Get Free 2000 FORD EXCURSION V8, 5.4L; SOHC; 16V; MPFI TSBs

Released 2/13/2007
LEATHER-WRAPPED STEERING WHEEL—LEATHER COMING LOOSE

Released 7/17/2006
ADDING ADDITIONAL BULBS TO TURN INDICATOR OR HAZARD FLASHER CIRCUITS—SERVICE TIPS

Released 2/8/2006
Extended Coverage Program - Certain 2000 Model Year Ford Excursion Vehicles Extended Warranty - Headlamp Switch Knob__THIS FIELD SERVICE ACTION EXPIRED ON MARCH 31, 2009. - Dealer Bulletin

Released 11/16/2005
SAFETY BELT RETRACTION SPEED

Released 10/3/2005
SAFETY BELT WEB STOP BUTTON SERVICE

Released 4/17/2005
VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY—CLIMATE CONTROL DEFAULTS TO DEFROST MODE

Released 5/24/2004
REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR—TERMINAL TAB REPAIR

Released 4/25/2004
HARD START OR NO START—7.3L

Released 12/21/2003
ENGINE—7.3L DIESEL—GLOW PLUG CONTROL MODULE—VEHICLES WITH CALIFORNIA EMISSIONS—SERVICE TIP

Released 12/21/2003
DRIVEABILITY—BUCK/SURGE FELT WITH SPEED CONTROL ENGAGED—7.3L ENGINE ONLY * ELECTRICAL—BUCK/SURGE FELT WITH SPEED CONTROL ENGAGED—7.3L ENGINE ONLY *

Released 2/23/2003
BODY—MIRROR—EXTERIOR MIRROR GLASS AND MOTOR REPLACEMENT—SERVICE TIPS

Released 10/22/2002
Special Field Action - Certain 1999 through 2002 Model Year F-Super Duty Vehicles, 1999 through 2002 F-53 Stripped Chassis Vehicles and 2000 through 2003 Excursion Vehicles - Wheel Lug Nut Torque Specification and Procedure Label__THIS FIELD SERVICE ACTION EXPIRED ON MAY 31, 2003. - Owner Letter - 1999-2002 F250/350

Released 12/8/2001
ELECTRICAL—REVISED MECHANICAL HOOD LAMP SWITCH TO REPLACE OLD STYLE MERCURY HOOD LAMP SWITCH

Released 5/18/2004
AXLE—FRONT HUBS NOT ENGAGING, NOT STAYING ENGAGED AND/OR UNLOCKING

Released 10/19/2003
BRAKES—BRAKE PULL—4X4 F-250/350 AND 4X4 EXCURSION VEHICLES ONLY

Released 3/14/2003
SUSPENSION—4X4 WHEEL HUB NON-ENGAGEMENT/DISENGAGEMENT * AXLE—4X4 WHEEL HUB NON-ENGAGEMENT/DISENGAGEMENT

Released 1/4/2003
FRONT LOCKING HUBS—SERVICE TIP

Released 6/17/2002
LAMP—BRAKE—INADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK

Released 4/9/2001
BRAKES—FRONT DISC BRAKE PAD AND/OR CALIPER RATTLE OVER BUMPS—REVISED FRONT BRAKE PADS, NOISE—RATTLE FROM FRONT DISC BRAKE PAD AND/OR CALIPER—REVISED FRONT BRAKE PADS

Released 2/6/2003
ENGINE—CYLINDER HEAD DECK LEAK—4.6 AND 5.4L ENGINES—NEW “SERVICE-ONLY” GASKET AND CYLINDER HEAD KITS AVAILABILITY

Released 12/23/2001
• ENGINE COOLANT—PROPYLENE GLYCOL—FORD MOTOR COMPANY POSITION ON ENGINE COOLANTS MADE FROM PROPYLENE GLYCOL • ENGINE COOLANT—PROPYLENE GLYCOL-BASED—FORD MOTOR COMPANY POSITION ON PROPYLENE GLYCOL-BASED ENGINE COOLANTS

Released 10/23/2000
TRANSMISSION—FLUID IN-LINE FILTER KIT—REPEAT REPAIRS OF TRANSMISSION—SERVICE TIPS

Released 3/13/2000
ENGINE—4.6L 2V OR 5.4L 2V COOLING SYSTEM-COOLANT LEAK FROM PASSENGER SIDE OF INTAKE MANIFOLD AT REAR CORNER OF HEAD—VEHICLES BUILT FROM 7/1/1998 THROUGH 6/30/2000—VEHICLES WITH 4.6L 2V OR 5.4L 2V ENGINE

