Get Free 2005 FORD F150 V8, 5.4L; SOHC TSBs

Released 4/23/2018
2001-2015 - Vehicles With Modular 4.6L, 5.4L Or 6.8L Engines - Determining Root Cause Of Engine Damage Due To Oil Pressure Loss.

Released 4/23/2018
Various Vehicles - 4.6L/5.4L/6.8L 3 Valve - Engine Noise Upper End And/Or Rough Running - Camshaft Roller Follower Replacement - Built On Or Before 8-Jan-2016

Released 4/23/2018
VISIBLE GREASE PURGE -FRONT HUB AND BEARING ASSEMBLY

Released 4/23/2018
2005-2008 F-150/2006-2008 MARK LT - ERRATIC FUEL GAUGE OPERATION MIL WITH DTCS P0460/P0463 OR INSTRUMENT CLUSTER MODULE DTC B1201 - BUILT BEFORE 12/3/2007

Released 4/23/2018
2005-2008 Remanufactured 5.4L 3v and 6.8L 3v - Ignition Coil Boots Included with Engine Packaging.

Released 4/23/2018
2003-2008 ELECTRONIC THROTTLE BODIES (ETB)EQUIPPED VEHICLES - HESITATION/LOSS OF RPM/DIFFICULTY STARTING/LOW IDLE RPM WITH OR WITHOUT MIL P0505 AND/OR P0506.

Released 10/19/2017
Remanufactured Powertrain Core Returns

Released 8/22/2017
2000 And Newer Ford, Lincoln And Mercury Vehicles - Aluminum Panel Corrosion

Released 8/15/2016
2004-2014 F-150 and 2006-2008 Mark LT - 4WD - Noisy Or Engaged Front Hubs In 2WD Mode - Integrated Wheel End (IWE) Vacuum Hose Repair Kit

Released 1/27/2016
2004 And Newer Vehicles Equipped With Flex Fuel Capability - Flex Fuel General Service Bulletin (GSB)

Released 12/15/2015
Multiple Vehicles - Transmission Cooler Flush General Service Bulletin (GSB)

Released 12/9/2015
Multiple Vehicles - Tire Pressure Monitor System (TPMS) General Service Bulletin (GSB)

Released 12/8/2015
Multiple Vehicles - Engine Failure Analysis General Service Bulletin (GSB)

Released 12/7/2015
Multiple Vehicles - Spark Plug Thread Repair - 4.6L/5.4L/6.8L Modular 2v Engines - General Service Bulletin (GSB)

Released 8/20/2015
Multiple Vehicles - 4.6L 3v And 5.4L 3v Engines - 3v Cam Phaser Installation General Service Bulletin (GSB)

Released 12/5/2008
DRIVERS SIDE COWL PANEL POPPED-UP

Released 11/25/2008
WATER LEAKS - ROOF OPENING PANEL DURING HIGH PRESSURE CAR WASH

Released 6/3/2008
RUST STAINS ON THE EDGES OF THE FRONT BUMPER CENTER VENT AND FOG LAMP OPENINGS

Released 1/7/2008
WATER LEAK—ROOF OPENING PANEL DURING HIGH PRESSURE CAR WASH

Released 12/10/2007
FRAME REPLACEMENT MATRIX—SERVICE TIP

Released 11/30/2007
TAILGATE STRIKER—NOISE/RATTLE

Released 11/21/2007
DRIVERS SIDE COWL PANEL POPPED-UP—BUILT BEFORE 11/12/2007

Released 10/26/2007
PAINT—INSTRUMENT PANEL—SCRATCH/MAR REPAIR TIPS

Released 7/30/2007
WRENCH LAMP ON—DTC P0731—4.2L AND 4R75E ONLY

Released 6/6/2007
RCM FAULT REPORTING USING DTCS AND BIT-MAPPED PARAMETER IDENTIFIERS (PIDS)— SERVICE TIPS

Released 6/5/2007
POWER SLIDING REAR WINDOW MOTOR REPLACEMENT

Released 5/9/2007
VIBRATION FROM THE DRIVELINE AT HIGHWAY SPEEDS

Released 5/9/2007
STEERING WHEEL VIBRATION AT 50 MPH (80 KM/H) OR HIGHER—STEERING WHEEL NIBBLE AT 65 MPH (105 KM/H) OR HIGHER

