Get Free 2003 FORD F150 V8, 4.6L TSBs

Released 10/19/2017
Remanufactured Powertrain Core Returns

Released 12/15/2015
Multiple Vehicles - Transmission Cooler Flush General Service Bulletin (GSB)

Released 12/8/2015
Multiple Vehicles - Engine Failure Analysis General Service Bulletin (GSB)

Released 3/7/2007
SPARK KNOCK UNDER LIGHT LOAD AND ACCELERATION—3.8L, 3.9L, AND 4.2L—SPLIT PORT INTAKE MANIFOLD RUNNER CONTROL (IMRC)

Released 11/16/2005
SAFETY BELT RETRACTION SPEED

Released 10/3/2005
SAFETY BELT WEB STOP BUTTON SERVICE

Released 9/11/2005
REMOVAL AND INSTALLATION OF REAR BOLT-IN GLASS—SERVICE TIP

Released 7/5/2004
BODY—FRONT WINDOW(S)—POP/THUMP NOISE END OF WINDOW TRAVEL AND/OR DRIVER’S WINDOW BOUNCE BACK AND REVERSE TO MID-POSITION

Released 6/20/2004
TICKING OR KNOCKING NOISE COMING FROM THE CATALYTIC CONVERTERS

Released 2/2/2004
BODY—BACK GLASS—SLIDING BACK GLASS WINDNOISE/WATER LEAK—SEAL REPLACEMENT

Released 12/15/2003
STEERING—TIE ROD END INSPECTION PROCEDURE

Released 10/11/2003
BODY—WATER LEAK FROM ROOF OPENING PANEL—ROOF OPENING PANEL BINDS OR WILL NOT OPEN PROPERLY * NOISE—RATTLE FROM ROOF OPENING PANEL AREA

Released 5/23/2003
BODY—BED EXTENDER—COMPONENT REPLACEMENT—SERVICE TIP

Released 3/4/2003
DRIVEABILITY—NO START—CRANK NO START— AMBIENT TEMPERATURE AT OR BELOW 0 DEGREE F (-17C)—VEHICLES BUILT 7/29/02 THROUGH 2/3/03 EQUIPPED WITH 4.6L ENGINE ONLY

Released 2/23/2003
BODY—MIRROR—EXTERIOR MIRROR GLASS AND MOTOR REPLACEMENT—SERVICE TIPS

Released 1/7/2003
BODY—WATER LEAK FROM ROOF OPENING PANEL AREA

Released 7/16/2002
BODY—PAINT—APPROVED PAINT MATERIALS FOR WARRANTY REPAIRS

Released 4/21/2002
STEERING—ROOF DITCH MATERIAL CRACKING—SERVICE TIPS

Released 3/16/2002
PAINT—NEW POLISHING PRODUCTS—SERVICE PROCEDURES

Released 2/25/2002
ELECTRICAL—CDX6 RADIO DAMAGED DURING SERVICE SHIPPING—CORRECT SHIPMENT PROCEDURES FOR CDX6 RADIO—SERVICE TIPS

Released 11/1/1996
LOCKS—INTRODUCTION OF NEW LOCK DESIGN—SERVICE TIP

Released 12/4/1994
PAINT—PRIMED SHEET METAL—PREP PROCEDURE AND MSDS INFORMATION

Released 6/2/1991
PAINT—CODES—REVISED 1991 FLEET COLOR PAINT CODE NUMBERS

Released 7/23/2002
COOLING SYSTEM—MOTORCRAFT PREMIUM GOLD ENGINE COOLANT—SERVICE TIPS

Released 5/8/2006
SPEED CONTROL DIAGNOSTICS—W/O SCP

Released 10/26/2005
CLUNK OR BUMP WHEN STARTING FROM A STOP

Released 7/18/2005
WIRING—SOLDERING AND CRIMPING REPAIRS— SOLDERING TIPS

Released 7/5/2004
BODY—FRONT WINDOW(S)—POP/THUMP NOISE END OF WINDOW TRAVEL AND/OR DRIVER’S WINDOW BOUNCE BACK AND REVERSE TO MID-POSITION