Released 7/17/2006
ADDING ADDITIONAL BULBS TO TURN INDICATOR OR HAZARD FLASHER CIRCUITS—SERVICE TIPS

Released 6/3/2006
HEADLAMP KNOB SWITCH—SERVICE TIP

Released 5/8/2006
SPEED CONTROL DIAGNOSTICS—W/O SCP

Released 12/4/2005
FALSE PARKING AID WARNINGS

Released 7/18/2005
WIRING—SOLDERING AND CRIMPING REPAIRS— SOLDERING TIPS

Released 5/24/2004
REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR—TERMINAL TAB REPAIR

Released 4/25/2004
HARD START OR NO START—7.3L

Released 12/21/2003
ENGINE—7.3L DIESEL—GLOW PLUG CONTROL MODULE—VEHICLES WITH CALIFORNIA EMISSIONS—SERVICE TIP

Released 12/21/2003
DRIVEABILITY—BUCK/SURGE FELT WITH SPEED CONTROL ENGAGED—7.3L ENGINE ONLY * ELECTRICAL—BUCK/SURGE FELT WITH SPEED CONTROL ENGAGED—7.3L ENGINE ONLY *

Released 5/20/2003
DRIVEABILITY—NO START/REPEAT STARTER FAILURE—REPEAT STARTER REPLACEMENT *

Released 2/23/2003
BODY—MIRROR—EXTERIOR MIRROR GLASS AND MOTOR REPLACEMENT—SERVICE TIPS

Released 1/18/2003
ELECTRICAL—REMOTE KEYLESS ENTRY (RKE)— SERVICE TIPS

Released 6/17/2002
LAMP—BRAKE—INADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK

Released 12/8/2001
• DRIVEABILITY—DIAGNOSTIC TROUBLE CODES (DTC) P0500, P1502 AND/OR U1039 CONTINENTAL MODELS ONLY—STICKING OR BINDING IGNITION LOCK CYLINDER—HIGH EFFORT WHEN TURNING IGNITION SWITCH • ELECTRICAL—STICKING OR BINDING IGNITION LOCK CYLINDER

Released 12/8/2001
ELECTRICAL—REVISED MECHANICAL HOOD LAMP SWITCH TO REPLACE OLD STYLE MERCURY HOOD LAMP SWITCH

Released 10/11/2001
WIRING—WIRE HARNESS TERMINAL REPAIR KIT AND WIRE SPLICE PROCEDURE

Released 6/2/2001
PASSIVE ANTI THEFT SYSTEM (PATS)—DIAGNOSTIC SERVICE TIPS

Released 12/4/2005
INTERMITTENT ROUGH IDLE—NON-COMMANDED INTERMITTENT ROUGH IDLE—NON-COMMANDED

Released 4/17/2004
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED—SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC’S)—SERVICE TIPS

Released 12/21/2003
ENGINE—7.3L DIT—HIGH INJECTION CONTROL PRESSURE READINGS—ENGINES BUILT AFTER ENGINE SERIAL NUMBER 896812

Released 12/21/2003
DRIVEABILITY—BUCK/SURGE FELT WITH SPEED CONTROL ENGAGED—7.3L ENGINE ONLY * ELECTRICAL—BUCK/SURGE FELT WITH SPEED CONTROL ENGAGED—7.3L ENGINE ONLY *

Released 12/21/2003
ENGINE—7.3L DIESEL—ENGINE KNOCK OR “CACKLE”—1999-2000 SUPER DUTY F-SERIES AND 2000 EXCURSIONS WITH ENGINE SERIAL NUMBERS 661894 THROUGH 1311240—ALL 1998-2000 E-SERIES WITH ENGINE SERIAL NUMBERS 661974 THROUGH 1311240 *

Released 11/9/2003
DRIVEABILITY—ROUGH IDLE AND/OR HESITATION ON ACCELERATION—VEHICLES EQUIPPED WITH 5.4L OR 6.8L ENGINE ONLY

Released 9/7/2001
DRIVEABILITY—HO2S (HEATED OXYGEN SENSOR), CATALYST, AND FUEL SYSTEM MONITORS—SERVICE TIPS—OBD II VEHICLES ONLY

