Get Free 2016 FORD EXPLORER V6, 3.7L; DOHC; 24V; SEFI TSBs

Released 1/29/2020
Various Vehicles - Running Board Concern Analysis

Released 1/29/2020
Various Vehicles - Glass Concern Analysis

Released 1/29/2020
2010-2020 Various Vehicles - Errors Caused By Swapping Modules From Like Vehicles Or Ordering Modules Using Another VIN

Released 1/29/2020
Various Vehicles - Interior Trim Steering Wheel Concern Analysis

Released 1/29/2020
2013-2020 Various Vehicles - Multi-Contour Seats - Intermittent Multi-Contour Seat Operation And/Or Massage And Lumbar Adjust Inoperative

Released 1/29/2020
2010-2020 - Various Vehicles - Glass Hydrofluoric Acid Damage

Released 1/29/2020
2013-2019 Explorer/Flex/MKT – Third Row Power-Fold Seats – Stow Motor Replacement

Released 1/29/2020
2011-2019 Explorer - Factory Keyless Entry Keypad - Driver Side B-Pillar Front Door Upper Moulding Loose

Released 1/29/2020
2016-2017 Explorer - Front Window Glass Jumps/Chatters During Up/Down Travel

Released 1/29/2020
2016-2019 Explorer - Roof Rail Covers Loose

Released 1/29/2020
2016-2019 Explorer - Heated Seat Lower Cushion Inoperative After Remote Start

Released 6/27/2019
2010-2019 Various Vehicles - Diagnostic Trouble Codes (DTCs) U2100 And/Or U2101 - Programmable Module Installation (PMI) Procedure

Released 6/27/2019
Various Vehicles - Clock Master

Released 6/27/2019
Various Vehicles - Paint And Bumper Concern Analysis

Released 6/27/2019
Parking Aid Sensor Diagnoses With No DTCs Present

Released 6/27/2019
2000 And Newer Ford, Lincoln And Mercury Vehicles - Aluminum Panel Corrosion

Released 6/27/2019
2016-2019 Explorer - Heated Seat Lower Cushion Inoperative After Remote Start

Released 6/27/2019
2016-2017 Explorer - Front Window Glass Jumps/Chatters During Up/Down Travel

Released 6/27/2019
2015-2019 Explorer - 2nd Row 60/40 Bench Seat - Left Seat Cushion Corner Loose And/Or Seat Foam Exposed

Released 6/27/2019
2016-2019 Various Vehicles – Front Climate Controlled Seat Inoperative, Buzzing Noise, And/Or Feels Too Warm - Multiple Diagnostic Trouble Codes (DTCs)

Released 6/27/2019
2016-2019 Explorer roof rack cap trim clips now available.

Released 6/27/2019
2011-2019 Explorer/2013-2019 Police Interceptor Utility - Center Console Rear Cup Holder Detached And/Or Center Console Rear Cup Holder Cover Panel Detached

Released 12/12/2018
Multiple Vehicles - Seat Cover Warranty Coverage Information

Released 12/12/2018
2013-2019 Various Vehicles - Seat Pan Looseness, Lateral Movement, Or Clunk/Thump Noise on Turns

Released 12/11/2018
2016-2019 Police Interceptor Utility - Illuminated Malfunction Indicator Lamp (MIL) - Diagnostic Trouble Code (DTC) P0073

Released 12/11/2018
2016-2019 Explorer - Power Folding 3rd Row Seat Will Not Latch/Unlatch From Folded Or Normal Position - Seat Latch Alignment

Released 12/11/2018
2016-2018 Explorer/Police Interceptor Utility - Liftgate Glass Broken - Built On Or Before 19-Mar-2018

Released 12/11/2018
2016-2018 Explorer/Police Interceptor Utility - Inoperative Power Windows/Power Mirrors/Roof Opening Panel/Roof Opening Panel Shield And/Or DTC B1088

Released 12/11/2018
2016-2018 Police Utility - Enabling Remote Keyless Entry (RKE)

Released 12/11/2018
2016 Explorer - Body Creak/Pop Noise Over Bumps - Right Front Subframe Bolt Area - Built On Or Before 31-Jan-2016

Released 5/8/2018
Glass Concern Analysis and Build Date Decoder

Released 5/1/2018
Ambient Air Temperature (AAT) Sensor

Released 4/23/2018
2013-2016 Various Vehicles - 6F35 Equipped - 2-3 Shift Hesitation After A Cold Soak

Released 4/23/2018
2012-2016 Escape, Fusion, Explorer, 2012-2015 Edge, 2013-2016 MKZ 2015-2016 MKC, 2016 MKX - Transfer Case - New Service Tool For Intermediate Shaft Seal

Released 4/23/2018
2013-2016 Explorer/Police Interceptor Utility - Front Door Trim Panels Delaminating

Released 4/23/2018
2016 Explorer/Flex/MKT/Taurus/MKS/Transit - 3.5L Gasoline Turbocharged Direct Injection (GTDI) - Illuminated MIL - DTCs P2096, P2097, P2098 And/Or P2099

Released 4/23/2018
2011-2016 Explorer/Taurus/Flex/MKT/MKS - 2.0L/2.3L/3.5L/3.7L - Ting/Pop/Click/Continuous Tick Noise - Front Halfshaft

Released 4/23/2018
2016 - Edge/Explorer/F-150/Mustang - Front Control/Display Interface Module (FCDIM) Blank Screen With 4.2-Inch Display - Built On Or Before 01-Nov-2016

Released 4/23/2018
2015-2016 Various Vehicles - 6F50/6F55 Transmission - No Reverse/3rd/5th Gear - Various DTCs - Built On 2-Nov-2015 And Through 1-Feb-2016 - New Service Part

Released 4/23/2018
2007-2016 Edge/MKX/Flex/MKT/MKZ/MKS/Taurus/Taurus Police/Explorer/Explorer Police – AWD - Ticking/Knocking Noise From Driveline – Built On Or Before 30-Jun-2016

