL—COLD WEATHER BELT CHIRP

Released 7/30/2007
LIGHTING ON AMBULANCE PACKAGES (US ONLY)

Released 4/19/2007
2008 F-SUPER DUTY- LIGHTING ON SNOW PLOW EQUIPPED VEHICLES—BUILT BEFORE 04/18/2007

Released 11/1/1996
LOCKS—INTRODUCTION OF NEW LOCK DESIGN—SERVICE TIP

Released 7/16/2012
6.4L - LACK OF POWER - DIAGNOSTIC TROUBLE CODE (DTC) P0088

Released 6/17/2011
6.4L - DIAGNOSTIC TROUBLE CODE (DTC) P040D - BUILT ON OR BEFORE 11/1/2009

Released 5/23/2011
6.4L CALIBRATION UPDATE - DIAGNOSTIC TROUBLE CODE (DTC) P0234

Released 1/10/2011
4.0L / 5.4L / 6.8L - CALIBRATION UPDATE - VARIOUS ISSUES

Released 10/5/2010
5.4L / 6.8L / 4.0L - DTC P0607 AND P061B

Released 12/21/2009
5.4L / 4.0L - DTC P0607

Released 9/17/2009
6.4L - VEHICLES BUILT BETWEEN 8/3/2007 AND 1/2/2008 - MODULE REPROGRAMMING

Released 9/9/2009
6.4L - VEHICLES BUILT BETWEEN 1/3/2008 AND 9/15/2008 - DTCS P0128, P0196, P1335, P0404, P0406, P246C AND P2463

Released 8/11/2009
6.4L - VEHICLES BUILT PRIOR TO 8/2/2007 - MODULE REPROGRAMMING

Released 8/11/2009
6.4L - VEHICLES BUILT BETWEEN 8/3/2007 AND 1/2/2008 - MODULE REPROGRAMMING

Released 8/11/2009
6.4L - VEHICLES BUILT BETWEEN 1/3/2008 AND 9/15/2008 - DTCS P0128, P0196, P1335, P0404, P0406, P246C AND P2463

Released 4/3/2009
5.4L AND 6.8L GAS ENGINE CALIBRATION UPDATE

Released 12/9/2008
6.4L - VEHICLES BUILT BETWEEN 8/3/2007 AND 1/2/2008 - MODULE REPROGRAMMING

Released 12/9/2008
6.4L - VEHICLES BUILT PRIOR TO 8/2/2007 - MODULE REPROGRAMMING

Released 12/9/2008
6.4L - VEHICLES BUILT BETWEEN 1/3/2008 AND 9/15/2008 - DTCS P0128, P0196, P1335, P0404, P0406, P246C AND P2463

Released 7/25/2008
6.4L—VEHICLES BUILT BEFORE 4/23/2007— ELECTRONIC THROTTLE CONTROL PEDAL REPLACEMENTS

Released 2/20/2008
6.4L DIESEL—REGENERATION FUNCTIONAL CHARACTERISTICS

Released 11/22/2010
6.4L ENGINE - LACKS POWER, MIL ON WITH DTCS P20E2, P20E3, P20E4, P2080, P2084, P242B, P0544, P2031, P242A, OR P200E

Released 10/28/2009
STAINLESS STEEL EXHAUST STUDS - 5.4L AND 6.8L 2V ENGINES

Released 9/17/2009
6.4L - VEHICLES BUILT BETWEEN 8/3/2007 AND 1/2/2008 - MODULE REPROGRAMMING

Released 9/9/2009
6.4L - VEHICLES BUILT BETWEEN 1/3/2008 AND 9/15/2008 - DTCS P0128, P0196, P1335, P0404, P0406, P246C AND P2463

Released 11/26/2008
6.4L DIESEL - WHITE SMOKE IN DAMP WEATHER CONDITIONS WHEN ACCELERATING - VEHICLES BUILT BEFORE 10/1/2008

Released 4/13/2007
6.4L DIESEL ENGINE—LACKS POWER, LEAKS FLUID TSB 07-8-9 FROM EXHAUST PIPE, ABNORMAL TAILPIPE SEDIMENT, WHITE SMOKE, EXHAUST SMELL, AND MIL ON

Released 4/2/2007
6.4L—EXHAUST SMOKE FROM FRONT OF VEHICLE—EXHAUST ODOR INSIDE VEHICLE

Released 9/30/2015
6.4L Diesel - High Pressure Fuel System Contamination - Water In Fuel General Service Bulletin (GSB)

Released 12/10/2012
2008-2010 F-Super Duty - 6.4L Diesel - Lacks Power, MIL On With DTCs P20E2, P20E 3, P20E4, P2080, P2084,P242A, P242B, P0544 Or P2031