Released 2/20/2004
OIL LEAK—TURBO PEDESTAL SEAL AT EXHAUST BACK PRESSURE ACTUATOR (EBP)—7.3L DIESEL

Released 12/21/2003
DRIVEABILITY—LOSS OF POWER AND EXTERNAL TURBO OIL LEAK—7.3L DIESEL * ENGINE—7.3L DIESEL—LOSS OF POWER AND EXTERNAL TURBO OIL LEAK * NOISE—EXHAUST NOISE FROM TURBO—7.3L DIESEL

Released 1/1/2003
ENGINE/EXHAUST/NOISE—“MISS” NOISE FROM EXHAUST—UPDATED EXHAUST Y-PIPE AVAILABLE—VEHICLES EQUIPPED WITH 5.4L OR 6.8L ENGINE—BUILT THROUGH 9/10/2000

Released 4/17/2005
VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY—CLIMATE CONTROL DEFAULTS TO DEFROST MODE

Released 4/25/2004
HARD START OR NO START—7.3L

Released 2/20/2004
OIL LEAK—TURBO PEDESTAL SEAL AT EXHAUST BACK PRESSURE ACTUATOR (EBP)—7.3L DIESEL

Released 12/21/2003
LACK OF POWER—UNDER A LOAD, AT CRUISE OR ON ACCELERATION—VEHICLES EQUIPPED WITH 7.3L DIT ENGINE ONLY—PRODUCED BEFORE 11/25/2000 ONLY *

Released 12/21/2003
DRIVEABILITY—LOSS OF POWER AND EXTERNAL TURBO OIL LEAK—7.3L DIESEL * ENGINE—7.3L DIESEL—LOSS OF POWER AND EXTERNAL TURBO OIL LEAK * NOISE—EXHAUST NOISE FROM TURBO—7.3L DIESEL

Released 12/21/2003
DRIVEABILITY—NO START, LOSS OF POWER OR ROUGH IDLE—DURING EXTREME COLD WEATHEROPERATION—FUEL GELLING—VEHICLES EQUIPPED WITH 7.3L ENGINE *

Released 12/21/2003
ENGINE—7.3L DIESEL—GLOW PLUG CONTROL MODULE—VEHICLES WITH CALIFORNIA EMISSIONS—SERVICE TIP

Released 12/21/2003
ENGINE—7.3L DIESEL—ENGINE KNOCK OR “CACKLE”—1999-2000 SUPER DUTY F-SERIES AND 2000 EXCURSIONS WITH ENGINE SERIAL NUMBERS 661894 THROUGH 1311240—ALL 1998-2000 E-SERIES WITH ENGINE SERIAL NUMBERS 661974 THROUGH 1311240 *

Released 5/20/2003
DRIVEABILITY—NO START/REPEAT STARTER FAILURE—REPEAT STARTER REPLACEMENT *

Released 4/16/2002
FUEL SYSTEM—FUEL PUMP “WHINING”/“BUZZING” NOISE COMES THROUGH ENTERTAINMENT OR TWO-WAY RADIO SPEAKER *

Released 12/8/2001
• DRIVEABILITY—DIAGNOSTIC TROUBLE CODES (DTC) P0500, P1502 AND/OR U1039 CONTINENTAL MODELS ONLY—STICKING OR BINDING IGNITION LOCK CYLINDER—HIGH EFFORT WHEN TURNING IGNITION SWITCH • ELECTRICAL—STICKING OR BINDING IGNITION LOCK CYLINDER

Released 12/15/2015
Multiple Vehicles - Transmission Cooler Flush General Service Bulletin (GSB)

Released 1/9/2007
MERCONâ ATF REPLACED BY MERCON (R) V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS

Released 12/18/2006
IDENTIFYING THE CORRECT REPLACEMENT HEAD GASKET FOR CERTAIN REMANUFACTURED ENGINES—SERVICE TIP

Released 4/14/2006
MERCON ATF IS BEING REPLACED BY MERCON V ATF AS A SERVICE FLUID.

