A free CarMD service

Get Free 2012 CHEVROLET VOLT L4, 1.4L; DOHC; 16V; MPFI; Hybrid TSBs

Technical Service Bulletins

Released 7/27/2020
Needle Bearings Found In The Oil Pan During An Oil Change

Released 7/13/2020
GE-52250 Power Smoke Diagnostic Leak Detector Turbocharger Charge Air And Induction System Tester MIL Reduced Engine Power

Get all TSBs for 5 vehicles for only $25

TSB Description
Released 6/5/2020 Power Steering Noise or Fluid Leak from Power Steering Pump, Gear or High Pressure Hose During Extreme Low Temperature Operation (Replace Power Steering Fluid)
Released 5/27/2020 Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability
Released 5/5/2020 GE-52250 Power Smoke Diagnostic Leak Detector Turbocharger Charge Air And Induction System Tester MIL Reduced Engine Power
Released 2/28/2020 Unscheduled Supplemental Services (Including Flushing Services and Additives) and Proper Use of GM Simplified Maintenance Schedules
Released 10/14/2019 Diagnostic Tip: Poor Engine Performance Or CEL On In Cold Ambient Temperatures On Vehicles Equipped With Turbocharged Gasoline Engines May Set One Or More Of The Following DTCs P0299 P2227
Released 10/9/2019 Information on Engine Oil Consumption Guidelines
Released 9/5/2019 Concerns or Questions Regarding Installation of Dealer Installed Accessories
Released 7/10/2019 Concerns Or Questions Regarding Installation Of Dealer Installed Accessories
Released 2/19/2019 Diagnostic Tip: Poor Engine Performance Or CEL On In Cold Ambient Temperatures On Vehicles Equipped With Turbocharged Gasoline Engines May Set One Or More Of The Following DTCs P0299 P2227
Released 1/11/2019 Poor Engine Performance Or CEL On In Cold Ambient Temperatures On Vehicles Equipped With Turbocharged Gasoline Engines May Set One Or More Of The Following DTCs P0299 P2227
Released 12/6/2018 Poor Engine Performance Or CEL On In Cold Ambient Temperatures On Vehicles Equipped With Turbocharged Gasoline Engines May Set One Or More Of The Following DTCs P0171 P0172 P0299 P2227
Released 7/25/2018 Identifying Non-GM (Aftermarket) Engine Calibrations for Gasoline Engines Using Tech 2 or GDS 2 (U.S. and Canada)
Released 3/16/2018 Eliminating Unwanted Odors in Vehicles
Released 10/7/2016 Properly Maintaining Vehicles in Dealer Inventory
Released 9/30/2016 Engine Oil Life Monitor Operation Calculation
Released 9/27/2016 Warranty Administration - Labor Operation 0600014 - Suspected Tampering or Vehicle Modifications
Released 9/1/2016 Fuel and Oil Additives - Facts and Myths - Maximizing Gasoline Fuel Economy
Released 5/13/2016 Accessory Power Outlet and Trailer Lighting Fuse Replacement - Use Global Labor Operation 5430130 Fuse Replacement
Released 5/10/2016 Abnormal Noise And Or Vibration While Driving Due To Non-GM Aftermarket Accessory
Released 4/12/2016 Information Regarding Magnetic Drain Plugs
Released 2/5/2016 Hem Flange Rust Repair
Released 10/31/2015 Information on Engine Oil Consumption Guidelines
Released 10/31/2015 Diagnostic Tips for Preventing Oil Leaks After Changing Oil and Filter
Released 10/31/2015 Engine and Automatic Transmission/Transaxle Identification
Released 10/31/2015 Warranty Administration - Causal Part Requirements for Transactions Submitted to GM for Payment
Released 9/12/2015 Air Conditioning Odor (Install Evaporator Core Dryer Kit and Apply Cooling Coil Coating)
Released 9/5/2015 Eliminating Unwanted Odors in Vehicles
Released 7/25/2015 Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability
Released 7/18/2015 Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability
Released 6/6/2015 Properly Maintaining Vehicles in Dealer Inventory
Released 3/14/2015 Unscheduled Supplemental Services (Including Flushing Services and Additives) and Proper Use of GM Simplified Maintenance Schedules (Canada Only)
Released 8/25/2014 Installation of Non-GM Approved Aftermarket Products
Released 2/8/2014 (Hybrid) Emergency First Responder Information
Released 1/24/2014 GM Accessories - Dealer-Installed, Repaired or Replaced During Warranty Coverage Period
Released 1/3/2014 New Engine Oil and Oil Filter Replacement Procedure in Service Information (SI)
Released 9/20/2013 (EREV Volt) Vacuum Coolant Fill Information
Released 8/7/2013 (EREV) Information On Proper Coolant Usage For All Of The Volt Cooling Systems
Released 8/1/2013 SES Light With DTC P0534
Released 6/28/2013 Key Cutting Procedure for Obtaining Replacement Key
Released 6/7/2013 IPC Odometer Programming Method Quick Reference Guide
Released 1/14/2012 Properly Maintaining Vehicles in Dealer Inventory
Released 1/13/2012 Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability
Released 1/13/2012 Properly Maintaining Vehicles in Dealer Inventory
Released 9/23/2011 Missing OnStar Owner Kit Integration in Vehicle Owner Manual
Released 8/23/2011 Transport Mode On Message Displayed in Driver Information Center (DIC) and/or Battery Light is Flashing (Follow Procedure as Outlined Below)
Released 7/22/2011 Car and Truck Fix it Right the First Time Issues

Released 9/30/2020
Warranty Administration - Dealer Empowerment for Goodwill, Customer Enthusiasm and Policy (U.S. Only)

Released 8/3/2020
Procedure For Attaching GDS2 Session Logs To Technical Assistance Cases Using Dealer Case Management (DCM) (US Dealers Only).

