Get Free 2008 FORD EXPEDITION V8, 5.4L; SOHC TSBs

Released 4/23/2018
New Wiring Repair Job Aid is available on PTS under the Service Tips tab

Released 4/23/2018
2001-2015 - Vehicles With Modular 4.6L, 5.4L Or 6.8L Engines - Determining Root Cause Of Engine Damage Due To Oil Pressure Loss.

Released 4/23/2018
2008-2018 Various Ford/Lincoln/Mercury Vehicles - Replacing/Upgrading Original Equipment SYNC/Navigation System Components Is Not Supported

Released 4/23/2018
Various Vehicles - 4.6L/5.4L/6.8L 3 Valve - Engine Noise Upper End And/Or Rough Running - Camshaft Roller Follower Replacement - Built On Or Before 8-Jan-2016

Released 4/23/2018
2008-2017 Various Ford/Lincoln/Mercury Vehicles - Replacing/Upgrading Original Equipment SYNC/Navigation System Components Is Not Supported

Released 4/23/2018
Dealer Installed Audio Upgrades

Released 4/23/2018
Accessory (Wireless) Keyless Entry Keypad Is Available With Remote Keyless Entry (RKE) Only And The Retrieval Of Master Code.

Released 4/23/2018
VEHICLES WITH P035X (OR P0351 - P0360) DTC CODES

Released 4/23/2018
2007-2008 EXPEDITION, NAVIGATOR - P0563 SYSTEM VOLTAGE HIGH

Released 4/23/2018
2005-2008 Remanufactured 5.4L 3v and 6.8L 3v - Ignition Coil Boots Included with Engine Packaging.

Released 4/23/2018
VISIBLE GREASE PURGE -FRONT HUB AND BEARING ASSEMBLY

Released 4/23/2018
Multiple Vehicles - Powerfold And/Or Telescoping Trailer Tow Mirrors- Shakes/Vibrates And/Or Changes Position While Driving

Released 4/23/2018
Vehicle No Start After Instrument Cluster Replacement Due to Proper Programmable Module Installation (PMI) Programming Not Being Performed.

Released 4/23/2018
Multi Vehicle Line - Receiver Dryer Cartridge Service Part Design Change

Released 9/25/2017
Various Vehicles - Module Programming and Reprogramming Procedures

Released 8/22/2017
2000 And Newer Ford, Lincoln And Mercury Vehicles - Aluminum Panel Corrosion

Released 9/30/2016
Multiple Vehicles - SYNC Software Programming v1.1

Released 4/27/2016
Multiple Vehicles - No PCM/Network Communication

Released 1/27/2016
2004 And Newer Vehicles Equipped With Flex Fuel Capability - Flex Fuel General Service Bulletin (GSB)

Released 12/15/2015
Multiple Vehicles - Transmission Cooler Flush General Service Bulletin (GSB)

Released 12/9/2015
Multiple Vehicles - Tire Pressure Monitor System (TPMS) General Service Bulletin (GSB)

Released 12/8/2015
Multiple Vehicles - Engine Failure Analysis General Service Bulletin (GSB)

Released 10/14/2015
Multple Vehicles - Wiring Repair General Service Bulletin (GSB)

Released 8/20/2015
Multiple Vehicles - 4.6L 3v And 5.4L 3v Engines - 3v Cam Phaser Installation General Service Bulletin (GSB)

Released 5/24/2010
Multiple Vehicles - Brake Disc Service Tips General Service Bulletin (GSB)

Released 5/6/2009
LONG WHEEL BASE (LWB) - FUEL GAUGE READS BETWEEN 3/4 AND 7/8 WHEN FULL

Released 11/25/2008
WATER LEAKS - ROOF OPENING PANEL DURING HIGH PRESSURE CAR WASH

Released 11/10/2008
INOPERATIVE OR NO COMMUNICATION WITH DUAL CLIMATE CONTROL SEAT MODULE (DCSM)

Released 9/9/2008
REAR POWER WINDOWS OPERATE SLOW / BIND / TSB 08-19-4 STICK—BUILT ON OR BEFORE 10/8/2007

Released 8/27/2008
POWER LIFTGATE—GRUNT/GROAN/SQUEAL NOISE

Released 8/19/2008
TICKING OR CREAKING SOUND—INSTRUMENT PANEL AREA

Released 7/2/2008
POWER LIFT GATE INOPERATIVE—ALL FUNCTIONAL SWITCHES, REMOTE KEYLESS ENTRY, WITH POWER LIFT GATE TRUNK MODULE DTC B117B