Released 1/1/2006
• DIAGNOSTIC TROUBLE CODES (DTCS)—P0350-P0360 COIL DTCS STORED IN MEMORY— ROUGH IDLE—MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED—COIL ON PLUG APPLICATIONS ONLY

Released 12/4/2005
INTERMITTENT ROUGH IDLE—NON-COMMANDED INTERMITTENT ROUGH IDLE—NON-COMMANDED

Released 8/22/2005
WDS COP KIT DIAGNOSTIC TIPS—COIL ON PLUG (COP) IGNITION SYSTEMS—ENGINE MISFIRE OR ROUGH RUNNING

Released 4/17/2005
VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY—CLIMATE CONTROL DEFAULTS TO DEFROST MODE

Released 3/20/2005
OIL PAN CORROSION—7.3L OR 6.0L

Released 5/18/2004
AXLE—FRONT HUBS NOT ENGAGING, NOT STAYING ENGAGED AND/OR UNLOCKING

Released 4/4/2004
ENGINE—7.3L DIESEL DI—HIGH PRESSURE OIL PUMP LEAK

Released 12/21/2003
LACK OF POWER—UNDER A LOAD, AT CRUISE OR ON ACCELERATION—VEHICLES EQUIPPED WITH 7.3L DIT ENGINE ONLY—PRODUCED BEFORE 11/25/2000 ONLY *

Released 12/21/2003
ENGINE—7.3L—EXTERNAL OIL LEAK DIAGNOSIS FOR 7.3L DIT ENGINES

Released 12/21/2003
DRIVEABILITY—LOSS OF POWER AND EXTERNAL TURBO OIL LEAK—7.3L DIESEL * ENGINE—7.3L DIESEL—LOSS OF POWER AND EXTERNAL TURBO OIL LEAK * NOISE—EXHAUST NOISE FROM TURBO—7.3L DIESEL

Released 12/21/2003
DRIVEABILITY—NO START, LOSS OF POWER OR ROUGH IDLE—DURING EXTREME COLD WEATHEROPERATION—FUEL GELLING—VEHICLES EQUIPPED WITH 7.3L ENGINE *

Released 12/21/2003
ENGINE—7.3L DIT—HIGH INJECTION CONTROL PRESSURE READINGS—ENGINES BUILT AFTER ENGINE SERIAL NUMBER 896812

Released 12/21/2003
ENGINE—7.3L DIESEL—GLOW PLUG CONTROL MODULE—VEHICLES WITH CALIFORNIA EMISSIONS—SERVICE TIP

Released 12/21/2003
ENGINE—7.3L DIESEL—ENGINE KNOCK OR “CACKLE”—1999-2000 SUPER DUTY F-SERIES AND 2000 EXCURSIONS WITH ENGINE SERIAL NUMBERS 661894 THROUGH 1311240—ALL 1998-2000 E-SERIES WITH ENGINE SERIAL NUMBERS 661974 THROUGH 1311240 *

Released 11/9/2003
DRIVEABILITY—ROUGH IDLE AND/OR HESITATION ON ACCELERATION—VEHICLES EQUIPPED WITH 5.4L OR 6.8L ENGINE ONLY

Released 8/14/2003
TRANSMISSION—NEW TRANSMISSION COOLER FLUSHER SERVICE TIPS

Released 3/14/2003
SUSPENSION—4X4 WHEEL HUB NON-ENGAGEMENT/DISENGAGEMENT * AXLE—4X4 WHEEL HUB NON-ENGAGEMENT/DISENGAGEMENT

Released 2/11/2003
SUSPENSION—ON-VEHICLE FRONT INTEGRATED HUB/BEARING ROCKING END-PLAY MEASUREMENT * AXLE—ON-VEHICLE FRONT INTEGRATED HUB/BEARING ROCKING END-PLAY MEASUREMENT

Released 2/6/2003
ENGINE—CYLINDER HEAD DECK LEAK—4.6 AND 5.4L ENGINES—NEW “SERVICE-ONLY” GASKET AND CYLINDER HEAD KITS AVAILABILITY

Released 1/4/2003
FRONT LOCKING HUBS—SERVICE TIP

Released 1/1/2003
ENGINE/EXHAUST/NOISE—“MISS” NOISE FROM EXHAUST—UPDATED EXHAUST Y-PIPE AVAILABLE—VEHICLES EQUIPPED WITH 5.4L OR 6.8L ENGINE—BUILT THROUGH 9/10/2000