Released 3/7/2007
SPARK KNOCK UNDER LIGHT LOAD AND ACCELERATION—3.8L, 3.9L, AND 4.2L—SPLIT PORT INTAKE MANIFOLD RUNNER CONTROL (IMRC)

Released 2/13/2007
LEATHER-WRAPPED STEERING WHEEL—LEATHER COMING LOOSE

Released 1/17/2007
POWER WINDOW SLOW UPWARD TRAVEL

Released 12/25/2006
ALUMINUM BODY PANELS—CORROSION—SERVICE TIP

Released 12/19/2006
RATTLE FROM TIP OUT ASHTRAY—VEHICLES BUILT PRIOR TO 1/1/2006

Released 12/16/2006
STUMBLE ON HEAVY DECELERATION AND/OR TIP-OUT IN MANUAL 2—5.4L 3V WITH 4R75E

Released 6/23/2006
NOISE FROM BACK GLASS—POWER SLIDING REAR WINDOW ONLY

Released 5/20/2006
PARKING AID SPEAKER INOPERATIVE—DTCS C1742 AND C1743

Released 5/2/2006
POWER FOLDING MIRROR OPERATION

Released 11/16/2005
SAFETY BELT RETRACTION SPEED

Released 11/3/2005
MIL AND/OR DTCS P0172, P0175, P0171, P0174—THROTTLE PEDAL RESPONSE/TIP IN HESITATION THROTTLE PEDAL RESPONSE/TIP IN HESITATION

Released 10/3/2005
SAFETY BELT WEB STOP BUTTON SERVICE

Released 9/11/2005
REMOVAL AND INSTALLATION OF REAR BOLT-IN GLASS—SERVICE TIP

Released 5/3/2005
ROOF DITCH MOLDING LOOSE—VEHICLES BUILT 1/3/2005 THROUGH 1/4/2005

Released 4/14/2005
WRENCH LIGHT ON WITH BOTH DTC P2106 AND P2135—VEHICLES BUILT 11/29/2004 AND PRIOR

Released 3/9/2005
INTERIOR PLASTIC TRIM—PAINT-TO-MATCH AND REPAIR—INTERIOR SPRAY PAINT AND ADHESION PROMOTER USAGE INSTRUCTIONS

Released 2/14/2005
HEADLINER BUFFETING/RATTLE NOISE—VEHICLES EQUIPPED WITH ROOF-OPENING PANEL AND BUILT PRIOR TO 6/1/2005

Released 1/19/2005
MIL ON—VARIOUS DRIVEABILITY CONDITIONS—5.4L 3-VALVE ENGINE—VEHICLES BUILT BEFORE 4/20/2005

Released 12/26/2004
FRONT DOOR TRIM APPLIQUE REMOVAL

Released 12/26/2004
BODY REPAIR PROCEDURE USING MIG WELDING FOR WELD BONDING

Released 12/26/2004
WELD BONDING PROCEDURE

Released 12/24/2004
CAMSHAFT AND LASH ADJUSTER DESIGN CHANGE—5.4L 3V ENGINE

Released 10/23/2004
AUDIBLE DRIVELINE MOAN ABOVE 45 MPH (72 KM/H) DURING ACCELERATION OR COASTING— VEHICLES BUILT 8/20/2004 TO 10/4/2004

Released 6/9/2004
BODY—PAINT—IRON PARTICLE REMOVAL - INDUSTRIAL FALLOUT—ACID RAIN NEUTRALIZATION

Released 5/24/2004
REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR—TERMINAL TAB REPAIR