Released 4/23/2018
2015-2016 Various Ford Vehicles - SYNC Gen 1 With 4.2 Inch Display - Bluetooth Pairing And Connection Concerns - Built On Or Before 1/24/2016

Released 4/23/2018
2014-2016 Multiple Vehicles - 6F35 - Harsh Reverse And Harsh/Delayed 3rd And 5th Up/Down Shifts - Without DTCs - Built On 1-Jan-2014 And Through 31-Dec-2015

Released 4/23/2018
2016 F150, Mustang And Explorer - No Audio After Starting The Engine - Screen Displays Loading Or Audio Off Message - Built On Or Before 4/15/2016

Released 4/23/2018
2016 Explorer and Lincoln MKX - Easy Entry/Exit Feature Does Not Stay Disabled - Built On Or Before 8/24/15

Released 4/23/2018
2016 Explorer - Genuine Ford Accessory Installed Remote Start - Instrument Panel Cluster (IPC) Remote Start / Climate Control Menu Items Grayed Out

Released 4/23/2018
2015 Edge, F150, Mustang and 2016 Explorer and MKX - Tire Pressure Monitoring System (TPMS) Sensors Difficult To Train

Released 4/23/2018
Various Vehicles - Perimeter Alarm Armed And Original Vehicle Keys Cannot Be Accessed to Enter Vehicle - CAN Protection Strategy

Released 4/23/2018
2013-2016 Edge, Flex, MKX, MKS, MKT, MKZ, Taurus, Police Sedan, Explorer, Police Utility - 6F50/6F55 Transmission Fluid Leak From Converter Housing

Released 4/23/2018
2016 Explorer with 3.5L Gasoline Turbocharged Direct Injection (GTDI) Engine, P0327/P0332

Released 4/23/2018
2016 Explorer Built On Or Before 5/8/2016 - Cooling Fan Noise

Released 4/23/2018
Various Vehicles - Adaptive Cruise Control Equipped - Unexpected Brief Reduction In Speed

Released 4/23/2018
2013-2016 Taurus Police And Explorer Police Top Speed Reduced After Transmission Service

Released 4/23/2018
Vehicle Health Report Inoperative with Aftermarket Device Plugged Into Data Link Connector

Released 4/23/2018
2016-2017 Explorer - Manual Front Passenger Seat Track - Stuck In Forward Position

Released 4/23/2018
2016-2017 Explorer/Taurus/Police Interceptor/MKS/Flex/MKT - 3.5L GTDI - Blue Or White Smoke From Exhaust While Driving After Extended Idle

Released 4/23/2018
2013-2017 Explorer/Taurus/MKS/Police Utility/Police Sedan - Exhaust Studs Not Missing

Released 4/23/2018
2016-2017 Explorer - Rear Door Lock Rod Binding

Released 4/23/2018
2016-2018 Police Utility - Enabling Remote Keyless Entry (RKE)

Released 4/23/2018
2011-2018 Explorer/2013-2018 Police Interceptor Utility - Center Console Rear Cup Holder Detached And/Or Center Console Rear Cup Holder Cover Panel Detached

Released 4/23/2018
2016-2017 Explorer - Front Window Glass Jumps/Chatters During Up/Down Travel

Released 4/23/2018
2016-2018 Police Utility - Front Amber Marker Lamps Flicker Only With Engine Running

Released 4/23/2018
2011-2016 Various Vehicles - Ambient Air Temperature Sensor (AAT) Pinpoint Test FA And FB Updated

Released 4/23/2018
2016-2018 Explorer roof rack cap trim clips now available.

Released 4/23/2018
2016-2018 Explorer - Base Model - Headlamp Signature Lighting Light Emitting Diodes (LEDs)

Released 4/23/2018
2011-2018 Explorer/Police Interceptor Utility/Police Interceptor Sedan Taurus/Flex/MKT and 2011-2016 MKS - 3.5L EcoBoost - Engine Assembly Replacement

Released 4/23/2018
2015-2017 Explorer, 2015-2016 F-150 - 3.5L GTDI - Illuminated Malfunction Indicator Lamp (MIL) - DTC P2195, P2197, P2626 And/Or P2629

Released 4/23/2018
2016-2017 Explorer roof rack cap trim clips now available.

Released 4/23/2018
2016-2017 3.5L and 3.7L Explorer Lower Roll Restrictor Rubber Strap Loose

Released 4/23/2018
2016-2017 Explorer - 3.5L/3.7L TiVCT - Rear Climate Control - Rear Blower Speed Erratic While Driving - Built on or Before 19-Apr-2017

Released 4/23/2018
2015-2017 Edge/MKX/Escape/MKC/Fusion/MKZ/Explorer - 2.0L/2.3L - Engine Appearance Cover Service Information

Released 4/23/2018
2016-2017 Ford And Lincoln Vehicles Equipped With SYNC 3 - Touchscreen Unresponsive

Released 4/23/2018
Multiple Vehicles - Safety Belt Retractor Webbing Does Not Extract From Stowed Position Or Exhibits Excessive Pressure On The Occupant During Use.

Released 4/23/2018
2016-2017 Various Vehicles - SYNC 3 - Blank Screen After Exiting Valet Mode

Released 4/23/2018
2016-2017 Multiple Vehicles - 2.0L/2.3L GTDI - Illuminated Malfunction Indicator Lamp (MIL) With Diagnostic Trouble Code (DTC) P0001

Released 4/23/2018
2013-2017 Various Vehicles - Ambient Air Temperature Sensor (AAT) Pinpoint Test Update In Workshop Manual (WSM) Section 413-01

Released 4/23/2018
Setting Correct Tire Pressure

Released 4/23/2018
2008-2017 Various Ford/Lincoln/Mercury Vehicles - Replacing/Upgrading Original Equipment SYNC/Navigation System Components Is Not Supported

Released 4/23/2018
2013-2017 Multiple Vehicles - 6F35/6F15 - Updated Front Pump Inspection Procedure

Released 4/23/2018
2011-2015 MKX And 2011-2017 Edge/Explorer/MKT/Flex/MKS/Taurus-Push Button Start-Shift To Park Or Transmission Not in Park Message-Discharged Battery/Unable To Remove Key