Get all TSBs for 5 vehicles for only $25

TSB Description
Released 6/24/2020 Warranty Administration - Dealer Empowerment for Goodwill, Customer Enthusiasm and Policy (U.S. Only)
Released 5/27/2020 Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability
Released 5/20/2020 IPC Odometer Programming Method Quick Reference Guide
Released 5/7/2020 New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores
Released 5/6/2020 Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability
Released 4/14/2020 Underbody Component Corrosion
Released 4/3/2020 Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability
Released 3/20/2020 Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability
Released 3/18/2020 Warranty Administration - Courtesy Transportation and Roadside Assistance Programs
Released 1/21/2020 Warranty Administration - Repurchase Vehicle Dealer Processing Fee Labor Operation and Submission Guidelines (U.S. ONLY)
Released 12/12/2019 Service Programming System (SPS) Errors (E4398, E4399, E4403, M4404, M4413, M6954, M6955, E4414, E4423, E4491 or E6961)
Released 11/25/2019 Use of Dealer Case Management (DCM) and Technician Preparedness for Contacting U.S. Technical Assistance (TAC)
Released 10/16/2019 Information for Dealers on How to Submit a Product Information Report (PIR) (Canada Only)
Released 9/6/2019 Procedure For Attaching GDS2 Session Logs To Technical Assistance Cases Using Dealer Case Management (US Dealers Only).
Released 9/5/2019 Creak/Pop Noise From Front Over Bumps
Released 8/19/2019 GM Wiring Repair Strategy Information
Released 6/26/2019 Information for Electrical Ground Repair - Use New Replacement Fasteners with Conductive Finish
Released 6/19/2019 Warranty Administration - Warranty SPS Control Module Reprogramming
Released 6/13/2019 Do Not Swap Modules in Vehicles with Global Electrical Systems
Released 6/4/2019 Reduced Propulsion Power without DTCs on Higher Mileage Vehicles
Released 5/13/2019 New Updated Calibrations Now For DTC P0AA6 To Prevent Possible Repeat Occurrences
Released 5/2/2019 Use of Dealer Case Management (DCM) and Technician Preparedness for Contacting U.S. Technical Assistance (TAC)
Released 4/23/2019 Intermittent Sunroof Operation, Bind, Noise, Auto-reverse, and/or Water Leaks
Released 4/2/2019 Do Not Swap Modules in Vehicles with Global Electrical Systems
Released 4/1/2019 Information on Proper Use of Floor Mats
Released 3/28/2019 Global Warranty Management (GWM) Warranty Parts Center (WPC) Parts Return Program Information
Released 3/26/2019 Warranty Administration - Updated - Dealer Empowerment Labor Operations and Customer Enthusiasm (U.S. Only)
Released 3/25/2019 Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability
Released 3/25/2019 New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores
Released 3/22/2019 Information on Proper Use of Floor Mats
Released 3/22/2019 Engineering Information (EI) Process
Released 3/18/2019 Information for Electrical Ground Repair - Use New Replacement Fasteners with Conductive Finish
Released 3/14/2019 Properly Maintaining Vehicles in Dealer Inventory
Released 3/13/2019 Procedure For Attaching GDS2 Session Logs To Technical Assistance Cases Using Dealer Case Management (US Dealers Only)
Released 3/13/2019 Procedure For Emailing Global Diagnostic System 2 (GDS2) Session Log To GM TAC (US and Canada Dealers Only).
Released 3/11/2019 Transport Mode On Message Displayed in DIC and/or Battery Light is Flashing
Released 3/8/2019 Procedure For Emailing Global Diagnostic System 2 (GDS2) Session Log To GM TAC (US and Canada Dealers Only)
Released 3/6/2019 Verifying Odometer Accuracy
Released 2/26/2019 Requesting a New Key Code for Customer with Lost or Stolen Keys
Released 2/8/2019 Unwanted Chime After BCM Program Update
Released 2/8/2019 Transport Mode On Message Displayed in DIC and/or Battery Light is Flashing
Released 2/8/2019 Warranty Administration â€“ Labor Operation 0600014 â€“ Suspected Tampering or Vehicle Modifications
Released 2/5/2019 Properly Maintaining Vehicles in Dealer Inventory
Released 1/31/2019 Use of Dealer Case Management (DCM) and Technician Preparedness for Contacting U.S. Technical Assistance (TAC)
Released 1/31/2019 Comeback Prevention Information and Using Customer Concern Verification Sheets (CCVS)
Released 1/18/2019 Warranty Administration - Revised Wiring Repair Labor Operations and Required Additional Information
Released 1/14/2019 Warranty Administration - Required Operating Procedures (U.S. Only)
Released 1/2/2019 Photographing Various Vehicle Concerns and Submitting Them to the GM Technical Assistance Center (TAC)
Released 12/21/2018 Warranty Administration - Customer Concern Not Duplicated (CCND) Labor Operation Numbers
Released 12/17/2018 GM TAC Support of Vehicle Vibration Complaints - U.S. and Canada Dealers Only
Released 12/13/2018 Use of Dealer Case Management (DCM) and Being Prepared for Contacting U.S. Technical Assistance (TAC)
Released 12/5/2018 Warranty Administration - Warranty, SPS, Control Module Diagnostics and Configuration Information, Programming, Set-Up
Released 12/5/2018 Information on Passenger Presence Sensing System (PPS or PSS) Concerns with Custom Upholstery, Accessory Seat Heaters or Other Comfort Enhancing Devices
Released 11/30/2018 Unable To Program New Or Replacement Key Fobs
Released 11/30/2018 Identifying Non-GM (Aftermarket) Engine Calibrations for Gasoline Engines Using Tech 2 or GDS 2 (U.S. and Canada)
Released 11/27/2018 Information for Dealers/Service Advisors on When and How to Submit a Pre-Repair Authorization (PRA) (U.S. Dealers Only)
Released 11/26/2018 Customer Satisfaction Program - Emission Warranty Coverage on EBCM Inadvertently Removed
Released 11/20/2018 Information for Dealers/Technicians on When and How to Submit a Field Product Report (FPR) (U.S. Dealers Only)
Released 11/20/2018 Requirements For OnStar Over The Air Programming And Updates
Released 11/20/2018 Diagnostic Tips: XM Audio Traffic And Travel Link Availability And Operation
Released 11/15/2018 Service Power Steering Message DTC C0800
Released 11/15/2018 Battery Too Cold Plug In To Warm Message Vehicle Will Not Start
Released 11/15/2018 Tips For operating the EL 50332 Hybrid/EV Battery Service Tool
Released 11/14/2018 Remote Monitoring of High Voltage Battery (U.S. Only)
Released 11/5/2018 Working with GM on a Product Assistance Claim (PAC)
Released 11/2/2018 Warranty Administration - Guidelines for Multiple Repairs with Independent Causes (GM Canada Dealers only)
Released 10/30/2018 Warranty Administration - Labor Operation 0600018 - Personal Property Damage
Released 10/26/2018 Use of Surface Conditioning Disks When Cleaning Gasket Sealing Surfaces and/or Reused Parts
Released 10/23/2018 Information on Disabling Passive Locking / Unlocking from Vehicle Outside Door Handles (U.S. and Canada Only)
Released 10/23/2018 Vehicle Vibration Diagnosis and TAC Requests For Assistance With Vibration Related Complaints
Released 10/19/2018 Vehicle Vibration Diagnosis and TAC Requests For Assistance With Vibration Related Complaints
Released 10/17/2018 Vehicle Vibration Diagnosis and TAC Requests For Assistance With Vibration Related Complaints
Released 10/17/2018 ELR And VOLT Misfire Detection - Service Information
Released 10/12/2018 Diagnostic Tip - Unable to Learn RKE Transmitters
Released 10/10/2018 AC Blows Warm or Poor Performance
Released 10/8/2018 PAC Courtesy Transportation Assistance Program
Released 10/3/2018 IPC Odometer Programming Method Quick Reference Guide
Released 10/3/2018 Diagnostic Tip: Fuel Injected Gasoline Engines Possible No Start Extended Crank or Fuel Pressure Related DTCs
Released 10/3/2018 Engine Replacement After Severe Internal Engine Damage - Replace Intake Manifold
Released 9/26/2018 Diagnostic Tip - Security Light on Intermittently / No Crank/No Start or Start Stall / Keyless Access Vehicles May Display No Remote/Fob Detected / Poor or No RKE Range / Service TPM
Released 9/20/2018 Customer Satisfaction - Carpeted Floor Mats Missing
Released 9/11/2018 High Voltage Lithium-Ion Battery Section Exchange Procedure
Released 9/11/2018 Warranty Administration - Essential Tools that Include Consumable Parts (U.S. Only)
Released 9/5/2018 Information on A/C Odors During Start Up in Hot Humid Climates
Released 8/29/2018 High Voltage Drive Motor Battery Repair And Exchange Process
Released 8/28/2018 Procedure For Emailing Global Diagnostic System 2 (GDS2) Session Log To GM TAC (US and Canada Dealers Only)
Released 8/27/2018 Diagnostic Tips for Intermittent Engine No Crank, Intermittent Exhaust Camshaft Position (CMP) Sensor Signal
Released 8/24/2018 Variable Diagnostic Time Allowances (U.S. Only)
Released 8/22/2018 Diagnostic Tips for Odor Emanating from HVAC System
Released 8/22/2018 Information on Paint Stain Under Protective Shipping Film
Released 8/22/2018 Rear and Side Tempered Glass Spots (Quench Marks)
Released 8/22/2018 Hem Flange Rust Repair
Released 8/22/2018 OEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification
Released 8/22/2018 Damaged, Disassembled or Improperly Packaged Turbochargers Returned to Warranty Part Center
Released 8/8/2018 Alleged Cylinders Out Of Round
Released 7/25/2018 Identifying Non-GM (Aftermarket) Engine Calibrations for Gasoline Engines Using Tech 2 or GDS 2 (U.S. and Canada)
Released 7/24/2018 Diagnostic Tip: Rear View Camera Brightness Control Options
Released 7/24/2018 Information on Internal Engine Noise or Damage After Oil Filter Replacement
Released 7/24/2018 Intake Manifold Inspection/Replacement After Severe Internal Engine Damage
Released 7/23/2018 Aftermarket ALDL or DLC Interface Devices Causing Multiple Issues
Released 7/3/2018 Intermittent Sunroof Operation, Bind, Noise, Auto-reverse, and/or Water Leaks
Released 6/22/2018 Dealer Responsibility for Cargo Carrying Capacity Labeling
Released 6/20/2018 AC Blows Warm or Poor Performance
Released 6/1/2018 Transport Mode On Message Displayed in DIC and/or Battery Light is Flashing
Released 5/30/2018 Global Warranty Management (GWM) Warranty Parts Center (WPC) Parts Return Program Information
Released 5/29/2018 Warranty Administration - High Voltage Battery Exchange Process Information
Released 5/23/2018 Diagnostic Tip: Apple Device Connectivity Issues due to USB Cord Concern
Released 5/14/2018 Warranty Administration - Required Operating Procedures (U.S. Only)
Released 5/10/2018 Warranty Administration - Courtesy Transportation and Roadside Assistance Programs
Released 5/4/2018 Diagnostic Tip for Intermittent Crank/No Start After Removal of Camshaft Sprockets
Released 5/4/2018 Warranty Administration - Proper Labor Operation Selection and Causal Part Identification for Warranty Transactions
Released 4/20/2018 Accessory Power Outlet and Trailer Lighting Fuse Replacement Labor Operation 5430130 Fuse Replacement
Released 4/9/2018 Information on Water or Ethylene Glycol in Transmission Fluid
Released 4/9/2018 (EREV) Drive Motor Generator Control Module (PIM) Part Restriction has ended
Released 4/6/2018 Underbody Component Corrosion
Released 4/4/2018 Diagnostic Tip: Rear View Camera Options
Released 3/27/2018 Transport Mode On Message Displayed in Driver Information Center (DIC) and/or Battery Light is Flashing (Follow Procedure as Outlined Below)
Released 3/16/2018 Eliminating Unwanted Odors in Vehicles
Released 3/9/2018 GM Accessories - Dealer-Installed, Repaired or Replaced During Warranty Coverage Period
Released 3/9/2018 Customer Satisfaction Program - Vehicle Communication Interface Module (VCIM) Programming Not Completed
Released 3/7/2018 New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores
Released 2/28/2018 Red LED, No WiFi Operation, and/or Limited OnStar Module Functionality After OnStar Module Replacement for Another Condition
Released 2/27/2018 Warranty Administration - Updated - Dealer Empowerment Labor Operations and Customer Enthusiasm (U.S. Only)
Released 2/2/2018 Do Not Swap Modules in Vehicles With Global Electrical Systems
Released 2/1/2018 Warranty Administration - Battery Testing and Warranty Replacement Requirements (North America ONLY)
Released 1/17/2018 Warranty Administration - Warranty Claims Submission - Outside Rear View Mirrors
Released 12/7/2017 Dealer Responsibility for Cargo Carrying Capacity Labeling
Released 12/5/2017 Intermittent No Crank/No Start, No Module Communication, MIL, Warning Lights, Vehicle Messages or DTCs Set by Various Control Modules - Diagnosing and Repairing Fretting Corrosion (Disconnect Affected Connector and Apply Dielectric Lubricant)
Released 11/17/2017 Intermittent Malfunction Indicator Lamp (MIL) Illuminated, DTC P2138 with Reduced Engine Power (Repair Instrument Panel (IP) to Body Harness Connector)
Released 11/17/2017 Information on COAX Repair Kit Availability
Released 11/7/2017 Verifying Odometer Accuracy
Released 10/6/2017 Diagnostic Tip - Diagnosing Vehicles with OnStar DTC B101D -37
Released 10/6/2017 Diagnostic Tips for Loss Of Brakes, Brake Pedal Going To Floor, Brake Pedal Hard, Brake Pedal Mushy, Possible Service Brake Assist and/or Service Stabilitrak Lights Illuminated
Released 9/28/2017 Diagnostic Tip: OnStar Vehicles with B101D and Symptom Codes
Released 8/30/2017 Aftermarket ALDL or DLC Interface Devices Causing Multiple Issues
Released 8/23/2017 Paint-less Dent Repair Process
Released 7/25/2017 Information on How to Prevent Inadvertent Vehicle Starting from Key Fob or OnStar Mobile Application
Released 7/11/2017 Vehicle Will Not Charge And Hybrid Loss Of Isolation With DTC P0AA6 And/Or P1FFF P1F0E P0DAA
Released 6/23/2017 Warranty Administration - Courtesy Transportation and Roadside Assistance Programs
Released 6/22/2017 Interior Cleaning -- Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer --Product Availability
Released 6/19/2017 (EREV) Volt and ELR 4ET50 Transmission Component Restriction Program Ended
Released 6/16/2017 Properly Maintaining Vehicles in Dealer Inventory
Released 6/16/2017 Seat Belt Extender Availability
Released 6/14/2017 Air Conditioning Odor (Install Evaporator Core Dryer Kit and Apply Cooling Coil Coating)
Released 5/22/2017 Chemical Staining, Pitting, Corrosion and/or Spotted Appearance of Chromed Aluminum Wheels
Released 5/15/2017 General Motors Dealership Critical Equipment Requirements and Recommendations
Released 5/10/2017 Broken or Separated Auxiliary Floor Mat Retainers, Floor Mat Retainer Wonâ€™t Seat on Carpet
Released 5/10/2017 Warranty Administration - Automatic Transmission Oil Cooler Flush and Flow Test
Released 4/25/2017 SES Light with Fuel Trim and or Oxygen Sensor Codes
Released 4/19/2017 Non-Design Intent Wheel Lock Nuts and Lug Nuts
Released 4/12/2017 Underbody Component Corrosion
Released 4/10/2017 Information on Proper Use of Floor Mats
Released 3/29/2017 Information on Driveline Clunk Noise
Released 3/15/2017 Warranty Administration - Field Action Courtesy Transportation Policy
Released 3/10/2017 Security Code Input Message with SPS Error Code E5659, M5304 and/or M5530 During TIS2web Programming
Released 2/20/2017 EBCM Wheel Speed Sensor Diagnostic Aid for ABS Message - Click or Ratchet Noise - Service Traction Message - Service Stabilitrak Message - Service Steering Message
Released 1/12/2017 Groan, Squeak or Rubbing Type Noise When Turning Steering Wheel
Released 12/19/2016 Information on Inappropriate Warranty Claims Submitted for Damaged Radios and Instrument Panel Clusters (IPCs)
Released 12/9/2016 GM of Canada New Vehicle Tire Warranty Program and GWM Transaction Submission Information
Released 12/5/2016 Warranty Administration - GM Dealer Empowerment Program and Goodwill Procedures
Released 11/15/2016 Alleged Cylinders Out Of Round
Released 11/10/2016 Information on Side Door Window Glass Chipping Caused by Hanging Vehicle Key Lock Box
Released 10/24/2016 Audio Muting When Listening to Some Sirius XM Channels Due to Interference in Some Geographic Locations
Released 10/21/2016 Information on Using MyBuick, MyCadillac, MyChevrolet, and MyGMC Phone Applications to Control GM Accessory Remote Start Kits
Released 10/7/2016 PQC Assembly Replacement Process - Dealers Required to Contact PQC Prior to Replacing an Assembly
Released 10/7/2016 Properly Maintaining Vehicles in Dealer Inventory
Released 9/30/2016 Vehicle Fuels Slow, Cannot Refuel or Fuel Pump Frequently Shuts Off Before Tank is Full (Replace Fuel Tank Filler Pipe)
Released 9/30/2016 Intermittent Pandora Operation
Released 9/30/2016 HomeLinkÂ® Programming to a Genie IntellicodeÂ® 2 Garage Door Opener
Released 9/30/2016 Unable to Access MP3 Files on CD, Bluetooth Connectivity, No Audio After a Bluetooth Call, Phone Book Usage Issues
Released 9/30/2016 Instructions for Installing Techline Infotainment DVD (GMNA Only)
Released 9/30/2016 CD/DVD Will Not Eject from Instrument Panel Mounted Player
Released 9/30/2016 Warranty Administration - Labor Operation 0600018 - Personal Property Damage
Released 9/30/2016 Information on Side Door Window Glass Chipping Caused by Hanging Vehicle Key Lock Box
Released 9/30/2016 Battery State of Charge (SOC) Drop After Charge Complete
Released 9/30/2016 Warranty Administration - Warranty Claims Submission - Outside Rear View Mirrors
Released 9/30/2016 Inadvertent Horn, Light, Remote Start, Lock/Unlock Activation or Charging Schedule Change
Released 9/30/2016 Information on USB Command and Control Multimedia Player Interface/List of Supported Apple Devices
Released 9/30/2016 Diagnosing DTC P0171
Released 9/30/2016 Changes to Essential and Available Tool Numbering System
Released 9/30/2016 Revised Steering Wheel Inflatable Restraint Module (Airbag) Replacement Procedure
Released 9/30/2016 Multiple Song Listings When Using USB Input
Released 9/30/2016 Wheel Balancing Machine Finish Damage to Chrome Clad or ChromeTechÂ® Wheels
Released 9/30/2016 Notchy or Stick/Slip Feeling in Steering Wheel Near Center Position
Released 9/30/2016 Handsfree/Bluetooth Audio Quality Issues
Released 9/27/2016 Warranty Administration - Labor Operation 0600014 - Suspected Tampering or Vehicle Modifications
Released 9/22/2016 Hem Flange Rust Repair
Released 9/22/2016 Information on Inappropriate Warranty Claims Submitted for Damaged Radios and Instrument Panel Clusters (IPCs)
Released 9/16/2016 IPC Odometer Programming Method Quick Reference Guide
Released 9/14/2016 OnStar Will Not Power Up
Released 9/9/2016 Rough Idle Crank No Start Extended Crank Or Misfire Due to Excessive Carbon On Top of the Valves or Sticking Valves
Released 8/12/2016 Special Coverage Adjustment - Accelerator Pedal Stalk Fracture
Released 8/12/2016 Warranty Administration - Servicing Vehicles from Canada (U.S. Dealers Only)
Released 8/3/2016 Non-approval of Clipping (Sectioning of Two Vehicles) for Collision Repair
Released 8/2/2016 Transport Mode On Message Displayed in Driver Information Center (DIC) and/or Battery Light is Flashing (Follow Procedure as Outlined Below)
Released 7/11/2016 Information for Engine Concerns Resulting from Lack of Scheduled Maintenance, Improper Service or Aftermarket Calibrations
Released 7/11/2016 Traction Control Light Flashes Under Hard Acceleration at Higher Road Speeds
Released 6/28/2016 Diagnostic Tip for Intermittent Crank/No Start After Removal of Cam Shaft Sprockets
Released 6/23/2016 Diagnostic Tip - Key Does Not Fold Or Will Not Stay Closed
Released 6/17/2016 Loss of Power Steering Assist, Hard to Steer, and/or Service Power Steering Message on DIC
Released 6/17/2016 Seat Belt Webbing/Latch Plate Becomes Twisted
Released 6/10/2016 Information on Proper Use of Floor Mats
Released 5/31/2016 Identifying Non-GM (Aftermarket) Engine Calibrations for Gasoline Engines Using Tech 2 or GDS 2 (U.S. and Canada)
Released 5/18/2016 Instrument Panel Cluster Will Not Dim After Replacement
Released 5/16/2016 New U.S. Dealer Special Tool Loan Program
Released 5/13/2016 Accessory Power Outlet and Trailer Lighting Fuse Replacement - Use Global Labor Operation 5430130 Fuse Replacement
Released 5/10/2016 Abnormal Noise And Or Vibration While Driving Due To Non-GM Aftermarket Accessory
Released 4/20/2016 Radio Does Not Mute Enough When OnStar Turn-By-Turn Navigation Directions Are Announced (Increase Volume Setting or Request Soft Mute Feature Change Through OnStar Customer Service)
Released 4/12/2016 Rear and Side Tempered Glass Spots (Quench Marks)
Released 4/12/2016 Information Regarding Magnetic Drain Plugs
Released 4/7/2016 Underbody Component Corrosion
Released 4/5/2016 Intermittent Sunroof Operation, Bind, Noise, Auto-reverse, and/or Water Leaks
Released 4/5/2016 Grease or Sealant Visible on Electronic Power Steering Gear - Should Not Be Interpreted as Leak
Released 3/29/2016 Being Prepared for TAC, Caller Preparedness and Checklist - Contacting U.S. Technical Assistance (TAC) and Use of Strategy Based Diagnostics
Released 3/14/2016 Power Foldaway Mirror Glass Shakes, Flutters at Normal Driving Speeds
Released 3/11/2016 Information Regarding Servicing Components Located Near SIR Components
Released 3/7/2016 Information on Slight Vehicle Movement in Park at Start Up After Cold Soak
Released 3/3/2016 Side Detection System Unavailable or Intermittently Side Blind Zone Stops Working
Released 3/2/2016 New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores
Released 3/2/2016 Properly Maintaining Vehicles in Dealer Inventory
Released 3/2/2016 Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability
Released 2/9/2016 Information on Inappropriate Warranty Claims Submitted for Damaged Radios and Instrument Panel Clusters (IPCs)
Released 2/8/2016 Odometer Servicing When The Odometer Cannot Be Set To The Actual Mileage
Released 2/5/2016 Hem Flange Rust Repair
Released 1/28/2016 Information on Passenger Presence Sensing System (PPS or PSS) Concerns with Custom Upholstery, Accessory Seat Heaters or Other Comfort Enhancing Devices
Released 1/1/2016 Information on Diagnosis and Replacement of Shock Absorber and Strut Due to Fluid Leak
Released 12/22/2015 IPC Odometer Programming Method Quick Reference Guide
Released 12/15/2015 OEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification
Released 12/14/2015 Important - Accessories Available Through Integrated Business Partners
Released 11/25/2015 GM TAC Support of Vehicle Vibration Complaints - U.S. and Canada Dealers Only
Released 11/23/2015 Verifying Odometer Accuracy
Released 11/12/2015 Warranty Administration - Revised Wiring Repair Labor Operations and Required Additional Information
Released 10/31/2015 White Film/Residue on Vehicle Interior, Door Trim Panels and/or Instrument Panel (IP)
Released 10/31/2015 Vehicle Vibration Diagnosis and TAC Requests For Assistance With Vibration Related Complaints
Released 10/31/2015 Updated Warranty and Policy Exchange Program for Electronic Products (U.S. and Canada)
Released 10/31/2015 Information on Engine Oil Consumption Guidelines
Released 10/31/2015 Diagnostic Tip Vehicle Will Not Crank Waiting To Initialize Message
Released 10/31/2015 (EREV / EV) CEL Or SVS Lamp On With History DTCs P16C4 Or P16C5 â€“ After Charging
Released 10/31/2015 Control Module Diagnostic Trouble Code(s) (DTC)(s) P0601, P0602, P0603, P0604, P0606, P062F, P06F3, P1621 Shared In Multiple Modules
Released 10/31/2015 Engine No Crank/No Start Due to Discharged 12V Battery
Released 10/31/2015 Use of Nitrogen Gas in Tires
Released 10/31/2015 Diagnostic Tip for Low Line Pressure or Pressure Regulator Valve Stuck After Pump Cover Replacement
Released 10/31/2015 Information on Paint Stain Under Protective Shipping Film
Released 10/31/2015 Warranty Administration - New Vehicle Maintenance Program Cross-Border Servicing between the U.S. and Canada
Released 10/31/2015 Mounting, Balancing and Installation of Accessory Wheels and Tires Available Through GM Accessories
Released 10/31/2015 Information on Poor, Limited, Reduced Remote Keyless Entry (RKE) or Remote Vehicle Start (RVS) Range
Released 10/31/2015 Exterior Lighting Components Tinted or Smoked by an Outside Vendor
Released 10/31/2015 High-Pitched / Whine Noise Heard Intermittently from Behind Rear Seats
Released 10/31/2015 SES light With Multiple High Voltage Battery Performance Codes
Released 10/31/2015 Reverse/Dome Lamps And Back Up Camera Inoperative 7FDR Fuse Open
Released 10/31/2015 Normal Characteristic - Heated Seat Operation After Performing A Remote Vehicle Start (RVS)
Released 10/31/2015 Availability of Passenger Compartment (Cabin) Air Filter
Released 10/31/2015 Diagnostic Tips for Preventing Oil Leaks After Changing Oil and Filter
Released 10/31/2015 Repair Information for Reconnection of Rear Window (Defroster) Contact or Tab
Released 10/31/2015 DTC C0544 and/or U0415 Set and Will Not Clear, Malfunction Indicator Lamp (MIL) On
Released 10/31/2015 Information on Proper Use of Floor Mats
Released 10/31/2015 Heated Seats Inoperative with DTC U0209 Reprogram Heated Seat Module
Released 10/31/2015 Special Coverage Adjustment - Power Steering Stick-Slip
Released 10/31/2015 Information on Drilling High Strength Steel Related to Collision Repair
Released 10/31/2015 Warranty Administration - Revised Customer Concern Not Duplicated (CCND) / Verified Labor Operation Numbers/How to Submit CCND Transactions in Global Warranty Management
Released 10/31/2015 Information on Removal/Cracking of Stainless Steel Wheel Nut Caps
Released 10/31/2015 Warranty, SPS, Control Module Diagnostics and Configuration Information, Programming, Set-Up
Released 10/31/2015 Customer Satisfaction - Liftgate Strut Rod Detaches
Released 10/31/2015 Information for Electrical Ground Repair - Use New Replacement Fasteners with Conductive Finish
Released 10/31/2015 Vibration Analysis Worksheet
Released 10/31/2015 Rattle or Popping Noise Heard in Rear Hatch Area
Released 10/31/2015 Wheel Alignment Specifications, Requirements and Recommendations for GM Vehicles
Released 10/31/2015 Automatic Transmission Shift and Engine Driveability Concerns and/or MIL ON Due to Aftermarket Oil Bath Type Air Filter Use
Released 10/31/2015 Turn By Turn Directions Not Displayed After Canada Upgrade
Released 10/31/2015 Unwanted Chime After BCM Program Update
Released 10/31/2015 PAC Courtesy Transportation Assistance Program
Released 10/31/2015 GM of Canada OnStar Cellular Communication Upgrade
Released 10/31/2015 Shorter Front Bumper Fascia Air Deflector Available for Service
Released 10/31/2015 Information on the Use of Non GM Approved Battery Chargers and Booster Packs
Released 10/31/2015 Seat Belt Webbing/Latch Plate Becomes Twisted
Released 10/31/2015 Water Present on Front Passenger Floor, A/C Drain Hose Not Positioned Correctly
Released 10/31/2015 Warranty Administration - Labor Operation 0600018 - Personal Property Damage
Released 10/31/2015 Updated Warranty and Policy Program for Electronic Products (U.S. and Canada)
Released 10/31/2015 Warranty Administration - Causal Part Requirements for Transactions Submitted to GM for Payment
Released 9/5/2015 Eliminating Unwanted Odors in Vehicles
Released 9/5/2015 High Voltage Drive Motor Battery Repair And Exchange Process
Released 9/5/2015 Enhancing Field Product Reports with Digital Pictures
Released 9/5/2015 Intermittent Malfunction Indicator Lamp (MIL) Illuminated, DTC P2138 with Reduced Engine Power (Repair Instrument Panel (IP) to Body Harness Connector)
Released 9/5/2015 Vehicle Fuels Slowly, Cannot Refuel or Fuel Pump Shuts Off Before Tank is Full
Released 8/22/2015 Warranty Administration - Essential Tools that Include Consumable Parts (U.S. Only)
Released 8/8/2015 Information on Proper Use of Floor Mats
Released 8/8/2015 Seat Belt Buckle Latching Issues and/or Seat Belt Warning Lights Illuminated
Released 7/25/2015 Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability
Released 7/25/2015 ACDelco Replacement Battery Warranty Procedures
Released 7/18/2015 New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores
Released 7/18/2015 Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability
Released 7/12/2015 TOP TIER Detergent Gasoline Information and Available Brands
Released 7/12/2015 Application of Anti-Corrosion Materials
Released 6/27/2015 Diagnostic Tips for Intermittent Engine No Crank, Intermittent Exhaust Camshaft Position (CMP) Sensor Signal
Released 6/27/2015 Information for Dealers/Technicians on When and How to Submit a Field Product Report (FPR) (U.S. Dealers Only)
Released 6/20/2015 Check Engine Lamp With DTC P0C57 P0C58 Or P0C62
Released 6/6/2015 Properly Maintaining Vehicles in Dealer Inventory
Released 6/1/2015 Customer Satisfaction - Automatic Crash Response System - Reprogram SDM
Released 5/30/2015 Usage of E85 Fuel in GM Vehicles
Released 5/23/2015 Information Regarding the Differences Between Leakage and Seepage
Released 5/16/2015 Noise, Vibration, Moaning Sounds and/or Rattle Heard at Idle or While Driving
Released 5/16/2015 Tips For operating the EL 50332 Hybrid/EV Battery Service Tool
Released 5/12/2015 Service Update for Inventory and Customer Vehicles - Insufficient Evaporative Emission Canister Capacity for Vapor Generation
Released 5/2/2015 Intermittently Key Will Not Rotate in Door or Ignition Lock Cylinder
Released 4/4/2015 Clunk Noise, Rear Transmission Mount Broken
Released 3/28/2015 Normal Characteristic - Key Off Radio Operation
Released 3/28/2015 Aftermarket ALDL or DLC Interface Devices Causing Multiple Issues
Released 1/31/2015 Information on Passenger Presence Sensing System (PPS or PSS) Concerns with Custom Upholstery, Accessory Seat Heaters or Other Comfort Enhancing Devices
Released 1/1/2015 Vehicle Will Not Charge And Hybrid Loss Of Isolation With DTC P0AA6 And/Or P1F0E P0DAA
Released 12/7/2014 Diagnostic Tip: OnStar Module Does Not Support All B101D Symptom Codes
Released 10/6/2014 Diagnostic Tip: Rear View Camera Options
Released 8/25/2014 Installation of Non-GM Approved Aftermarket Products
Released 8/18/2014 Supplemental Repair Required for Drive Motor Battery Coolant Radiator Replacement Due to Stone/Foreign Material Impact
Released 8/8/2014 Concerns Or Questions Regarding The Installation Of Dealer Installed Accessories
Released 8/7/2014 Inside Rear View Mirror is Loose and/or Mirror Mounting Bracket Fell Off
Released 7/17/2014 Electric Vehicle Electronics and Propulsion Diagnostic Tips
Released 7/17/2014 Key Cutting Procedure for Obtaining Replacement Key
Released 7/17/2014 Information on Water Pump Replacement
Released 7/17/2014 Rear Doors Intermittently will not Open from Inside and/or Electric Child Lock (ECL) LED Light in the ECL Switch Flashing
Released 7/17/2014 High Voltage Safety - High Voltage Disabling
Released 7/14/2014 Powertrain and Various Electrical/Electronic Control Issues
Released 7/11/2014 Information Regarding A/C Service Valve Tethered Cap Requirements in the State of Idaho
Released 7/10/2014 Software Update for EL-50332 Hybrid/EV Battery Service Tool
Released 7/8/2014 Procedure For Emailing Global Diagnostic System 2 (GDS2) Session Log To
Released 6/19/2014 Radio Reprogramming Using Techline/Service Programming System (SPS) - Ensuring Correct Vehicle Selection
Released 6/6/2014 Rattle or Popping Noise Heard in Rear Hatch Area
Released 5/23/2014 Rattle or Popping Noise Heard in Rear Hatch Area
Released 5/21/2014 (EREV) Diagnostic Tips for Intermittent MIL With DTC P0AB9
Released 5/16/2014 DTC Symptom Byte Documentation
Released 2/11/2014 Diagnostic Tip - MDI Cable Or SAS Learning Issues When Repairing Service Stability/Traction Message Or DTC C0710 SYM71
Released 2/8/2014 (Hybrid) Emergency First Responder Information
Released 2/7/2014 Heated Seats Inoperative With DTC U0209
Released 2/6/2014 Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum Wheel Bead Seat Corrosion (Clean and Resurface Wheel Bead Seat)
Released 2/1/2014 No Audio On Certain XM Radio Channels
Released 1/29/2014 Diagnostic Information for Intermittent 110/220V AC Plug-In Charging
Released 1/28/2014 Normal Characteristic - Key Off Radio Operation
Released 1/24/2014 GM Accessories - Dealer-Installed, Repaired or Replaced During Warranty Coverage Period
Released 1/4/2014 Proper Wheel Installation and Wheel Torque Techniques
Released 1/4/2014 Loose Ground Terminal Repair and Proper Labor Code
Released 1/3/2014 New Engine Oil and Oil Filter Replacement Procedure in Service Information (SI)
Released 11/29/2013 Rearview Camera Display Has Low Contrast When Backing Up in Direct Sunlight and/or at Night
Released 10/4/2013 Diagnostic Tip: Diagnosing Vehicles with OnStar DTC B101D-37
Released 10/1/2013 Information on Glass Ultra Violet UV Ray Protection And Tint Percentage
Released 8/23/2013 Oil Pressure Switch Replacement Information
Released 7/24/2013 TAC Part Restriction - Accessory DC Power Control Module (APM)
Released 6/19/2013 Information on Slight Vehicle Movement in Park at Start Up After Cold Soak
Released 6/19/2013 Dealership Service Consultant Procedure as Vehicle Comes into Service Drive for Tire Pressure Monitor (TPM) System Message, Light and Customer Information
Released 6/19/2013 Global Information for GM dexos 1 and dexos 2 Engine Oil Specifications, Licensed Brands, and Service Fill
Released 6/19/2013 Repair Information for Reconnection of Rear Window Defroster (Defogger) Contact or Tab
Released 6/19/2013 Correct Selection Of Labor Codes
Released 5/31/2013 Unexpected Loss of Radio Audio (Radio Goes Silent/No Sound) and Other Blackberry Phone - Bluetooth Issues
Released 4/23/2013 Odometer Servicing When The Odometer Cannot Be Set To The Actual Mileage
Released 4/19/2013 Diagnostic Tip - Key Does Not Fold Or Will Not Stay Closed
Released 4/12/2013 Information on Driveline Clunk Noise
Released 4/3/2013 High-Pitched / Whine Noise Heard Intermittently From Behind Rear Seats
Released 3/29/2013 Vehicle Software Enhancements
Released 3/22/2013 Vibration Analysis Worksheet
Released 3/22/2013 No XM Signal Radio Screen Display Message on UFU Radios Without UP9 MyLink/IntelliLink Option
Released 3/8/2013 Supplemental Repair Required for Drive Motor Battery Coolant Radiator Replacement Due to Stone/Foreign Materil Impact
Released 3/1/2013 Paint-less Dent Repair Process
Released 3/1/2013 No Crank/No Start, Dead Battery Due to Parasitic Drain/Discharge
Released 2/15/2013 Windshield Wiper Performance, Cleaning Instructions and Maintenance
Released 2/15/2013 Information for Electrical Ground Repair - Use New Replacement Fasteners with Conductive Finish
Released 2/11/2013 Prior To Any Circuit Testing
Released 1/8/2013 How To Disable The Remote Express Down Feature For Key Fob
Released 1/4/2013 Driver Airbag Light Flashing and/or Passenger Airbag ON Indicator Does Not Illuminate with Passenger Present After SDM Reprogramming
Released 1/1/2013 Various Driveability Symptoms Due to Clogged Fuel Injectors, MIL/SES DTCs P0171, P0172, P0174, P0300, P1174, P1175 (Clean Fuel Injectors and/or Perform Injector Test With AFIT CH-47976)
Released 1/1/2013 Information on Counterfeit Airbag Modules
Released 9/4/2012 IPC Odometer Programming Method Quick Reference Guide
Released 9/4/2012 Key Cutting Procedure for Obtaining Replacement Key
Released 5/3/2012 Information on Tire Radial Force Variation (RFV)
Released 4/15/2012 Passenger Presence System (PPS) May Command Seat Belt Reminder Chime and Passenger Airbag Indicator On When Electronic Devices or Conductive Objects are Placed on Front Passenger Seat, DTCs 5045 or B0074 0F May Set in PPS Module
Released 4/8/2012 Knock or Pop Noise Heard When Coming to a Stop or at Low Speeds Over Small Bumps
Released 3/19/2012 Hem Flange Rust Repair
Released 1/19/2012 Properly Maintaining Vehicles in Dealer Inventory
Released 1/19/2012 Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability
Released 1/14/2012 Properly Maintaining Vehicles in Dealer Inventory
Released 1/13/2012 Properly Maintaining Vehicles in Dealer Inventory
Released 1/13/2012 Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability
Released 1/13/2012 Properly Maintaining Vehicles in Dealer Inventory
Released 1/12/2012 Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability
Released 12/28/2011 Wind Buffeting (Noise) when Power Windows Operated
Released 12/27/2011 Wind Buffeting (Noise) when Power Windows Operated
Released 11/16/2011 SERVICE HIGH VOLTAGE CHARGING SYSTEM Message Displayed on Driver Information Center (DIC), Hybrid/EV Charging System Disabled, DTCs Set, Revised HV Battery Surge Tank Coolant Fill Level
Released 10/24/2011 Use of Surface Conditioning Disks When Cleaning Engine Gasket Sealing Surfaces and/or Reused Engine Parts
Released 10/22/2011 Warranty Code Generated By EL-50313 Midtronics GR8 Battery Tester/Charger Required for Claim Processing On Labor Operation 4041510 and Battery Part Restriction (North America ONLY)
Released 10/17/2011 Safety Belt Locking Conditions (Normal Operating Characteristics)
Released 10/13/2011 Eliminating Unwanted Odors in Vehicles
Released 9/23/2011 Missing OnStar Owner Kit Integration in Vehicle Owner Manual
Released 9/20/2011 Shorter Front Bumper Fascia Air Deflector Available for Service
Released 9/11/2011 Seat Belt Webbing/Latch Plate Becomes Twisted
Released 9/8/2011 Seat Belt Webbing/Latch Plate Becomes Twisted
Released 9/7/2011 Seat Belt Webbing/Latch Plate Becomes Twisted
Released 8/23/2011 Transport Mode On Message Displayed in Driver Information Center (DIC) and/or Battery Light is Flashing (Follow Procedure as Outlined Below)
Released 8/23/2011 Transport Mode On Message Displayed in Driver Information Center (DIC) and/or Battery Light is Flashing (Follow Procedure as Outlined Below)
Released 7/22/2011 Car and Truck Fix it Right the First Time Issues
Released 7/22/2011 Car and Truck Fix it Right the First Time Issues
Released 7/15/2011 Key Code Security Rules and Information on GM KeyCode Look-Up Application (Canada Only)
Released 7/11/2011 Key Cutting Procedure for Obtaining Replacement Key
Released 6/7/2011 Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability
Released 4/14/2011 New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores
Released 1/17/1997 Car and Truck Fix it Right the First Time Issues