Released 11/1/1996
LOCKS—INTRODUCTION OF NEW LOCK DESIGN—SERVICE TIP

Released 12/4/1994
PAINT—PRIMED SHEET METAL—PREP PROCEDURE AND MSDS INFORMATION

Released 6/2/1991
PAINT—CODES—REVISED 1991 FLEET COLOR PAINT CODE NUMBERS

Released 12/25/2004
MAGNESIUM ALLOY RADIATOR CORE SUPPORT- UNIQUE HANDLING AND REPAIR PROCEDURES SERVICE TIPS

Released 4/23/2018
2005-2008 F-150/2006-2008 MARK LT - ERRATIC FUEL GAUGE OPERATION MIL WITH DTCS P0460/P0463 OR INSTRUMENT CLUSTER MODULE DTC B1201 - BUILT BEFORE 12/3/2007

Released 4/23/2018
2005-2008 Remanufactured 5.4L 3v and 6.8L 3v - Ignition Coil Boots Included with Engine Packaging.

Released 4/23/2018
2003-2008 ELECTRONIC THROTTLE BODIES (ETB)EQUIPPED VEHICLES - HESITATION/LOSS OF RPM/DIFFICULTY STARTING/LOW IDLE RPM WITH OR WITHOUT MIL P0505 AND/OR P0506.

Released 12/7/2015
Multiple Vehicles - Spark Plug Thread Repair - 4.6L/5.4L/6.8L Modular 2v Engines - General Service Bulletin (GSB)

Released 3/7/2011
Safety Recall - Certain 2004 through 2006 Model Year F-150 Built at Norfolk, Kansas City, and Dearborn Assembly Plants and 2006 Model Year Mark LT Vehicles Built at Dearborn Assembly Plant - Clockspring to Driver Side Frontal Air Bag Wire Harness Replacement - Owner Letter

Released 2/22/2011
Safety Recall - Certain 2005 through 2006 Model Year F-150 Vehicles Built at Norfolk Assembly Plant - Clockspring to Driver Side Frontal Air Bag Wire Harness Replacement - Technical Info

Released 2/22/2011
Safety Recall - Certain 2005 through 2006 Model Year F-150 Vehicles Built at Norfolk Assembly Plant - Clockspring to Driver Side Frontal Air Bag Wire Harness Replacement - Dealer Bulletin

Released 2/22/2011
Safety Recall - Certain 2005 through 2006 Model Year F-150 Vehicles Built at Norfolk Assembly Plant - Clockspring to Driver Side Frontal Air Bag Wire Harness Replacement - Additional Information - Background Summary

Released 2/22/2011
Safety Recall - Certain 2005 through 2006 Model Year F-150 Vehicles Built at Norfolk Assembly Plant - Clockspring to Driver Side Frontal Air Bag Wire Harness Replacement - Additional Information - Recall Reimbursement

