Get Free 2005 FORD F250 V8, 7.3L; Diesel; Turbo TSBs

Released 4/23/2018
1999-2011 F-SUPER DUTY EQUIPPED WITH ESOF 4X4 WITH DTC P1865 AND/OR P1867

Released 4/23/2018
2005-2017 F-Super Duty 4x4 – Front Hub Vacuum Seal Shield Kit Now Available – Extreme Dust, Mud Or Tar Sand Conditions

Released 4/23/2018
2004-2016 Econoline/F-Super Duty with Dana 70 or Dana 80 Trac-Loc® Limited-Slip Differential - Rear Axle Chatter On Turns

Released 4/23/2018
Various Vehicles - 4.6L/5.4L/6.8L 3 Valve - Engine Noise Upper End And/Or Rough Running - Camshaft Roller Follower Replacement - Built On Or Before 8-Jan-2016

Released 4/23/2018
REPLACEMENT TRANSMISSION FLUID FOR SERVICING TORQSHIFT TRANSMISSIONS

Released 4/23/2018
2003-2010 - Vehicles Equipped With 6.0L Or 4.5L Diesel Engines - Damage To The Injector Pressure Regulator (IPR) Screen

Released 4/23/2018
2005-2008 Remanufactured 5.4L 3v and 6.8L 3v - Ignition Coil Boots Included with Engine Packaging.

Released 4/23/2018
2003-2008 ELECTRONIC THROTTLE BODIES (ETB)EQUIPPED VEHICLES - HESITATION/LOSS OF RPM/DIFFICULTY STARTING/LOW IDLE RPM WITH OR WITHOUT MIL P0505 AND/OR P0506.

Released 11/28/2017
2000-2010 F-Super Duty/E-Series/Excursion - Diesel Remanufactured Component Identification

Released 2/17/2016
Vehicles with 6.0L Diesel - Crank/No Start Supplement - General Service Bulletin (GSB)

Released 1/27/2016
2004 And Newer Vehicles Equipped With Flex Fuel Capability - Flex Fuel General Service Bulletin (GSB)

Released 12/15/2015
Multiple Vehicles - Transmission Cooler Flush General Service Bulletin (GSB)

Released 12/9/2015
Multiple Vehicles - Tire Pressure Monitor System (TPMS) General Service Bulletin (GSB)

Released 12/8/2015
Multiple Vehicles - Engine Failure Analysis General Service Bulletin (GSB)

Released 12/7/2015
Multiple Vehicles - Spark Plug Thread Repair - 4.6L/5.4L/6.8L Modular 2v Engines - General Service Bulletin (GSB)

Released 8/20/2015
Multiple Vehicles - 4.6L 3v And 5.4L 3v Engines - 3v Cam Phaser Installation General Service Bulletin (GSB)

Released 11/25/2008
WATER LEAKS - ROOF OPENING PANEL DURING HIGH PRESSURE CAR WASH

Released 6/3/2008
RUST STAINS ON THE EDGES OF THE FRONT BUMPER CENTER VENT AND FOG LAMP OPENINGS

Released 5/23/2008
4X4 ONLY—BANGING/CLUNKING NOISE WHEN DRIVING—CONTACT WITH JOUNCE BUMPER—COLD TEMPERATURES

Released 3/1/2008
VIBRATION/HOP AT 40-48 MPH (68-77 KM/H)—(8.0 TSB 07-5-11 HZ)—TRAILER HITCH EQUIPPED VEHICLES ONLY

Released 11/30/2007
TAILGATE STRIKER—NOISE/RATTLE

Released 10/12/2007
5.4L GAS ENGINES—DTC P0171, P0172, P0174, P0175 WITH OR WITHOUT DRIVABILITY CONCERNS—CRUISE CONTROL SURGE

Released 6/25/2007
DRIVELINE NOISE UNDER LIGHT LOAD—40-50 MPH (64-80 KM/H)—6.0L REGULAR CAB 4X2 WITH 137 INCH WHEELBASE

Released 5/14/2007
STUCK OR JUMPING / BOUNCING / ERRATIC SPEEDOMETER AND/OR TACHOMETER

Released 5/4/2007
FRONT DOOR SIDE GLASS SCRATCHED DUE TO COLLECTION OF DIRT/DEBRIS IN WARPED OUTER WINDOW MOLDING

Released 2/13/2007
LEATHER-WRAPPED STEERING WHEEL—LEATHER COMING LOOSE

Released 9/23/2006
HESITATION, RUNS ROUGH, OR SURGE EITHER ON ACCELERATION OR DURING IDLE IN GEAR AND OCCURS RIGHT AFTER INITIAL COLD ENGINE START UP