Released 2/21/2008
SATELLITE DIGITAL AUDIO RECEIVER SYSTEM (SDARS), MAY NOT SEEK ALL SIRIUS SATELLITE RADIO CHANNELS

Released 2/7/2008
COLD START FEAD HOOT—WHISTLE NOISE / BUILT BEFORE 1/28/2008

Released 1/7/2008
WATER LEAK—ROOF OPENING PANEL DURING HIGH PRESSURE CAR WASH

Released 10/24/2007
POOR SEAT COOLING PERFORMANCE—BUILT BEFORE 7/16/2007

Released 10/17/2007
GAP/FIT—HEADLINER TO ROOF OPENING PANEL

Released 10/11/2007
CLIMATE CONTROL SEAT FUNCTION INOPERATIVE—NO COMMUNICATION—DCSM— VEHICLES BUILT PRIOR TO 8/31/2007

Released 9/24/2007
SNAPPING/POPPING NOISE—DRIVER SIDE TSB 07-20-4 POWERFOLD MIRROR—BUILT FROM 5/7/2007 TO 7/16/2007

Released 6/26/2008
STABILITY/TRACTION CONTROL INDICATOR— TSB 08-14-2 SLIDING-CAR ICON—ON OR FLASHING—DTC C1996 OR SENSITIVE ESC/RSC ACTIVATION NO CODES

Released 4/23/2018
Dealer Installed Audio Upgrades

Released 4/23/2018
Accessory (Wireless) Keyless Entry Keypad Is Available With Remote Keyless Entry (RKE) Only And The Retrieval Of Master Code.

Released 4/23/2018
VEHICLES WITH P035X (OR P0351 - P0360) DTC CODES

Released 4/23/2018
2007-2008 EXPEDITION, NAVIGATOR - P0563 SYSTEM VOLTAGE HIGH

Released 4/23/2018
2005-2008 Remanufactured 5.4L 3v and 6.8L 3v - Ignition Coil Boots Included with Engine Packaging.

Released 4/23/2018
Multiple Vehicles - Powerfold And/Or Telescoping Trailer Tow Mirrors- Shakes/Vibrates And/Or Changes Position While Driving

Released 4/23/2018
Vehicle No Start After Instrument Cluster Replacement Due to Proper Programmable Module Installation (PMI) Programming Not Being Performed.

Released 9/30/2016
Multiple Vehicles - SYNC Software Programming v1.1

Released 4/27/2016
Multiple Vehicles - No PCM/Network Communication

Released 10/14/2015
Multple Vehicles - Wiring Repair General Service Bulletin (GSB)

Released 9/30/2009
SPEAKER POP AND/OR RADIO INOPERATIVE/BLANK/LOCKED UP

Released 5/1/2009
COLD START FEAD HOOT - WHISTLE NOISE

Released 10/3/2008
SYNC SOFTWARE PROGRAMMING SERVICE TIPS

Released 9/24/2008
STEERING WHEEL ANGLE CIRCUIT AND/OR SIGNAL TSB 08-20-8 FAILURE—C1277-C1278—BUILT ON/OR BEFORE 4/10/2008

Released 8/4/2008
DIAGNOSTIC TROUBLE CODES (DTCS) P0345 AND/OR P0349—NO DRIVEABILITY SYMPTOMS, MIL LIGHT ON

Released 6/5/2008
INOPERATIVE RKE TRANSMITTER (KEY FOB)— DISCHARGED KEY FOB BATTERY

Released 3/5/2008
DISCHARGED BATTERIES—VEHICLES IN STORAGE/LIMITED USAGE

Released 2/21/2008
SATELLITE DIGITAL AUDIO RECEIVER SYSTEM (SDARS), MAY NOT SEEK ALL SIRIUS SATELLITE RADIO CHANNELS

Released 10/24/2007
POOR SEAT COOLING PERFORMANCE—BUILT BEFORE 7/16/2007

Released 8/4/2008
DIAGNOSTIC TROUBLE CODES (DTCS) P0345 AND/OR P0349—NO DRIVEABILITY SYMPTOMS, MIL LIGHT ON

Released 2/7/2008
MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC)—P0456

Released 9/4/2008
LONG WHEEL BASE (LWB)—FUEL GAUGE READS BETWEEN 3/4 AND 7/8 WHEN FULL

Released 4/25/2008
WHISTLE NOISE FROM THE HEATER/AIR CONDITIONING WHILE CHANGING TEMPERATURE SETTING—BUILT ON OR BEFORE 12/4/2007

Released 4/1/2008
SPARK PLUG REMOVAL INSTRUCTIONS—4.6L 3V/5.4L 3V/6.8L 3V

Released 11/27/2007
ENGINE MISFIRE DURING CRUISE WITH OR WITHOUT DTCS (MEXICO ONLY

Released 4/25/2008
WHISTLE NOISE FROM THE HEATER/AIR CONDITIONING WHILE CHANGING TEMPERATURE SETTING—BUILT ON OR BEFORE 12/4/2007