Released 5/6/2019
Additional Information On Bleeding The Brakes

Released 3/20/2019
Explanation Electric Range Variation and Driving Tips For Maximum Range

Get all TSBs for 5 vehicles for only $25

TSB Description
Released 12/5/2018 Warranty Administration - Warranty, SPS, Control Module Diagnostics and Configuration Information, Programming, Set-Up
Released 10/6/2017 Diagnostic Tips for Loss Of Brakes, Brake Pedal Going To Floor, Brake Pedal Hard, Brake Pedal Mushy, Possible Service Brake Assist and/or Service Stabilitrak Lights Illuminated
Released 6/16/2017 Properly Maintaining Vehicles in Dealer Inventory
Released 4/12/2017 Underbody Component Corrosion
Released 2/20/2017 EBCM Wheel Speed Sensor Diagnostic Aid for ABS Message - Click or Ratchet Noise - Service Traction Message - Service Stabilitrak Message - Service Steering Message
Released 10/7/2016 Properly Maintaining Vehicles in Dealer Inventory
Released 6/21/2016 EBCM Wheel Speed Sensor Diagnostic Aid for ABS Message -Click Or Ratchet Noise- Service Traction Message - Service Stabilitrak Message - Service Steering Message
Released 3/2/2016 New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores
Released 3/2/2016 Properly Maintaining Vehicles in Dealer Inventory
Released 10/31/2015 Service Stabilitrak DTC C0196 After Vehicle Has Been Transported
Released 10/31/2015 Warranty Administration - Revised Customer Concern Not Duplicated (CCND) / Verified Labor Operation Numbers/How to Submit CCND Transactions in Global Warranty Management
Released 10/31/2015 TAC Parts Restriction Ended - EBCM and BPMV
Released 8/1/2015 Properly Maintaining Vehicles in Dealer Inventory
Released 6/13/2015 Service Stability Message With DTC C012E And C12FE
Released 6/6/2015 Properly Maintaining Vehicles in Dealer Inventory
Released 5/30/2015 Diagnostic Tip - MDI Cable Or SAS Learning Issues When Repairing Service Stability/Traction Message Or Chassis Buss DTCs
Released 9/17/2014 Additional Information On Bleeding The Brakes
Released 9/11/2014 TAC Parts Restriction - EBCM And BPMV
Released 4/25/2014 TAC Parts Restriction - EBCM And BPMV
Released 3/5/2014 Additional Information On Bleeding The Brakes
Released 2/7/2014 Additional Information On Bleeding The Brakes
Released 2/7/2014 TAC Parts Restriction - EBCM And BPMV
Released 2/6/2014 TAC Parts Restriction - EBCM And BPMV
Released 9/23/2013 (EREV) Explanation Electric Range Variation and Driving Tips For Maximum Range
Released 6/21/2013 FMVSS Noncompliance - Front Brakes Lock During ABS, Stability Control, or Traction Control Activation
Released 5/10/2013 EBCM Wheel Speed Sensor Diagnostic Aid for ABS Message - Click Or Ratchet Noise - Service Traction Message - Service Stabilitrak Message - Service Steering Message
Released 3/22/2013 Aftermarket ALDL or DLC Interface Devices Causing Multiple Issues
Released 3/19/2013 EBCM Wheel Speed Sensor Diagnostic Aid for ABS Message - Click Or Ratchet Noise - Service Traction Message - Service Stabilitrak Message
Released 2/18/2013 Pulsation Or Drumming Noise Felt Through Brake Pedal On Light Apply
Released 5/15/2012 Information on FNC Brake Rotors
Released 1/19/2012 Properly Maintaining Vehicles in Dealer Inventory
Released 1/17/2012 Car and Truck Fix it Right the First Time Issues
Released 1/14/2012 Properly Maintaining Vehicles in Dealer Inventory
Released 1/13/2012 Properly Maintaining Vehicles in Dealer Inventory
Released 7/22/2011 Car and Truck Fix it Right the First Time Issues
Released 1/17/1997 Car and Truck Fix it Right the First Time Issues

Released 10/24/2019
Check Engine Light with DTC P0C4A

Released 3/1/2019
(EREV Volt) Vacuum Coolant Fill Information

Get all TSBs for 5 vehicles for only $25

TSB Description
Released 5/10/2017 Warranty Administration - Automatic Transmission Oil Cooler Flush and Flow Test
Released 3/7/2017 Information on the Use of Stop Leak Additives in the Coolant System
Released 2/20/2017 Information on the Use of Stop Leak Additives in the Coolant System
Released 8/2/2016 Use of Surface Conditioning Disks When Cleaning Engine Gasket Sealing Surfaces and/or Reused Engine Parts
Released 2/24/2016 Information on the Use of Stop Leak Additives in the Coolant System
Released 2/11/2016 Unscheduled Supplemental Services (Including Flushing Services and Additives) and Proper Use of GM Simplified Maintenance Schedules (U.S. Only)
Released 10/31/2015 Update To The PDI Form For Installing Coolant Tank Tamper Resistant Bracket
Released 10/31/2015 (EREV) Information On Proper Coolant Usage for Ampera / ELR / Volt Cooling Systems
Released 10/31/2015 Warranty Administration - Revised Customer Concern Not Duplicated (CCND) / Verified Labor Operation Numbers/How to Submit CCND Transactions in Global Warranty Management
Released 10/31/2015 (EREV Volt) Vacuum Coolant Fill Information
Released 5/2/2015 Information on the Use of Stop Leak Additives in the Coolant System
Released 5/2/2015 Supplement To High Voltage Battery Pack Removal Procedure
Released 4/4/2015 Clunk Noise, Rear Transmission Mount Broken
Released 3/14/2015 Unscheduled Supplemental Services (Including Flushing Services and Additives) and Proper Use of GM Simplified Maintenance Schedules (Canada Only)
Released 8/18/2014 Supplemental Repair Required for Drive Motor Battery Coolant Radiator Replacement Due to Stone/Foreign Material Impact
Released 7/17/2014 Information on Water Pump Replacement
Released 6/16/2014 Service Update for Inventory and Customer Vehicles - RESS Battery Coolant Level Low - Expires with Base Warranty
Released 10/4/2013 Information on Water Pump Replacement
Released 3/8/2013 Supplemental Repair Required for Drive Motor Battery Coolant Radiator Replacement Due to Stone/Foreign Materil Impact
Released 9/4/2012 Key Cutting Procedure for Obtaining Replacement Key
Released 9/4/2012 Customer Satisfaction - Enhancements for Side Impact Pole Performance
Released 9/4/2012 Customer Satisfaction - Enhancements for Side Impact Pole Performance
Released 9/4/2012 Customer Satisfaction - Enhancements for Side Impact Pole Performance
Released 9/4/2012 Customer Satisfaction - Enhancements for Side Impact Pole Performance
Released 9/4/2012 Customer Satisfaction - Enhancements for Side Impact Pole Performance
Released 11/16/2011 SERVICE HIGH VOLTAGE CHARGING SYSTEM Message Displayed on Driver Information Center (DIC), Hybrid/EV Charging System Disabled, DTCs Set, Revised HV Battery Surge Tank Coolant Fill Level

Released 7/24/2020
Diagnostic Tip - Security Light on Intermittently / No Crank/No Start or Start Stall / Keyless Access Vehicles May Display No Remote/Fob Detected / Poor or No RKE Range / Service TPM