Released 9/22/2006
6.0L—MIL ON WITH DTC P2138, P2139, AND P2140

Released 7/17/2006
ADDING ADDITIONAL BULBS TO TURN INDICATOR OR HAZARD FLASHER CIRCUITS—SERVICE TIPS

Released 5/26/2006
KING RANCH CREW CAB MODEL ONLY—WHITE CORROSION ON RUNNING BOARDS

Released 5/20/2006
PARKING AID SPEAKER INOPERATIVE—DTCS C1742 AND C1743

Released 5/15/2006
SLIDING POWER WINDOW (BACK GLASS) SERVICE PROCEDURE

Released 1/16/2006
CHROME TOW HOOKS RUSTING PREMATURELY VEHICLES BUILT PRIOR TO 7/17/2006

Released 12/10/2005
MIL ON AND DTCS P035X—5.4L OR 6.8L ENGINE

Released 11/25/2005
BUMPER COVER WAVY/WARPED

Released 11/16/2005
SAFETY BELT RETRACTION SPEED

Released 10/3/2005
SAFETY BELT WEB STOP BUTTON SERVICE

Released 9/14/2005
LACK OF A/C COOLING—CLIMATE CONTROL MODE SELECTION NOT WORKING

Released 7/13/2005
INSTRUMENT PANEL SCRATCH AND MAR—SERVICE TIP

Released 7/5/2005
LOW BATTERY VOLTAGE—SNOW PLOW EQUIPPED VEHICLES—6.0L DIESEL WITH SINGLE GENERATOR

Released 6/18/2005
MIL, DTCS P0172, P0175, P2106, HESITATION SURGE, HARSH DRIVE ENGAGEMENTS

Released 4/17/2005
VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY—CLIMATE CONTROL DEFAULTS TO DEFROST MODE

Released 4/14/2005
WRENCH LIGHT ON WITH BOTH DTC P2106 AND P2135—VEHICLES BUILT 11/29/2004 AND PRIOR

Released 3/9/2005
INTERIOR PLASTIC TRIM—PAINT-TO-MATCH AND REPAIR—INTERIOR SPRAY PAINT AND ADHESION PROMOTER USAGE INSTRUCTIONS

Released 2/1/2005
TEMPERATURE GAUGE READS HOT

Released 12/26/2004
WELD BONDING PROCEDURE

Released 9/23/2004
WATER LEAK—ROOF FLANGE AREA—WATER ACCUMULATION IN HEADLINER AND/OR LEAK AT THE CAB FLOOR PAN AREA

Released 6/9/2004
BODY—PAINT—IRON PARTICLE REMOVAL - INDUSTRIAL FALLOUT—ACID RAIN NEUTRALIZATION

Released 11/1/1996
LOCKS—INTRODUCTION OF NEW LOCK DESIGN—SERVICE TIP

Released 6/2/1991
PAINT—CODES—REVISED 1991 FLEET COLOR PAINT CODE NUMBERS

Released 4/27/2007
ABS LIGHT ON AND POSSIBLE DTCS C1175, C1236, P0500, P0503

Released 4/23/2006
DRIVE-AWAY SHUDDER OR VIBRATION

Released 2/16/2006
FRONT WHEEL BEARING NOISE—F-250/350 4X2 VEHICLES BUILT PRIOR TO 7/21/2006

Released 9/8/2009
COOLING SYSTEM DIAGNOSTICS - OIL IN ENGINE COOLANT - 6.0L

Released 4/14/2009
DIESEL COOLANT MAINTENANCE - SERVICE TIPS

Released 4/13/2009
COOLANT LOSS - 6.0L

Released 11/5/2008
6.0L DIESEL FUEL IN ENGINE COOLANT DIAGNOSTICS

Released 6/19/2008
LACK OF A/C COOLING DUE TO DESICCANT MATERIAL CLOGGING THE ORIFICE TUBE

Released 5/16/2008
COOLANT LOSS—6.0L

Released 11/13/2007
COOLING SYSTEM DIAGNOSTICS—OIL IN ENGINE COOLANT—6.0L

Released 5/18/2007
DIESEL ENGINE—OVERHEATING WITH A SNOW PLOW INSTALLED ON VEHICLES WITHOUT THE FACTORY INSTALLED SNOW PLOW PACKAGE

Released 2/2/2007
LACK OF COOLING FAN OPERATION—6.0L

Released 12/21/2006
MIL ON—DTC P1285 / P1299—5.4L 3V / 6.8L 3V—FALSE OVERHEAT

Released 12/21/2006
HEATER CORE LEAKAGE AND ELECTROLYSIS (INFORMATION ONLY)

Released 12/13/2005
FEAD BELT FRAYED/SHREDDED/BROKEN—6.0L DIESEL ENGINE—VEHICLES BUILT THROUGH 1/1/2005

Released 9/14/2005
LACK OF A/C COOLING—CLIMATE CONTROL MODE SELECTION NOT WORKING

Released 4/23/2018
2003-2008 ELECTRONIC THROTTLE BODIES (ETB)EQUIPPED VEHICLES - HESITATION/LOSS OF RPM/DIFFICULTY STARTING/LOW IDLE RPM WITH OR WITHOUT MIL P0505 AND/OR P0506.