Released 4/23/2018
Multiple Vehicles - ABS Module - Programmable Module Installation (PMI) With Diagnostic Trouble Code (DTC) C1020

Released 4/23/2018
2008-2017 Ford/Mercury/Lincoln - Vehicle Health Report (VHR) Generates Service Required Message

Released 4/23/2018
2015-2018 - Explorer - Hankook Brand Tire - Chipping, Cutting And/Or Unusual/Accelerated Tread Wear

Released 4/23/2018
2013-2018 Transit Connect - Long Wheelbase - 60/40 left Side Second Row Seat Stuck Or Difficult To Fold/Unfold - Built On 9-Jan-2013 And Through 5-Jan-2018

Released 4/23/2018
Various Vehicles - 2.0L/2.3L/2.7L EcoBoost, 5.0L, 5.2L - Engine Oil Pressure (EOP) Sensor Oil Leak

Released 4/23/2018
2015-2018 Explorer - 2nd Row 60/40 Bench Seat - Left Seat Cushion Corner Loose And/Or Seat Foam Exposed

Released 4/23/2018
2016-2018 Explorer - Automatic Temperature Control With Premium AM/FM/CD - Temperature Control Switch Broken Or Missing

Released 4/23/2018
Accessory (Wireless) Keyless Entry Keypad Is Available With Remote Keyless Entry (RKE) Only And The Retrieval Of Master Code.

Released 4/23/2018
Dealer Installed Audio Upgrades

Released 4/23/2018
2009-2018 Various Vehicles - No Start - Illuminated MIL And Diagnostic Trouble Code (DTC) P161A After Powertrain Control Module (PCM) Replacement

Released 4/23/2018
2013-2018 Various Vehicles - 1.5L/2.3L/2.7L/3.0L EcoBoost, 2.5L - All Wheel Drive (AWD) - Power Transfer Unit (PTU) Intermediate Shaft Seal Fluid Leak

Released 4/23/2018
Various Vehicles - Data Link Connector (DLC) Connection - Vehicles Equipped With Gateway Module (GWM)

Released 4/23/2018
2011-2016 Multiple Vehicles – Universal Garage Door Programming Concerns

Released 4/23/2018
Some Vehicles Could Exhibit Misfire Codes After Certain Repairs - Multiple Vehicle Lines

Released 4/23/2018
2007-2016 Various Vehicles - All Wheel Drive (AWD) - Propane Or Natural Gas Odor During Idle Or Low Speed Driving - Built On Or Before 30-Jun-2016

Released 4/23/2018
Integrated Diagnostic System (IDS) Session File Upload Request When Replacing A Powertrain Control Module (PCM)

Released 4/23/2018
2008-2018 Various Ford/Lincoln/Mercury Vehicles - Replacing/Upgrading Original Equipment SYNC/Navigation System Components Is Not Supported

Released 4/23/2018
2013-2018 - Various Vehicles - Lane Keeping System (LKS) - Vibration/Steering Pull or Drift Concerns

Released 4/23/2018
2015-2018 Explorer - Hankook Brand 20 Inch Tire - Tread Wear Tire Replacement

Released 4/17/2018
Ambient Air Temperature (AAT) Sensor

Released 4/5/2018
2013-2018 Various Vehicles - Instrument Panel Cluster Mask / Lens Warranty

Released 3/29/2018
2010-2018 Various Vehicles - Ear Clamp Removal Procedure

Released 2/22/2018
Laminated/Tempered/Heated Glass Damage General Service Bulletin

Released 11/30/2017
Various Vehicles - Universal Serial Port (USB) Media Hub Warranty GSB

Released 11/3/2017
Passive Anti Theft System (PATS) Key Programming

Released 10/11/2017
Multiple Vehicles - Touch Screen Warranty GSB

Released 9/25/2017
Various Vehicles - Module Programming and Reprogramming Procedures

Released 8/22/2017
2000 And Newer Ford, Lincoln And Mercury Vehicles - Aluminum Panel Corrosion

Released 8/8/2017
2013 - 2017 Police Interceptor Utility - 3.7L Ti-VCT - Cracked One Piece Catalytic Converter Manifold

Released 8/7/2017
Engine Oil Maintenance Inspection

Released 6/28/2017
12 Volt Battery Charging and Testing Quick Reference Guide-

Released 6/26/2017
Multiple Vehicles - Wiring Repair / Harness Replacement - Best Practices for Warranty Claiming

Released 6/15/2017
Multiple Vehicles - Front Controls Interface Module (FCIM) Warrantable VS Non-warrantable Conditions General Service Bulletin (GSB)

Released 5/15/2017
2016-2017 Explorer/Police Utility - Exhaust Odor In Vehicle

Released 5/1/2017
Adaptive Cruise Control & Collision Warning Radar Alignment Process

Released 3/20/2017
2016-2017 Explorer - 2.3L Engine - Idle Speed Dropping Below Specification - Built On Or Before 28-Feb-2017

Released 3/10/2017
Multiple Vehicles- Interior Mirror General Service Bulletin (GSB)

Released 3/9/2017
Multiple Vehicles - Leather/Vinyl Seat Cover General Service Bulletin (GSB)

Released 2/23/2017
Multiple Vehicles- Body Interior Trim and Steering Wheel Damage vs. Defect General Service Bulletin (GSB)

Released 2/2/2017
Multiple Vehicles- Wiper Blade Warrantable Vs. Non-Warrantable General Service Bulletin (GSB)

Released 10/14/2016
Multiple Vehicles - Surface Preparation For Oil Leaks

Released 10/11/2016
2016 Explorer - Front Park Aid - Intermittent Front Park Aid Fault Message With Or Without Diagnostic Trouble Codes (DTCs) - Built On Or Before 10-May-2016

Released 10/7/2016
2015-2016 - 2.0L/2.5L/3.5L/3.7L - Illuminated Wrench Lamp With Intermittent Loss Of Power - DTCs P2111, P2112 And/Or P2119 - Built On Or Before 31-May-2016