Released 7/21/2020
(EREV) Diagnostic Tips for Intermittent MIL With DTC P0AB9

Get all TSBs for 5 vehicles for only $25

TSB Description
Released 6/26/2020 Procedure For Emailing Global Diagnostic System 2 (GDS2) Session Log To GM TAC (US and Canada Dealers Only)
Released 5/21/2020 Misfire Template
Released 5/20/2020 IPC Odometer Programming Method Quick Reference Guide
Released 5/14/2020 IPC Odometer Programming Method Quick Reference Guide
Released 11/26/2019 Key Code Security Rules and Information on GM KeyCode Look-Up Application (U.S. Only)
Released 11/5/2019 J-35616-64B Or EL-35616-58 Terminal Test Probe Information/Repair
Released 10/24/2019 Check Engine Light with DTC P0C4A
Released 10/23/2019 Information on High Voltage Battery Pack Refurbish Kit
Released 9/25/2019 Do Not Swap Modules in Vehicles with Global Electrical Systems
Released 9/25/2019 Customer Satisfaction Program - Loss of Propulsion Due to Low Cell Voltage
Released 9/12/2019 High Voltage Drive Motor Battery TAC Approval and Exchange Program
Released 8/19/2019 GM Wiring Repair Strategy Information
Released 8/13/2019 (EREV / EV) CEL Or SVS Lamp On With History DTCs P16C4 Or P16C5 â€“ After Charging
Released 7/23/2019 Vehicle Will Not Charge DTC P0D26
Released 7/19/2019 Vehicle Will Not Charge And Hybrid Loss Of Isolation With DTC P0AA6 And/Or P1FFF P1F0E P0DAA
Released 7/9/2019 MIL Possible DTCs P1B10 And Or P1B0F
Released 7/9/2019 (EREV) (BEV) Diagnostic Tips For Service Charging System, Battery Saver Message or Low Battery Indicator Displayed On Electric Vehicles
Released 6/24/2019 Information on Counterfeit Airbag Modules
Released 6/17/2019 Vehicle Will Not Charge And Hybrid Loss Of Isolation With DTC P0AA6 And/Or P1FFF P1F0E P0DAA
Released 6/17/2019 Diagnostic Aid: Vehicle Will Not Shift Out Of Park
Released 6/17/2019 Unable To Charge Malfunction Indicator Lamp With DTC P16C1 Or P16C2
Released 6/4/2019 Reduced Propulsion Power without DTCs on Higher Mileage Vehicles
Released 6/3/2019 J-35616-64B Terminal Test Probe / Replacement Terminal / Terminated Lead
Released 5/28/2019 Procedure For Attaching GDS2 Session Logs To Technical Assistance Cases Using Dealer Case Management (US Dealers Only).
Released 5/24/2019 Information on No Start, Loss or Reduction of Propulsion - DTC P0AFA and/or P0BBE Set
Released 5/22/2019 Diagnostic Tip Vehicle Will Not Crank Waiting To Initialize Message
Released 5/13/2019 3 Phase Connector Block and Harness update (2011-2012 Volt)
Released 5/6/2019 Unable To Charge The Vehicle At A Remote Location
Released 5/1/2019 Reduced Propulsion Power without DTCs on Higher Mileage Vehicles (with P1.4 Cell Chemistry)
Released 4/23/2019 Intermittent Sunroof Operation, Bind, Noise, Auto-reverse, and/or Water Leaks
Released 4/15/2019 (Hybrid) Emergency First Responder Information
Released 4/2/2019 Do Not Swap Modules in Vehicles with Global Electrical Systems
Released 4/2/2019 (EREV) Informational - Testing And Charging Of The Absorbent Glass Mat (AGM) 12 Volt Battery Models
Released 3/20/2019 (EREV) Reduced Propulsion Power While Driving in Mountains
Released 3/20/2019 Diagnostic Tip - Tick or squeak noise from engine
Released 3/11/2019 Transport Mode On Message Displayed in DIC and/or Battery Light is Flashing
Released 1/29/2019 Cold Weather and Long Stand Time Battery Maintenance and Testing Tips
Released 1/22/2019 Diagnostic Tip - Security Light on Intermittently / No Crank/No Start or Start Stall / Keyless Access Vehicles May Display No Remote/Fob Detected / Poor or No RKE Range / Service TPo
Released 1/18/2019 Warranty Administration - Revised Wiring Repair Labor Operations and Required Additional Information
Released 1/17/2019 Vehicle Will Not Charge DTC P0D26
Released 1/2/2019 EREV 120v Charge Cord Frayed or Plug Deformed And Possibly Split EVSE
Released 12/13/2018 New Charge Receptacle To Address Charge Related Issues Diagnosed To A Receptacle - This May Include DTCs P0D22 P0D26 P0D58 P0D59
Released 12/13/2018 Exterior Lamp Condensation and Replacement Guidelines
Released 11/30/2018 Unable To Program New Or Replacement Key Fobs
Released 11/30/2018 Identifying Non-GM (Aftermarket) Engine Calibrations for Gasoline Engines Using Tech 2 or GDS 2 (U.S. and Canada)
Released 11/26/2018 Customer Satisfaction Program - Emission Warranty Coverage on EBCM Inadvertently Removed
Released 11/20/2018 Requirements For OnStar Over The Air Programming And Updates
Released 11/20/2018 Diagnostic Tips: XM Audio Traffic And Travel Link Availability And Operation
Released 11/15/2018 Service Power Steering Message DTC C0800
Released 11/15/2018 Battery Too Cold Plug In To Warm Message Vehicle Will Not Start
Released 11/15/2018 Tips For operating the EL 50332 Hybrid/EV Battery Service Tool
Released 11/14/2018 Remote Monitoring of High Voltage Battery (U.S. Only)
Released 10/23/2018 Information on Disabling Passive Locking / Unlocking from Vehicle Outside Door Handles (U.S. and Canada Only)
Released 10/23/2018 Vehicle Vibration Diagnosis and TAC Requests For Assistance With Vibration Related Complaints
Released 10/17/2018 ELR And VOLT Misfire Detection - Service Information
Released 10/12/2018 Diagnostic Tip - Unable to Learn RKE Transmitters
Released 10/3/2018 IPC Odometer Programming Method Quick Reference Guide
Released 9/26/2018 Diagnostic Tip - Security Light on Intermittently / No Crank/No Start or Start Stall / Keyless Access Vehicles May Display No Remote/Fob Detected / Poor or No RKE Range / Service TPM
Released 9/11/2018 High Voltage Lithium-Ion Battery Section Exchange Procedure
Released 8/29/2018 High Voltage Drive Motor Battery Repair And Exchange Process
Released 8/28/2018 Procedure For Emailing Global Diagnostic System 2 (GDS2) Session Log To GM TAC (US and Canada Dealers Only)
Released 8/27/2018 Diagnostic Tips for Intermittent Engine No Crank, Intermittent Exhaust Camshaft Position (CMP) Sensor Signal
Released 8/24/2018 Variable Diagnostic Time Allowances (U.S. Only)
Released 7/24/2018 Diagnostic Tip: Rear View Camera Brightness Control Options
Released 7/24/2018 Information on Internal Engine Noise or Damage After Oil Filter Replacement
Released 7/23/2018 Aftermarket ALDL or DLC Interface Devices Causing Multiple Issues
Released 7/3/2018 Intermittent Sunroof Operation, Bind, Noise, Auto-reverse, and/or Water Leaks
Released 6/1/2018 Transport Mode On Message Displayed in DIC and/or Battery Light is Flashing
Released 5/29/2018 Warranty Administration - High Voltage Battery Exchange Process Information
Released 5/23/2018 Diagnostic Tip: Apple Device Connectivity Issues due to USB Cord Concern
Released 5/4/2018 Diagnostic Tip for Intermittent Crank/No Start After Removal of Camshaft Sprockets
Released 4/20/2018 Accessory Power Outlet and Trailer Lighting Fuse Replacement Labor Operation 5430130 Fuse Replacement
Released 4/4/2018 Diagnostic Tip: Rear View Camera Options
Released 3/27/2018 Transport Mode On Message Displayed in Driver Information Center (DIC) and/or Battery Light is Flashing (Follow Procedure as Outlined Below)
Released 3/7/2018 New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores
Released 2/28/2018 Red LED, No WiFi Operation, and/or Limited OnStar Module Functionality After OnStar Module Replacement for Another Condition
Released 2/2/2018 (EREV) Whine, Scrape, Whistle Type Noise While Driving
Released 2/1/2018 Warranty Administration - Battery Testing and Warranty Replacement Requirements (North America ONLY)
Released 12/7/2017 Cold Weather and Long Stand Time Battery Maintenance and Testing Tips
Released 12/5/2017 Intermittent No Crank/No Start, No Module Communication, MIL, Warning Lights, Vehicle Messages or DTCs Set by Various Control Modules - Diagnosing and Repairing Fretting Corrosion (Disconnect Affected Connector and Apply Dielectric Lubricant)
Released 11/17/2017 Information on COAX Repair Kit Availability
Released 11/7/2017 Verifying Odometer Accuracy
Released 10/6/2017 Diagnostic Tip - Diagnosing Vehicles with OnStar DTC B101D -37
Released 9/5/2017 Updated Warranty and Policy Exchange Program for Electronic Products (U.S. and Canada)
Released 8/30/2017 Aftermarket ALDL or DLC Interface Devices Causing Multiple Issues
Released 7/25/2017 Transport Mode On Message Displayed in Driver Information Center (DIC) and/or Battery Light is Flashing (Follow Procedure as Outlined Below)
Released 7/25/2017 Information on How to Prevent Inadvertent Vehicle Starting from Key Fob or OnStar Mobile Application
Released 7/17/2017 Reduced Propulsion Power without DTCs on Higher Mileage Vehicles
Released 7/11/2017 Vehicle Will Not Charge And Hybrid Loss Of Isolation With DTC P0AA6 And/Or P1FFF P1F0E P0DAA
Released 6/28/2017 High Voltage Drive Motor Battery Repair and Exchange Process
Released 6/16/2017 Properly Maintaining Vehicles in Dealer Inventory
Released 6/8/2017 (EREV) Whine, Scrape, Whistle Type Noise While Driving
Released 6/8/2017 Check Engine Lamp With DTC P0C57 P0C58 Or P0C62
Released 6/2/2017 Vehicle Will Not Charge And Hybrid Loss Of Isolation With DTC P0AA6 And/Or P1F0E P0DAA
Released 4/6/2017 Warranty Administration - Battery Testing and Warranty Replacement Requirements (North America ONLY)
Released 3/7/2017 (EREV) Drive Motor Generator Control Module (PIM) Part Restriction
Released 2/23/2017 Check Engine Lamp With DTC P0C57 P0C58 Or P0C62
Released 2/23/2017 Explanation Electric Range Variation and Driving Tips for Maximum Range
Released 2/20/2017 Diagnostic Tip Vehicle Will Not Crank Waiting To Initialize Message
Released 2/20/2017 (EREV) Reduced Propulsion with P0C17 P1B03 Or P0C01 (Drive Motor 1 Only)
Released 1/26/2017 Drive Motor Generator Control Module (T6 PIM) Engineering Study on High Mileage First Generation Volts
Released 1/26/2017 (EREV) Drive Motor Generator Control Module (PIM) Part Restriction
Released 1/26/2017 P0604 Stored in the Hybrid Powertrain Control Module
Released 1/17/2017 Transport Mode On Message Displayed in Driver Information Center (DIC) and/or Battery Light is Flashing (Follow Procedure as Outlined Below)
Released 12/1/2016 (EREV) Volt and ELR 4ET50 Transmission Component Restriction Program
Released 11/7/2016 Transport Mode On Message Displayed in Driver Information Center (DIC) and/or Battery Light is Flashing (Follow Procedure as Outlined Below)
Released 10/27/2016 HPCM2 Fault Code P0606 Control Module Internal Performance
Released 10/17/2016 Warranty Administration - Changes in Powertrain Warranty Coverage Effective with 2010 Model Year
Released 10/13/2016 Warranty Administration - Battery Testing and Warranty Replacement Requirements (North America ONLY)
Released 10/7/2016 Properly Maintaining Vehicles in Dealer Inventory
Released 10/6/2016 Warranty Administration - Battery Testing and Warranty Replacement Requirements (North America ONLY)
Released 10/3/2016 High Voltage Drive Motor Battery Repair And Exchange Process
Released 9/30/2016 Battery State of Charge (SOC) Drop After Charge Complete
Released 9/30/2016 Revised Steering Wheel Inflatable Restraint Module (Airbag) Replacement Procedure
Released 9/27/2016 Warranty Administration - Labor Operation 0600014 - Suspected Tampering or Vehicle Modifications
Released 9/16/2016 IPC Odometer Programming Method Quick Reference Guide
Released 9/1/2016 Diagnostic Tip Vehicle Will Not Crank Waiting To Initialize Message
Released 8/30/2016 J-35616-64B Terminal Test Probe / Replacement Terminal / Terminated Lead
Released 8/12/2016 Warranty Administration - Battery Testing and Warranty Replacement Requirements (North America ONLY)
Released 6/14/2016 Prior To Any Circuit Testing
Released 5/18/2016 Instrument Panel Cluster Will Not Dim After Replacement
Released 5/16/2016 Warranty Administration - Revised Wiring Repair Labor Operations and Required Additional Information
Released 5/13/2016 Exterior Lighting Components Tinted or Smoked by an Outside Vendor
Released 5/13/2016 Accessory Power Outlet and Trailer Lighting Fuse Replacement - Use Global Labor Operation 5430130 Fuse Replacement
Released 5/6/2016 Transport Mode On Message Displayed in Driver Information Center (DIC) and/or Battery Light is Flashing (Follow Procedure as Outlined Below)
Released 4/22/2016 Warranty Administration - Battery Testing and Warranty Replacement Requirements (North America ONLY)
Released 4/20/2016 Cold Weather and Long Stand Time Battery Maintenance and Testing Tips
Released 4/19/2016 Normal Characteristic - OnStar Power Consumption
Released 3/15/2016 New Charge Receptacle To Address Charge Related Issues Diagnosed To A Receptacle - This May Include DTCs P0D22 P0D26 P0D58 P0D59
Released 3/11/2016 Information Regarding Servicing Components Located Near SIR Components
Released 3/11/2016 Explanation Electric Range Variation and Driving Tips For Maximum Range
Released 3/4/2016 Premature Catalytic Converter Failures
Released 3/3/2016 Transport Mode On Message Displayed in Driver Information Center (DIC) and/or Battery Light is Flashing (Follow Procedure as Outlined Below)
Released 3/2/2016 New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores
Released 3/2/2016 Properly Maintaining Vehicles in Dealer Inventory
Released 3/2/2016 Warranty Code Generated By EL-50313 Midtronics GR8 Battery Tester/Charger Required for Claim Processing On Labor Operation 4041510, 4041520 and 250 Mile/400 Km Labor Operation Restriction (North America ONLY)
Released 2/12/2016 Headlamp, Tail Lamp, License Lamp or Fog/Driving Lamp Damage
Released 2/8/2016 Exterior Lamp Condensation and Replacement Guidelines
Released 2/8/2016 Odometer Servicing When The Odometer Cannot Be Set To The Actual Mileage
Released 2/4/2016 (EREV) Drive Motor Generator Control Module (PIM) Part Restriction
Released 2/1/2016 Explanation Electric Range Variation and Driving Tips For Maximum Range
Released 1/28/2016 Information on Passenger Presence Sensing System (PPS or PSS) Concerns with Custom Upholstery, Accessory Seat Heaters or Other Comfort Enhancing Devices
Released 11/23/2015 Verifying Odometer Accuracy
Released 11/12/2015 Warranty Administration - Revised Wiring Repair Labor Operations and Required Additional Information
Released 10/31/2015 Unable To Complete Software Update On The EL-50332 EV Battery Service Tool
Released 10/31/2015 Updated Warranty and Policy Exchange Program for Electronic Products (U.S. and Canada)
Released 10/31/2015 How To Disable The Remote Express Down Feature For Key Fob
Released 10/31/2015 Diagnostic Tip Vehicle Will Not Crank Waiting To Initialize Message
Released 10/31/2015 Check Engine Lamp With DTC P0C57 P0C58 Or P0C62
Released 10/31/2015 (EREV) Informational - Testing And Charging Of The Absorbent Glass Mat (AGM) 12 Volt Battery
Released 10/31/2015 Engine No Crank/No Start Due to Discharged 12V Battery
Released 10/31/2015 (EREV) Informational - Testing And Charging Of The Absorbent Glass Mat (AGM) 12 Volt Battery
Released 10/31/2015 Information on Poor, Limited, Reduced Remote Keyless Entry (RKE) or Remote Vehicle Start (RVS) Range
Released 10/31/2015 Exterior Lighting Components Tinted or Smoked by an Outside Vendor
Released 10/31/2015 Informational Front And Rear Fuse Block Terminated Leads
Released 10/31/2015 High-Pitched / Whine Noise Heard Intermittently from Behind Rear Seats
Released 10/31/2015 SES light With Multiple High Voltage Battery Performance Codes
Released 10/31/2015 Normal Characteristic - Heated Seat Operation After Performing A Remote Vehicle Start (RVS)
Released 10/31/2015 HPCM Fault DTC P1A56 Hybrid Battery Voltage Discharge Circuit
Released 10/31/2015 Update To The PDI Form For Installing Coolant Tank Tamper Resistant Bracket
Released 10/31/2015 Reverse/Dome Lamps And Back Up Camera Inoperative F7DR Fuse Open
Released 10/31/2015 Transport Mode On Message Displayed in Driver Information Center (DIC) and/or Battery Light is Flashing (Follow Procedure as Outlined Below)
Released 10/31/2015 (EV / EREV) P1EE6 Set With Or Without Service Vehicle Soon (SVS) Or Check Engine Lamp (CEL) On After Charging
Released 10/31/2015 High Voltage Drive Motor Battery Repair and Exchange Process
Released 10/31/2015 (EREV) Diagnostic Tips for Intermittent MIL With DTC P0AB9
Released 10/31/2015 New Charge Receptacle To Address Charge Related Issues Diagnosed To A Receptacle - This May Include DTCs P0D22 P0D26 P0D58 P0D59
Released 10/31/2015 (EREV) Reduced Propulsion with P0C17 P1B03 Or P0C01 (Drive Motor 1 Only)
Released 10/31/2015 J-35616-64B Terminal Test Probe / Replacement Terminal / Terminated Lead
Released 10/31/2015 Warranty Administration - Revised Wiring Repair Labor Operations and Required Additional Information
Released 10/31/2015 (EREV) Drive Motor Generator Control Module (PIM) Part Restriction
Released 10/31/2015 Warranty Administration - Revised Customer Concern Not Duplicated (CCND) / Verified Labor Operation Numbers/How to Submit CCND Transactions in Global Warranty Management
Released 10/31/2015 Warranty, SPS, Control Module Diagnostics and Configuration Information, Programming, Set-Up
Released 10/31/2015 ACDelco® Replacement Battery Warranty Procedures
Released 10/31/2015 Information for Electrical Ground Repair - Use New Replacement Fasteners with Conductive Finish
Released 10/31/2015 TAC Part Restriction Ended - T18 Battery Charge Module (OBCM) Part Restriction
Released 10/31/2015 Heated Seats Inoperative with DTC U0209 Reprogram Heated Seat Module
Released 10/31/2015 Cold Weather and Long Stand Time Battery Maintenance and Testing Tips
Released 10/31/2015 Reverse/Dome Lamps And Back Up Camera Inoperative F7DR Fuse Open
Released 10/31/2015 EREV 120v Charge Cord Frayed or Plug Deformed And Possibly Split EVSE
Released 10/31/2015 GM of Canada OnStar Cellular Communication Upgrade
Released 10/31/2015 (EREV) Charge Incomplete Charge Interrupted and MIL - With DTCs P0D3E or P0D3F
Released 10/31/2015 (EREV) DTC P0335 And Or P0336 Stored In The T6 Power Inverter Module (HPCM)
Released 10/31/2015 3 Phase Connector Block and Harness update (2011-2012 Volt)
Released 10/31/2015 Information on the Use of Non GM Approved Battery Chargers and Booster Packs
Released 10/31/2015 Cold Weather and Long Stand Time Battery Maintenance and Testing Tips
Released 9/12/2015 Accessory Power Outlet and Trailer Lighting Fuse Replacement - Use Global Labor Operation 5430130 Fuse Replacement
Released 9/5/2015 GM Wiring Repair Strategy Information
Released 9/5/2015 High Voltage Drive Motor Battery Repair And Exchange Process
Released 9/5/2015 Warranty Code Generated By EL-50313 Midtronics GR8 Battery Tester/Charger Required for Claim Processing On Labor Operation 4041510, 4041520 and 250 Mile/400 Km Labor Operation Restriction (North America ONLY)
Released 8/1/2015 Properly Maintaining Vehicles in Dealer Inventory
Released 7/25/2015 ACDelco Replacement Battery Warranty Procedures
Released 7/4/2015 Check Engine Lamp With DTC P0C57 P0C58 Or P0C62
Released 7/4/2015 (EREV) (BEV) Diagnostic Tips For Service Charging System, Battery Saver Message or Low Battery Indicator Displayed On Electric Vehicles
Released 6/20/2015 (Hybrid) Emergency First Responder Information
Released 6/20/2015 Chevrolet Spark EV (BEV) Diagnostic Tips For Battery Saver Message Or Low Battery Indicator Displayed
Released 6/20/2015 Check Engine Lamp With DTC P0C57 P0C58 Or P0C62
Released 6/6/2015 Properly Maintaining Vehicles in Dealer Inventory
Released 6/1/2015 Customer Satisfaction - Automatic Crash Response System - Reprogram SDM
Released 5/16/2015 TAC Part Restriction Ended Hybrid Powertrain Control Module 2 (HPCM 2) Part Restriction
Released 5/16/2015 Tips For operating the EL 50332 Hybrid/EV Battery Service Tool
Released 5/2/2015 Supplement To High Voltage Battery Pack Removal Procedure
Released 5/2/2015 Headlamp, Tail Lamp, License Lamp or Fog/Driving Lamp Damage
Released 5/2/2015 Transport Mode On Message Displayed in Driver Information Center (DIC) and/or Battery Light is Flashing (Follow Procedure as Outlined Below)
Released 3/28/2015 Aftermarket ALDL or DLC Interface Devices Causing Multiple Issues
Released 3/28/2015 Unable To Charge Malfunction Indicator Lamp With DTC P16C1 Or P16C2
Released 3/14/2015 Warranty Administration â€“ Labor Operation 0600014 â€“ Suspected Tampering or Vehicle Modifications
Released 1/31/2015 Information on Passenger Presence Sensing System (PPS or PSS) Concerns with Custom Upholstery, Accessory Seat Heaters or Other Comfort Enhancing Devices
Released 1/1/2015 Radio Does Not Mute Enough When OnStar Turn-By-Turn Navigation Directions Are Announced (Increase Volume Setting or Request Soft Mute Feature Change Through OnStar Customer Service)
Released 1/1/2015 Vehicle Will Not Charge And Hybrid Loss Of Isolation With DTC P0AA6 And/Or P1F0E P0DAA
Released 11/6/2014 T18 Battery Charge Module (OBCM) Part Restriction
Released 10/31/2014 (EREV) DTC P0335 And Or P0336 Stored In The T6 Power Inverter Module (HPCM)
Released 10/21/2014 (EREV) Drive Motor Generator Control Module (PIM) Part Restriction
Released 10/21/2014 Informational Front And Rear Fuse Block Terminated Leads
Released 10/1/2014 New Updated Calibrations Now For DTC P0AA6 To Prevent Possible Repeat Occurrences
Released 9/16/2014 TAC Part Restriction Ended - Accessory DC Power Control Module (APM)
Released 9/11/2014 Vehicle Will Not Charge And Hybrid Loss Of Isolation With DTC P0AA6
Released 9/11/2014 Unable To Connect High Voltage Cable To Replacement Accessory DC Power Control Module (APM)
Released 8/25/2014 Installation of Non-GM Approved Aftermarket Products
Released 8/8/2014 Concerns Or Questions Regarding The Installation Of Dealer Installed Accessories
Released 7/31/2014 New Charge Receptacle To Address Charge Related Issues Diagnosed To A Receptacle - This May Include DTCs P0D22 P0D26 P0D58 P0D59
Released 7/17/2014 Electric Vehicle Electronics and Propulsion Diagnostic Tips
Released 7/17/2014 Accessory Power Outlet and Trailer Lighting Fuse Replacement - Use GLC Labor Operation 5430130 Fuse Replacement
Released 7/17/2014 Rear Doors Intermittently will not Open from Inside and/or Electric Child Lock (ECL) LED Light in the ECL Switch Flashing
Released 7/17/2014 High Voltage Safety - High Voltage Disabling
Released 7/14/2014 Powertrain and Various Electrical/Electronic Control Issues
Released 7/10/2014 Software Update for EL-50332 Hybrid/EV Battery Service Tool
Released 6/19/2014 Radio Reprogramming Using Techline/Service Programming System (SPS) - Ensuring Correct Vehicle Selection
Released 6/4/2014 Vehicle Will Not Charge And Hybrid Loss Of Isolation With DTC P0AA6 And/Or P1F0E P0DAA
Released 5/16/2014 DTC Symptom Byte Documentation
Released 5/8/2014 How To Disable The Remote Express Down Feature For Key
Released 4/12/2014 (EREV) Drive Motor Generator Control Module (PIM) Part Restriction
Released 2/12/2014 Diagnostic Tip - Unable to Learn RKE Transmitters
Released 2/11/2014 Vehicle Will Not Charge DTC P0D26
Released 2/11/2014 Diagnostic Tip - MDI Cable Or SAS Learning Issues When Repairing Service Stability/Traction Message Or DTC C0710 SYM71
Released 2/8/2014 Battery Too Cold Plug In To Warm Message Vehicle Will Not Start
Released 2/8/2014 (Hybrid) Emergency First Responder Information
Released 2/1/2014 No Audio On Certain XM Radio Channels
Released 1/28/2014 Normal Characteristic - Key Off Radio Operation
Released 1/4/2014 Loose Ground Terminal Repair and Proper Labor Code
Released 11/22/2013 Engine No Crank/No Start Due to Discharged 12V Battery
Released 11/12/2013 Vehicle Will Not Charge And Hybrid Loss Of Isolation With DTC P0AA6 And/Or P1F0E P0DAA
Released 11/8/2013 T18 Battery Charge Module (OBCM) Part Restriction
Released 10/25/2013 ECE Noncompliance - Daytime Running Lamps Not Working as Designed (Export Vehicles Only)
Released 10/18/2013 DTC C0544 and/or U0415 Set and Will Not Clear, Malfunction Indicator Lamp (MIL) On
Released 10/16/2013 Spark EV Chevrolet Volt Opel Ampera Models With Or Without Service Vehicle Soon Lamp - SVS - or Check Engine Lamp On With DTC P0534 Set Current Or History
Released 10/15/2013 Unable To Charge Check Engine Lamp with DTC P16C1 Or P16C2
Released 10/15/2013 Vehicle Will Not Charge And Hybrid Loss Of Isolation With DTC P0AA6 And/Or P1F0E
Released 10/5/2013 OnStar Will Not Power Up
Released 10/4/2013 Service Update for Inventory and Customer Vehicles - Power Inverter Module Reprogram - Expires with Base Warranty
Released 9/27/2013 P1EE6 Set (EV or EREV) Volt, Spark EV, ELR and Ampera Vehicles With Or Without Service Vehicle Soon Lamp (SVS) On after charging at 240V Charge Station
Released 9/27/2013 (EREV) DTC P0335 And/Or P0336 Stored In The HPCM
Released 9/14/2013 OnStar Will Not Power Up
Released 8/23/2013 Oil Pressure Switch Replacement Information
Released 8/2/2013 Engineering Information - Engine No Crank/No Start Due to Discharged 12V Battery
Released 8/1/2013 SES Light With DTC P0534
Released 7/24/2013 TAC Part Restriction - Accessory DC Power Control Module (APM)
Released 6/21/2013 FMVSS Noncompliance - Front Brakes Lock During ABS, Stability Control, or Traction Control Activation
Released 6/19/2013 Information on Slight Vehicle Movement in Park at Start Up After Cold Soak
Released 6/19/2013 Global Information for GM dexos 1 and dexos 2 Engine Oil Specifications, Licensed Brands, and Service Fill
Released 6/19/2013 Repair Information for Reconnection of Rear Window Defroster (Defogger) Contact or Tab
Released 6/7/2013 (EREV) Charge Incomplete Charge Interrupted And MIL, With DTCs P0D3E or P0D3F with P1E00
Released 5/31/2013 Unexpected Loss of Radio Audio (Radio Goes Silent/No Sound) and Other Blackberry Phone - Bluetooth Issues
Released 5/29/2013 Normal Characteristic - Unable To Pause CD Or Media
Released 5/24/2013 (EREV) Whine, Scrape, Whistle Type Noise While Driving DTC: P0A46
Released 5/15/2013 J-35616-64B Terminal Test Probe And Replacement Terminal
Released 5/3/2013 Check Engine Lamp with DTC P0C58 Or P0C62
Released 4/29/2013 Normal Characteristic - Heated Seat Operation After Performing A Remote Vehicle Start (RVS)
Released 4/26/2013 Engineering Information - Engine No Crank/No Start Due to Discharged 12V Battery
Released 4/23/2013 Odometer Servicing When The Odometer Cannot Be Set To The Actual Mileage
Released 4/18/2013 (EREV) Whine Scrape Whistle Type Noise While Driving DTC P0A46
Released 4/12/2013 Information on Driveline Clunk Noise
Released 3/29/2013 Vehicle Software Enhancements
Released 3/29/2013 Accessory Power Outlet and Trailer Lighting Fuse Replacement Labor Operation N1720 Fuse Replacement
Released 3/29/2013 Powertrain and Various Electrical/Electronic Control Issues
Released 3/22/2013 Aftermarket ALDL or DLC Interface Devices Causing Multiple Issues
Released 3/22/2013 Vibration Analysis Worksheet
Released 3/22/2013 No XM Signal Radio Screen Display Message on UFU Radios Without UP9 MyLink/IntelliLink Option
Released 3/22/2013 OnStar Will Not Power Up
Released 3/21/2013 Diagnostic Tip - Unable to Learn RKE Transmitters
Released 3/15/2013 SES Light With DTC U0111
Released 3/15/2013 SES Light With DTC P0A1F
Released 3/5/2013 (BEV, EREV) Charge Incomplete Charge Interrupted And MIL, With DTCs P0D3E P1E00
Released 3/1/2013 DVD Navigation Update Program, Navigation Disc Diagnostic Aid, AVN Software Update Discs and Ordering Information
Released 3/1/2013 Paint-less Dent Repair Process
Released 3/1/2013 No Crank/No Start, Dead Battery Due to Parasitic Drain/Discharge
Released 2/15/2013 Windshield Wiper Performance, Cleaning Instructions and Maintenance
Released 2/15/2013 Information for Electrical Ground Repair - Use New Replacement Fasteners with Conductive Finish
Released 2/13/2013 Informational - MIL Possible DTCs P1B10 And Or P1B0F
Released 2/11/2013 Prior To Any Circuit Testing
Released 2/1/2013 Engineering Information - Engine No Crank/No Start Due to Discharged 12V Battery
Released 1/30/2013 TAC Part Restriction - Vehicle Wiring Harness
Released 1/30/2013 (BEV, EREV) Charge Incomplete Charge Interrupted And MIL, Information Only
Released 1/16/2013 TAC Part Restriction - Accessory Power Module (APM)
Released 1/8/2013 How To Disable The Remote Express Down Feature For Key Fob
Released 1/4/2013 Engineering Information - Engine No Crank/No Start Due to Discharged 12V Battery
Released 1/4/2013 No XM Signal Radio Screen Display Message on UFU Radios Without UP9 MyLink/IntelliLink Option
Released 1/4/2013 Driver Airbag Light Flashing and/or Passenger Airbag ON Indicator Does Not Illuminate with Passenger Present After SDM Reprogramming
Released 1/1/2013 Accessory Power Outlet and Trailer Lighting Fuse Replacement Labor Operation N1720 Fuse Replacement
Released 1/1/2013 High Voltage Battery Section Serviceability - Essential Tool EL-50332
Released 1/1/2013 Information on Counterfeit Airbag Modules
Released 1/1/2013 IPC Odometer Programming Method Quick Reference Guide
Released 1/1/2013 Information on Counterfeit Airbag Modules
Released 12/19/2012 (EREV) Whine, Scrape, Whistle Type Noise While Driving
Released 12/18/2012 (EREV) DTC P0335 and Or P0336 Stored In The HPCM
Released 12/18/2012 High Voltage Drive Motor Battery Repair And Exchange Process
Released 12/17/2012 Checking Smartphone Bluetooth Software Update Status
Released 12/14/2012 Poor Remote Transmitter Range/Remote Start Or TPM Indicator On
Released 9/4/2012 Customer Satisfaction - Driver Airbag Inspection
Released 9/4/2012 Diagnostic Information for Intermittent 110/220V AC Plug-In Charging
Released 9/4/2012 Customer Satisfaction - Enhancements for Side Impact Pole Performance
Released 9/4/2012 Customer Satisfaction - Driver Airbag Inspection
Released 9/4/2012 Customer Satisfaction - Driver Airbag Inspection
Released 9/4/2012 Customer Satisfaction - Enhancements for Side Impact Pole Performance
Released 9/4/2012 Customer Satisfaction - Enhanced 120 Volt Charge Cord
Released 9/4/2012 Customer Satisfaction - Enhancements for Side Impact Pole Performance
Released 9/4/2012 Customer Satisfaction - Enhancements for Side Impact Pole Performance
Released 9/4/2012 Customer Satisfaction - Enhanced 120 Volt Charge Cord
Released 9/4/2012 Customer Satisfaction - Enhancements for Side Impact Pole Performance
Released 9/4/2012 Customer Satisfaction - Enhancements for Side Impact Pole Performance
Released 5/8/2012 Properly Maintaining Vehicles in Dealer Inventory
Released 4/15/2012 Passenger Presence System (PPS) May Command Seat Belt Reminder Chime and Passenger Airbag Indicator On When Electronic Devices or Conductive Objects are Placed on Front Passenger Seat, DTCs 5045 or B0074 0F May Set in PPS Module
Released 3/5/2012 Part Restriction and Ordering Process Information for OnStar Vehicle Communication Interface Modules (VCIM)
Released 3/3/2012 Warranty, SPS, Control Module Diagnostics and Configuration Information, Programming, Set-Up
Released 2/14/2012 Installation of Non-GM Approved Aftermarket Products
Released 2/10/2012 Service Programming System (SPS) Errors (E4398, E4399, E4403, E4404 E4413, E4414, E4423 or E4491, E4494)
Released 1/19/2012 Properly Maintaining Vehicles in Dealer Inventory
Released 1/17/2012 Car and Truck Fix it Right the First Time Issues
Released 1/14/2012 Properly Maintaining Vehicles in Dealer Inventory
Released 1/13/2012 Properly Maintaining Vehicles in Dealer Inventory
Released 1/13/2012 Properly Maintaining Vehicles in Dealer Inventory
Released 12/28/2011 Wind Buffeting (Noise) when Power Windows Operated
Released 11/17/2011 SERVICE HIGH VOLTAGE CHARGING SYSTEM Message Displayed on Driver Information Center (DIC), Hybrid/EV Charging System Disabled, DTCs Set
Released 11/16/2011 SERVICE HIGH VOLTAGE CHARGING SYSTEM Message Displayed on Driver Information Center (DIC), Hybrid/EV Charging System Disabled, DTCs Set, Revised HV Battery Surge Tank Coolant Fill Level
Released 11/16/2011 SERVICE HIGH VOLTAGE CHARGING SYSTEM Message Displayed on Driver Information Center (DIC), Hybrid/EV Charging System Disabled, DTCs Set, Revised HV Battery Surge Tank Coolant Fill Level
Released 10/22/2011 Warranty Code Generated By EL-50313 Midtronics GR8 Battery Tester/Charger Required for Claim Processing On Labor Operation 4041510 and Battery Part Restriction (North America ONLY)
Released 9/17/2011 Transport Mode On Message Displayed in Driver Information Center (DIC) and/or Battery Light is Flashing (Follow Procedure as Outlined Below)
Released 9/15/2011 Transport Mode On Message Displayed in Driver Information Center (DIC) and/or Battery Light is Flashing (Follow Procedure as Outlined Below)
Released 9/13/2011 Transport Mode On Message Displayed in Driver Information Center (DIC) and/or Battery Light is Flashing (Follow Procedure as Outlined Below)
Released 9/11/2011 Transport Mode On Message Displayed in Driver Information Center (DIC) and/or Battery Light is Flashing (Follow Procedure as Outlined Below)
Released 9/7/2011 Transport Mode On Message Displayed in Driver Information Center (DIC) and/or Battery Light is Flashing (Follow Procedure as Outlined Below)
Released 9/4/2011 Transport Mode On Message Displayed in Driver Information Center (DIC) and/or Battery Light is Flashing (Follow Procedure as Outlined Below)
Released 8/24/2011 Transport Mode On Message Displayed in Driver Information Center (DIC) and/or Battery Light is Flashing (Follow Procedure as Outlined Below)
Released 8/23/2011 Transport Mode On Message Displayed in Driver Information Center (DIC) and/or Battery Light is Flashing (Follow Procedure as Outlined Below)
Released 8/23/2011 Transport Mode On Message Displayed in Driver Information Center (DIC) and/or Battery Light is Flashing (Follow Procedure as Outlined Below)
Released 8/23/2011 Transport Mode On Message Displayed in Driver Information Center (DIC) and/or Battery Light is Flashing (Follow Procedure as Outlined Below)
Released 8/23/2011 Transport Mode On Message Displayed in Driver Information Center (DIC) and/or Battery Light is Flashing (Follow Procedure as Outlined Below)
Released 7/22/2011 Car and Truck Fix it Right the First Time Issues
Released 6/6/2011 Information for Electrical Ground Repair - Use New Replacement Fasteners with Conductive Finish
Released 5/19/2011 IPC Odometer Programming Method Quick Reference Guide
Released 5/13/2011 Headlamp, Tail Lamp or Fog/Driving Lamp Damage
Released 1/17/1997 Car and Truck Fix it Right the First Time Issues