Released 11/28/2017
2000-2010 F-Super Duty/E-Series/Excursion - Diesel Remanufactured Component Identification

Released 12/7/2015
Multiple Vehicles - Spark Plug Thread Repair - 4.6L/5.4L/6.8L Modular 2v Engines - General Service Bulletin (GSB)

Released 8/3/2011
Compliance Recall - Certain 2011 Model Year Ranger Vehicles Built with a Suspect Multifunction Switch and Certain Vehicles Serviced with a Suspect Multifunction Switch - Multifunction Switch Inspection and Replacement - Owner Letter

Released 7/7/2011
Compliance Recall - Certain 2011 Model Year Ranger Vehicles Built with a Suspect Multifunction Switch and Certain Vehicles Serviced with a Suspect Multifunction Switch - Multifunction Switch Inspection and Replacement - Dealer Bulletin

Released 7/7/2011
Compliance Recall - Certain 2011 Model Year Ranger Vehicles Built with a Suspect Multifunction Switch and Certain Vehicles Serviced with a Suspect Multifunction Switch - Multifunction Switch Inspection and Replacement - Technical Info

Released 7/7/2011
Compliance Recall - Certain 2011 Model Year Ranger Vehicles Built with a Suspect Multifunction Switch and Certain Vehicles Serviced with a Suspect Multifunction Switch - Multifunction Switch Inspection and Replacement - Additional Information - Background Summary

Released 4/3/2009
DIAGNOSTIC PROCEDURE FOR TRAILER TOW LIGHTS - SERVICE TIP

Released 8/21/2008
MIL ON—P0506 AND/OR P0505—HESITATION/LOSS OF RPM/DIFFICULTY STARTING/LOW IDLE RPM

Released 6/3/2008
RUST STAINS ON THE EDGES OF THE FRONT BUMPER CENTER VENT AND FOG LAMP OPENINGS

Released 2/27/2008
BATTERY SERVICE—OPERATION OF BATTERY EYE—CHARGING SERVICE TIPS

Released 5/14/2007
STUCK OR JUMPING / BOUNCING / ERRATIC SPEEDOMETER AND/OR TACHOMETER

Released 4/27/2007
ABS LIGHT ON AND POSSIBLE DTCS C1175, C1236, P0500, P0503

Released 12/19/2006
DTC P0340/P0344/P0345/P0349—4.6L 3V AND 5.4L 3V

Released 12/14/2006
NO CRANK / STARTER TERMINAL FATIGUE

Released 8/15/2006
KEYPAD DIAGNOSTICS—DEALER INSTALLED ACCESSORY

Released 7/21/2006
AUDIO / NAVIGATION SERVICE AND ORDERING PROCEDURES

Released 7/17/2006
ADDING ADDITIONAL BULBS TO TURN INDICATOR OR HAZARD FLASHER CIRCUITS—SERVICE TIPS

Released 1/6/2006
DIAGNOSTIC PROCEDURE FOR TRAILER TOW LIGHTS—SERVICE TIP

Released 12/13/2005
FEAD BELT FRAYED/SHREDDED/BROKEN—6.0L DIESEL ENGINE—VEHICLES BUILT THROUGH 1/1/2005

Released 12/11/2005
VARIOUS ELECTRICAL AND/OR DRIVEABILITY SYMPTOMS AND/OR DTCS—PDB MINI FUSE LOOSE—VEHICLES BUILT BEFORE 05/11/2005

Released 10/26/2005
CLUNK OR BUMP WHEN STARTING FROM A STOP

Released 8/18/2005
SERVICE KIT AVAILABLE FOR WIPER MOTOR WIRING

Released 7/18/2005
WIRING—SOLDERING AND CRIMPING REPAIRS— SOLDERING TIPS

Released 7/5/2005
LOW BATTERY VOLTAGE—SNOW PLOW EQUIPPED VEHICLES—6.0L DIESEL WITH SINGLE GENERATOR

Released 4/6/2005
FALSE PARKING AID WARNINGS

Released 1/20/2005
BROKEN OR CORRODED BOLT ON BATTERY TERMINAL

Released 9/23/2004
WATER LEAK—ROOF FLANGE AREA—WATER ACCUMULATION IN HEADLINER AND/OR LEAK AT THE CAB FLOOR PAN AREA

Released 6/9/2004
BODY—PAINT—IRON PARTICLE REMOVAL - INDUSTRIAL FALLOUT—ACID RAIN NEUTRALIZATION

Released 11/1/1996
LOCKS—INTRODUCTION OF NEW LOCK DESIGN—SERVICE TIP

Released 6/22/2010
6.8L - HESITATION/LOSS OF RPM/LOW IDLE RPM/DRIVEABILITY CONCERNS

Released 11/19/2009
6.0L DIESEL CALIBRATION UPDATE - VARIOUS ISSUES

Released 11/2/2009
6.0L DIESEL-DRIVEABILITY-NO START/HARD START/LONG CRANK/MISFIRE/RUNS ROUGH/LACK OF POWER/BUCK/JERK OR EXCESSIVE EXHAUST SMOKE DIAGNOSIS