Released 3/8/2004
ELECTRICAL—SPLICING NEW WIRE(S) INTO EXISTING ELECTRICAL HARNESS—SERVICE PROCEDURE

Released 2/2/2004
BODY—BACK GLASS—SLIDING BACK GLASS WINDNOISE/WATER LEAK—SEAL REPLACEMENT

Released 10/11/2003
BODY—WATER LEAK FROM ROOF OPENING PANEL—ROOF OPENING PANEL BINDS OR WILL NOT OPEN PROPERLY * NOISE—RATTLE FROM ROOF OPENING PANEL AREA

Released 5/23/2003
BODY—BED EXTENDER—COMPONENT REPLACEMENT—SERVICE TIP

Released 2/23/2003
BODY—MIRROR—EXTERIOR MIRROR GLASS AND MOTOR REPLACEMENT—SERVICE TIPS

Released 1/18/2003
ELECTRICAL—REMOTE KEYLESS ENTRY (RKE)— SERVICE TIPS

Released 1/7/2003
BODY—WATER LEAK FROM ROOF OPENING PANEL AREA

Released 7/16/2002
BODY—PAINT—APPROVED PAINT MATERIALS FOR WARRANTY REPAIRS

Released 6/17/2002
LAMP—BRAKE—INADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK

Released 2/25/2002
ELECTRICAL—CDX6 RADIO DAMAGED DURING SERVICE SHIPPING—CORRECT SHIPMENT PROCEDURES FOR CDX6 RADIO—SERVICE TIPS

Released 11/1/1996
LOCKS—INTRODUCTION OF NEW LOCK DESIGN—SERVICE TIP

Released 4/17/2004
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED—SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC’S)—SERVICE TIPS

Released 6/6/2003
DRIVEABILITY—BI-FUEL—OXYGEN SENSOR DIAGNOSTICS—HIGH OXYGEN SENSOR VOLTAGE READING

Released 3/20/2003
DRIVEABILITY—MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH DTC’S P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457

Released 3/4/2003
DRIVEABILITY—NO START—CRANK NO START— AMBIENT TEMPERATURE AT OR BELOW 0 DEGREE F (-17C)—VEHICLES BUILT 7/29/02 THROUGH 2/3/03 EQUIPPED WITH 4.6L ENGINE ONLY

Released 6/20/2004
TICKING OR KNOCKING NOISE COMING FROM THE CATALYTIC CONVERTERS

Released 6/25/2003
ENGINE—ROMEO BUILT 4.6L 2V—TICK NOISE FROM ENGINE—ENGINES BUILT BEFORE 9/17/2003

Released 10/13/2011
Safety Recall - Certain 1997 through 2003 Model Year F-150, 2004 Model Year F-150 Heritage, 1997 through 1999 Model Year F-250 Light Duty, and 2002 through 2003 Model Year Blackwood Vehicles Operated in Corrosion States - Fuel Tank Strap Inspection and Repair - Owner Letter

Released 8/18/2011
Safety Recall - Certain 1997 through 2003 Model Year F-150, 2004 Model Year F-150 Heritage, 1997 through 1999 Model Year F-250 Light Duty, and 2002 through 2003 Model Year Blackwood Vehicles Operated in Corrosion States - Fuel Tank Strap Inspection and Repair - Dealer Bulletin

Released 8/3/2011
Safety Recall - Certain 1997 through 2003 Model Year F-150, 2004 Model Year F-150 Heritage, 1997 through 1999 Model Year F-250 Light Duty, and 2002 through 2003 Model Year Blackwood Vehicles Operated in Corrosion States - Fuel Tank Strap Inspection and Repair - Additional Information - Recall Reimbursement

Released 8/1/2011
Safety Recall - Certain 1997 through 2003 Model Year F-150, 2004 Model Year F-150 Heritage, 1997 through 1999 Model Year F-250 Light Duty, and 2002 through 2003 Model Year Blackwood Vehicles Operated in Corrosion States - Fuel Tank Strap Inspection and Repair - Dealer Q&A

Released 8/1/2011
Safety Recall - Certain 1997 through 2003 Model Year F-150, 2004 Model Year F-150 Heritage, 1997 through 1999 Model Year F-250 Light Duty, and 2002 through 2003 Model Year Blackwood Vehicles Operated in Corrosion States - Fuel Tank Strap Inspection and Repair - Technical Info