Released 4/10/2019
(EREV) MIL DTC P0497

Released 3/7/2018
New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores

Get all TSBs for 5 vehicles for only $25

TSB Description
Released 2/2/2018 Do Not Swap Modules in Vehicles With Global Electrical Systems
Released 12/5/2017 Intermittent No Crank/No Start, No Module Communication, MIL, Warning Lights, Vehicle Messages or DTCs Set by Various Control Modules - Diagnosing and Repairing Fretting Corrosion (Disconnect Affected Connector and Apply Dielectric Lubricant)
Released 3/10/2017 Security Code Input Message with SPS Error Code E5659, M5304 and/or M5530 During TIS2web Programming
Released 10/17/2016 Warranty Administration - Changes in Powertrain Warranty Coverage Effective with 2010 Model Year
Released 9/26/2016 Handling Requests For Modifications To Permanently Import / Export Vehicles Between The US And Canada
Released 6/28/2016 Diagnostic Tip for Intermittent Crank/No Start After Removal of Cam Shaft Sprockets
Released 10/31/2015 Control Module Diagnostic Trouble Code(s) (DTC)(s) P0601, P0602, P0603, P0604, P0606, P062F, P06F3, P1621 Shared In Multiple Modules
Released 10/31/2015 Product Safety - Unintentional Engine Running
Released 10/31/2015 (EV / EREV) P1EE6 Set With Or Without Service Vehicle Soon (SVS) Or Check Engine Lamp (CEL) On After Charging
Released 10/31/2015 Warranty, SPS, Control Module Diagnostics and Configuration Information, Programming, Set-Up
Released 10/31/2015 How to Identify Factory or Aftermarket CNG, LPG, Bi-Fuel Systems
Released 5/16/2015 Noise, Vibration, Moaning Sounds and/or Rattle Heard at Idle or While Driving
Released 5/12/2015 Service Update for Inventory and Customer Vehicles - Insufficient Evaporative Emission Canister Capacity for Vapor Generation
Released 4/11/2015 Service Update for Inventory and Customer Vehicles - Insufficient Evaporative Emission Canister Capacity for Vapor Generation
Released 9/11/2014 (EREV) Hybrid Powertrain Control Module 2 (HPCM 2) Part Restriction
Released 9/9/2014 ELR And VOLT Misfire Detection - Service Information
Released 7/14/2014 Powertrain and Various Electrical/Electronic Control Issues
Released 2/5/2014 (EREV) Hybrid Powertrain Control Module 2 (HPCM 2) Part Restriction
Released 1/24/2014 (EREV) Hybrid Powertrain Control Module 2 (HPCM 2) Part Restriction
Released 1/10/2014 (EREV) MIL DTC P0497
Released 3/22/2013 Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V6 and V8 Gasoline Engines Using Tech 2 or Global Diagnostic System 2 (GDS 2)
Released 2/1/2013 Aftermarket ALDL or DLC Interface Devices Causing Multiple Issues
Released 1/8/2013 Check Engine Lamp with DTC P0111
Released 12/18/2012 (EREV) DTC P0335 and Or P0336 Stored In The HPCM
Released 12/13/2012 Check Engine Lamp with DTC P0111
Released 9/4/2012 Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V8 Gasoline Engines Using Tech 2 or Global Diagnostic System 2 (GDS 2)
Released 3/3/2012 Warranty, SPS, Control Module Diagnostics and Configuration Information, Programming, Set-Up
Released 2/10/2012 Service Programming System (SPS) Errors (E4398, E4399, E4403, E4404 E4413, E4414, E4423 or E4491, E4494)
Released 1/17/2012 Car and Truck Fix it Right the First Time Issues
Released 7/22/2011 Car and Truck Fix it Right the First Time Issues
Released 1/17/1997 Car and Truck Fix it Right the First Time Issues