Released 4/3/2009
6.0L DIESEL CALIBRATION UPDATE - VARIOUS ISSUES

Released 12/22/2008
6.0L - COKING DEPOSITS DIAGNOSTIC - EGR DTCS P0401, P0402, P0404, P1335

Released 8/28/2008
6.0L—HARD START / LONG CRANK / NO START—LOW INJECTOR CONTROL PRESSURE (ICP)

Released 8/21/2008
MIL ON—P0506 AND/OR P0505—HESITATION/LOSS OF RPM/DIFFICULTY STARTING/LOW IDLE RPM

Released 5/16/2008
COOLANT LOSS—6.0L

Released 11/13/2007
COOLING SYSTEM DIAGNOSTICS—OIL IN ENGINE COOLANT—6.0L

Released 10/12/2007
5.4L GAS ENGINES—DTC P0171, P0172, P0174, P0175 WITH OR WITHOUT DRIVABILITY CONCERNS—CRUISE CONTROL SURGE

Released 10/12/2007
6.0L—MIL ON—P0401, P0402, P0404, P1335—LACK OF POWER OR SURGE

Released 7/6/2007
ERRATIC SHIFTS—SPEEDS ABOVE 50 MPH (80 TSB 07-14-8 KM/H) AND/OR ENGAGEMENT SHUDDER

Released 1/22/2007
6.0L—REDUCED ENGINE PERFORMANCE—HIGH ALTITUD

Released 12/22/2006
WATER-IN-FUEL (WIF) LAMP ON / FLICKERING

Released 9/23/2006
HESITATION, RUNS ROUGH, OR SURGE EITHER ON ACCELERATION OR DURING IDLE IN GEAR AND OCCURS RIGHT AFTER INITIAL COLD ENGINE START UP

Released 9/22/2006
6.0L—MIL ON WITH DTC P2138, P2139, AND P2140

Released 8/4/2006
5.4L 3V MALFUNCTION INDICATOR LAMP ON WITH P0455—LOW SPEED ENGINE SURGE—CALIBRATION UPDATE

Released 12/19/2005
TURBO-INDUCED EXHAUST MOAN/DRONE AT 1500-2000 RPM—6.0L BUILT AFTER 9/29/2003

Released 12/10/2005
MIL ON AND DTCS P035X—5.4L OR 6.8L ENGINE

Released 9/21/2005
WHINE/WHISTLE NOISE—6.0L

Released 4/14/2005
WRENCH LIGHT ON WITH BOTH DTC P2106 AND P2135—VEHICLES BUILT 11/29/2004 AND PRIOR

Released 4/11/2005
VARIOUS DRIVEABILITY SYMPTOMS—CALIBRATION UPDATE RELEASE—6.0L DIESEL ENGINE

Released 10/20/2004
TORQSHIFT TRANSMISSION AND PTO OPERATION— PTO LINE PRESSURE INSUFFICIENT—POSSIBLE TRANSMISSION DAMAGE

Released 2/23/2008
COLD START DRIVEABILITY—WHITE SMOKE, LACKS POWER, EXHAUST ODOR, SURGES, RUNS ROUGH, OR NO START—6.0L

Released 5/24/2007
5.4L AND 6.8L ENGINES—EXHAUST SYSTEM SNAP/POP/TICK/PING NOISE—VEHICLES BUILT ON OR BEFORE 9/8/2006

Released 12/19/2005
TURBO-INDUCED EXHAUST MOAN/DRONE AT 1500-2000 RPM—6.0L BUILT AFTER 9/29/2003

Released 9/13/2005
DIESEL EXHAUST SMELL IN CAB—6.0L ENGINE

Released 7/9/2012
DTCS P0505, P0506 AND/OR ENGINE IDLE RPM FLUCTUATION - HARD START

Released 2/22/2012
SLOW FUEL FILL - 5.4L, 6.2L AND 6.8L ENGINES

Released 4/1/2011
SLOW FUEL FILL - 5.4, 6.2 AND 6.8 ENGINES

Released 6/11/2010
6.0L - RUNS ROUGH, LACKS POWER, HARD START, NO START

Released 10/5/2009
SLOW FUEL FILL - 5.4 AND 6.8 ENGINES

Released 8/5/2009
6.0L TURBOCHARGER CARBON DEPOSIT DIAGNOSTICS AND SERVICE TIPS

Released 4/21/2009
SLOW FUEL FILL - 5.4 AND 6.8 ENGINES

Released 12/12/2008
6.0L DIESEL - DRIVEABILITY - NO START, HARD START, RUNS ROUGH - FUEL INJECTION CONTROL MODULE DIAGNOSIS