Released 8/1/2011
Safety Recall - Certain 1997 through 2003 Model Year F-150, 2004 Model Year F-150 Heritage, 1997 through 1999 Model Year F-250 Light Duty, and 2002 through 2003 Model Year Blackwood Vehicles Operated in Corrosion States - Fuel Tank Strap Inspection and Repair - Customer Information Sheet: Passed Inspection

Released 8/1/2011
Safety Recall - Certain 1997 through 2003 Model Year F-150, 2004 Model Year F-150 Heritage, 1997 through 1999 Model Year F-250 Light Duty, and 2002 through 2003 Model Year Blackwood Vehicles Operated in Corrosion States - Fuel Tank Strap Inspection and Repair - Customer Information Sheet: Did Not Pass Inspection

Released 7/29/2011
Safety Recall - Certain 1997 through 2003 Model Year F-150, 2004 Model Year F-150 Heritage, 1997 through 1999 Model Year F-250 Light Duty, and 2002 through 2003 Model Year Blackwood Vehicles Operated in Corrosion States - Fuel Tank Strap Inspection and Repair - Additional Information - Background Summary

Released 3/7/2007
SPARK KNOCK UNDER LIGHT LOAD AND ACCELERATION—3.8L, 3.9L, AND 4.2L—SPLIT PORT INTAKE MANIFOLD RUNNER CONTROL (IMRC)

Released 8/22/2005
WDS COP KIT DIAGNOSTIC TIPS—COIL ON PLUG (COP) IGNITION SYSTEMS—ENGINE MISFIRE OR ROUGH RUNNING

Released 6/22/2005
MIL ON WITH DTC P1131 AND/OR P1151—4.2L ENGINE

Released 6/5/2005
ALTERNATIVE FUEL VEHICLE—COMPRESSED NATURAL GAS FUEL TANK INSPECTION

Released 6/20/2003
DRIVEABILITY—DEDICATED COMPRESSED NATURAL GAS (CNG) VEHICLES—4.6L AND 5.4L ENGINE—ROUGH IDLE, HARD START OR NO START WHEN COLD—LOSS OF POWER—LEAN FUEL DTC’S—RESTRICTED CATALYTIC CONVERTER *

Released 6/6/2003
DRIVEABILITY—BI-FUEL—OXYGEN SENSOR DIAGNOSTICS—HIGH OXYGEN SENSOR VOLTAGE READING

Released 3/18/2003
DRIVEABILITY—DEDICATED COMPRESSED NATURAL GAS (CNG)—ROUGH IDLE OR NO START WHEN COLD—VEHICLES EQUIPPED WITH DEDICATED 4.6L OR 5.4L CNG ENGINE ONLY

Released 3/10/2003
DRIVEABILITY—BI-FUEL CNG/LPG LOW FLOW NJECTOR SERVICE KIT WITHOUT COOLANT LOCK-OFF * DRIVEABILITY—CRANK NO START—BI-FUEL CNG/LPG VEHICLES—LOW FLOW INJECTOR SERVICE KIT WITHOUT COOLANT LOCK-OFF

Released 2/4/2003
FUEL—BI-FUEL—CNG FUEL LEAK AT FILL VALVE— E-SERIES AND F-SERIES CNG FILL VALVE— REVISED SERVICE PARTS

Released 1/22/2002
DRIVEABILITY—SURGE/ROLLING IDLE—GEAR DRIVEN SYNCHRONIZERS—INCORRECT INSTALLATION—CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION *

Released 6/16/2009
WHITE FLAKES COMING FROM A/C VENTS

Released 12/15/2008
WHITE FLAKES COMING FROM A/C VENTS

Released 12/21/2006
HEATER CORE LEAKAGE AND ELECTROLYSIS (INFORMATION ONLY)

Released 9/4/2006
A/C COMPRESSOR NOT OPERATIONAL / LOW FREON—SHAFT SEAL LEAKS

Released 11/10/2005
WHITE FLAKES COMING FROM A/C VENTS

Released 4/23/2018
1997-2003 F-150/2004 F-150 Heritage/1997-1999 F-250/2002-2003 Blackwood - Safety Recall 11S21 - Fuel Tank Strap Fracture - Requests For Recall Service Action

Released 10/19/2017
Remanufactured Powertrain Core Returns

Released 12/15/2015
Multiple Vehicles - Transmission Cooler Flush General Service Bulletin (GSB)

Released 12/8/2015
Multiple Vehicles - Engine Failure Analysis General Service Bulletin (GSB)