Released 9/30/2016
Multiple Vehicles - SYNC Software Programming v1.1

Released 9/13/2016
2016 Explorer - 2.3L Gasoline Turbocharged Direct Injection (GTDI) - Illuminated Malfunction Indicator Lamp (MIL) - Lack Of Power - DTC P0299

Released 9/8/2016
Multiple Vehicles- Paint Defects / Damage General Service Bulletin (GSB)

Released 8/19/2016
Multiple Vehicles- Grille Defects / Damage General Service Bulletin (GSB)

Released 8/1/2016
2016 Explorer With Hands-Free Liftgate And Without Trailer Towing Package - Liftgate Opens When Walking Next To Rear Bumper

Released 7/26/2016
Multiple Vehicles - Historical Powertrain Diagnostic Trouble Codes (DTC) General Service Bulletin (GSB)

Released 7/11/2016
2009-2010 F-150, 2011-2016 Explorer - Front Seat Cushion Cover Loose

Released 6/28/2016
3.5L - Illuminated MIL - DTC P0011, P0015, P0016, P0017, P0018, P0019, P0021 And/Or P0025 - Under 3200 Km (2000 Miles)

Released 6/15/2016
2016 Explorer And MKX - Incorrect Memory Seat Operation And/Or Easy Entry/Exit Seat Operation - Built On Or Before 3/11/2016

Released 6/14/2016
Multiple Vehicles - Engine Oil White Fluorescent Dye Usage General Service Bulletin (GSB)

Released 5/3/2016
2015-2016 Edge And 2016 Explorer - Climate Controlled Seats - Lack Of Cooling Performance From The Front Seat Backrest - Built On Or Before 2/12/2016

Released 4/27/2016
Multiple Vehicles - No PCM/Network Communication

Released 4/8/2016
Multiple Vehicles - Automatic Transmission Main Control Inspection - General Service Bulletin (GSB)

Released 3/30/2016
Multiple Vehicles- Exterior Mirror General Service Bulletin (GSB)

Released 3/23/2016
Multiple Vehicles- Glass Panel Build Date Decoder General Service Bulletin (GSB)

Released 2/24/2016
Multiple Vehicles - Coolant Pump Inspection - General Service Bulletin (GSB)

Released 2/22/2016
2016 Explorer - Body Creak/Pop Noise Over Bumps - Right Front Subframe Bolt Area - Built On Or Before 1/31/2016

Released 2/19/2016
2.0 AND 2.3L GTDI - Illuminated MIL - DTC P0011, P0016, P0015 And/Or P0017 - Under 3200 Km (2000 Miles)

Released 2/5/2016
Multiple Vehicles- Bumper Warrantable / Non-Warrantable General Service Bulletin (GSB)

Released 1/28/2016
Multiple Vehicles - Driver On Coil Ignition Test - 3 Wire Coils - General Service Bulletin (GSB)

Released 1/27/2016
2004 And Newer Vehicles Equipped With Flex Fuel Capability - Flex Fuel General Service Bulletin (GSB)

Released 1/27/2016
Multiple Vehicles - Environmental Fallout Paint Damage General Service Bulletin (GSB)

Released 1/25/2016
Multiple Vehicles- Exterior Lighting Condensation Warranty Coverage General Service Bulletin (GSB)

Released 1/19/2016
2016 Explorer Police Utility - 3.7L TiVCT - Delayed Upshift At Speeds Close To 160 Km/h (100 MPH) - Built On Or Before 11/16/2015

Released 1/15/2016
Multiple Vehicles - Electric Power Assist System (EPAS) Pull Drift Compensation General Service Bulletin (GSB)

Released 1/5/2016
Multiple Vehicles - Chrome Running Boards Defects Vs. Damage General Service Bulletin (GSB)

Released 12/23/2015
2014-2016 Explorer - Air Bag Warning Light Illuminated With Diagnostic Trouble Codes (DTCs) B141B And/Or B141C

Released 12/17/2015
Multiple Vehicles - How To Upload An IDS Session File - General Service Bulletin (GSB)

Released 12/15/2015
Multiple Vehicles - Transmission Cooler Flush General Service Bulletin (GSB)

Released 12/14/2015
Multiple Vehicles - PCM Ignition Coil Driver Test - 2 Wire Coil - General Service Bulletin (GSB)

Released 12/10/2015
2016 Explorer - Genuine Ford Accessory Installed Remote Start - Park Lamps Do Not Illuminate During Remote Start

Released 12/10/2015
Various 2013 and newer vehicles - Supplemental Restraints System (SRS) Air Bag Squib Connector GSB

Released 12/9/2015
Multiple Vehicles - Tire Pressure Monitor System (TPMS) General Service Bulletin (GSB)

Released 12/8/2015
2016 Explorer - 2.3L GTDI And 3.5L Duratec With Active Grille Shutters - Snapping or Popping Sound After Start-Up - Built On Or Before 11/24/2015

Released 12/8/2015
Multiple Vehicles - Engine Failure Analysis General Service Bulletin (GSB)

Released 11/24/2015
Various Vehicles - Live Network Monitor Test Usage

Released 11/24/2015
Multiple Vehicles - PSCM Wiring Harness Inspection Checklist General Service Bulletin (GSB)

Released 11/24/2015
Multiple Vehicles- Body Gap Flushness Measurement Tools General Service Bulletin (GSB)

Released 11/5/2015
Multiple Vehicles - Wheel Concern Analysis General Service Bulletin (GSB)

Released 10/19/2015
Multiple Vehicle Lines Equipped With 2.0L GTDI Or 2.3L GTDI – Front Wheel Drive Equipped - Vibration And/Or Grinding/Banging/Clicking Noise

Released 10/14/2015
Multple Vehicles - Wiring Repair General Service Bulletin (GSB)

Released 10/12/2015
Multiple Vehicles- Tape Stripe General Service Bulletin (GSB)

Released 10/2/2015
2016 Explorer - 3.5L GTDI - Malfunction Indicator Lamp (MIL) On With DTC P0012 And/Or P0022 - Built On Or Before 9/12/2015