Released 11/5/2008
6.0L DIESEL FUEL IN ENGINE COOLANT DIAGNOSTICS

Released 9/12/2008
6.0L ENGINE—MISFIRE, LACK OF POWER, BUCK / TSB 08-20-1 JERK, EXCESSIVE SMOKE, CRANK / NO START— DIAGNOSTICS FOR FUEL SYSTEM—SERVICE TIPS

Released 8/28/2008
6.0L—HARD START / LONG CRANK / NO START—LOW INJECTOR CONTROL PRESSURE (ICP)

Released 8/4/2008
6.0L TURBOCHARGER CARBON DEPOSIT DIAGNOSTICS AND SERVICE TIPS

Released 4/1/2008
SPARK PLUG REMOVAL INSTRUCTIONS—4.6L 3V/5.4L 3V/6.8L 3V

Released 3/7/2008
6.0L—OIL SEEP OR BOOST PRESSURE LEAK AT HOT SIDE CHARGE AIR COOLER DUCT

Released 2/23/2008
COLD START DRIVEABILITY—WHITE SMOKE, LACKS POWER, EXHAUST ODOR, SURGES, RUNS ROUGH, OR NO START—6.0L

Released 2/15/2008
SLOW FUEL FILL—MIL ON WITH DTC P0191

Released 1/18/2008
6.0L—COKING DEPOSIT DIAGNOSTICS—SERVICE TIP

Released 11/21/2007
WATER IN THE FUEL TANK BEHIND REAR AXLE— 6.4L, 6.0L, AND 7.3L DIESEL ENGINE

Released 3/16/2007
6.0L DIESEL ENGINE—BUCK/JERK WHEN PULLING LARGE/HEAVY GOOSE NECK TRAILERS

Released 12/22/2006
WATER-IN-FUEL (WIF) LAMP ON / FLICKERING

Released 11/13/2006
6.0L—MIL ON WITH DTC P0460

Released 9/23/2006
HESITATION, RUNS ROUGH, OR SURGE EITHER ON ACCELERATION OR DURING IDLE IN GEAR AND OCCURS RIGHT AFTER INITIAL COLD ENGINE START UP

Released 12/19/2005
TURBO-INDUCED EXHAUST MOAN/DRONE AT 1500-2000 RPM—6.0L BUILT AFTER 9/29/2003

Released 12/19/2005
LONG CRANK OR RUNS ROUGH AT FACTORY DELIVERY OR AFTER HIGH PRESSURE OIL SYSTEM REPAIR—6.0L

Released 9/21/2005
WHINE/WHISTLE NOISE—6.0L

Released 8/22/2005
WDS COP KIT DIAGNOSTIC TIPS—COIL ON PLUG (COP) IGNITION SYSTEMS—ENGINE MISFIRE OR ROUGH RUNNING

Released 4/17/2005
VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY—CLIMATE CONTROL DEFAULTS TO DEFROST MODE

Released 3/22/2005
LOW POWER—COLD SIDE CHARGE AIR COOLER CAC) DISCONNECTED—OIL LEAK AT CAC CONNECTIONS—6.0L ENGINE—VEHICLES BUILT 4/1/2004 THROUGH 2/20/2005

Released 2/2/2007
LACK OF COOLING FAN OPERATION—6.0L

Released 12/22/2006
HEATER CORE LEAKS—6.0L ENGINE

Released 12/21/2006
HEATER CORE LEAKAGE AND ELECTROLYSIS (INFORMATION ONLY)

Released 9/4/2006
A/C COMPRESSOR NOT OPERATIONAL / LOW FREON—SHAFT SEAL LEAKS

Released 9/14/2005
LACK OF A/C COOLING—CLIMATE CONTROL MODE SELECTION NOT WORKING

Released 2/1/2005
TEMPERATURE GAUGE READS HOT

Released 12/11/2018
Various Vehicles - 4.6L/5.4L/6.8L 3 Valve - Engine Noise Upper End And/Or Rough Running - Camshaft Roller Follower Replacement - Built On Or Before 8-Jan-2016

Released 12/11/2018
Multiple Vehicle Lines - Revised Engine Oil Leak Diagnostic Procedure Using New White Fluorescent Dye

Released 6/7/2018
Various Vehicles - Engine Failure Analysis General Service Bulletin (GSB)

Released 5/22/2018
2000-2010 F-Super Duty/E-Series/Excursion - Diesel Remanufactured Component Identification

Released 4/23/2018
2001-2015 - Vehicles With Modular 4.6L, 5.4L Or 6.8L Engines - Determining Root Cause Of Engine Damage Due To Oil Pressure Loss.