Released 12/21/2002
OSCILLATION/BOUNCE—HIGHWAY SPEEDS—4X2 CHECKING CYLINDER HEAD AND BLOCK FLATNESS

Released 9/1/2002
ENGINE—ENGINE OIL—RECOMMENDED APPLICATIONS FOR SAE 5W-20 AND SAE 5W-30 MOTOR OILS—GASOLINE AND FLEXIBLE FUEL VEHICLES ONLY

Released 4/11/2002
ENGINE—NEW GASKET REMOVER/CLEANER AND SERVICE TIPS FOR ALUMINUM HEADS AND BLOCKS

Released 1/21/2002
TRANSMISSION—4R100/E4OD—TORQUE CONVERTER ACCESS EXTERNAL DUST PLUG MAY BECOME DISLODGED

Released 12/23/2001
• ENGINE COOLANT—PROPYLENE GLYCOL—FORD MOTOR COMPANY POSITION ON ENGINE COOLANTS MADE FROM PROPYLENE GLYCOL • ENGINE COOLANT—PROPYLENE GLYCOL-BASED—FORD MOTOR COMPANY POSITION ON PROPYLENE GLYCOL-BASED ENGINE COOLANTS

Released 6/2/2001
PASSIVE ANTI THEFT SYSTEM (PATS)—DIAGNOSTIC SERVICE TIPS

Released 10/23/2000
TRANSMISSION—FLUID IN-LINE FILTER KIT—REPEAT REPAIRS OF TRANSMISSION—SERVICE TIPS

Released 4/24/2000
TRANSMISSION—4R100—FLUID OVERHEATS DURING SEVERE DUTY—AVAILABILITY OF UPDATED FLUID COOLER/FILTER KIT—VEHICLES PRODUCED BEFORE 2/6/2000

Released 3/13/2000
ENGINE—4.6L 2V OR 5.4L 2V COOLING SYSTEM-COOLANT LEAK FROM PASSENGER SIDE OF INTAKE MANIFOLD AT REAR CORNER OF HEAD—VEHICLES BUILT FROM 7/1/1998 THROUGH 6/30/2000—VEHICLES WITH 4.6L 2V OR 5.4L 2V ENGINE

Released 1/26/2000
ENGINE/NOISE-FROM ENGINE—ROUGH IDLE/MISS AFTER START-UP DURING COLD AMBIENT TEMPERATURES LESS THAN -12 DEGREES C (10 DEGREES F)—VEHICLES BUILT 3/1/1996 THROUGH 7/31/2000

Released 3/25/1999
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED—DIAGNOSTIC TROUBLE CODES (DTCS) P0135, P0141, P0155, P0161, AND P0455— NO DRIVEABILITY CONCERNS —VEHICLES WITH 5.4L ENGINE

Released 3/28/2001
Safety Recall - Certain 2000 Model Year Taurus, Sable and Excursion Vehicles - Headlamp Switch Knob Replacement - Administrative Information

Released 1/9/2007
MERCONâ ATF REPLACED BY MERCON (R) V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS

Released 3/14/2003
SUSPENSION—4X4 WHEEL HUB NON-ENGAGEMENT/DISENGAGEMENT * AXLE—4X4 WHEEL HUB NON-ENGAGEMENT/DISENGAGEMENT

Released 2/11/2003
SUSPENSION—ON-VEHICLE FRONT INTEGRATED HUB/BEARING ROCKING END-PLAY MEASUREMENT * AXLE—ON-VEHICLE FRONT INTEGRATED HUB/BEARING ROCKING END-PLAY MEASUREMENT

Released 12/19/2002
Special Field Action - Certain 1999 through 2002 Model Year F-Super Duty Vehicles, 1999 through 2002 F-53 Stripped Chassis Vehicles and 2000 through 2003 Excursion Vehicles - Wheel Lug Nut Torque Specification and Procedure Label__THIS FIELD SERVICE ACTION EXPIRED ON MAY 31, 2003. - Dealer Bulletin

Released 1/3/2001
STEERING—WANDERING/STIFF STEERING OR POOR RETURNABILITY AFTER TURNS—4X4 VEHICLES ONLY, SUSPENSION—WANDERING/STIFF STEERING OR POOR RETURNABILITY AFTER TURNS—4X4 VEHICLES ONLY

Released 7/18/2005
WIRING—SOLDERING AND CRIMPING REPAIRS— SOLDERING TIPS

Released 10/11/2001
WIRING—WIRE HARNESS TERMINAL REPAIR KIT AND WIRE SPLICE PROCEDURE