Released 9/17/2015
2011-2016 Explorer - Whistle Or Buzz-Type Noise From Front Cowl Panel Grille Cover At Highway Speeds

Released 9/11/2015
2013 And Newer Vehicles - Gasoline Engine - Adaptive Fuel Viewer GSB

Released 8/20/2015
2015-2016 Multiple Vehicles- New SYNC Accessory Protocol Interface Module (APIM) System Reset General Service Bulletin (GSB)

Released 8/18/2015
Multiple Vehicles - Cloth Seat Cover General Service Bulletin (GSB)

Released 9/4/2012
Multiple Vehicles - Lower End Engine Noise Diagnostic Aid - Inspecting the Oil Filter Element General Service Bulletin (GSB)

Released 5/24/2010
Multiple Vehicles - Brake Disc Service Tips General Service Bulletin (GSB)

Released 1/29/2020
2011-2019 Explorer - Factory Keyless Entry Keypad - Driver Side B-Pillar Front Door Upper Moulding Loose

Released 1/29/2020
2016-2017 Explorer - Front Window Glass Jumps/Chatters During Up/Down Travel

Released 1/29/2020
2012-2019 Various Vehicles - Battery Cable Clamp Corrosion Repair

Released 1/29/2020
2016-2019 Explorer - Heated Seat Lower Cushion Inoperative After Remote Start

Released 6/27/2019
2016-2019 Various Vehicles - SYNC 3 - SYNC WiFi Update Message Displayed Every Key Cycle

Released 6/27/2019
SYNC 3 Intermittent Blank/Black Screen Diagnostics

Released 6/27/2019
Various Vehicles - Clock Master

Released 6/27/2019
LVDS and USB Cable Tester

Released 6/27/2019
Various Vehicles - Exterior Lighting Concern Analysis

Released 6/27/2019
2017-2019 F-Super Duty, 2017-2019 Continental, 2016-2018 Explorer/Police Interceptor Utility - Various Electrical Symptoms - BJB Relay Module

Released 6/27/2019
2012-2019 Various Vehicles - Smartlink Repairs

Released 6/27/2019
2013-2018 Various Ford And Lincoln Vehicles - Adaptive Cruise Control/Collision Warning Inoperative - DTC U3000:49 In CCM - Built On Or Before 19-Oct-2017

Released 6/27/2019
2016-2017 Explorer/Police Interceptor Utility - 3.5L EcoBoost - Illuminated MIL - DTCs P0325, P0327, P0330 And/Or P0332 - Built On Or Before 30-Sep-2016

Released 6/27/2019
2016-2017 Explorer - Front Window Glass Jumps/Chatters During Up/Down Travel

Released 6/27/2019
2013-2019 Explorer - 2.3L EcoBoost - Accessory Drive Belt Noise And/Or Charging System Warning Indicator Illuminated

Released 6/27/2019
2016-2019 Police Interceptor Utility - Front Amber Marker Lamps Flicker Only With Engine Running

Released 12/11/2018
Various Vehicles - Data Link Connector (DLC) Connection - Vehicles Equipped With Gateway Module (GWM)

Released 12/11/2018
2016-2018 Explorer/Police Interceptor Utility - Inoperative Power Windows/Power Mirrors/Roof Opening Panel/Roof Opening Panel Shield And/Or DTC B1088

Released 12/11/2018
2016-2018 Police Utility - Enabling Remote Keyless Entry (RKE)

Released 5/1/2018
Ambient Air Temperature (AAT) Sensor

Released 4/27/2018
LVDS and USB Cable Tester General Service Bulletin

Released 4/23/2018
2016 - Edge/Explorer/F-150/Mustang - Front Control/Display Interface Module (FCDIM) Blank Screen With 4.2-Inch Display - Built On Or Before 01-Nov-2016

Released 4/23/2018
2015-2016 Various Ford Vehicles - SYNC Gen 1 With 4.2 Inch Display - Bluetooth Pairing And Connection Concerns - Built On Or Before 1/24/2016

Released 4/23/2018
2016 F150, Mustang And Explorer - No Audio After Starting The Engine - Screen Displays Loading Or Audio Off Message - Built On Or Before 4/15/2016

Released 4/23/2018
2016 Explorer - Genuine Ford Accessory Installed Remote Start - Instrument Panel Cluster (IPC) Remote Start / Climate Control Menu Items Grayed Out

Released 4/23/2018
Various Vehicles - Perimeter Alarm Armed And Original Vehicle Keys Cannot Be Accessed to Enter Vehicle - CAN Protection Strategy

Released 4/23/2018
2016 Explorer with 3.5L Gasoline Turbocharged Direct Injection (GTDI) Engine, P0327/P0332

Released 4/23/2018
Various Vehicles - Adaptive Cruise Control Equipped - Unexpected Brief Reduction In Speed

Released 4/23/2018
Vehicle Health Report Inoperative with Aftermarket Device Plugged Into Data Link Connector

Released 4/23/2018
2016-2017 Explorer - Manual Front Passenger Seat Track - Stuck In Forward Position

Released 4/23/2018
2016-2017 Explorer/Taurus/Police Interceptor/MKS/Flex/MKT - 3.5L GTDI - Blue Or White Smoke From Exhaust While Driving After Extended Idle

Released 4/23/2018
2016-2018 Police Utility - Enabling Remote Keyless Entry (RKE)

Released 4/23/2018
2016-2018 Police Utility - Front Amber Marker Lamps Flicker Only With Engine Running

Released 4/23/2018
2011-2016 Various Vehicles - Ambient Air Temperature Sensor (AAT) Pinpoint Test FA And FB Updated

Released 4/23/2018
2016-2018 Explorer - Base Model - Headlamp Signature Lighting Light Emitting Diodes (LEDs)

Released 4/23/2018
2016-2017 Ford And Lincoln Vehicles Equipped With SYNC 3 - Touchscreen Unresponsive

Released 4/23/2018
2016-2017 Various Vehicles - SYNC 3 - Blank Screen After Exiting Valet Mode