Released 4/23/2018
2003-2014 Multiple Vehicles with a Torqshift Transmission Intermittent Clunk When Shifting Between Reverse and Park and/or During 2-3 Shift

Released 4/23/2018
1999-2011 F-SUPER DUTY EQUIPPED WITH ESOF 4X4 WITH DTC P1865 AND/OR P1867

Released 4/23/2018
2004-2016 Econoline/F-Super Duty with Dana 70 or Dana 80 Trac-Loc® Limited-Slip Differential - Rear Axle Chatter On Turns

Released 4/23/2018
Various Vehicles - 4.6L/5.4L/6.8L 3 Valve - Engine Noise Upper End And/Or Rough Running - Camshaft Roller Follower Replacement - Built On Or Before 8-Jan-2016

Released 4/23/2018
REPLACEMENT TRANSMISSION FLUID FOR SERVICING TORQSHIFT TRANSMISSIONS

Released 4/23/2018
2003-2010 - Vehicles Equipped With 6.0L Or 4.5L Diesel Engines - Damage To The Injector Pressure Regulator (IPR) Screen

Released 11/28/2017
2000-2010 F-Super Duty/E-Series/Excursion - Diesel Remanufactured Component Identification

Released 2/17/2016
Vehicles with 6.0L Diesel - Crank/No Start Supplement - General Service Bulletin (GSB)

Released 12/15/2015
Multiple Vehicles - Transmission Cooler Flush General Service Bulletin (GSB)

Released 12/8/2015
Multiple Vehicles - Engine Failure Analysis General Service Bulletin (GSB)

Released 12/7/2015
Multiple Vehicles - Spark Plug Thread Repair - 4.6L/5.4L/6.8L Modular 2v Engines - General Service Bulletin (GSB)

Released 8/20/2015
Multiple Vehicles - 4.6L 3v And 5.4L 3v Engines - 3v Cam Phaser Installation General Service Bulletin (GSB)

Released 5/29/2014
5.4L 3V – Intermittent Rattle Noise While Driving / Rough Idle When Engine Is At Operating Temperature

Released 7/20/2012
5.4L INTERMITTENT RATTLE NOISE / ROUGH IDLE WHEN ENGINE IS AT OPERATING TEMPERATURE

Released 12/16/2009
6.0L DIESEL FUEL IN ENGINE COOLANT DIAGNOSTICS - BUILT ON OR BEFORE 9/30/2008

Released 10/22/2009
4.5L, 6.0L AND 6.4L DIESEL HEAD GASKET CLEANING AND CYLINDER HEAD INSPECTION PROCEDURES

Released 6/17/2009
4.5L, 6.0L AND 6.4L DIESEL HEAD GASKET CLEANING AND CYLINDER HEAD INSPECTION PROCEDURES

Released 12/9/2008
5.4L 3V WITH P030X AND/OR P0316 ACCOMPANIED BY SPARK KNOCK

Released 11/5/2008
6.0L DIESEL FUEL IN ENGINE COOLANT DIAGNOSTICS

Released 9/12/2008
6.0L ENGINE—MISFIRE, LACK OF POWER, BUCK / TSB 08-20-1 JERK, EXCESSIVE SMOKE, CRANK / NO START— DIAGNOSTICS FOR FUEL SYSTEM—SERVICE TIPS

Released 8/28/2008
6.0L—HARD START / LONG CRANK / NO START—LOW INJECTOR CONTROL PRESSURE (ICP)

Released 8/21/2008
MIL ON—P0506 AND/OR P0505—HESITATION/LOSS OF RPM/DIFFICULTY STARTING/LOW IDLE RPM

Released 5/16/2008
COOLANT LOSS—6.0L

Released 3/7/2008
6.0L—OIL SEEP OR BOOST PRESSURE LEAK AT HOT SIDE CHARGE AIR COOLER DUCT

Released 3/1/2008
VIBRATION/HOP AT 40-48 MPH (68-77 KM/H)—(8.0 TSB 07-5-11 HZ)—TRAILER HITCH EQUIPPED VEHICLES ONLY

Released 1/18/2008
6.0L—COKING DEPOSIT DIAGNOSTICS—SERVICE TIP

Released 11/21/2007
WATER IN THE FUEL TANK BEHIND REAR AXLE— 6.4L, 6.0L, AND 7.3L DIESEL ENGINE

Released 11/13/2007
COOLING SYSTEM DIAGNOSTICS—OIL IN ENGINE COOLANT—6.0L

Released 10/12/2007
5.4L GAS ENGINES—DTC P0171, P0172, P0174, P0175 WITH OR WITHOUT DRIVABILITY CONCERNS—CRUISE CONTROL SURGE

Released 7/6/2007
ERRATIC SHIFTS—SPEEDS ABOVE 50 MPH (80 TSB 07-14-8 KM/H) AND/OR ENGAGEMENT SHUDDER

Released 6/25/2007
DRIVELINE NOISE UNDER LIGHT LOAD—40-50 MPH (64-80 KM/H)—6.0L REGULAR CAB 4X2 WITH 137 INCH WHEELBASE

Released 5/24/2007
5.4L AND 6.8L ENGINES—EXHAUST SYSTEM SNAP/POP/TICK/PING NOISE—VEHICLES BUILT ON OR BEFORE 9/8/2006

Released 5/18/2007
DIESEL ENGINE—OVERHEATING WITH A SNOW PLOW INSTALLED ON VEHICLES WITHOUT THE FACTORY INSTALLED SNOW PLOW PACKAGE

