Get Free 2003 FORD CROWN VICTORIA V8, 4.6L TSBs

Released 4/23/2018
INSTALLATION OF FRAME REPLACEMENT KITS (5D058/5D059) ON CERTAIN 03-07 MY TOWN CAR AND 03-05 MY CROWN VICTORIA AND GRAND MARQUIS VEHICLES

Released 8/22/2017
2000 And Newer Ford, Lincoln And Mercury Vehicles - Aluminum Panel Corrosion

Released 12/15/2015
Multiple Vehicles - Transmission Cooler Flush General Service Bulletin (GSB)

Released 12/8/2015
Multiple Vehicles - Engine Failure Analysis General Service Bulletin (GSB)

Released 6/6/2007
RCM FAULT REPORTING USING DTCS AND BIT-MAPPED PARAMETER IDENTIFIERS (PIDS)— SERVICE TIPS

Released 2/13/2007
LEATHER-WRAPPED STEERING WHEEL—LEATHER COMING LOOSE

Released 12/25/2006
ALUMINUM BODY PANELS—CORROSION—SERVICE TIP

Released 11/16/2005
SAFETY BELT RETRACTION SPEED

Released 10/3/2005
SAFETY BELT WEB STOP BUTTON SERVICE

Released 12/18/2004
DRIVER’S SEAT COVER WEAR THROUGH

Released 6/7/2004
ELECTRICAL—CLIMATE CONTROL—REGISTER VENT RATTLE WITH A/C BLOWER ON * NOISE—CLIMATE CONTROL—REGISTER VENT RATTLE WITH A/C BLOWER ON

Released 5/24/2004
REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR—TERMINAL TAB REPAIR

Released 4/12/2004
FRONT DOOR CATCHES ON WEATHERSTRIP—ROOF SIDE RAIL—VEHICLES BUILT PRIOR TO 5/1/2004

Released 12/15/2003
TRIM—INTERIOR DOOR PANEL CARPET INSERTS PEELING OFF OR LOOSE—VEHICLES BUILT BEFORE 6/10/2003 ONLY

Released 3/19/2003
BODY—HEADLAMP—MOISTURE IN HEADLAMP ASSEMBLY * ELECTRICAL—HEADLAMP—MOISTURE IN HEADLAMP ASSEMBLY

Released 2/23/2003
BODY—MIRROR—EXTERIOR MIRROR GLASS AND MOTOR REPLACEMENT—SERVICE TIPS

Released 1/10/2003
PAINT—PLASTIC BUMPER/FASCIA PARTS—PREPARATION PROCEDURES—SERVICE TIPS

Released 11/17/2002
BODY—COLLISION REPAIR UPDATES

Released 7/16/2002
BODY—PAINT—APPROVED PAINT MATERIALS FOR WARRANTY REPAIRS

Released 3/16/2002
PAINT—NEW POLISHING PRODUCTS—SERVICE PROCEDURES

Released 1/15/2002
ELECTRICAL—AFTERMARKET ACCESSORIES INOPERATIVE OR NOT OPERATING AS DESIGNED -POLICE INTERCEPTOR MODELS BUILT BEFORE 5/23/2002 ONLY

Released 12/1/1996
LOCKS—INTRODUCTION OF NEW LOCK DESIGN— SERVICE TIP

Released 12/4/1994
PAINT—PRIMED SHEET METAL—PREP PROCEDURE AND MSDS INFORMATION

Released 6/17/2002
LAMP—BRAKE—INADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK

Released 8/14/2003
TRANSMISSION—NEW TRANSMISSION COOLER FLUSHER SERVICE TIPS

Released 7/23/2002
COOLING SYSTEM—MOTORCRAFT PREMIUM GOLD ENGINE COOLANT—SERVICE TIPS

Released 2/27/2008
BATTERY SERVICE—OPERATION OF BATTERY EYE—CHARGING SERVICE TIPS

Released 12/25/2006
ALUMINUM BODY PANELS—CORROSION—SERVICE TIP

Released 12/14/2006
NO CRANK / STARTER TERMINAL FATIGUE

Released 5/8/2006
SPEED CONTROL DIAGNOSTICS—W/O SCP

Released 9/4/2005
UNCOMMANDED WINDSHIELD WIPER OPERATION

Released 7/18/2005
WIRING—SOLDERING AND CRIMPING REPAIRS— SOLDERING TIPS

Released 12/25/2004
DIAGNOSTIC TROUBLE CODE (DTC) B1342—RESTRAINT CONTROL MODULE (RCM)—DIAGNOSTIC SERVICE TIP

Released 12/21/2004
CHARGING SYSTEM—HIGH OUTPUT GENERATOR NOW AVAILABLE FOR SERVICING 2003 POLICE INTERCEPTOR VEHICLES

Released 5/24/2004
REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR—TERMINAL TAB REPAIR

Released 4/14/2004
IGNITION LOCK CYLINDER BINDING—POLICE INTERCEPTORS BUILT BEFORE 10/31/2003

Released 11/14/2003
BODY—RADIATOR ALIGNMENT PIN GROUND CLEARANCE

Released 3/19/2003
BODY—HEADLAMP—MOISTURE IN HEADLAMP ASSEMBLY * ELECTRICAL—HEADLAMP—MOISTURE IN HEADLAMP ASSEMBLY

Released 2/23/2003
BODY—MIRROR—EXTERIOR MIRROR GLASS AND MOTOR REPLACEMENT—SERVICE TIPS

Released 1/18/2003
ELECTRICAL—REMOTE KEYLESS ENTRY (RKE)— SERVICE TIPS

Released 11/17/2002
BODY—COLLISION REPAIR UPDATES

Released 7/21/2002
ELECTRICAL—AIRBAG DIAGNOSTIC TROUBLE CODES (DTC) B2290 AND/OR B2295—DIAGNOSTIC SERVICE TIPS

Released 7/16/2002
BODY—PAINT—APPROVED PAINT MATERIALS FOR WARRANTY REPAIRS

Released 6/17/2002
LAMP—BRAKE—INADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK

Released 1/15/2002
ELECTRICAL—AFTERMARKET ACCESSORIES INOPERATIVE OR NOT OPERATING AS DESIGNED -POLICE INTERCEPTOR MODELS BUILT BEFORE 5/23/2002 ONLY

Released 3/11/2005
MIL ON AND DTC P0460 IN MEMORY

Released 1/3/2005
MAF DIAGNOSTIC SERVICE TIP—VEHICLES EQUIPPED WITH EGR SYSTEM MODULE (ESM)

Released 12/15/2004
DIAGNOSTIC TROUBLE CODE (DTC) P0442

Released 4/17/2004
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED—SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC’S)—SERVICE TIPS

Released 3/20/2003
DRIVEABILITY—MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH DTC’S P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457

Released 6/25/2003
ENGINE—ROMEO BUILT 4.6L 2V—TICK NOISE FROM ENGINE—ENGINES BUILT BEFORE 9/17/2003

Released 8/22/2005
WDS COP KIT DIAGNOSTIC TIPS—COIL ON PLUG (COP) IGNITION SYSTEMS—ENGINE MISFIRE OR ROUGH RUNNING

Released 6/5/2005
ALTERNATIVE FUEL VEHICLE—COMPRESSED NATURAL GAS FUEL TANK INSPECTION

Released 11/19/2004
LACK OF A/C COOLING—RESTRICTED/REDUCED AIR FLOW THROUGH VENTS—EVAPORATOR CORE ICING

Released 4/14/2004
IGNITION LOCK CYLINDER BINDING—POLICE INTERCEPTORS BUILT BEFORE 10/31/2003

Released 7/11/2003
DRIVEABILITY—CNG—POSSIBLE FUEL LEAK AT FILL VALVE—FILL VALVE SERVICE PART REVISIONS—CNG VEHICLES ONLY

Released 6/20/2003
DRIVEABILITY—DEDICATED COMPRESSED NATURAL GAS (CNG) VEHICLES—4.6L AND 5.4L ENGINE—ROUGH IDLE, HARD START OR NO START WHEN COLD—LOSS OF POWER—LEAN FUEL DTC’S—RESTRICTED CATALYTIC CONVERTER *