Released 4/23/2018
2016-2017 Multiple Vehicles - 2.0L/2.3L GTDI - Illuminated Malfunction Indicator Lamp (MIL) With Diagnostic Trouble Code (DTC) P0001

Released 4/23/2018
2013-2017 Various Vehicles - Ambient Air Temperature Sensor (AAT) Pinpoint Test Update In Workshop Manual (WSM) Section 413-01

Released 4/23/2018
2008-2017 Various Ford/Lincoln/Mercury Vehicles - Replacing/Upgrading Original Equipment SYNC/Navigation System Components Is Not Supported

Released 4/23/2018
Multiple Vehicles - ABS Module - Programmable Module Installation (PMI) With Diagnostic Trouble Code (DTC) C1020

Released 4/23/2018
2008-2017 Ford/Mercury/Lincoln - Vehicle Health Report (VHR) Generates Service Required Message

Released 4/23/2018
2013-2018 Transit Connect - Long Wheelbase - 60/40 left Side Second Row Seat Stuck Or Difficult To Fold/Unfold - Built On 9-Jan-2013 And Through 5-Jan-2018

Released 4/23/2018
2016-2018 Explorer - Automatic Temperature Control With Premium AM/FM/CD - Temperature Control Switch Broken Or Missing

Released 4/23/2018
Accessory (Wireless) Keyless Entry Keypad Is Available With Remote Keyless Entry (RKE) Only And The Retrieval Of Master Code.

Released 4/23/2018
Dealer Installed Audio Upgrades

Released 4/23/2018
2009-2018 Various Vehicles - No Start - Illuminated MIL And Diagnostic Trouble Code (DTC) P161A After Powertrain Control Module (PCM) Replacement

Released 4/23/2018
Various Vehicles - Data Link Connector (DLC) Connection - Vehicles Equipped With Gateway Module (GWM)

Released 4/23/2018
2011-2016 Multiple Vehicles – Universal Garage Door Programming Concerns

Released 4/23/2018
Some Vehicles Could Exhibit Misfire Codes After Certain Repairs - Multiple Vehicle Lines

Released 4/23/2018
2007-2016 Various Vehicles - All Wheel Drive (AWD) - Propane Or Natural Gas Odor During Idle Or Low Speed Driving - Built On Or Before 30-Jun-2016

Released 4/23/2018
Integrated Diagnostic System (IDS) Session File Upload Request When Replacing A Powertrain Control Module (PCM)

Released 4/17/2018
Ambient Air Temperature (AAT) Sensor

Released 11/30/2017
Various Vehicles - Universal Serial Port (USB) Media Hub Warranty GSB

Released 10/11/2017
Multiple Vehicles - Touch Screen Warranty GSB

Released 6/28/2017
12 Volt Battery Charging and Testing Quick Reference Guide-

Released 6/26/2017
Multiple Vehicles - Wiring Repair / Harness Replacement - Best Practices for Warranty Claiming

Released 6/19/2017
Permanent DTC Overview

Released 3/20/2017
2016-2017 Explorer - 2.3L Engine - Idle Speed Dropping Below Specification - Built On Or Before 28-Feb-2017

Released 10/7/2016
2015-2016 - 2.0L/2.5L/3.5L/3.7L - Illuminated Wrench Lamp With Intermittent Loss Of Power - DTCs P2111, P2112 And/Or P2119 - Built On Or Before 31-May-2016

Released 9/30/2016
Multiple Vehicles - SYNC Software Programming v1.1

Released 9/13/2016
2016 Explorer - 2.3L Gasoline Turbocharged Direct Injection (GTDI) - Illuminated Malfunction Indicator Lamp (MIL) - Lack Of Power - DTC P0299

Released 8/1/2016
2016 Explorer With Hands-Free Liftgate And Without Trailer Towing Package - Liftgate Opens When Walking Next To Rear Bumper

Released 7/26/2016
Multiple Vehicles - Historical Powertrain Diagnostic Trouble Codes (DTC) General Service Bulletin (GSB)

Released 7/11/2016
2009-2010 F-150, 2011-2016 Explorer - Front Seat Cushion Cover Loose

Released 6/28/2016
3.5L - Illuminated MIL - DTC P0011, P0015, P0016, P0017, P0018, P0019, P0021 And/Or P0025 - Under 3200 Km (2000 Miles)

Released 5/3/2016
2015-2016 Edge And 2016 Explorer - Climate Controlled Seats - Lack Of Cooling Performance From The Front Seat Backrest - Built On Or Before 2/12/2016

Released 4/27/2016
Multiple Vehicles - No PCM/Network Communication

Released 2/24/2016
Multiple Vehicles - Coolant Pump Inspection - General Service Bulletin (GSB)

Released 2/19/2016
2.0 AND 2.3L GTDI - Illuminated MIL - DTC P0011, P0016, P0015 And/Or P0017 - Under 3200 Km (2000 Miles)

Released 2/5/2016
Multiple Vehicles- Bumper Warrantable / Non-Warrantable General Service Bulletin (GSB)

Released 1/28/2016
Multiple Vehicles - Driver On Coil Ignition Test - 3 Wire Coils - General Service Bulletin (GSB)

Released 1/15/2016
Multiple Vehicles - Electric Power Assist System (EPAS) Pull Drift Compensation General Service Bulletin (GSB)

Released 12/23/2015
2014-2016 Explorer - Air Bag Warning Light Illuminated With Diagnostic Trouble Codes (DTCs) B141B And/Or B141C

Released 12/17/2015
Multiple Vehicles - How To Upload An IDS Session File - General Service Bulletin (GSB)

Released 12/14/2015
Multiple Vehicles - PCM Ignition Coil Driver Test - 2 Wire Coil - General Service Bulletin (GSB)

Released 12/10/2015
2016 Explorer - Genuine Ford Accessory Installed Remote Start - Park Lamps Do Not Illuminate During Remote Start

Released 12/10/2015
Various 2013 and newer vehicles - Supplemental Restraints System (SRS) Air Bag Squib Connector GSB