Released 5/4/2007
6.0L—SERVICE REMANUFACTURED ENGINE, CYLINDER BLOCK, AND CYLINDER HEAD IDENTIFICATION

Released 3/16/2007
6.0L DIESEL ENGINE—BUCK/JERK WHEN PULLING LARGE/HEAVY GOOSE NECK TRAILERS

Released 1/22/2007
6.0L—REDUCED ENGINE PERFORMANCE—HIGH ALTITUD

Released 1/9/2007
MERCONâ ATF REPLACED BY MERCON (R) V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS

Released 12/22/2006
HEATER CORE LEAKS—6.0L ENGINE

Released 12/22/2006
WATER-IN-FUEL (WIF) LAMP ON / FLICKERING

Released 12/21/2006
MIL ON—DTC P1285 / P1299—5.4L 3V / 6.8L 3V—FALSE OVERHEAT

Released 12/19/2006
DTC P0340/P0344/P0345/P0349—4.6L 3V AND 5.4L 3V

Released 12/18/2006
IDENTIFYING THE CORRECT REPLACEMENT HEAD GASKET FOR CERTAIN REMANUFACTURED ENGINES—SERVICE TIP

Released 11/13/2006
6.0L—MIL ON WITH DTC P0460

Released 10/21/2006
6.0L—REVISED CYLINDER HEAD FLATNESS CHECK PROCEDURE AND SPECIFICATION

Released 9/23/2006
HESITATION, RUNS ROUGH, OR SURGE EITHER ON ACCELERATION OR DURING IDLE IN GEAR AND OCCURS RIGHT AFTER INITIAL COLD ENGINE START UP

Released 8/19/2006
TICKING AND / OR KNOCKING NOISE / STARTUP RATTLE FROM ENGINE—4.6L / 5.4L 3V

Released 8/4/2006
5.4L 3V MALFUNCTION INDICATOR LAMP ON WITH P0455—LOW SPEED ENGINE SURGE—CALIBRATION UPDATE

Released 6/22/2006
BUCK/JERK STEADY THROTTLE OR SLIGHT TIP IN—6.0L—BUILT ON OR BEFORE 3/15/2006

Released 4/23/2006
DRIVE-AWAY SHUDDER OR VIBRATION

Released 4/2/2006
EXHAUST SMOKE AND/OR SMELL, HARSH TRANSMISSION SHIFTS—6.0L

Released 2/16/2006
FRONT WHEEL BEARING NOISE—F-250/350 4X2 VEHICLES BUILT PRIOR TO 7/21/2006

Released 1/26/2006
MERCON ATF IS BEING REPLACED BY MERCON V AS A SERVICE FLUID FOR SOME MANUAL TRANSMISSIONS

Released 12/19/2005
LONG CRANK OR RUNS ROUGH AT FACTORY DELIVERY OR AFTER HIGH PRESSURE OIL SYSTEM REPAIR—6.0L

Released 12/13/2005
FEAD BELT FRAYED/SHREDDED/BROKEN—6.0L DIESEL ENGINE—VEHICLES BUILT THROUGH 1/1/2005

Released 12/11/2005
VARIOUS ELECTRICAL AND/OR DRIVEABILITY SYMPTOMS AND/OR DTCS—PDB MINI FUSE LOOSE—VEHICLES BUILT BEFORE 05/11/2005

Released 12/10/2005
MIL ON AND DTCS P035X—5.4L OR 6.8L ENGINE

Released 12/6/2005
STEERING GEAR NOISE—6.0L DIESEL ENGINE—VEHICLES BUILT BEFORE 11/24/2004

Released 10/26/2005
CLUNK OR BUMP WHEN STARTING FROM A STOP

Released 9/21/2005
WHINE/WHISTLE NOISE—6.0L

Released 9/13/2005
DIESEL EXHAUST SMELL IN CAB—6.0L ENGINE

Released 8/22/2005
WDS COP KIT DIAGNOSTIC TIPS—COIL ON PLUG (COP) IGNITION SYSTEMS—ENGINE MISFIRE OR ROUGH RUNNING

Released 6/18/2005
MIL, DTCS P0172, P0175, P2106, HESITATION SURGE, HARSH DRIVE ENGAGEMENTS

Released 6/16/2005
MISFIRE, LACK OF POWER, SMOKE, SLOW CRANK IN COLD WEATHER ON INITIAL START UP—6.0L ENGINE

Released 6/3/2005
4X4 TRANSFER CASE JUMP OUT OF 4H OR 4L— MANUAL SHIFT TRANSFER CASE

Released 4/17/2005
VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY—CLIMATE CONTROL DEFAULTS TO DEFROST MODE