Released 2/15/2018
Identifying Non-GM (Aftermarket) Engine Calibrations for Gasoline Engines Using Tech 2 or GDS 2 (U.S. and Canada)

Released 1/31/2018
Information on Close-Coupled Converter and Engine Replacement

Get all TSBs for 5 vehicles for only $25

TSB Description
Released 8/31/2017 Intake Manifold Inspection/Replacement After Severe Internal Engine Damage
Released 4/25/2017 SES Light with Fuel Trim and or Oxygen Sensor Codes
Released 4/12/2017 Underbody Component Corrosion
Released 3/4/2016 Premature Catalytic Converter Failures
Released 3/2/2016 New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores
Released 3/2/2016 Properly Maintaining Vehicles in Dealer Inventory
Released 1/14/2016 Information on Close-Coupled Converter and Engine Replacement
Released 11/30/2015 Premature Catalytic Converter Failures
Released 10/31/2015 (EREV) Engine Or Exhaust Noise While Driving In Extended Range Mode
Released 10/31/2015 Warranty Administration - Revised Customer Concern Not Duplicated (CCND) / Verified Labor Operation Numbers/How to Submit CCND Transactions in Global Warranty Management
Released 6/6/2015 Properly Maintaining Vehicles in Dealer Inventory
Released 9/27/2013 (EREV) Engine Or Exhaust Noise While Driving In Extended Range Mode
Released 2/1/2013 Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V6 and V8 Gasoline Engines Using Tech 2 or Global Diagnostic System 2 (GDS 2)
Released 1/1/2013 Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V8 Gasoline Engines Using Tech 2 or Global Diagnostic System 2 (GDS 2)

Released 5/21/2020
Misfire Template

Released 5/8/2020
EPA Summer Grade Gasoline Waiver Allows Use of Winter Grade Surplus Potential Drivability Concerns P0300 P0171 P0174 P228C Fuel Smell Odor Longer Extended Cranking Time Hesitation Engine Stalls

Get all TSBs for 5 vehicles for only $25

TSB Description
Released 1/14/2020 Diagnostic Tip: Poor Engine Performance Or CEL On In Cold Ambient Temperatures On Vehicles Equipped With Turbocharged Gasoline Engines May Set One Or More Of The Following DTCs P0299 P2227
Released 10/22/2019 GE-52250 Power Smoke Diagnostic Leak Detector Turbocharger Charge Air And Induction System Tester MIL Reduced Engine Power
Released 6/26/2019 TOP TIER Detergent Gasoline and TOP TIER Diesel Fuel Information and Licensed Brands
Released 6/19/2019 Warranty Administration - Warranty SPS Control Module Reprogramming
Released 5/15/2019 Information on Malfunction Indicator Lamp (MIL) Illuminated - DTC P0171 Set
Released 4/10/2019 (EREV) MIL DTC P0497
Released 3/7/2019 TOP TIER Detergent Gasoline and TOP TIER Diesel Fuel Information and Licensed Brands
Released 12/3/2018 SES Light with Fuel Trim and or Oxygen Sensor Codes
Released 11/30/2018 Identifying Non-GM (Aftermarket) Engine Calibrations for Gasoline Engines Using Tech 2 or GDS 2 (U.S. and Canada)
Released 10/3/2018 Diagnostic Tip: Fuel Injected Gasoline Engines Possible No Start Extended Crank or Fuel Pressure Related DTCs
Released 7/25/2018 Identifying Non-GM (Aftermarket) Engine Calibrations for Gasoline Engines Using Tech 2 or GDS 2 (U.S. and Canada)
Released 2/27/2018 Information on Vehicles Sitting Outside on Dealer Lots for Extended Periods of Time with Hard Start or Crank/No Start Condition
Released 11/22/2017 Automatic Transmission Shift and Engine Driveability Concerns and/or MIL ON Due to Aftermarket Oil Bath Type Air Filter Use
Released 7/25/2017 Information on How to Prevent Inadvertent Vehicle Starting from Key Fob or OnStar Mobile Application
Released 6/16/2017 Properly Maintaining Vehicles in Dealer Inventory
Released 2/20/2017 Customer Satisfaction Program - Vehicles with Key Codes Improperly Handled by Third Party
Released 12/20/2016 Explanation Electric Range Variation and Driving Tips for Maximum Range
Released 10/17/2016 Warranty Administration - Changes in Powertrain Warranty Coverage Effective with 2010 Model Year
Released 10/7/2016 Properly Maintaining Vehicles in Dealer Inventory
Released 10/6/2016 TOP TIER Detergent Gasoline Information and Available Brands
Released 9/30/2016 Vehicle Fuels Slow, Cannot Refuel or Fuel Pump Frequently Shuts Off Before Tank is Full (Replace Fuel Tank Filler Pipe)
Released 9/1/2016 Fuel and Oil Additives - Facts and Myths - Maximizing Gasoline Fuel Economy
Released 8/12/2016 Special Coverage Adjustment - Accelerator Pedal Stalk Fracture
Released 8/2/2016 Use of Surface Conditioning Disks When Cleaning Engine Gasket Sealing Surfaces and/or Reused Engine Parts
Released 6/23/2016 Diagnostic Tip - Key Does Not Fold Or Will Not Stay Closed
Released 3/2/2016 New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores
Released 3/2/2016 Properly Maintaining Vehicles in Dealer Inventory
Released 10/31/2015 Maintenance Cleaning of Fuel Injectors
Released 10/31/2015 (EREV) Engine Or Exhaust Noise While Driving In Extended Range Mode
Released 10/31/2015 (EREV) Diagnostic Tips for Intermittent MIL With DTC P0AB9
Released 10/31/2015 TOP TIER Detergent Gasoline Information and Available Brands
Released 10/31/2015 Warranty Administration - Revised Customer Concern Not Duplicated (CCND) / Verified Labor Operation Numbers/How to Submit CCND Transactions in Global Warranty Management
Released 10/31/2015 Diagnostic Tip - Key Does Not Fold Or Will Not Stay Closed
Released 10/31/2015 Automatic Transmission Shift and Engine Driveability Concerns and/or MIL ON Due to Aftermarket Oil Bath Type Air Filter Use
Released 10/31/2015 Diagnostic Tip - Tick or squeak noise from engine
Released 10/31/2015 How to Identify Factory or Aftermarket CNG, LPG, Bi-Fuel Systems
Released 9/5/2015 Vehicle Fuels Slowly, Cannot Refuel or Fuel Pump Shuts Off Before Tank is Full
Released 8/22/2015 (EREV) MIL DTC P0497
Released 7/12/2015 TOP TIER Detergent Gasoline Information and Available Brands
Released 6/27/2015 Diagnostic Tips for Intermittent Engine No Crank, Intermittent Exhaust Camshaft Position (CMP) Sensor Signal
Released 5/30/2015 Usage of E85 Fuel in GM Vehicles
Released 5/23/2015 Information Regarding the Differences Between Leakage and Seepage
Released 5/2/2015 Information Regarding the Differences Between Leakage and Seepage
Released 5/2/2015 Intermittently Key Will Not Rotate in Door or Ignition Lock Cylinder
Released 3/28/2015 Product Quality Center (PQC) Assembly Replacement Process - For Service Agents Not Required to Contact PQC Prior to Assembly Replacement
Released 10/7/2014 Cylinder 1 Miss On Left Turns And Cylinder 4 Miss On Right Turns - Possible Fuel Contamination
Released 1/10/2014 (EREV) MIL DTC P0497
Released 1/9/2014 (EREV) Intermittent MIL With DTC P0AB9
Released 1/30/2013 (EREV) Intermittent MIL With DTC P0AB9 And Or P16E0 Stored Current Or History After A Low Fuel Event
Released 1/1/2013 Various Driveability Symptoms Due to Clogged Fuel Injectors, MIL/SES DTCs P0171, P0172, P0174, P0300, P1174, P1175 (Clean Fuel Injectors and/or Perform Injector Test With AFIT CH-47976)
Released 1/19/2012 Properly Maintaining Vehicles in Dealer Inventory
Released 1/17/2012 Car and Truck Fix it Right the First Time Issues
Released 1/14/2012 Properly Maintaining Vehicles in Dealer Inventory
Released 7/22/2011 Car and Truck Fix it Right the First Time Issues
Released 7/15/2011 Key Code Security Rules and Information on GM KeyCode Look-Up Application (Canada Only)
Released 7/11/2011 Key Cutting Procedure for Obtaining Replacement Key

Released 7/27/2020
AC Blows Warm or Poor Performance

Released 1/17/2020
Spark EV Chevrolet Volt Opel Ampera Models With Or Without Service Vehicle Soon Lamp - SVS - or Check Engine Lamp On With DTC P0534 Set Current Or History

Get all TSBs for 5 vehicles for only $25

TSB Description
Released 6/13/2019 Do Not Swap Modules in Vehicles with Global Electrical Systems
Released 4/2/2019 Do Not Swap Modules in Vehicles with Global Electrical Systems
Released 2/5/2019 Spark EV Chevrolet Volt Opel Ampera Models With Or Without Service Vehicle Soon Lamp - SVS - or Check Engine Lamp On With DTC P0534 Set Current Or History
Released 10/10/2018 AC Blows Warm or Poor Performance
Released 9/5/2018 Information on A/C Odors During Start Up in Hot Humid Climates
Released 8/22/2018 Diagnostic Tips for Odor Emanating from HVAC System
Released 6/20/2018 AC Blows Warm or Poor Performance
Released 6/14/2017 Air Conditioning Odor (Install Evaporator Core Dryer Kit and Apply Cooling Coil Coating)
Released 2/24/2016 Information on the Use of Stop Leak Additives in the Coolant System
Released 2/11/2016 Unscheduled Supplemental Services (Including Flushing Services and Additives) and Proper Use of GM Simplified Maintenance Schedules (U.S. Only)
Released 1/28/2016 Information on Passenger Presence Sensing System (PPS or PSS) Concerns with Custom Upholstery, Accessory Seat Heaters or Other Comfort Enhancing Devices
Released 12/5/2015 Air Conditioning Odor (Install Evaporator Core Dryer Kit and Apply Cooling Coil Coating)
Released 10/31/2015 (EREV) Engine Or Exhaust Noise While Driving In Extended Range Mode
Released 10/31/2015 Normal Characteristic - Heated Seat Operation After Performing A Remote Vehicle Start (RVS)
Released 10/31/2015 Availability of Passenger Compartment (Cabin) Air Filter
Released 10/31/2015 Repair Information for Reconnection of Rear Window (Defroster) Contact or Tab
Released 10/31/2015 Warranty Administration - Revised Customer Concern Not Duplicated (CCND) / Verified Labor Operation Numbers/How to Submit CCND Transactions in Global Warranty Management
Released 10/31/2015 Water Present on Front Passenger Floor, A/C Drain Hose Not Positioned Correctly
Released 9/12/2015 Air Conditioning Odor (Install Evaporator Core Dryer Kit and Apply Cooling Coil Coating)
Released 7/25/2015 Air Conditioning Odor (Install Evaporator Core Dryer Kit and Apply Cooling Coil Coating)
Released 5/23/2015 Information Regarding the Differences Between Leakage and Seepage
Released 5/2/2015 Information Regarding the Differences Between Leakage and Seepage
Released 5/2/2015 Information on the Use of Stop Leak Additives in the Coolant System
Released 3/14/2015 Unscheduled Supplemental Services (Including Flushing Services and Additives) and Proper Use of GM Simplified Maintenance Schedules (Canada Only)
Released 8/19/2014 TAC Part Restriction Ended - AC Compressor And Integrated Control Module (ACCM)
Released 7/11/2014 Information Regarding A/C Service Valve Tethered Cap Requirements in the State of Idaho
Released 2/6/2014 TAC Part Restriction - AC Compressor And Integrated Control Module (ACCM)
Released 11/12/2013 Vehicle Will Not Charge And Hybrid Loss Of Isolation With DTC P0AA6 And/Or P1F0E P0DAA
Released 10/16/2013 Spark EV Chevrolet Volt Opel Ampera Models With Or Without Service Vehicle Soon Lamp - SVS - or Check Engine Lamp On With DTC P0534 Set Current Or History
Released 8/1/2013 SES Light With DTC P0534
Released 4/29/2013 Normal Characteristic - Heated Seat Operation After Performing A Remote Vehicle Start (RVS)
Released 1/10/2013 TAC Part Restriction - AC Compressor And Integrated Control Module (ACCM)
Released 10/13/2011 Eliminating Unwanted Odors in Vehicles
Released 8/10/2011 Air Conditioning Odor (Install Evaporator Core Dryer Kit and Apply Cooling Coil Coating)
Released 7/22/2011 Car and Truck Fix it Right the First Time Issues
Released 4/11/2011 Repair Information for Reconnection of Rear Window Defroster Contact or Tab