Released 3/18/2003
DRIVEABILITY—DEDICATED COMPRESSED NATURAL GAS (CNG)—ROUGH IDLE OR NO START WHEN COLD—VEHICLES EQUIPPED WITH DEDICATED 4.6L OR 5.4L CNG ENGINE ONLY

Released 3/23/2002
DRIVEABILITY—FUEL PRESSURE RELIEF VALVE (SCHRADER VALVE) DISCONTINUED * ENGINE—3.0L/3.8L/4.6L—FUEL PRESSURE RELIEF VALVE (SCHRADER VALVE) DISCONTINUED

Released 12/15/2008
WHITE FLAKES COMING FROM A/C VENTS

Released 12/21/2006
HEATER CORE LEAKAGE AND ELECTROLYSIS (INFORMATION ONLY)

Released 11/10/2005
WHITE FLAKES COMING FROM A/C VENTS

Released 12/15/2004
DIAGNOSTIC TROUBLE CODE (DTC) P0442

Released 11/19/2004
LACK OF A/C COOLING—RESTRICTED/REDUCED AIR FLOW THROUGH VENTS—EVAPORATOR CORE ICING

Released 6/7/2004
ELECTRICAL—CLIMATE CONTROL—REGISTER VENT RATTLE WITH A/C BLOWER ON * NOISE—CLIMATE CONTROL—REGISTER VENT RATTLE WITH A/C BLOWER ON

Released 4/23/2018
2001-2015 - Vehicles With Modular 4.6L, 5.4L Or 6.8L Engines - Determining Root Cause Of Engine Damage Due To Oil Pressure Loss.

Released 12/15/2015
Multiple Vehicles - Transmission Cooler Flush General Service Bulletin (GSB)

Released 12/8/2015
Multiple Vehicles - Engine Failure Analysis General Service Bulletin (GSB)

Released 10/17/2007
4.6L 2V, 5.4L 2V, OR 6.8L 2V—SPARK PLUG THREAD REPAIR PROCEDURE—NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY

Released 1/9/2007
MERCONâ ATF REPLACED BY MERCON (R) V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS

Released 12/18/2006
IDENTIFYING THE CORRECT REPLACEMENT HEAD GASKET FOR CERTAIN REMANUFACTURED ENGINES—SERVICE TIP

Released 8/22/2005
WDS COP KIT DIAGNOSTIC TIPS—COIL ON PLUG (COP) IGNITION SYSTEMS—ENGINE MISFIRE OR ROUGH RUNNING

Released 6/5/2005
ALTERNATIVE FUEL VEHICLE—COMPRESSED NATURAL GAS FUEL TANK INSPECTION

Released 4/2/2005
IDLE VIBRATION—VEHICLES EQUIPPED WITH SINGLE EXHAUST

Released 3/11/2005
MIL ON AND DTC P0460 IN MEMORY

Released 1/3/2005
MAF DIAGNOSTIC SERVICE TIP—VEHICLES EQUIPPED WITH EGR SYSTEM MODULE (ESM)

Released 4/14/2004
IGNITION LOCK CYLINDER BINDING—POLICE INTERCEPTORS BUILT BEFORE 10/31/2003

Released 11/14/2003
BODY—RADIATOR ALIGNMENT PIN GROUND CLEARANCE

Released 8/14/2003
TRANSMISSION—NEW TRANSMISSION COOLER FLUSHER SERVICE TIPS

Released 7/15/2003
ENGINE—4.6L—GRINDING TYPE NOISE FROM ENGINE TIMING CHAIN AREA * NOISE—GRINDING TYPE NOISE FROM ENGINE TIMING CHAIN AREA