Released 8/21/2008
MIL ON—P0506 AND/OR P0505—HESITATION/LOSS OF RPM/DIFFICULTY STARTING/LOW IDLE RPM

Released 6/3/2008
RUST STAINS ON THE EDGES OF THE FRONT BUMPER CENTER VENT AND FOG LAMP OPENINGS

Released 2/27/2008
BATTERY SERVICE—OPERATION OF BATTERY EYE—CHARGING SERVICE TIPS

Released 12/25/2006
ALUMINUM BODY PANELS—CORROSION—SERVICE TIP

Released 12/19/2006
SHUDDER/VIBRATION ON MODERATE TO HARD ACCELERATION

Released 12/19/2006
DTC P0340/P0344/P0345/P0349—4.6L 3V AND 5.4L 3V

Released 12/14/2006
NO CRANK / STARTER TERMINAL FATIGUE

Released 12/8/2006
INTERMITTENT IWE NOISE, 4WDH LIGHT AND/OR 4X4 SYSTEM INOPERATIVE, DTCS—C1979 AND C1980

Released 8/17/2006
SERVICE WIRING HARNESS REPLACEMENT GUIDELINES—SERVICE TIPS

Released 8/15/2006
KEYPAD DIAGNOSTICS—DEALER INSTALLED ACCESSORY

Released 7/21/2006
AUDIO / NAVIGATION SERVICE AND ORDERING PROCEDURES

Released 1/7/2006
NEUTRAL TOW CAPABILITY—SERVICE KIT REQUIREMENTS

Released 12/10/2005
INTERMITTENT CD PLAYER CONCERNS—AUDIO UNIT PROGRAMMABLE MODULE INSTALLATION (PMI) REQUIREMENTS

Released 7/18/2005
WIRING—SOLDERING AND CRIMPING REPAIRS— SOLDERING TIPS

Released 5/5/2005
KEYLESS ENTRY KEYPAD INOPERATIVE

Released 4/6/2005
FALSE PARKING AID WARNINGS

Released 12/26/2004
BODY REPAIR PROCEDURE USING MIG WELDING FOR WELD BONDING

Released 6/9/2004
BODY—PAINT—IRON PARTICLE REMOVAL - INDUSTRIAL FALLOUT—ACID RAIN NEUTRALIZATION

Released 5/24/2004
REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR—TERMINAL TAB REPAIR

Released 11/1/1996
LOCKS—INTRODUCTION OF NEW LOCK DESIGN—SERVICE TIP

Released 8/21/2008
MIL ON—P0506 AND/OR P0505—HESITATION/LOSS OF RPM/DIFFICULTY STARTING/LOW IDLE RPM

Released 7/30/2007
WRENCH LAMP ON—DTC P0731—4.2L AND 4R75E ONLY

Released 6/6/2007
RCM FAULT REPORTING USING DTCS AND BIT-MAPPED PARAMETER IDENTIFIERS (PIDS)— SERVICE TIPS

Released 11/3/2005
MIL AND/OR DTCS P0172, P0175, P0171, P0174—THROTTLE PEDAL RESPONSE/TIP IN HESITATION THROTTLE PEDAL RESPONSE/TIP IN HESITATION

Released 4/14/2005
WRENCH LIGHT ON WITH BOTH DTC P2106 AND P2135—VEHICLES BUILT 11/29/2004 AND PRIOR

Released 1/19/2005
MIL ON—VARIOUS DRIVEABILITY CONDITIONS—5.4L 3-VALVE ENGINE—VEHICLES BUILT BEFORE 4/20/2005

Released 1/3/2005
MAF DIAGNOSTIC SERVICE TIP—VEHICLES EQUIPPED WITH EGR SYSTEM MODULE (ESM)

Released 7/9/2012
DTCS P0505, P0506 AND/OR ENGINE IDLE RPM FLUCTUATION - HARD START

Released 4/15/2008
GRINDING NOISE FROM CLIMATE CONTROL— TSB 08-8-9 CHANGING AIR DISTRIBUTION MODES—BUILT AFTER 11/29/2005

Released 4/1/2008
SPARK PLUG REMOVAL INSTRUCTIONS—4.6L 3V/5.4L 3V/6.8L 3V

Released 1/22/2008
ERRATIC FUEL GAUGE OPERATION—MIL ON—DTCS P0460/P0463 OR INSTRUMENT CLUSTER MODULE DTC B1201—VEHICLES BUILT BEFORE 12/3/2007

Released 3/7/2007
SPARK KNOCK UNDER LIGHT LOAD AND ACCELERATION—3.8L, 3.9L, AND 4.2L—SPLIT PORT INTAKE MANIFOLD RUNNER CONTROL (IMRC)