Released 2/22/2012
SLOW FUEL FILL - 5.4L, 6.2L AND 6.8L ENGINES

Released 4/26/2011
6.4L - LACKS POWER - DTC P0088

Released 4/1/2011
SLOW FUEL FILL - 5.4, 6.2 AND 6.8 ENGINES

Released 1/22/2010
6.4L AIR INDUCTION SYSTEM RESTRICTION - SNOW

Released 1/14/2010
5.4L ENGINE - DIAGNOSTIC TROUBLE CODE (DTC) P2135

Released 10/5/2009
SLOW FUEL FILL - 5.4 AND 6.8 ENGINES

Released 4/21/2009
SLOW FUEL FILL - 5.4 AND 6.8 ENGINES

Released 3/19/2009
6.4L AIR INDUCTION SYSTEM RESTRICTION - SNOW - BUILT ON OR BEFORE 3/16/2009

Released 11/26/2008
6.4L DIESEL - WHITE SMOKE IN DAMP WEATHER CONDITIONS WHEN ACCELERATING - VEHICLES BUILT BEFORE 10/1/2008

Released 4/1/2008
SPARK PLUG REMOVAL INSTRUCTIONS—4.6L 3V/5.4L 3V/6.8L 3V

Released 2/15/2008
SLOW FUEL FILL—MIL ON WITH DTC P0191

Released 2/12/2008
6.4L AIR INDUCTION SYSTEM RESTRICTION— SNOW—BUILT BEFORE 9/18/2007

Released 1/10/2008
6.4L—CHARGE AIR COOLER (CAC) PAINT PROCEDURE—BUILT BEFORE 8/1/2007

Released 12/20/2007
6.4L—INTERMITTENT NO START / LACK OF POWER—DTC P0003 AND/OR BLOWN FUSE 74— BUILT PRIOR—8/20/2007

Released 11/21/2007
WATER IN THE FUEL TANK BEHIND REAR AXLE— 6.4L, 6.0L, AND 7.3L DIESEL ENGINE

Released 4/13/2007
6.4L DIESEL ENGINE—LACKS POWER, LEAKS FLUID TSB 07-8-9 FROM EXHAUST PIPE, ABNORMAL TAILPIPE SEDIMENT, WHITE SMOKE, EXHAUST SMELL, AND MIL ON

Released 9/10/2008
A/C SLOW TO COOL—DUAL AUTOMATIC TEMPERATURE CONTROL (DATC)—BUILD DATE BEFORE 6/28/2007

Released 6/30/2008
LACK OF HEAT WHEN—SNOWPLOW AND/OR TSB 08-14-4 WINTER GRILL COVER—EATC EQUIPPED VEHICLES ONLY

Released 6/3/2008
RUST STAINS ON THE EDGES OF THE FRONT BUMPER CENTER VENT AND FOG LAMP OPENINGS

Released 2/12/2008
6.4L AIR INDUCTION SYSTEM RESTRICTION— SNOW—BUILT BEFORE 9/18/2007

Released 12/19/2007
BLOWER MOTOR INOPERATIVE OR STUCK ON HIGH

Released 11/21/2007
6.4L ENGINE BUILT BEFORE 06/18/2007—HEATER CORE NOISE—ALSO DESCRIBED AS GURGLING, RATTLE, OR SCRAPING NOISE

Released 12/11/2018
Multiple Vehicle Lines - Revised Engine Oil Leak Diagnostic Procedure Using New White Fluorescent Dye

Released 12/11/2018
Various Vehicles - 4.6L/5.4L/6.8L 3 Valve - Engine Noise Upper End And/Or Rough Running - Camshaft Roller Follower Replacement - Built On Or Before 8-Jan-2016

Released 6/7/2018
Various Vehicles - Engine Failure Analysis General Service Bulletin (GSB)

Released 5/22/2018
2000-2010 F-Super Duty/E-Series/Excursion - Diesel Remanufactured Component Identification

Released 4/23/2018
2001-2015 - Vehicles With Modular 4.6L, 5.4L Or 6.8L Engines - Determining Root Cause Of Engine Damage Due To Oil Pressure Loss.

Released 4/23/2018
2003-2014 Multiple Vehicles with a Torqshift Transmission Intermittent Clunk When Shifting Between Reverse and Park and/or During 2-3 Shift

Released 4/23/2018
2008-2014 F-Super Duty, Econoline, F-53, and F-59 With a 5R110 Torqshift-Transmission Oil To Air Cooler Can Now Be Flushed After Some Repairs

Released 4/23/2018
2004-2016 Econoline/F-Super Duty with Dana 70 or Dana 80 Trac-Loc® Limited-Slip Differential - Rear Axle Chatter On Turns

Released 4/23/2018
Various Vehicles - 4.6L/5.4L/6.8L 3 Valve - Engine Noise Upper End And/Or Rough Running - Camshaft Roller Follower Replacement - Built On Or Before 8-Jan-2016