Released 10/17/2007
4.6L 2V, 5.4L 2V, OR 6.8L 2V—SPARK PLUG THREAD REPAIR PROCEDURE—NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY

Released 2/15/2007
SOME 1997-2007 VEHICLES WITH 5.4L 2V AND 6.8L 2V MODULAR ENGINE SPARK PLUG THREAD OUT OF WARRANTY REPAIR PROCEDURE FOR ALUMINUM HEADS

Released 1/9/2007
MERCONâ ATF REPLACED BY MERCON (R) V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS

Released 12/18/2006
IDENTIFYING THE CORRECT REPLACEMENT HEAD GASKET FOR CERTAIN REMANUFACTURED ENGINES—SERVICE TIP

Released 4/14/2006
MERCON ATF IS BEING REPLACED BY MERCON V ATF AS A SERVICE FLUID.

Released 1/26/2006
MERCON ATF IS BEING REPLACED BY MERCON V AS A SERVICE FLUID FOR SOME MANUAL TRANSMISSIONS

Released 12/4/2005
INTERMITTENT ROUGH IDLE—NON-COMMANDED INTERMITTENT ROUGH IDLE—NON-COMMANDED

Released 10/26/2005
CLUNK OR BUMP WHEN STARTING FROM A STOP

Released 8/22/2005
WDS COP KIT DIAGNOSTIC TIPS—COIL ON PLUG (COP) IGNITION SYSTEMS—ENGINE MISFIRE OR ROUGH RUNNING

Released 6/22/2005
MIL ON WITH DTC P1131 AND/OR P1151—4.2L ENGINE

Released 6/5/2005
ALTERNATIVE FUEL VEHICLE—COMPRESSED NATURAL GAS FUEL TANK INSPECTION

Released 4/5/2005
USE OF STAINLESS STEEL EXHAUST STUDS IN SERVICE FOR 5.4L 2V ENGINE

Released 3/23/2005
REAR AXLE NOISE REPAIR

Released 6/1/2004
NOISE—DRIVELINE CLUNKING/GRUNTING NOISE OR SHUDDER SENSATION DURING LIGHT TO MODERATE ACCELERATION AND/OR BRAKING *

Released 8/14/2003
TRANSMISSION—NEW TRANSMISSION COOLER FLUSHER SERVICE TIPS

Released 6/25/2003
ENGINE—ROMEO BUILT 4.6L 2V—TICK NOISE FROM ENGINE—ENGINES BUILT BEFORE 9/17/2003

Released 6/20/2003
DRIVEABILITY—DEDICATED COMPRESSED NATURAL GAS (CNG) VEHICLES—4.6L AND 5.4L ENGINE—ROUGH IDLE, HARD START OR NO START WHEN COLD—LOSS OF POWER—LEAN FUEL DTC’S—RESTRICTED CATALYTIC CONVERTER *

Released 5/23/2003
BODY—BED EXTENDER—COMPONENT REPLACEMENT—SERVICE TIP

Released 3/18/2003
DRIVEABILITY—DEDICATED COMPRESSED NATURAL GAS (CNG)—ROUGH IDLE OR NO START WHEN COLD—VEHICLES EQUIPPED WITH DEDICATED 4.6L OR 5.4L CNG ENGINE ONLY

Released 3/4/2003
DRIVEABILITY—NO START—CRANK NO START— AMBIENT TEMPERATURE AT OR BELOW 0 DEGREE F (-17C)—VEHICLES BUILT 7/29/02 THROUGH 2/3/03 EQUIPPED WITH 4.6L ENGINE ONLY

Released 2/4/2003
FUEL—BI-FUEL—CNG FUEL LEAK AT FILL VALVE— E-SERIES AND F-SERIES CNG FILL VALVE— REVISED SERVICE PARTS

Released 12/21/2002
OSCILLATION/BOUNCE—HIGHWAY SPEEDS—4X2 CHECKING CYLINDER HEAD AND BLOCK FLATNESS

Released 7/23/2002
COOLING SYSTEM—MOTORCRAFT PREMIUM GOLD ENGINE COOLANT—SERVICE TIPS

Released 1/22/2002
DRIVEABILITY—SURGE/ROLLING IDLE—GEAR DRIVEN SYNCHRONIZERS—INCORRECT INSTALLATION—CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION *

Released 1/21/2002
TRANSMISSION—4R100/E4OD—TORQUE CONVERTER ACCESS EXTERNAL DUST PLUG MAY BECOME DISLODGED

Released 6/4/1991
TRANSMISSION—AUTOMATIC—ELECTRONIC TRANSMISSION DIAGNOSTIC AND REPAIR CHART

Released 10/13/2011
Safety Recall - Certain 1997 through 2003 Model Year F-150, 2004 Model Year F-150 Heritage, 1997 through 1999 Model Year F-250 Light Duty, and 2002 through 2003 Model Year Blackwood Vehicles Operated in Corrosion States - Fuel Tank Strap Inspection and Repair - Owner Letter

Released 8/18/2011
Safety Recall - Certain 1997 through 2003 Model Year F-150, 2004 Model Year F-150 Heritage, 1997 through 1999 Model Year F-250 Light Duty, and 2002 through 2003 Model Year Blackwood Vehicles Operated in Corrosion States - Fuel Tank Strap Inspection and Repair - Dealer Bulletin

Released 8/3/2011
Safety Recall - Certain 1997 through 2003 Model Year F-150, 2004 Model Year F-150 Heritage, 1997 through 1999 Model Year F-250 Light Duty, and 2002 through 2003 Model Year Blackwood Vehicles Operated in Corrosion States - Fuel Tank Strap Inspection and Repair - Additional Information - Recall Reimbursement

Released 8/1/2011
Safety Recall - Certain 1997 through 2003 Model Year F-150, 2004 Model Year F-150 Heritage, 1997 through 1999 Model Year F-250 Light Duty, and 2002 through 2003 Model Year Blackwood Vehicles Operated in Corrosion States - Fuel Tank Strap Inspection and Repair - Dealer Q&A

Released 8/1/2011
Safety Recall - Certain 1997 through 2003 Model Year F-150, 2004 Model Year F-150 Heritage, 1997 through 1999 Model Year F-250 Light Duty, and 2002 through 2003 Model Year Blackwood Vehicles Operated in Corrosion States - Fuel Tank Strap Inspection and Repair - Technical Info

Released 8/1/2011
Safety Recall - Certain 1997 through 2003 Model Year F-150, 2004 Model Year F-150 Heritage, 1997 through 1999 Model Year F-250 Light Duty, and 2002 through 2003 Model Year Blackwood Vehicles Operated in Corrosion States - Fuel Tank Strap Inspection and Repair - Customer Information Sheet: Passed Inspection

Released 8/1/2011
Safety Recall - Certain 1997 through 2003 Model Year F-150, 2004 Model Year F-150 Heritage, 1997 through 1999 Model Year F-250 Light Duty, and 2002 through 2003 Model Year Blackwood Vehicles Operated in Corrosion States - Fuel Tank Strap Inspection and Repair - Customer Information Sheet: Did Not Pass Inspection

Released 7/29/2011
Safety Recall - Certain 1997 through 2003 Model Year F-150, 2004 Model Year F-150 Heritage, 1997 through 1999 Model Year F-250 Light Duty, and 2002 through 2003 Model Year Blackwood Vehicles Operated in Corrosion States - Fuel Tank Strap Inspection and Repair - Additional Information - Background Summary

Released 4/22/2003
WHEEL—CORRECT LUG NUT TORQUE SPECIFICATIONS—INCREASED WHEEL NUT AND STUD SIZE—SERVICE TIP

Released 1/5/2003
STEERING—POWER STEERING PUMP WHINE NOISE—VEHICLES PRODUCED ON OR BEFORE 10/7/02 ONLY * NOISE—“WHINE” NOISE FROM POWER STEERING PUMP—VEHICLES PRODUCED ON OR BEFORE 10/7/02 ONLY

Released 11/1/1996
LOCKS—INTRODUCTION OF NEW LOCK DESIGN—SERVICE TIP

Released 8/22/2005
WDS COP KIT DIAGNOSTIC TIPS—COIL ON PLUG (COP) IGNITION SYSTEMS—ENGINE MISFIRE OR ROUGH RUNNING

Released 7/18/2005
WIRING—SOLDERING AND CRIMPING REPAIRS— SOLDERING TIPS

Released 12/4/1994
PAINT—PRIMED SHEET METAL—PREP PROCEDURE AND MSDS INFORMATION