Released 10/8/2020
Misfire Template

Released 7/27/2020
Needle Bearings Found In The Oil Pan During An Oil Change

Get all TSBs for 5 vehicles for only $25

TSB Description
Released 7/21/2020 (EREV) Diagnostic Tips for Intermittent MIL With DTC P0AB9
Released 6/23/2020 Warranty Administration - Engine and Transmission Assembly Replacement (U.S. Only)
Released 5/21/2020 Misfire Template
Released 5/5/2020 GE-52250 Power Smoke Diagnostic Leak Detector Turbocharger Charge Air And Induction System Tester MIL Reduced Engine Power
Released 3/9/2020 Information on Malfunction Indicator Lamp (MIL) Illuminated with Multiple Fuel Trim and/or Oxygen Sensor Codes Set
Released 10/29/2019 Information on Driveline Clunk Noise
Released 10/9/2019 Information on Engine Oil Consumption Guidelines
Released 8/19/2019 GM Wiring Repair Strategy Information
Released 8/15/2019 Engine Replacement After Severe Internal Engine Damage - Replace Intake Manifold
Released 8/13/2019 Information on Internal Engine Noise or Damage After Oil Filter Replacement
Released 8/12/2019 Information on Slight Vehicle Movement in Park at Start Up After Cold Soak
Released 6/26/2019 Aftermarket ALDL or DLC Interface Devices Causing Multiple Issues
Released 6/25/2019 Use of Surface Conditioning Disks When Cleaning Gasket Sealing Surfaces and/or Reused Parts
Released 6/19/2019 Warranty Administration - Warranty SPS Control Module Reprogramming
Released 6/17/2019 P0604 Stored in the Hybrid Powertrain Control Module
Released 6/17/2019 Check Engine Lamp With DTC P0C57 P0C58 Or P0C62
Released 6/13/2019 Do Not Swap Modules in Vehicles with Global Electrical Systems
Released 5/20/2019 Information on Water or Ethylene Glycol in Transmission Fluid
Released 5/15/2019 Information on Malfunction Indicator Lamp (MIL) Illuminated - DTC P0171 Set
Released 5/13/2019 Transmission oil in the TPIM at the AUX pump connector
Released 5/7/2019 Avoiding Torque Converter Or Crankshaft Damage While Diagnosing Noise Concerns Do Not Separate The Torque Converter From the Flex Plate
Released 5/6/2019 Needle Bearings Found In The Oil Pan During An Oil Change
Released 5/1/2019 Reduced Propulsion Power without DTCs on Higher Mileage Vehicles (with P1.4 Cell Chemistry)
Released 4/24/2019 HPCM2 Fault Code P0606 Control Module Internal Performance
Released 4/17/2019 Reduced Propulsion Power without DTCs on Higher Mileage Vehicles
Released 4/15/2019 (EREV) Diagnostic Tips for Intermittent MIL With DTC P0AB9
Released 4/5/2019 (EREV) Engine Or Exhaust Noise While Driving In Extended Range Mode
Released 4/2/2019 Manual Transmission Operating Characteristics
Released 4/2/2019 Do Not Swap Modules in Vehicles with Global Electrical Systems
Released 3/29/2019 (EREV) Reduced Propulsion Power While Driving in Mountains
Released 3/20/2019 (EREV) Reduced Propulsion Power While Driving in Mountains
Released 3/20/2019 Diagnostic Tip - Tick or squeak noise from engine
Released 3/20/2019 Explanation Electric Range Variation and Driving Tips For Maximum Range
Released 2/18/2019 Misfire Template
Released 2/8/2019 (EREV) Whine, Scrape, Whistle Type Noise While Driving, P0A46
Released 2/5/2019 Spark EV Chevrolet Volt Opel Ampera Models With Or Without Service Vehicle Soon Lamp - SVS - or Check Engine Lamp On With DTC P0534 Set Current Or History
Released 1/22/2019 Diagnostic Tip - Security Light on Intermittently / No Crank/No Start or Start Stall / Keyless Access Vehicles May Display No Remote/Fob Detected / Poor or No RKE Range / Service TPo
Released 1/11/2019 Poor Engine Performance Or CEL On In Cold Ambient Temperatures On Vehicles Equipped With Turbocharged Gasoline Engines May Set One Or More Of The Following DTCs P0299 P2227
Released 12/13/2018 High Voltage Drive Motor Battery Repair And Exchange Process
Released 12/6/2018 Poor Engine Performance Or CEL On In Cold Ambient Temperatures On Vehicles Equipped With Turbocharged Gasoline Engines May Set One Or More Of The Following DTCs P0171 P0172 P0299 P2227
Released 12/5/2018 Warranty Administration - Warranty, SPS, Control Module Diagnostics and Configuration Information, Programming, Set-Up
Released 12/3/2018 SES Light with Fuel Trim and or Oxygen Sensor Codes
Released 10/30/2018 Warranty Administration - Labor Operation 0600018 - Personal Property Damage
Released 10/23/2018 Vehicle Vibration Diagnosis and TAC Requests For Assistance With Vibration Related Complaints
Released 10/19/2018 Vehicle Vibration Diagnosis and TAC Requests For Assistance With Vibration Related Complaints
Released 10/17/2018 Vehicle Vibration Diagnosis and TAC Requests For Assistance With Vibration Related Complaints
Released 10/17/2018 ELR And VOLT Misfire Detection - Service Information
Released 10/3/2018 Engine Replacement After Severe Internal Engine Damage - Replace Intake Manifold
Released 9/26/2018 Diagnostic Tip - Security Light on Intermittently / No Crank/No Start or Start Stall / Keyless Access Vehicles May Display No Remote/Fob Detected / Poor or No RKE Range / Service TPM
Released 8/27/2018 Diagnostic Tips for Intermittent Engine No Crank, Intermittent Exhaust Camshaft Position (CMP) Sensor Signal
Released 8/22/2018 OEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification
Released 8/22/2018 Damaged, Disassembled or Improperly Packaged Turbochargers Returned to Warranty Part Center
Released 8/8/2018 Alleged Cylinders Out Of Round
Released 7/24/2018 Information on Internal Engine Noise or Damage After Oil Filter Replacement
Released 7/24/2018 Intake Manifold Inspection/Replacement After Severe Internal Engine Damage
Released 4/9/2018 Information on Water or Ethylene Glycol in Transmission Fluid
Released 4/9/2018 (EREV) Drive Motor Generator Control Module (PIM) Part Restriction has ended
Released 2/27/2018 Warranty Administration - Updated - Dealer Empowerment Labor Operations and Customer Enthusiasm (U.S. Only)
Released 2/15/2018 Identifying Non-GM (Aftermarket) Engine Calibrations for Gasoline Engines Using Tech 2 or GDS 2 (U.S. and Canada)
Released 2/13/2018 Cold Start Misfires MIL P0300
Released 2/2/2018 Do Not Swap Modules in Vehicles With Global Electrical Systems
Released 2/2/2018 (EREV) Whine, Scrape, Whistle Type Noise While Driving
Released 12/21/2017 TOP TIER Detergent Gasoline and TOP TIER Diesel Fuel Information and Licensed Brands
Released 12/5/2017 Intermittent No Crank/No Start, No Module Communication, MIL, Warning Lights, Vehicle Messages or DTCs Set by Various Control Modules - Diagnosing and Repairing Fretting Corrosion (Disconnect Affected Connector and Apply Dielectric Lubricant)
Released 11/30/2017 Information on Engine Oil Consumption Guidelines
Released 9/21/2017 Volt 5ET50 Transmission Component Restriction Program
Released 8/31/2017 Intake Manifold Inspection/Replacement After Severe Internal Engine Damage
Released 8/21/2017 Alleged Cylinders Out Of Round
Released 6/19/2017 (EREV) Volt and ELR 4ET50 Transmission Component Restriction Program Ended
Released 5/26/2017 GM TAC Support of Vehicle Vibration Complaints - U.S. and Canada Dealers Only
Released 5/10/2017 Warranty Administration - Automatic Transmission Oil Cooler Flush and Flow Test
Released 4/25/2017 SES Light with Fuel Trim and or Oxygen Sensor Codes
Released 4/12/2017 Underbody Component Corrosion
Released 3/29/2017 Information on Driveline Clunk Noise
Released 3/10/2017 Security Code Input Message with SPS Error Code E5659, M5304 and/or M5530 During TIS2web Programming
Released 3/9/2017 Volt 5ET50 Transmission Component Restriction Program
Released 1/25/2017 Cold Start Misfires MIL P0300
Released 12/1/2016 (EREV) Volt and ELR 4ET50 Transmission Component Restriction Program
Released 11/15/2016 Alleged Cylinders Out Of Round
Released 10/27/2016 Information on Slight Vehicle Movement in Park at Start Up After Cold Soak
Released 10/17/2016 Warranty Administration - Changes in Powertrain Warranty Coverage Effective with 2010 Model Year
Released 10/12/2016 Warranty Administration - Change in Automatic Transmission Add Condition Documentation and Claim Submission
Released 10/6/2016 TOP TIER Detergent Gasoline Information and Available Brands
Released 9/30/2016 Diagnosing DTC P0171
Released 9/30/2016 Engine Oil Life Monitor Operation Calculation
Released 9/28/2016 (EREV) Volt and ELR 4ET50 Transmission Component Restriction Program
Released 9/9/2016 Rough Idle Crank No Start Extended Crank Or Misfire Due to Excessive Carbon On Top of the Valves or Sticking Valves
Released 8/29/2016 Engine Repair Tip for Installation of Pistons
Released 8/2/2016 Use of Surface Conditioning Disks When Cleaning Engine Gasket Sealing Surfaces and/or Reused Engine Parts
Released 7/11/2016 Information for Engine Concerns Resulting from Lack of Scheduled Maintenance, Improper Service or Aftermarket Calibrations
Released 7/5/2016 (EREV) Volt and ELR 4ET50 Transmission Component Restriction Program
Released 6/28/2016 Diagnostic Tip for Intermittent Crank/No Start After Removal of Cam Shaft Sprockets
Released 5/31/2016 Identifying Non-GM (Aftermarket) Engine Calibrations for Gasoline Engines Using Tech 2 or GDS 2 (U.S. and Canada)
Released 4/27/2016 PQC Assembly Replacement Process - For Dealers Required to Contact PQC Prior to Replacing an Assembly (U.S. and Canada Only)
Released 4/12/2016 Information Regarding Magnetic Drain Plugs
Released 4/7/2016 Manual Transmission Operating Characteristics
Released 3/7/2016 Information on Slight Vehicle Movement in Park at Start Up After Cold Soak
Released 3/2/2016 Properly Maintaining Vehicles in Dealer Inventory
Released 2/11/2016 Needle Bearings Found in the oil pan During An Oil Change
Released 2/11/2016 Unscheduled Supplemental Services (Including Flushing Services and Additives) and Proper Use of GM Simplified Maintenance Schedules (U.S. Only)
Released 1/14/2016 Information on Close-Coupled Converter and Engine Replacement
Released 12/15/2015 OEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification
Released 11/23/2015 (EREV) Volt and ELR 4ET50 Transmission Component Restriction Program
Released 10/31/2015 Information on Engine Oil Consumption Guidelines
Released 10/31/2015 Diagnostic Tip for Low Line Pressure or Pressure Regulator Valve Stuck After Pump Cover Replacement
Released 10/31/2015 (EREV) Engine Or Exhaust Noise While Driving In Extended Range Mode
Released 10/31/2015 Clunk Noise, Rear Transmission Mount Broken
Released 10/31/2015 Diagnostic Tips for Preventing Oil Leaks After Changing Oil and Filter
Released 10/31/2015 (EREV) Diagnostic Tips for Intermittent MIL With DTC P0AB9
Released 10/31/2015 Rough Idle Crank No Start Extended Crank or Misfire Due to Excessive Carbon On Top of the Valves or Sticking Valves
Released 10/31/2015 Information on Driveline Clunk Noise
Released 10/31/2015 (EREV) Drive Motor Generator Control Module (PIM) Part Restriction
Released 10/31/2015 Warranty Administration - Revised Customer Concern Not Duplicated (CCND) / Verified Labor Operation Numbers/How to Submit CCND Transactions in Global Warranty Management
Released 10/31/2015 Engine Repair Tip for Installation of Pistons
Released 10/31/2015 Vibration Analysis Worksheet
Released 10/31/2015 Manual Transmission Operating Characteristics
Released 10/31/2015 PAC Courtesy Transportation Assistance Program
Released 10/31/2015 Engine and Automatic Transmission/Transaxle Identification
Released 10/31/2015 Transmission oil in the TPIM at the AUX pump connector
Released 8/8/2015 Intake Manifold Inspection/Replacement After Severe Internal Engine Damage
Released 7/18/2015 Manual Transmission Operating Characteristics
Released 7/4/2015 Check Engine Lamp With DTC P0C57 P0C58 Or P0C62
Released 5/23/2015 Information Regarding the Differences Between Leakage and Seepage
Released 5/23/2015 Intake Manifold Inspection/Replacement After Severe Internal Engine Damage
Released 5/2/2015 Information Regarding the Differences Between Leakage and Seepage
Released 5/2/2015 (EREV) Whine, Scrape, Whistle Type Noise While Driving
Released 4/18/2015 Engine Oil Life Monitor Operation Calculation
Released 4/18/2015 (EREV) Whine - Scrape - Whistle Type Noise While Driving
Released 4/4/2015 Clunk Noise, Rear Transmission Mount Broken
Released 3/28/2015 (EREV) Whine - Scrape - Whistle Type Noise While Driving
Released 3/28/2015 Product Quality Center (PQC) Assembly Replacement Process - For Service Agents Not Required to Contact PQC Prior to Assembly Replacement
Released 3/14/2015 Unscheduled Supplemental Services (Including Flushing Services and Additives) and Proper Use of GM Simplified Maintenance Schedules (Canada Only)
Released 1/1/2015 Vehicle Will Not Charge And Hybrid Loss Of Isolation With DTC P0AA6 And/Or P1F0E P0DAA
Released 9/9/2014 ELR And VOLT Misfire Detection - Service Information
Released 7/17/2014 Alleged Cylinders Out Of Round
Released 7/17/2014 Diagnostic Tip for Intermittent Crank/No Start After Removal of Cam Shaft Sprockets
Released 5/21/2014 (EREV) Diagnostic Tips for Intermittent MIL With DTC P0AB9
Released 5/21/2014 (EREV) Drive Motor Generator Control Module (PIM) Part Restriction
Released 5/20/2014 Cold Start Misfires MIL P0300
Released 4/12/2014 (EREV) Drive Motor Generator Control Module (PIM) Part Restriction
Released 2/20/2014 MIL Possible DTCs P1B10 And Or P1B0F
Released 2/20/2014 Diagnostic Tip Vehicle Will Not Crank Waiting To Initialize Message
Released 2/11/2014 Diagnostic Tip - MDI Cable Or SAS Learning Issues When Repairing Service Stability/Traction Message Or DTC C0710 SYM71
Released 2/7/2014 (Volt/ELR) Service Stabilitrak DTC C0196 After Vehicle Has Been Transported
Released 2/5/2014 (EREV) Hybrid Powertrain Control Module 2 (HPCM 2) Part Restriction
Released 2/5/2014 (EREV) Volt and ELR 4ET50 Transmission Component Restriction Program
Released 1/25/2014 4ET50 Electric Drive Unit Service – Rotor B Replacement
Released 1/24/2014 (EREV) Hybrid Powertrain Control Module 2 (HPCM 2) Part Restriction
Released 1/9/2014 (EREV) Intermittent MIL With DTC P0AB9
Released 1/3/2014 New Engine Oil and Oil Filter Replacement Procedure in Service Information (SI)
Released 1/1/2014 Diagnostic Tip for Intermittent Crank/No Start After Removal of Cam Shaft Sprockets
Released 12/5/2013 (EREV) Whine Scrape Whistle Type Noise While Driving
Released 11/22/2013 Engine No Crank/No Start Due to Discharged 12V Battery
Released 11/21/2013 (EREV) Whine, Scrape, Whistle Type Noise While Driving
Released 10/4/2013 Diagnostic Tip: Diagnosing Vehicles with OnStar DTC B101D-37
Released 9/27/2013 (EREV) Engine Or Exhaust Noise While Driving In Extended Range Mode
Released 9/27/2013 (EREV) DTC P0335 And/Or P0336 Stored In The HPCM
Released 9/23/2013 (EREV) Explanation Electric Range Variation and Driving Tips For Maximum Range
Released 9/12/2013 (EREV) MIL DTC P0797 Set In The TCM Diagnostic Tips
Released 9/10/2013 (EREV) Reduced Propulsion Power While Driving In Mountains
Released 8/23/2013 Oil Pressure Switch Replacement Information
Released 6/19/2013 Information on Slight Vehicle Movement in Park at Start Up After Cold Soak
Released 6/19/2013 Global Information for GM dexos 1 and dexos 2 Engine Oil Specifications, Licensed Brands, and Service Fill
Released 5/24/2013 (EREV) Whine, Scrape, Whistle Type Noise While Driving DTC: P0A46
Released 5/21/2013 GM TAC Support of Vehicle Vibration Complaints - U.S. Dealers Only
Released 5/7/2013 Service Repair Tip - Using Caution During Service Procedures Involving Plastic Components
Released 5/3/2013 (EREV) Volt 4ET50 Transmission Component Restriction Program
Released 4/12/2013 Information on Driveline Clunk Noise
Released 3/22/2013 Aftermarket ALDL or DLC Interface Devices Causing Multiple Issues
Released 3/22/2013 Vibration Analysis Worksheet
Released 3/22/2013 Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V6 and V8 Gasoline Engines Using Tech 2 or Global Diagnostic System 2 (GDS 2)
Released 2/1/2013 Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V6 and V8 Gasoline Engines Using Tech 2 or Global Diagnostic System 2 (GDS 2)
Released 1/30/2013 (EREV) MIL DTC P0797 Set In The TCM Diagnostic Tips
Released 1/1/2013 Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V8 Gasoline Engines Using Tech 2 or Global Diagnostic System 2 (GDS 2)
Released 9/4/2012 Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V8 Gasoline Engines Using Tech 2 or Global Diagnostic System 2 (GDS 2)
Released 5/15/2012 Information on Servicing Plastic Components and Transferring on a New Service Engine
Released 5/8/2012 Properly Maintaining Vehicles in Dealer Inventory
Released 3/5/2012 Warranty, SPS, Control Module Diagnostics and Configuration Information, Programming, Set-Up
Released 3/3/2012 Warranty, SPS, Control Module Diagnostics and Configuration Information, Programming, Set-Up
Released 1/19/2012 Properly Maintaining Vehicles in Dealer Inventory
Released 1/17/2012 Car and Truck Fix it Right the First Time Issues
Released 1/14/2012 Properly Maintaining Vehicles in Dealer Inventory
Released 11/16/2011 SERVICE HIGH VOLTAGE CHARGING SYSTEM Message Displayed on Driver Information Center (DIC), Hybrid/EV Charging System Disabled, DTCs Set, Revised HV Battery Surge Tank Coolant Fill Level
Released 10/24/2011 Use of Surface Conditioning Disks When Cleaning Engine Gasket Sealing Surfaces and/or Reused Engine Parts
Released 7/22/2011 Car and Truck Fix it Right the First Time Issues
Released 5/17/2011 Information on Slight Vehicle Movement in Park at Start Up After Cold Soak
Released 5/6/2011 Information on Driveline Clunk Noise when Shifting Between PARK and DRIVE, PARK and REVERSE or DRIVE and REVERSE
Released 1/17/1997 Car and Truck Fix it Right the First Time Issues

Released 3/9/2018
Customer Satisfaction Program - Vehicle Communication Interface Module (VCIM) Programming Not Completed

Released 9/28/2017
Diagnostic Tip: OnStar Vehicles with B101D and Symptom Codes

Get all TSBs for 5 vehicles for only $25

TSB Description
Released 3/15/2017 Warranty Administration - Field Action Courtesy Transportation Policy
Released 2/20/2017 Customer Satisfaction Program - Vehicles with Key Codes Improperly Handled by Third Party
Released 8/12/2016 Special Coverage Adjustment - Accelerator Pedal Stalk Fracture
Released 7/13/2016 38660 - A16-2038660 GMI700 31UX Missing GM Roadside Kit
Released 10/31/2015 Special Coverage Adjustment - Power Steering Stick-Slip
Released 10/31/2015 Customer Satisfaction - Liftgate Strut Rod Detaches
Released 10/31/2015 Special Coverage Adjustment - Power Steering Stick-Slip
Released 6/1/2015 Customer Satisfaction - Automatic Crash Response System - Reprogram SDM
Released 6/21/2013 FMVSS Noncompliance - Front Brakes Lock During ABS, Stability Control, or Traction Control Activation
Released 9/4/2012 Customer Satisfaction - Driver Airbag Inspection
Released 9/4/2012 Customer Satisfaction - Enhancements for Side Impact Pole Performance
Released 9/4/2012 Customer Satisfaction - Driver Airbag Inspection
Released 9/4/2012 Customer Satisfaction - Driver Airbag Inspection
Released 9/4/2012 Customer Satisfaction - Enhancements for Side Impact Pole Performance
Released 9/4/2012 Customer Satisfaction - Enhancements for Side Impact Pole Performance
Released 9/4/2012 Customer Satisfaction - Enhancements for Side Impact Pole Performance
Released 9/4/2012 Customer Satisfaction - Enhanced 120 Volt Charge Cord
Released 9/4/2012 Customer Satisfaction - Enhancements for Side Impact Pole Performance
Released 9/4/2012 Customer Satisfaction - Enhancements for Side Impact Pole Performance

Released 8/14/2020
Warranty Administration - General Motors New Vehicle Tire Warranty Program (U.S. Dealers Only)

Released 6/5/2020
Power Steering Noise or Fluid Leak from Power Steering Pump, Gear or High Pressure Hose During Extreme Low Temperature Operation (Replace Power Steering Fluid)