Released 8/22/2005
WDS COP KIT DIAGNOSTIC TIPS—COIL ON PLUG (COP) IGNITION SYSTEMS—ENGINE MISFIRE OR ROUGH RUNNING

Released 6/16/2009
WHITE FLAKES COMING FROM A/C VENTS

Released 12/15/2008
WHITE FLAKES COMING FROM A/C VENTS

Released 11/3/2008
EATC—INTERMITTENT WARM AIR OUTPUT TSB 08-23-6 TEMPERATURE SET 68-72 F (18-22 C) EMTC— INABILITY TO CONTROL TEMPERATURE OUTPUT

Released 6/3/2008
RUST STAINS ON THE EDGES OF THE FRONT BUMPER CENTER VENT AND FOG LAMP OPENINGS

Released 4/15/2008
GRINDING NOISE FROM CLIMATE CONTROL— TSB 08-8-9 CHANGING AIR DISTRIBUTION MODES—BUILT AFTER 11/29/2005

Released 6/18/2007
PASSENGER FRONT FLOOR WATER LEAK—A/C CONDENSATION LEAKING

Released 12/21/2006
HEATER CORE LEAKAGE AND ELECTROLYSIS (INFORMATION ONLY)

Released 9/4/2006
A/C COMPRESSOR NOT OPERATIONAL / LOW FREON—SHAFT SEAL LEAKS

Released 8/17/2006
SERVICE WIRING HARNESS REPLACEMENT GUIDELINES—SERVICE TIPS

Released 11/10/2005
WHITE FLAKES COMING FROM A/C VENTS

Released 3/4/2005
COOLING FAN CLUTCH NOISE—VEHICLES BUILT PRIOR TO 10/1/2004—5.4L AND 4.6L ENGINES

Released 6/7/2018
Various Vehicles - Engine Failure Analysis General Service Bulletin (GSB)

Released 4/23/2018
2001-2015 - Vehicles With Modular 4.6L, 5.4L Or 6.8L Engines - Determining Root Cause Of Engine Damage Due To Oil Pressure Loss.

Released 4/23/2018
Various Vehicles - 4.6L/5.4L/6.8L 3 Valve - Engine Noise Upper End And/Or Rough Running - Camshaft Roller Follower Replacement - Built On Or Before 8-Jan-2016

Released 4/23/2018
VISIBLE GREASE PURGE -FRONT HUB AND BEARING ASSEMBLY

Released 10/19/2017
Remanufactured Powertrain Core Returns

Released 8/15/2016
2004-2014 F-150 and 2006-2008 Mark LT - 4WD - Noisy Or Engaged Front Hubs In 2WD Mode - Integrated Wheel End (IWE) Vacuum Hose Repair Kit

Released 12/15/2015
Multiple Vehicles - Transmission Cooler Flush General Service Bulletin (GSB)

Released 12/8/2015
Multiple Vehicles - Engine Failure Analysis General Service Bulletin (GSB)

Released 12/7/2015
Multiple Vehicles - Spark Plug Thread Repair - 4.6L/5.4L/6.8L Modular 2v Engines - General Service Bulletin (GSB)

Released 8/20/2015
Multiple Vehicles - 4.6L 3v And 5.4L 3v Engines - 3v Cam Phaser Installation General Service Bulletin (GSB)

Released 5/29/2014
5.4L 3V – Intermittent Rattle Noise While Driving / Rough Idle When Engine Is At Operating Temperature

Released 7/20/2012
5.4L INTERMITTENT RATTLE NOISE / ROUGH IDLE WHEN ENGINE IS AT OPERATING TEMPERATURE

Released 10/5/2009
UN-COMMANDED TCC APPLY ON THE 1-2 SHIFT CAUSING PERCEPTION OF HESITATION AND/OR LACK OF POWER DURING SHIFT

Released 12/9/2008
5.4L 3V WITH P030X AND/OR P0316 ACCOMPANIED BY SPARK KNOCK

Released 8/21/2008
MIL ON—P0506 AND/OR P0505—HESITATION/LOSS OF RPM/DIFFICULTY STARTING/LOW IDLE RPM

Released 3/13/2008
LOBO—REAR AXLE TUBE FRACTURE AT CENTER CARRIER (MEXICO ONLY)