Released 4/17/2008
EATC BLOWER INTERMITTENTLY INOPERATIVE— STUCK ON HIGH/OFF

Released 12/14/2007
A/C COMPRESSOR—CUTS OUT HIGH AMBIENT TEMPERATURES/SEIZED—POOR A/C PERFORMANCE—BUILT BEFORE 11/1/2007

Released 10/24/2007
POOR SEAT COOLING PERFORMANCE—BUILT BEFORE 7/16/2007

Released 10/11/2007
CLIMATE CONTROL SEAT FUNCTION INOPERATIVE—NO COMMUNICATION—DCSM— VEHICLES BUILT PRIOR TO 8/31/2007

Released 6/7/2018
Various Vehicles - Engine Failure Analysis General Service Bulletin (GSB)

Released 4/23/2018
2001-2015 - Vehicles With Modular 4.6L, 5.4L Or 6.8L Engines - Determining Root Cause Of Engine Damage Due To Oil Pressure Loss.

Released 4/23/2018
Various Vehicles - 4.6L/5.4L/6.8L 3 Valve - Engine Noise Upper End And/Or Rough Running - Camshaft Roller Follower Replacement - Built On Or Before 8-Jan-2016

Released 4/23/2018
VISIBLE GREASE PURGE -FRONT HUB AND BEARING ASSEMBLY

Released 12/15/2015
Multiple Vehicles - Transmission Cooler Flush General Service Bulletin (GSB)

Released 12/8/2015
Multiple Vehicles - Engine Failure Analysis General Service Bulletin (GSB)

Released 8/20/2015
Multiple Vehicles - 4.6L 3v And 5.4L 3v Engines - 3v Cam Phaser Installation General Service Bulletin (GSB)

Released 5/29/2014
5.4L 3V – Intermittent Rattle Noise While Driving / Rough Idle When Engine Is At Operating Temperature

Released 7/20/2012
5.4L INTERMITTENT RATTLE NOISE / ROUGH IDLE WHEN ENGINE IS AT OPERATING TEMPERATURE

Released 9/2/2010
5.4L WITH 6R75/6R80 - DELAYED FORWARD/REVERSE ENGAGEMENT - DTCS P0741, P0731, AND/OR P0735 - AFTER COLD START

Released 3/13/2009
6R75 TRANSMISSION - SQUAWK NOISE DURING POWER/FORCED DOWNSHIFT

Released 10/23/2008
DRIVELINE BUMP WHILE BRAKING—BELOW 10 MPH (16 KM/H)

Released 10/10/2008
4 WHEEL DRIVE/ALL WHEEL DRIVE—WITH CONTROL TRAC —SHUDDER ON ACCELERATION/DECELERATION OR BINDING ON SLOW TURNS

Released 9/5/2008
UNITIZED SEAL DIAGNOSIS—LEAK / GREASE OIL TSB 08-19-3 SEPARATION—AXLE BEARING SEAL 8.8 IFS, 8.8 IRS, AND 9.75 IRS AXLES

Released 8/4/2008
DIAGNOSTIC TROUBLE CODES (DTCS) P0345 AND/OR P0349—NO DRIVEABILITY SYMPTOMS, MIL LIGHT ON

Released 6/19/2008
6R60-6R75 TRANSMISSIONS—REPLACEMENT REQUIREMENTS—JOB 1 ONLY

Released 2/7/2008
COLD START FEAD HOOT—WHISTLE NOISE / BUILT BEFORE 1/28/2008

Released 2/7/2008
MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC)—P0456

Released 11/27/2007
ENGINE MISFIRE DURING CRUISE WITH OR WITHOUT DTCS (MEXICO ONLY

Released 11/20/2008
REAR LOAD LEVELING LEAKS DOWN IN EXTREME COLD WEATHER

Released 11/17/2008
VIBRATION DIAGNOSTICS - STEERING WHEEL NIBBLE - TIRE WHEEL RUNOUT AND BALANCE

Released 10/10/2008
4 WHEEL DRIVE/ALL WHEEL DRIVE—WITH CONTROL TRAC —SHUDDER ON ACCELERATION/DECELERATION OR BINDING ON SLOW TURNS

Released 9/24/2008
STEERING WHEEL ANGLE CIRCUIT AND/OR SIGNAL TSB 08-20-8 FAILURE—C1277-C1278—BUILT ON/OR BEFORE 4/10/2008

Released 9/12/2008
SQUEAK / RATTLE FRONT OR REAR SUSPENSION

Released 9/4/2008
LONG WHEEL BASE (LWB)—FUEL GAUGE READS BETWEEN 3/4 AND 7/8 WHEN FULL

Released 8/19/2008
TICKING OR CREAKING SOUND—INSTRUMENT PANEL AREA

Released 6/26/2008
STABILITY/TRACTION CONTROL INDICATOR— TSB 08-14-2 SLIDING-CAR ICON—ON OR FLASHING—DTC C1996 OR SENSITIVE ESC/RSC ACTIVATION NO CODES

Released 2/14/2007
VIBRATION DIAGNOSIS—TIRE/WHEEL RUNOUT