Released 11/24/2015
Various Vehicles - Live Network Monitor Test Usage

Released 11/24/2015
Multiple Vehicles - PSCM Wiring Harness Inspection Checklist General Service Bulletin (GSB)

Released 10/14/2015
Multple Vehicles - Wiring Repair General Service Bulletin (GSB)

Released 10/2/2015
2016 Explorer - 3.5L GTDI - Malfunction Indicator Lamp (MIL) On With DTC P0012 And/Or P0022 - Built On Or Before 9/12/2015

Released 9/11/2015
2013 And Newer Vehicles - Gasoline Engine - Adaptive Fuel Viewer GSB

Released 8/20/2015
2015-2016 Multiple Vehicles- New SYNC Accessory Protocol Interface Module (APIM) System Reset General Service Bulletin (GSB)

Released 4/23/2018
Integrated Diagnostic System (IDS) Session File Upload Request When Replacing A Powertrain Control Module (PCM)

Released 6/19/2017
Permanent DTC Overview

Released 12/11/2018
2013-2018 Police Interceptor Utilty - 3.7L TiVCT - Illuminated Malfunction Indicator Lamp (MIL) - Diagnostic Trouble Code (DTC) P0420 And/Or P0430

Released 4/23/2018
2013-2017 Explorer/Taurus/MKS/Police Utility/Police Sedan - Exhaust Studs Not Missing

Released 8/8/2017
2013 - 2017 Police Interceptor Utility - 3.7L Ti-VCT - Cracked One Piece Catalytic Converter Manifold

Released 4/23/2018
2016 Explorer/Flex/MKT/Taurus/MKS/Transit - 3.5L Gasoline Turbocharged Direct Injection (GTDI) - Illuminated MIL - DTCs P2096, P2097, P2098 And/Or P2099

Released 1/27/2016
2004 And Newer Vehicles Equipped With Flex Fuel Capability - Flex Fuel General Service Bulletin (GSB)

Released 1/29/2020
2008-2019 Various Ford/Lincoln/Mercury Vehicles - Inoperative Heating, Ventilation, And Air Conditioning (HVAC) Blower Motor

Released 6/27/2019
2013-2019 Various Vehicles - External Variable Displacement Control (EVDC) A/C Compressor Diagnostic Tool

Released 6/27/2019
2008-2019 Various Ford/Lincoln/Mercury Vehicles - Inoperative Heating, Ventilation, And Air Conditioning (HVAC) Blower Motor

Released 12/11/2018
2016-2018 Explorer - Air Conditioning (A/C) Defaults to Heat And Defrost During Remote Start - Built On Or Before 07-Aug-2018

Released 4/23/2018
2016-2017 Explorer - 3.5L/3.7L TiVCT - Rear Climate Control - Rear Blower Speed Erratic While Driving - Built on or Before 19-Apr-2017

Released 4/23/2018
2013-2017 Various Vehicles - Ambient Air Temperature Sensor (AAT) Pinpoint Test Update In Workshop Manual (WSM) Section 413-01

Released 5/15/2017
2016-2017 Explorer/Police Utility - Exhaust Odor In Vehicle

Released 1/29/2020
2015-2019 Various Vehicles - No Crank - Security Access Error Code 232: Key Table Not Allocated

Released 6/27/2019
Various Vehicles - Automatic Transmission - Multi Purpose Grease Application On Torque Converter Pilot Hub And Presence Of Engine And Crank Alignment Dowels

Released 6/27/2019
2010-2019 Various Vehicles - Turbocharged Engines - Oil Supply Filter Replacement When Replacing The Turbocharger Or The Turbocharger Oil Supply Tube

Released 6/27/2019
2013-2018 Various Vehicles - All Wheel Drive (AWD) - Right Side Transfer Case Fluid Leak

Released 6/27/2019
2015-2016 Edge/MKX/Flex/MKT/MKZ/Taurus/Taurus Police/Explorer/Explorer Police - 3.7L Or 3.5L - AWD - PTU Venting, Noise, Odor - Built On Or Before 10-Jun-2016

Released 6/27/2019
2016-2017 Explorer/Police Interceptor Utility - 3.5L EcoBoost - Illuminated MIL - DTCs P0325, P0327, P0330 And/Or P0332 - Built On Or Before 30-Sep-2016

Released 6/27/2019
2013-2016 MKS, 2013-2019 Explorer/Taurus/Police Interceptor Utility/Police Interceptor Sedan - Exhaust Studs May Appear To Be Missing

Released 6/27/2019
2013-2019 Explorer - 2.3L EcoBoost - Accessory Drive Belt Noise And/Or Charging System Warning Indicator Illuminated

Released 12/11/2018
2013-2019 Police Interceptor Sedan/Utility Top Speed Reduced After Transmission Service

Released 12/11/2018
2001-2019 Various Vehicles - 2.0L, 2.3L, And 2.5L 4-Cylinder Engine - Rear Main Seal Kit Tool Usage

Released 12/11/2018
Multiple Vehicle Lines - Revised Engine Oil Leak Diagnostic Procedure Using New White Fluorescent Dye

Released 12/11/2018
2013-2018 Police Interceptor Utility - 3.7L TiVCT - Engine Vibration And/Or Engine Mount Leaking

Released 12/11/2018
2015-2017 Explorer/Police Interceptor Utility - 3.5L EcoBoost - Surge Or Hesitation At 50-60 MPH - No Diagnostic Trouble Codes (DTCs)

Released 12/11/2018
2013-2018 Various Vehicles - All Wheel Drive (AWD) - Right Side Transfer Case Fluid Leak

Released 6/7/2018
Various Vehicles - Engine Failure Analysis General Service Bulletin (GSB)

Released 4/23/2018
2013-2016 Various Vehicles - 6F35 Equipped - 2-3 Shift Hesitation After A Cold Soak

Released 4/23/2018
2012-2016 Escape, Fusion, Explorer, 2012-2015 Edge, 2013-2016 MKZ 2015-2016 MKC, 2016 MKX - Transfer Case - New Service Tool For Intermediate Shaft Seal