Released 4/12/2005
REAR AXLE LEAK—DANA S-110 REAR AXLE

Released 4/11/2005
VARIOUS DRIVEABILITY SYMPTOMS—CALIBRATION UPDATE RELEASE—6.0L DIESEL ENGINE

Released 3/22/2005
LOW POWER—COLD SIDE CHARGE AIR COOLER CAC) DISCONNECTED—OIL LEAK AT CAC CONNECTIONS—6.0L ENGINE—VEHICLES BUILT 4/1/2004 THROUGH 2/20/2005

Released 3/20/2005
OIL PAN CORROSION—7.3L OR 6.0L

Released 2/18/2005
DTC P2106, HARSH DRIVE ENGAGEMENTS TRANSMISSION SHUDDER—5.4L 3V ENGINE

Released 1/12/2005
ENGINE QUITS UPON DRIVE OR REVERSE ENGAGEMENT, OR WHEN COMING TO A STOP— TORQSHIFT TRANSMISSION

Released 10/20/2004
TORQSHIFT TRANSMISSION AND PTO OPERATION— PTO LINE PRESSURE INSUFFICIENT—POSSIBLE TRANSMISSION DAMAGE

Released 6/4/1991
TRANSMISSION—AUTOMATIC—ELECTRONIC TRANSMISSION DIAGNOSTIC AND REPAIR CHART

Released 7/7/2011
Compliance Recall - Certain 2011 Model Year Ranger Vehicles Built with a Suspect Multifunction Switch and Certain Vehicles Serviced with a Suspect Multifunction Switch - Multifunction Switch Inspection and Replacement - Technical Info

Released 7/7/2011
Compliance Recall - Certain 2011 Model Year Ranger Vehicles Built with a Suspect Multifunction Switch and Certain Vehicles Serviced with a Suspect Multifunction Switch - Multifunction Switch Inspection and Replacement - Additional Information - Background Summary

Released 4/20/2011
4X4 ONLY - BANGING/CLUNKING NOISE WHEN DRIVING - CONTACT WITH JOUNCE BUMPER - COLD TEMPERATURES

Released 1/15/2010
4X4 ONLY - BANGING/CLUNKING NOISE WHEN DRIVING - CONTACT WITH JOUNCE BUMPER - COLD TEMPERATURES

Released 11/17/2008
VIBRATION DIAGNOSTICS - STEERING WHEEL NIBBLE - TIRE WHEEL RUNOUT AND BALANCE

Released 5/23/2008
4X4 ONLY—BANGING/CLUNKING NOISE WHEN DRIVING—CONTACT WITH JOUNCE BUMPER—COLD TEMPERATURES

Released 6/25/2007
DRIVELINE NOISE UNDER LIGHT LOAD—40-50 MPH (64-80 KM/H)—6.0L REGULAR CAB 4X2 WITH 137 INCH WHEELBASE

Released 5/23/2007
BRAKE PEDAL KICKBACK OR GRABBING

Released 5/10/2007
STEERING WHEEL OSCILLATION

Released 3/26/2007
REAR OF VEHICLE IS TOO HIGH/LOW—5TH WHEEL TSB 07-7-2 AND GOOSE NECK APPLICATIONS—4X4 VEHICLES ONLY

Released 2/14/2007
VIBRATION DIAGNOSIS—TIRE/WHEEL RUNOUT

Released 2/13/2007
LEATHER-WRAPPED STEERING WHEEL—LEATHER COMING LOOSE

Released 1/9/2007
MERCONâ ATF REPLACED BY MERCON (R) V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS

Released 11/22/2006
POWER STEERING FLUID LEAK AT JUMPER LINE TO HYDROBOOST CONNECTION—VEHICLES BUILT BEFORE 5/25/2006

Released 2/16/2006
FRONT WHEEL BEARING NOISE—F-250/350 4X2 VEHICLES BUILT PRIOR TO 7/21/2006

Released 12/6/2005
STEERING GEAR NOISE—6.0L DIESEL ENGINE—VEHICLES BUILT BEFORE 11/24/2004

Released 6/23/2004
VEHICLE LEAN/SAG WHEN OBSERVED FROM REAR OF VEHICLE

Released 11/1/1996
LOCKS—INTRODUCTION OF NEW LOCK DESIGN—SERVICE TIP

Released 8/22/2005
WDS COP KIT DIAGNOSTIC TIPS—COIL ON PLUG (COP) IGNITION SYSTEMS—ENGINE MISFIRE OR ROUGH RUNNING

Released 7/18/2005
WIRING—SOLDERING AND CRIMPING REPAIRS— SOLDERING TIPS

Released 3/9/2005
INTERIOR PLASTIC TRIM—PAINT-TO-MATCH AND REPAIR—INTERIOR SPRAY PAINT AND ADHESION PROMOTER USAGE INSTRUCTIONS