Released 4/23/2018
1999-2011 F-SUPER DUTY EQUIPPED WITH ESOF 4X4 WITH DTC P1865 AND/OR P1867

Released 4/23/2018
2006-2009 F-SUPER DUTY - 4WD HUB USEAGE - SERVICE TIP

Released 4/23/2018
2007-2008 CROWN VICTORIA/GRAND MARQUIS/TOWN CAR/E150/F150 - 4R75E TRANSMISSION INTERMEDIATE ONE WAY CLUTCH AND SNAP RING SERVICE TIP

Released 4/23/2018
REPLACEMENT TRANSMISSION FLUID FOR SERVICING TORQSHIFT TRANSMISSIONS

Released 4/23/2018
2008-2010 F-SUPER DUTY EQUIPPED WITH 6.4L, AUTO TRANS, ADJUSTABLE PEDALS - BUCK/JERK, SURGE TOWING 5TH WHEEL AND GOOSENECK TRAILERS.

Released 11/28/2017
2000-2010 F-Super Duty/E-Series/Excursion - Diesel Remanufactured Component Identification

Released 12/15/2015
Multiple Vehicles - Transmission Cooler Flush General Service Bulletin (GSB)

Released 12/8/2015
Multiple Vehicles - Engine Failure Analysis General Service Bulletin (GSB)

Released 12/7/2015
Multiple Vehicles - Spark Plug Thread Repair - 4.6L/5.4L/6.8L Modular 2v Engines - General Service Bulletin (GSB)

Released 9/30/2015
6.4L Diesel - High Pressure Fuel System Contamination - Water In Fuel General Service Bulletin (GSB)

Released 8/25/2015
6.4L Diesel - Oil Cooler Service Tips General Service Bulletin (GSB)

Released 8/20/2015
Multiple Vehicles - 4.6L 3v And 5.4L 3v Engines - 3v Cam Phaser Installation General Service Bulletin (GSB)

Released 5/29/2014
5.4L 3V – Intermittent Rattle Noise While Driving / Rough Idle When Engine Is At Operating Temperature

Released 12/22/2013
2008–2011 TorqShift Equipped Vehicles - DTC P0710 and/or P0713 TFT Sensor - Buil t On Or Before 8/1/2010

Released 7/20/2012
5.4L INTERMITTENT RATTLE NOISE / ROUGH IDLE WHEN ENGINE IS AT OPERATING TEMPERATURE

Released 10/1/2010
6.4L - NEW ENHANCED SHORT BLOCK - BUILD UP/REPAIR ROBUSTNESS PROCEDURES - INFORMATION ONLY

Released 10/22/2009
4.5L, 6.0L AND 6.4L DIESEL HEAD GASKET CLEANING AND CYLINDER HEAD INSPECTION PROCEDURES

Released 9/29/2009
SHUDDER OR VIBRATION ON ACCELERATION - ESPECIALLY WHEN LOADED

Released 8/3/2009
6.4L DIESEL ENGINE TICKING/TAPPING NOISE

Released 6/17/2009
4.5L, 6.0L AND 6.4L DIESEL HEAD GASKET CLEANING AND CYLINDER HEAD INSPECTION PROCEDURES

Released 2/25/2009
SHUDDER OR VIBRATION ON ACCELERATION - ESPECIALLY WHEN LOADED

Released 12/12/2008
5R110W COLD WEATHER TRANSMISSION FAILURE IN VEHICLES BUILT BETWEEN 5/18/2007 AND 11/1/2008

Released 12/9/2008
6.4L - VEHICLES BUILT BETWEEN 1/3/2008 AND 9/15/2008 - DTCS P0128, P0196, P1335, P0404, P0406, P246C AND P2463

Released 9/9/2008
6.4L DIESEL ENGINE TICKING / TAPPING NOISE

Released 7/30/2008
MANUAL TRANSMISSION—DIFFICULT TO SHIFT COLD—0 TO 40 DEGREES F (-18 TO 4 DEGREES C)

Released 7/29/2008
CYLINDER CONTRIBUTION DIAGNOSTICS—6.4L DIESEL ENGINE—SERVICE TIP

Released 7/25/2008
6.4L - VEHICLES BUILT BETWEEN 1/3/2008 AND 6/25/2008 - DIAGNOSTIC TROUBLE CODES P0128, P0196, P1335, P0404, P0406, P246C AND P2463