Released 12/10/2007
FRAME REPLACEMENT MATRIX—SERVICE TIP

Released 10/17/2007
4.6L 2V, 5.4L 2V, OR 6.8L 2V—SPARK PLUG THREAD REPAIR PROCEDURE—NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY

Released 6/18/2007
PASSENGER FRONT FLOOR WATER LEAK—A/C CONDENSATION LEAKING

Released 5/9/2007
VIBRATION FROM THE DRIVELINE AT HIGHWAY SPEEDS

Released 1/9/2007
MERCONâ ATF REPLACED BY MERCON (R) V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS

Released 12/19/2006
SHUDDER/VIBRATION ON MODERATE TO HARD ACCELERATION

Released 12/19/2006
DTC P0340/P0344/P0345/P0349—4.6L 3V AND 5.4L 3V

Released 12/18/2006
IDENTIFYING THE CORRECT REPLACEMENT HEAD GASKET FOR CERTAIN REMANUFACTURED ENGINES—SERVICE TIP

Released 12/16/2006
STUMBLE ON HEAVY DECELERATION AND/OR TIP-OUT IN MANUAL 2—5.4L 3V WITH 4R75E

Released 12/11/2006
4X4 FRONT DIFFERENTIAL BRACKET REPAIR

Released 12/8/2006
INTERMITTENT IWE NOISE, 4WDH LIGHT AND/OR 4X4 SYSTEM INOPERATIVE, DTCS—C1979 AND C1980

Released 8/19/2006
TICKING AND / OR KNOCKING NOISE / STARTUP RATTLE FROM ENGINE—4.6L / 5.4L 3V

Released 8/9/2006
INOPERATIVE ESOF 4X4 SYSTEM WITH DTC P1867

Released 7/22/2006
UN-COMMANDED TCC APPLY ON THE 1-2 SHIFT CAUSING PERCEPTION OF HESITATION AND/OR LACK OF POWER DURING SHIFT

Released 1/26/2006
MERCON ATF IS BEING REPLACED BY MERCON V AS A SERVICE FLUID FOR SOME MANUAL TRANSMISSIONS

Released 12/21/2005
SERVICE PROCEDURE FOR REPAIR OR REPLACEMENT OF COLUMN SHIFT CABLE

Released 12/18/2005
MIL ON WITH DTC P061B AND/OR P2106 AFTER COLD START AND RAPID TRANSMISSION GEAR ENGAGEMENT—VEHICLES BUILT 8/23/2004 THROUGH 1/15/2005—5.4L 3-VALVE ENGINE

Released 12/10/2005
HARSH 3-2 DOWNSHIFT BETWEEN 17-25 MPH (27-40 KM/H)—NO DTCS—4R75E AUTOMATIC TRANSMISSION—VEHICLES BUILT BEFORE 4/20/2005

Released 11/26/2005
DRIVESHAFT SLIP-BUMP ON DECELERATION OR ACCELERATION FROM A STOP

Released 11/3/2005
MIL AND/OR DTCS P0172, P0175, P0171, P0174—THROTTLE PEDAL RESPONSE/TIP IN HESITATION THROTTLE PEDAL RESPONSE/TIP IN HESITATION

Released 8/22/2005
WDS COP KIT DIAGNOSTIC TIPS—COIL ON PLUG (COP) IGNITION SYSTEMS—ENGINE MISFIRE OR ROUGH RUNNING

Released 3/23/2005
REAR AXLE NOISE REPAIR

Released 3/4/2005
COOLING FAN CLUTCH NOISE—VEHICLES BUILT PRIOR TO 10/1/2004—5.4L AND 4.6L ENGINES

Released 1/19/2005
MIL ON—VARIOUS DRIVEABILITY CONDITIONS—5.4L 3-VALVE ENGINE—VEHICLES BUILT BEFORE 4/20/2005

Released 1/3/2005
MAF DIAGNOSTIC SERVICE TIP—VEHICLES EQUIPPED WITH EGR SYSTEM MODULE (ESM)

