Get Free 2004 FORD EXPLORER SPORT TRAC V6, 4.0L; SOHC; FFV TSBs

Released 12/8/2015
Multiple Vehicles - Engine Failure Analysis General Service Bulletin (GSB)

Released 11/30/2007
TAILGATE STRIKER—NOISE/RATTLE

Released 9/24/2007
REAR POWER WINDOW MOTOR TSB 07-20-5 INOPERATIVE/STUCK IN THE UP POSITION

Released 6/6/2007
RCM FAULT REPORTING USING DTCS AND BIT-MAPPED PARAMETER IDENTIFIERS (PIDS)— SERVICE TIPS

Released 2/13/2007
LEATHER-WRAPPED STEERING WHEEL—LEATHER COMING LOOSE

Released 11/20/2005
VIBRATION/MOAN DRIVING 75-80 MPH (121-129 KM/H)—4X4 WITH 4.10 AXLE

Released 11/16/2005
SAFETY BELT RETRACTION SPEED

Released 10/3/2005
SAFETY BELT WEB STOP BUTTON SERVICE

Released 9/11/2005
REMOVAL AND INSTALLATION OF REAR BOLT-IN GLASS—SERVICE TIP

Released 8/10/2005
PAINT PEELING/CRACKING ON CENTER FINISH PANEL

Released 4/3/2005
MOONROOF SQUEAK AND/OR RATTLE NOISE— CORNER INSERT REPAIR

Released 3/9/2005
INTERIOR PLASTIC TRIM—PAINT-TO-MATCH AND REPAIR—INTERIOR SPRAY PAINT AND ADHESION PROMOTER USAGE INSTRUCTIONS

Released 12/3/2004
BODY—HEADLAMP—MOISTURE IN HEADLAMP

Released 6/16/2004
POWER LUMBAR BLADDER EXPANDING THROUGH BACK OF SEAT

Released 6/9/2004
BODY—PAINT—IRON PARTICLE REMOVAL - INDUSTRIAL FALLOUT—ACID RAIN NEUTRALIZATION

Released 5/24/2004
REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR—TERMINAL TAB REPAIR

Released 5/23/2003
BODY—BED EXTENDER—COMPONENT REPLACEMENT—SERVICE TIP

Released 5/19/2003
BODY—POWER REAR WINDOW BOUNCES BACK OPEN WHEN CLOSING * ELECTRICAL—POWER REAR WINDOW BOUNCES BACK OPEN WHEN CLOSING

Released 4/19/2003
BODY—POWER REAR WINDOW RATTLE WHEN IN VENT POSITION * NOISE—POWER REAR WINDOW RATTLE WHEN IN VENT POSITION

Released 2/23/2003
BODY—MIRROR—EXTERIOR MIRROR GLASS AND MOTOR REPLACEMENT—SERVICE TIPS

Released 5/8/2006
SPEED CONTROL DIAGNOSTICS—W/O SCP

Released 1/7/2006
NEUTRAL TOW CAPABILITY—SERVICE KIT REQUIREMENTS

Released 7/18/2005
WIRING—SOLDERING AND CRIMPING REPAIRS— SOLDERING TIPS

Released 3/10/2005
ACCELERATOR PEDAL VIBRATION/BUZZ AT 1500-1800 RPM

Released 12/3/2004
BODY—HEADLAMP—MOISTURE IN HEADLAMP

Released 6/9/2004
BODY—PAINT—IRON PARTICLE REMOVAL - INDUSTRIAL FALLOUT—ACID RAIN NEUTRALIZATION

Released 5/24/2004
REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR—TERMINAL TAB REPAIR

Released 5/23/2003
BODY—BED EXTENDER—COMPONENT REPLACEMENT—SERVICE TIP

Released 5/19/2003
BODY—POWER REAR WINDOW BOUNCES BACK OPEN WHEN CLOSING * ELECTRICAL—POWER REAR WINDOW BOUNCES BACK OPEN WHEN CLOSING