Released 7/25/2008
6.4L—VEHICLES BUILT BEFORE 4/23/2007— ELECTRONIC THROTTLE CONTROL PEDAL REPLACEMENTS

Released 6/17/2008
6.4L - VEHICLES BUILT PRIOR TO 8/3/2007 - MODULE REPROGRAMMING

Released 6/17/2008
.. 6.4L - VEHICLES BUILT BETWEEN 8/3/2007 AND 1/3/2008 - MODULE REPROGRAMMING

Released 3/4/2008
6.4L—DTC P0528 AND/OR P0529

Released 11/21/2007
WATER IN THE FUEL TANK BEHIND REAR AXLE— 6.4L, 6.0L, AND 7.3L DIESEL ENGINE

Released 11/21/2007
6.4L ENGINE BUILT BEFORE 06/18/2007—HEATER CORE NOISE—ALSO DESCRIBED AS GURGLING, RATTLE, OR SCRAPING NOISE

Released 11/13/2007
ENGINE KNOCK ON 6.8L 3V ENGINES WITH ENGINE BUILD DATES BETWEEN 6/26/2007 AND 8/30/2007

Released 9/24/2007
MOAN/DRONE AT 1500-2000 RPM—DANA 80 DUAL REAR WHEEL AXLE

Released 5/18/2007
DIESEL ENGINE—OVERHEATING WITH A SNOW PLOW INSTALLED ON VEHICLES WITHOUT THE FACTORY INSTALLED SNOW PLOW PACKAGE

Released 4/13/2007
6.4L DIESEL ENGINE—LACKS POWER, LEAKS FLUID TSB 07-8-9 FROM EXHAUST PIPE, ABNORMAL TAILPIPE SEDIMENT, WHITE SMOKE, EXHAUST SMELL, AND MIL ON

Released 6/4/1991
TRANSMISSION—AUTOMATIC—ELECTRONIC TRANSMISSION DIAGNOSTIC AND REPAIR CHART

Released 12/9/2015
Multiple Vehicles - Tire Pressure Monitor System (TPMS) General Service Bulletin (GSB)

Released 5/15/2015
SAFETY RECALL - Advance Notice - Safety Recall 15S08: Certain 2008-2010 Model Year F-250 / F-350 F-Super Duty Vehicles Serviced with Steering Gear DC3Z-3504-D (STG-454) - Steering Gear Mounting Spacer Installation

Released 4/20/2011
4X4 ONLY - BANGING/CLUNKING NOISE WHEN DRIVING - CONTACT WITH JOUNCE BUMPER - COLD TEMPERATURES

Released 12/13/2010
CLUNK/POP NOISE HEARD/FELT UNDER FLOOR PAN WHILE TURNING - BUILT ON OR BEFORE 11/15/2010

Released 1/15/2010
4X4 ONLY - BANGING/CLUNKING NOISE WHEN DRIVING - CONTACT WITH JOUNCE BUMPER - COLD TEMPERATURES

Released 9/29/2009
SHUDDER OR VIBRATION ON ACCELERATION - ESPECIALLY WHEN LOADED

Released 11/17/2008
VIBRATION DIAGNOSTICS - STEERING WHEEL NIBBLE - TIRE WHEEL RUNOUT AND BALANCE

Released 6/11/2008
CONTAMINATED POWER STEERING FLUID— APPEARANCE—STRAWBERRY MILK SHAKE

Released 5/23/2008
4X4 ONLY—BANGING/CLUNKING NOISE WHEN DRIVING—CONTACT WITH JOUNCE BUMPER—COLD TEMPERATURES

Released 2/5/2008
WHEEL LIP MOULDINGS LOOSE/WARPED (EXCLUDES KING RANCH)—BUILT BEFORE 10/5/2007

Released 9/24/2007
MOAN/DRONE AT 1500-2000 RPM—DANA 80 DUAL REAR WHEEL AXLE

Released 9/6/2007
5.4L AND 6.8L—SRW—POWER STEERING PUMP NOISE, LEAK, OR HOT FLUID

Released 5/23/2007
BRAKE PEDAL KICKBACK OR GRABBING

Released 5/18/2007
F-450 PICK UP—TIRE/WHEEL BALANCE AND RUNOUT PROCEDURE USING HUNTER 9700

Released 3/26/2007
REAR OF VEHICLE IS TOO HIGH/LOW—5TH WHEEL TSB 07-7-2 AND GOOSE NECK APPLICATIONS—4X4 VEHICLES ONLY

Released 2/14/2007
VIBRATION DIAGNOSIS—TIRE/WHEEL RUNOUT

Released 2/13/2007
LEATHER-WRAPPED STEERING WHEEL—LEATHER COMING LOOSE

Released 11/1/1996
LOCKS—INTRODUCTION OF NEW LOCK DESIGN—SERVICE TIP

Released 12/13/2010
CLUNK/POP NOISE HEARD/FELT UNDER FLOOR PAN WHILE TURNING - BUILT ON OR BEFORE 11/15/2010

Released 10/13/2010
6.4L - FRONT END SHEET METAL BODY BOLT REMOVAL - SPUN CAGE NUT

Released 4/7/2010
CLUNK/POP NOISE HEARD/FELT UNDER FLOOR PAN WHILE TURNING