Released 12/24/2004
CAMSHAFT AND LASH ADJUSTER DESIGN CHANGE—5.4L 3V ENGINE

Released 10/23/2004
AUDIBLE DRIVELINE MOAN ABOVE 45 MPH (72 KM/H) DURING ACCELERATION OR COASTING— VEHICLES BUILT 8/20/2004 TO 10/4/2004

Released 6/4/1991
TRANSMISSION—AUTOMATIC—ELECTRONIC TRANSMISSION DIAGNOSTIC AND REPAIR CHART

Released 2/22/2011
Safety Recall - Certain 2005 through 2006 Model Year F-150 Vehicles Built at Norfolk Assembly Plant - Clockspring to Driver Side Frontal Air Bag Wire Harness Replacement - Dealer Bulletin

Released 2/22/2011
Safety Recall - Certain 2005 through 2006 Model Year F-150 Vehicles Built at Norfolk Assembly Plant - Clockspring to Driver Side Frontal Air Bag Wire Harness Replacement - Additional Information - Background Summary

Released 2/22/2011
Safety Recall - Certain 2005 through 2006 Model Year F-150 Vehicles Built at Norfolk Assembly Plant - Clockspring to Driver Side Frontal Air Bag Wire Harness Replacement - Additional Information - Recall Reimbursement

Released 10/5/2007
HIGH PRESSURE POWER STEERING LINE TSB 07-21-3 SEEPAGE—COLD CLIMATES ONLY (EXCLUDING HERITAGE F-150)

Released 5/9/2007
STEERING WHEEL VIBRATION AT 50 MPH (80 KM/H) OR HIGHER—STEERING WHEEL NIBBLE AT 65 MPH (105 KM/H) OR HIGHER

Released 2/14/2007
VIBRATION DIAGNOSIS—TIRE/WHEEL RUNOUT

Released 2/13/2007
LEATHER-WRAPPED STEERING WHEEL—LEATHER COMING LOOSE

Released 1/9/2007
MERCONâ ATF REPLACED BY MERCON (R) V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS

Released 3/4/2006
ALTERNATE TIRES APPROVED FOR OFF ROAD USE

Released 12/21/2005
FRONT BRAKE ROUGHNESS—SHUDDER WHILE BRAKING

Released 12/9/2005
STEERING COLUMN RATTLE/CLUNKING WHILE DRIVING OVER ROUGH SURFACES AND WHEN TURNING THE STEERING WHEEL

Released 11/26/2005
DRIVESHAFT SLIP-BUMP ON DECELERATION OR ACCELERATION FROM A STOP

Released 7/26/2005
RAPID SHOULDER (TOE) WEAR ON INSIDE EDGE OF FRONT TIRES

Released 1/15/2005
CLICKING/TICKING NOISE FROM STEERING COLUMN—VEHICLES BUILT BEFORE 5/31/2005

Released 11/1/1996
LOCKS—INTRODUCTION OF NEW LOCK DESIGN—SERVICE TIP

Released 10/17/2007
4.6L 2V, 5.4L 2V, OR 6.8L 2V—SPARK PLUG THREAD REPAIR PROCEDURE—NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY

Released 8/22/2005
WDS COP KIT DIAGNOSTIC TIPS—COIL ON PLUG (COP) IGNITION SYSTEMS—ENGINE MISFIRE OR ROUGH RUNNING

Released 7/18/2005
WIRING—SOLDERING AND CRIMPING REPAIRS— SOLDERING TIPS

Released 3/9/2005
INTERIOR PLASTIC TRIM—PAINT-TO-MATCH AND REPAIR—INTERIOR SPRAY PAINT AND ADHESION PROMOTER USAGE INSTRUCTIONS

Released 12/4/1994
PAINT—PRIMED SHEET METAL—PREP PROCEDURE AND MSDS INFORMATION