Released 4/19/2003
BODY—POWER REAR WINDOW RATTLE WHEN IN VENT POSITION * NOISE—POWER REAR WINDOW RATTLE WHEN IN VENT POSITION

Released 2/23/2003
BODY—MIRROR—EXTERIOR MIRROR GLASS AND MOTOR REPLACEMENT—SERVICE TIPS

Released 4/17/2004
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED—SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC’S)—SERVICE TIPS

Released 4/3/2005
MOONROOF SQUEAK AND/OR RATTLE NOISE— CORNER INSERT REPAIR

Released 3/10/2005
ACCELERATOR PEDAL VIBRATION/BUZZ AT 1500-1800 RPM

Released 11/25/2004
MOAN/VIBRATION DURING A/C OPERATION

Released 4/19/2003
BODY—POWER REAR WINDOW RATTLE WHEN IN VENT POSITION * NOISE—POWER REAR WINDOW RATTLE WHEN IN VENT POSITION

Released 12/15/2015
Multiple Vehicles - Transmission Cooler Flush General Service Bulletin (GSB)

Released 12/8/2015
Multiple Vehicles - Engine Failure Analysis General Service Bulletin (GSB)

Released 1/9/2007
MERCONâ ATF REPLACED BY MERCON (R) V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS

Released 12/24/2006
5R44E / 5R55E SERVICE PART LEVEL CHANGE /COMPATIBILITY

Released 12/18/2006
IDENTIFYING THE CORRECT REPLACEMENT HEAD GASKET FOR CERTAIN REMANUFACTURED ENGINES—SERVICE TIP

Released 1/26/2006
MERCON ATF IS BEING REPLACED BY MERCON V AS A SERVICE FLUID FOR SOME MANUAL TRANSMISSIONS

Released 12/17/2005
STEERING SHUDDER DURING LOW SPEED MANEUVERS—4.0L ENGINE

Released 12/6/2005
FRONT AXLE LEAKS FLUID FROM VENT TUBE—VEHICLES EQUIPPED WITH 4X4 OR AWD

Released 11/20/2005
VIBRATION/MOAN DRIVING 75-80 MPH (121-129 KM/H)—4X4 WITH 4.10 AXLE

Released 8/22/2005
WDS COP KIT DIAGNOSTIC TIPS—COIL ON PLUG (COP) IGNITION SYSTEMS—ENGINE MISFIRE OR ROUGH RUNNING

Released 3/15/2005
NO 3RD GEAR, DTC P0733 (3RD GEAR INCORRECT RATIO) AND FLASHING TCIL—VEHICLES BUILT PRIOR TO 9/23/2004

Released 1/3/2005
MAF DIAGNOSTIC SERVICE TIP—VEHICLES EQUIPPED WITH EGR SYSTEM MODULE (ESM)

Released 10/19/2004
OIL LEAK FROM OIL FILTER ADAPTER—4.0L SOHC ENGINE BUILT BEFORE 4/1/2004

Released 10/18/2004
4X4 NOT ENGAGING OR INTERMITTENT 4X4 ENGAGEMENT—VEHICLES BUILT PRIOR TO 4/1/2004

Released 5/23/2003
BODY—BED EXTENDER—COMPONENT REPLACEMENT—SERVICE TIP

Released 1/9/2007
MERCONâ ATF REPLACED BY MERCON (R) V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS

Released 12/17/2005
STEERING SHUDDER DURING LOW SPEED MANEUVERS—4.0L ENGINE

Released 11/11/2005
IRREGULAR TIRE WEAR

Released 3/21/2004
SQUEAKING NOISE FROM REAR SWAY BAR LINK

Released 7/18/2005
WIRING—SOLDERING AND CRIMPING REPAIRS— SOLDERING TIPS

Released 3/9/2005
INTERIOR PLASTIC TRIM—PAINT-TO-MATCH AND REPAIR—INTERIOR SPRAY PAINT AND ADHESION PROMOTER USAGE INSTRUCTIONS