Released 7/11/2003
DRIVEABILITY—CNG—POSSIBLE FUEL LEAK AT FILL VALVE—FILL VALVE SERVICE PART REVISIONS—CNG VEHICLES ONLY

Released 6/25/2003
ENGINE—ROMEO BUILT 4.6L 2V—TICK NOISE FROM ENGINE—ENGINES BUILT BEFORE 9/17/2003

Released 6/20/2003
DRIVEABILITY—DEDICATED COMPRESSED NATURAL GAS (CNG) VEHICLES—4.6L AND 5.4L ENGINE—ROUGH IDLE, HARD START OR NO START WHEN COLD—LOSS OF POWER—LEAN FUEL DTC’S—RESTRICTED CATALYTIC CONVERTER *

Released 5/5/2003
AXLE—REAR AXLE SHAFT AND/OR AXLE BEARING PREMATURE WEAR—VEHICLES PRODUCED BEFORE 1/1/2003 ONLY

Released 3/18/2003
DRIVEABILITY—DEDICATED COMPRESSED NATURAL GAS (CNG)—ROUGH IDLE OR NO START WHEN COLD—VEHICLES EQUIPPED WITH DEDICATED 4.6L OR 5.4L CNG ENGINE ONLY

Released 3/8/2003
ENGINE—ENGINE OIL LEVEL INDICATOR MARKINGS—REPORTS OF LOW OIL LEVELS

Released 12/21/2002
OSCILLATION/BOUNCE—HIGHWAY SPEEDS—4X2 CHECKING CYLINDER HEAD AND BLOCK FLATNESS

Released 11/17/2002
BODY—COLLISION REPAIR UPDATES

Released 7/23/2002
COOLING SYSTEM—MOTORCRAFT PREMIUM GOLD ENGINE COOLANT—SERVICE TIPS

Released 4/11/2002
ENGINE—NEW GASKET REMOVER/CLEANER AND SERVICE TIPS FOR ALUMINUM HEADS AND BLOCKS

Released 3/23/2002
DRIVEABILITY—FUEL PRESSURE RELIEF VALVE (SCHRADER VALVE) DISCONTINUED * ENGINE—3.0L/3.8L/4.6L—FUEL PRESSURE RELIEF VALVE (SCHRADER VALVE) DISCONTINUED

Released 2/24/2002
TRANSMISSION—4R70W—OVERDRIVE INOPERATIVE—VEHICLES PRODUCED 3/26/2002 THROUGH 6/30/2002 EQUIPPED WITH POLICE PACKAGE ONLY

Released 12/2/2006
AIR SUSPENSION COMPRESSOR NOISE

Released 5/15/2004
SQUEAK OR RUBBING NOISE FROM FRONT SUSPENSION—FRONT SPRING INSULATOR REVISED

Released 6/19/2003
SUSPENSION—HARSH RIDE—SUSPENSION SITS LOW IN FRONT—BASE VEHICLES WITH STEEL WHEELS OR VEHICLES EQUIPPED WITH HANDLING PACKAGE—VEHICLES BUILT BEFORE 1/1/2003

Released 5/12/2003
WHEELS—POLICE INTERCEPTOR TIRES—DO NOT MIX TIRE TYPES

Released 12/1/1996
LOCKS—INTRODUCTION OF NEW LOCK DESIGN— SERVICE TIP

Released 8/22/2005
WDS COP KIT DIAGNOSTIC TIPS—COIL ON PLUG (COP) IGNITION SYSTEMS—ENGINE MISFIRE OR ROUGH RUNNING

Released 7/18/2005
WIRING—SOLDERING AND CRIMPING REPAIRS— SOLDERING TIPS

Released 12/4/1994
PAINT—PRIMED SHEET METAL—PREP PROCEDURE AND MSDS INFORMATION