Released 4/23/2018
2016 Explorer/Flex/MKT/Taurus/MKS/Transit - 3.5L Gasoline Turbocharged Direct Injection (GTDI) - Illuminated MIL - DTCs P2096, P2097, P2098 And/Or P2099

Released 4/23/2018
2011-2016 Explorer/Taurus/Flex/MKT/MKS - 2.0L/2.3L/3.5L/3.7L - Ting/Pop/Click/Continuous Tick Noise - Front Halfshaft

Released 4/23/2018
2007-2016 Edge/MKX/Flex/MKT/MKZ/MKS/Taurus/Taurus Police/Explorer/Explorer Police – AWD - Ticking/Knocking Noise From Driveline – Built On Or Before 30-Jun-2016

Released 4/23/2018
2014-2016 Multiple Vehicles - 6F35 - Harsh Reverse And Harsh/Delayed 3rd And 5th Up/Down Shifts - Without DTCs - Built On 1-Jan-2014 And Through 31-Dec-2015

Released 4/23/2018
2013-2016 Edge, Flex, MKX, MKS, MKT, MKZ, Taurus, Police Sedan, Explorer, Police Utility - 6F50/6F55 Transmission Fluid Leak From Converter Housing

Released 4/23/2018
2016 Explorer Built On Or Before 5/8/2016 - Cooling Fan Noise

Released 4/23/2018
2013-2016 Taurus Police And Explorer Police Top Speed Reduced After Transmission Service

Released 4/23/2018
2016-2017 Explorer/Taurus/Police Interceptor/MKS/Flex/MKT - 3.5L GTDI - Blue Or White Smoke From Exhaust While Driving After Extended Idle

Released 4/23/2018
2016-2018 Explorer roof rack cap trim clips now available.

Released 4/23/2018
2015-2017 Explorer, 2015-2016 F-150 - 3.5L GTDI - Illuminated Malfunction Indicator Lamp (MIL) - DTC P2195, P2197, P2626 And/Or P2629

Released 4/23/2018
2011-2015 MKX And 2011-2017 Edge/Explorer/MKT/Flex/MKS/Taurus-Push Button Start-Shift To Park Or Transmission Not in Park Message-Discharged Battery/Unable To Remove Key

Released 4/23/2018
Various Vehicles - 2.0L/2.3L/2.7L EcoBoost, 5.0L, 5.2L - Engine Oil Pressure (EOP) Sensor Oil Leak

Released 4/23/2018
2009-2018 Various Vehicles - No Start - Illuminated MIL And Diagnostic Trouble Code (DTC) P161A After Powertrain Control Module (PCM) Replacement

Released 4/23/2018
2013-2018 Various Vehicles - 1.5L/2.3L/2.7L/3.0L EcoBoost, 2.5L - All Wheel Drive (AWD) - Power Transfer Unit (PTU) Intermediate Shaft Seal Fluid Leak

Released 4/23/2018
Some Vehicles Could Exhibit Misfire Codes After Certain Repairs - Multiple Vehicle Lines

Released 8/7/2017
Engine Oil Maintenance Inspection

Released 5/1/2017
Adaptive Cruise Control & Collision Warning Radar Alignment Process

Released 3/20/2017
2016-2017 Explorer - 2.3L Engine - Idle Speed Dropping Below Specification - Built On Or Before 28-Feb-2017

Released 10/14/2016
Multiple Vehicles - Surface Preparation For Oil Leaks

Released 6/14/2016
Multiple Vehicles - Engine Oil White Fluorescent Dye Usage General Service Bulletin (GSB)

Released 4/8/2016
Multiple Vehicles - Automatic Transmission Main Control Inspection - General Service Bulletin (GSB)

Released 1/19/2016
2016 Explorer Police Utility - 3.7L TiVCT - Delayed Upshift At Speeds Close To 160 Km/h (100 MPH) - Built On Or Before 11/16/2015

Released 12/15/2015
Multiple Vehicles - Transmission Cooler Flush General Service Bulletin (GSB)

Released 12/8/2015
Multiple Vehicles - Engine Failure Analysis General Service Bulletin (GSB)

Released 10/19/2015
Multiple Vehicle Lines Equipped With 2.0L GTDI Or 2.3L GTDI – Front Wheel Drive Equipped - Vibration And/Or Grinding/Banging/Clicking Noise

Released 9/4/2012
Multiple Vehicles - Lower End Engine Noise Diagnostic Aid - Inspecting the Oil Filter Element General Service Bulletin (GSB)

Released 6/27/2019
Various Vehicles - Diagnostic Trouble Code (DTC) P1635

Released 12/12/2018
Various Vehicles - Wheel Concern Analysis General Service Bulletin

Released 12/11/2018
2013-2019 Various Vehicles - Lane Keeping System (LKS) - Vibration/Steering Pull Or Drift Concerns

Released 4/23/2018
2015 Edge, F150, Mustang and 2016 Explorer and MKX - Tire Pressure Monitoring System (TPMS) Sensors Difficult To Train

Released 4/23/2018
Setting Correct Tire Pressure

Released 4/23/2018
2015-2018 - Explorer - Hankook Brand Tire - Chipping, Cutting And/Or Unusual/Accelerated Tread Wear

Released 4/23/2018
2013-2018 - Various Vehicles - Lane Keeping System (LKS) - Vibration/Steering Pull or Drift Concerns

Released 3/23/2016
Multiple Vehicles- Glass Panel Build Date Decoder General Service Bulletin (GSB)

Released 12/9/2015
Multiple Vehicles - Tire Pressure Monitor System (TPMS) General Service Bulletin (GSB)

Released 11/5/2015
Multiple Vehicles - Wheel Concern Analysis General Service Bulletin (GSB)

Released 12/11/2018
Multiple Vehicle Lines - Revised Engine Oil Leak Diagnostic Procedure Using New White Fluorescent Dye

Released 12/11/2018
2013-2018 Various Vehicles - All Wheel Drive (AWD) - Right Side Transfer Case Fluid Leak

Released 5/8/2018
Glass Concern Analysis and Build Date Decoder

Released 4/27/2018
LVDS and USB Cable Tester General Service Bulletin