Get all TSBs for 5 vehicles for only $25

TSB Description
Released 4/29/2020 Warranty Administration - General Motors New Vehicle Tire Warranty Program (U.S. Dealers Only)
Released 2/26/2020 Warranty Administration - General Motors New Vehicle Tire Warranty Program (U.S. Dealers Only)
Released 6/19/2019 Warranty Administration - Warranty SPS Control Module Reprogramming
Released 5/9/2019 Information on Tire Radial Force Variation (RFV)
Released 3/22/2019 Information on Vehicle Pulls to the Left or Right When Regenerative Braking Paddle Applied and/or When Brake Pedal Applied
Released 1/18/2019 Service Stabilitrak DTC C0196 After Vehicle Has Been Transported
Released 12/17/2018 GM TAC Support of Vehicle Vibration Complaints - U.S. and Canada Dealers Only
Released 12/5/2018 Warranty Administration - General Motors New Vehicle Tire Warranty Program (U.S. Dealers Only)
Released 11/15/2018 Service Power Steering Message DTC C0800
Released 3/7/2018 New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores
Released 1/4/2018 GM of Canada New Vehicle Tire Warranty Program and GWM Transaction Submission Information
Released 12/15/2017 Warranty Administration - General Motors New Vehicle Tire Warranty Program (U.S. Dealers Only)
Released 6/16/2017 Properly Maintaining Vehicles in Dealer Inventory
Released 5/26/2017 GM TAC Support of Vehicle Vibration Complaints - U.S. and Canada Dealers Only
Released 5/22/2017 Chemical Staining, Pitting, Corrosion and/or Spotted Appearance of Chromed Aluminum Wheels
Released 4/19/2017 Non-Design Intent Wheel Lock Nuts and Lug Nuts
Released 4/12/2017 Underbody Component Corrosion
Released 3/17/2017 Power Steering Fluid Leak at Fluid Reservoir or Reservoir Connection
Released 1/12/2017 Groan, Squeak or Rubbing Type Noise When Turning Steering Wheel
Released 12/9/2016 GM of Canada New Vehicle Tire Warranty Program and GWM Transaction Submission Information
Released 12/5/2016 Warranty Administration - GM Dealer Empowerment Program and Goodwill Procedures
Released 11/9/2016 GM of Canada New Vehicle Tire Warranty Program and GWM Transaction Submission Information
Released 11/7/2016 Warranty Administration - General Motors New Vehicle Tire Warranty Program (U.S. Dealers Only)
Released 10/18/2016 GM of Canada New Vehicle Tire Warranty Program and GWM Transaction Submission Information
Released 10/13/2016 General Motors New Vehicle Wheel Warranty Coverage
Released 10/7/2016 Properly Maintaining Vehicles in Dealer Inventory
Released 9/30/2016 Warranty Administration - General Motors New Vehicle Tire Warranty Program (U.S. Dealers Only)
Released 9/30/2016 Power Steering Fluid Leak at Fluid Reservoir or Reservoir Connection
Released 9/30/2016 Wheel Balancing Machine Finish Damage to Chrome Clad or ChromeTechÂ® Wheels
Released 9/30/2016 Notchy or Stick/Slip Feeling in Steering Wheel Near Center Position
Released 9/27/2016 Warranty Administration - Labor Operation 0600014 - Suspected Tampering or Vehicle Modifications
Released 9/1/2016 Fuel and Oil Additives - Facts and Myths - Maximizing Gasoline Fuel Economy
Released 7/13/2016 38660 - A16-2038660 GMI700 31UX Missing GM Roadside Kit
Released 7/11/2016 Traction Control Light Flashes Under Hard Acceleration at Higher Road Speeds
Released 6/22/2016 Information on Slight or Mild Tire Feathering and Recommended Practices (Normal Tire Wear Condition)
Released 6/17/2016 Loss of Power Steering Assist, Hard to Steer, and/or Service Power Steering Message on DIC
Released 5/25/2016 Refinishing Aluminum Wheels
Released 5/20/2016 Information on Tire/Wheel Characteristics (Vibration, Balance, Shake, Flat Spotting) of GM Original Equipment Tires
Released 5/17/2016 Groan, Squeak or Rubbing Type Noise When Turning Steering Wheel
Released 4/5/2016 Grease or Sealant Visible on Electronic Power Steering Gear - Should Not Be Interpreted as Leak
Released 3/30/2016 Chemical Staining, Pitting, Corrosion and/or Spotted Appearance of Chromed Aluminum Wheels
Released 3/2/2016 New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores
Released 3/2/2016 Properly Maintaining Vehicles in Dealer Inventory
Released 2/23/2016 Vibration Shortly After Tires are Mounted/Preventing Vibration from Wheel Slip (Tire Sliding on Wheel)
Released 2/12/2016 Clarification of Use - Dealer Empowerment Labor Operations and Customer Enthusiasm (U.S. Only)
Released 2/11/2016 Unscheduled Supplemental Services (Including Flushing Services and Additives) and Proper Use of GM Simplified Maintenance Schedules (U.S. Only)
Released 1/1/2016 General Motors New Vehicle Tire Warranty Program (U.S. Dealers Only)
Released 1/1/2016 Information on Diagnosis and Replacement of Shock Absorber and Strut Due to Fluid Leak
Released 11/25/2015 GM TAC Support of Vehicle Vibration Complaints - U.S. and Canada Dealers Only
Released 11/25/2015 Information on Tire Radial Force Variation (RFV)
Released 10/31/2015 Use of Nitrogen Gas in Tires
Released 10/31/2015 Chemical Staining, Pitting, Corrosion and/or Spotted Appearance of Chromed Aluminum Wheels
Released 10/31/2015 Mounting, Balancing and Installation of Accessory Wheels and Tires Available Through GM Accessories
Released 10/31/2015 DTC C0544 and/or U0415 Set and Will Not Clear, Malfunction Indicator Lamp (MIL) On
Released 10/31/2015 Special Coverage Adjustment - Power Steering Stick-Slip
Released 10/31/2015 Warranty Administration - Revised Customer Concern Not Duplicated (CCND) / Verified Labor Operation Numbers/How to Submit CCND Transactions in Global Warranty Management
Released 10/31/2015 Information on Removal/Cracking of Stainless Steel Wheel Nut Caps
Released 10/31/2015 Tire Pressure Monitor (TPM) Concerns After Accessory Wheel Installation
Released 10/31/2015 Vibration Analysis Worksheet
Released 10/31/2015 Guidelines when Changing Tire and Wheel Size
Released 10/31/2015 Wheel Alignment Specifications, Requirements and Recommendations for GM Vehicles
Released 10/31/2015 Wheel Alignment Specifications, Requirements and Recommendations for GM Vehicles
Released 10/31/2015 Special Coverage Adjustment - Power Steering Stick-Slip
Released 10/31/2015 Loss of Power Steering Assist, Hard to Steer, and/or Service Power Steering Message on DIC
Released 9/12/2015 General Motors New Vehicle Tire Warranty Program (U.S. Dealers Only)
Released 8/15/2015 Loss of Power Steering Assist, Hard to Steer, and/or Service Power Steering Message on DIC
Released 8/1/2015 Properly Maintaining Vehicles in Dealer Inventory
Released 7/18/2015 New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores
Released 6/20/2015 GM TAC Support of Vehicle Vibration Complaints - US And Canada Dealers Only
Released 6/13/2015 Global Warranty Management (GWM) Warranty Parts Center (WPC) Parts Return Program Information
Released 6/6/2015 Properly Maintaining Vehicles in Dealer Inventory
Released 6/1/2015 Notchy or Stick/Slip Feeling in Steering Wheel Near Center Position
Released 5/2/2015 Information Regarding the Differences Between Leakage and Seepage
Released 3/14/2015 Warranty Administration â€“ Labor Operation 0600014 â€“ Suspected Tampering or Vehicle Modifications
Released 3/14/2015 Unscheduled Supplemental Services (Including Flushing Services and Additives) and Proper Use of GM Simplified Maintenance Schedules (Canada Only)
Released 2/27/2014 Groan, Squeak or Rubbing Type Noise When Turning Steering Wheel
Released 2/11/2014 Diagnostic Tip - MDI Cable Or SAS Learning Issues When Repairing Service Stability/Traction Message Or DTC C0710 SYM71
Released 2/6/2014 Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum Wheel Bead Seat Corrosion (Clean and Resurface Wheel Bead Seat)
Released 2/6/2014 Information on Slight or Mild Tire Feathering and Recommended Practices (Normal Tire Wear Condition)
Released 2/6/2014 Vibration Shortly After Tires are Mounted/Preventing Vibration from Wheel Slip (Tire Sliding on Wheel)
Released 1/4/2014 Proper Wheel Installation and Wheel Torque Techniques
Released 12/19/2013 NJ1 PQC Part Restriction Electric Power Steering Module Ended
Released 11/27/2013 Subject: Diagnostic Tip - Service Steering Message or Service Stability Message
Released 10/18/2013 DTC C0544 and/or U0415 Set and Will Not Clear, Malfunction Indicator Lamp (MIL) On
Released 9/23/2013 (EREV) Explanation Electric Range Variation and Driving Tips For Maximum Range
Released 6/19/2013 Dealership Service Consultant Procedure as Vehicle Comes into Service Drive for Tire Pressure Monitor (TPM) System Message, Light and Customer Information
Released 6/14/2013 DTC C0544 and/or U0415 Set and Will Not Clear, Malfunction Lamp Indicator (MIL) On
Released 5/21/2013 GM TAC Support of Vehicle Vibration Complaints - U.S. Dealers Only
Released 3/22/2013 Aftermarket ALDL or DLC Interface Devices Causing Multiple Issues
Released 3/22/2013 Vibration Analysis Worksheet
Released 1/18/2013 Electric Power Steering System Squeak Noise/Whining or Sticking when Turning Steering Wheel
Released 1/1/2013 Proper Wheel Installation and Wheel Torque Techniques
Released 12/14/2012 Poor Remote Transmitter Range/Remote Start Or TPM Indicator On
Released 9/4/2012 Clunk or Thump Type Noise from Front Suspension
Released 5/17/2012 Information on Slight or Mild Tire Feathering and Recommended Practices (Normal Tire Wear Condition)
Released 5/8/2012 Properly Maintaining Vehicles in Dealer Inventory
Released 5/3/2012 Information on Tire Radial Force Variation (RFV)
Released 4/8/2012 Knock or Pop Noise Heard When Coming to a Stop or at Low Speeds Over Small Bumps
Released 3/27/2012 Hydraulic Power Steering System Leak - Required Diagnostic Actions
Released 2/21/2012 Power Steering Fluid Leak from Power Steering Pump, Gear or High Pressure Hose During Extreme Low Temperature Operation (Replace Power Steering Fluid)
Released 1/23/2012 Hydraulic Power Steering System Leak - Required Diagnostic Actions
Released 1/19/2012 Properly Maintaining Vehicles in Dealer Inventory
Released 1/17/2012 Car and Truck Fix it Right the First Time Issues
Released 1/14/2012 Properly Maintaining Vehicles in Dealer Inventory
Released 1/13/2012 Properly Maintaining Vehicles in Dealer Inventory
Released 1/13/2012 Properly Maintaining Vehicles in Dealer Inventory
Released 12/3/2011 Information on Diagnosis and Replacement of Shock Absorber and Strut Due to Fluid Leak
Released 7/22/2011 Car and Truck Fix it Right the First Time Issues
Released 4/21/2011 Chemical Staining, Pitting, Corrosion and/or Spotted Appearance of Chromed Aluminum Wheels
Released 4/14/2011 New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores

Released 7/13/2020
GE-52250 Power Smoke Diagnostic Leak Detector Turbocharger Charge Air And Induction System Tester MIL Reduced Engine Power

Released 11/26/2019
Key Code Security Rules and Information on GM KeyCode Look-Up Application (U.S. Only)

Get all TSBs for 5 vehicles for only $25

TSB Description
Released 11/5/2019 J-35616-64B Or EL-35616-58 Terminal Test Probe Information/Repair
Released 10/23/2019 Information on High Voltage Battery Pack Refurbish Kit
Released 10/10/2019 Vehicle Vibration Diagnosis and TAC Requests For Assistance With Vibration Related Complaints
Released 10/9/2019 Key Code Security Rules and Information on GM KeyCode Look-Up Application (U.S. Only)
Released 9/17/2019 Global Warranty Management (GWM) Warranty Parts Center (WPC) Parts Return Program Information
Released 6/3/2019 J-35616-64B Terminal Test Probe / Replacement Terminal / Terminated Lead
Released 5/9/2019 Information on Tire Radial Force Variation (RFV)
Released 11/27/2018 Information for Dealers/Service Advisors on When and How to Submit a Pre-Repair Authorization (PRA) (U.S. Dealers Only)
Released 11/20/2018 Information for Dealers/Technicians on When and How to Submit a Field Product Report (FPR) (U.S. Dealers Only)
Released 11/5/2018 Working with GM on a Product Assistance Claim (PAC)
Released 10/26/2018 Use of Surface Conditioning Disks When Cleaning Gasket Sealing Surfaces and/or Reused Parts
Released 10/8/2018 PAC Courtesy Transportation Assistance Program
Released 9/11/2018 Warranty Administration - Essential Tools that Include Consumable Parts (U.S. Only)
Released 6/22/2018 Dealer Responsibility for Cargo Carrying Capacity Labeling
Released 5/30/2018 Global Warranty Management (GWM) Warranty Parts Center (WPC) Parts Return Program Information
Released 5/14/2018 Warranty Administration - Required Operating Procedures (U.S. Only)
Released 5/10/2018 Warranty Administration - Courtesy Transportation and Roadside Assistance Programs
Released 2/1/2018 Warranty Administration - Battery Testing and Warranty Replacement Requirements (North America ONLY)
Released 12/15/2017 Warranty Administration - Required Operating Procedures (U.S. Only)
Released 12/4/2017 Enhancing Field Product Reports with Digital Pictures
Released 8/23/2017 Paint-less Dent Repair Process
Released 8/10/2017 Warranty Administration - Required Operating Procedures (U.S. Only)
Released 7/25/2017 Warranty Administration - Required Operating Procedures (U.S. Only)
Released 6/23/2017 Warranty Administration - Courtesy Transportation and Roadside Assistance Programs
Released 6/22/2017 Interior Cleaning -- Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer --Product Availability
Released 6/8/2017 New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores
Released 6/2/2017 Concerns Or Questions Regarding Installation Of Dealer Installed Accessories
Released 5/26/2017 GM TAC Support of Vehicle Vibration Complaints - U.S. and Canada Dealers Only
Released 5/15/2017 General Motors Dealership Critical Equipment Requirements and Recommendations
Released 4/26/2017 Warranty Administration - Updated - Dealer Empowerment Labor Operations and Customer Enthusiasm (U.S. Only)
Released 4/6/2017 Warranty Administration - Battery Testing and Warranty Replacement Requirements (North America ONLY)
Released 3/15/2017 Warranty Administration - Field Action Courtesy Transportation Policy
Released 3/15/2017 Procedure For Emailing Global Diagnostic System 2 (GDS2) Session Log To GM TAC (US and Canada Dealers Only)
Released 12/14/2016 Global Warranty Management (GWM) Warranty Parts Center (WPC) Parts Return Program Information
Released 12/5/2016 Warranty Administration - GM Dealer Empowerment Program and Goodwill Procedures
Released 11/18/2016 Concerns Or Questions Regarding Installation Of Dealer Installed Accessories
Released 11/14/2016 Warranty Administration - Change in Product Field Action Customer Reimbursement Procedure (U.S. Dealers Only)
Released 11/1/2016 Warranty Administration - Updated - Dealer Empowerment Labor Operations and Customer Enthusiasm (U.S. Only)
Released 10/13/2016 Warranty Administration - Required Operating Procedures (U.S. Only)
Released 10/10/2016 Warranty Administration - Revised Exterior Labor Operations (Labor Only-No Part Replaced) and Required Warranty Claim Submission Information
Released 10/7/2016 PQC Assembly Replacement Process - Dealers Required to Contact PQC Prior to Replacing an Assembly
Released 10/6/2016 Warranty Administration - Battery Testing and Warranty Replacement Requirements (North America ONLY)
Released 9/30/2016 Changes to Essential and Available Tool Numbering System
Released 9/30/2016 Warranty Administration - Courtesy Transportation and Roadside Assistance Programs
Released 9/27/2016 Warranty Administration - New Global Labor Codes
Released 9/19/2016 Comeback Prevention Information and Using Customer Concern Verification Sheets (CCVS)
Released 8/12/2016 Warranty Administration - Battery Testing and Warranty Replacement Requirements (North America ONLY)
Released 8/12/2016 Warranty Administration - Servicing Vehicles from Canada (U.S. Dealers Only)
Released 7/13/2016 38660 - A16-2038660 GMI700 31UX Missing GM Roadside Kit
Released 6/8/2016 Warranty Administration - Required Operating Procedures (U.S. Only)
Released 5/20/2016 Warranty Administration - Required Operating Procedures (U.S. Only)
Released 5/20/2016 Service Programming System (SPS) Errors (E4398, E4399, E4403, M4404 M4413, E4414, E4423 or E4491)
Released 5/16/2016 New U.S. Dealer Special Tool Loan Program
Released 4/22/2016 Warranty Administration - Battery Testing and Warranty Replacement Requirements (North America ONLY)
Released 4/18/2016 Warranty, SPS, Control Module Diagnostics and Configuration Information, Programming, Set-Up
Released 4/14/2016 Battery Testing and Warranty Replacement Requirements (North America ONLY)
Released 3/29/2016 Being Prepared for TAC, Caller Preparedness and Checklist - Contacting U.S. Technical Assistance (TAC) and Use of Strategy Based Diagnostics
Released 3/29/2016 Information on COAX Repair Kit Availability
Released 3/14/2016 Warranty Administration - Courtesy Transportation and Roadside Assistance Programs
Released 3/1/2016 Warranty Administration - Required Operating Procedures (U.S. Only)
Released 2/5/2016 Hem Flange Rust Repair
Released 11/25/2015 GM TAC Support of Vehicle Vibration Complaints - U.S. and Canada Dealers Only
Released 10/31/2015 Vehicle Vibration Diagnosis and TAC Requests For Assistance With Vibration Related Complaints
Released 10/31/2015 Unable To Complete Software Update On The EL-50332 EV Battery Service Tool
Released 10/31/2015 PQC Assembly Replacement Process - For Dealers Required to Contact PQC Prior to Replacing an Assembly (U.S. and Canada Only)
Released 10/31/2015 Warranty Administration - New Vehicle Maintenance Program Cross-Border Servicing between the U.S. and Canada
Released 10/31/2015 Warranty Administration - GM Dealer Empowerment Program and Goodwill Procedures
Released 10/31/2015 Product Quality Center (PQC) Assembly Replacement Process - For Dealers Required to Contact PQC Prior to Replacing an Assembly (U.S. and Canada Only)
Released 10/31/2015 J-35616-64B Terminal Test Probe / Replacement Terminal / Terminated Lead
Released 10/31/2015 Information on Drilling High Strength Steel Related to Collision Repair
Released 10/31/2015 Warranty Administration - Required Operating Procedures (U.S. Only)
Released 10/31/2015 Engine Repair Tip for Installation of Pistons
Released 10/31/2015 Comeback Prevention Information and Using Customer Concern Verification Sheets (CCVS)
Released 10/31/2015 Warranty Administration - Change in Product Field Action Customer Reimbursement Procedure (U.S. Dealers Only)
Released 10/31/2015 Information on the Use of Non GM Approved Battery Chargers and Booster Packs
Released 10/31/2015 Warranty Administration - Causal Part Requirements for Transactions Submitted to GM for Payment
Released 9/12/2015 Air Conditioning Odor (Install Evaporator Core Dryer Kit and Apply Cooling Coil Coating)
Released 9/5/2015 GM Wiring Repair Strategy Information
Released 9/5/2015 Enhancing Field Product Reports with Digital Pictures
Released 8/22/2015 Warranty Administration - Essential Tools that Include Consumable Parts (U.S. Only)
Released 8/8/2015 Warranty Administration - Courtesy Transportation and Roadside Assistance Programs
Released 7/25/2015 Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability
Released 7/18/2015 Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability
Released 7/12/2015 Application of Anti-Corrosion Materials
Released 6/20/2015 GM TAC Support of Vehicle Vibration Complaints - US And Canada Dealers Only
Released 5/16/2015 Tips For operating the EL 50332 Hybrid/EV Battery Service Tool
Released 3/14/2015 Warranty Administration - Required Operating Procedures (U.S. Only)
Released 12/5/2014 Information for Dealers on How to Submit a Product Information Report (PIR) (Canada Only)
Released 7/10/2014 Software Update for EL-50332 Hybrid/EV Battery Service Tool
Released 7/8/2014 Procedure For Emailing Global Diagnostic System 2 (GDS2) Session Log To
Released 5/22/2014 Warranty Code Generated By EL-50313 Midtronics GR8 Battery Tester/Charger Required for Claim Processing On Labor Operation 4041510, 4041520 and 250 Mile/400 Km Labor Operation Restriction (North America ONLY)
Released 2/8/2014 (Hybrid) Emergency First Responder Information
Released 2/6/2014 Information on Slight or Mild Tire Feathering and Recommended Practices (Normal Tire Wear Condition)
Released 11/29/2013 Software Update for EL-50332 Hybrid/EV Battery Service Tool
Released 9/20/2013 (EREV Volt) Vacuum Coolant Fill Information
Released 6/28/2013 Key Cutting Procedure for Obtaining Replacement Key
Released 6/19/2013 Correct Selection Of Labor Codes
Released 6/7/2013 IPC Odometer Programming Method Quick Reference Guide
Released 5/21/2013 GM TAC Support of Vehicle Vibration Complaints - U.S. Dealers Only
Released 5/15/2013 J-35616-64B Terminal Test Probe And Replacement Terminal
Released 5/10/2013 Procedure For Emailing Global Diagnostic System 2 (GDS2) Session Log To GM TAC (US and Canada Dealers Only)
Released 3/22/2013 Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V6 and V8 Gasoline Engines Using Tech 2 or Global Diagnostic System 2 (GDS 2)
Released 3/1/2013 Paint-less Dent Repair Process
Released 1/1/2013 IPC Odometer Programming Method Quick Reference Guide
Released 9/4/2012 GM Accessories - Dealer-Installed, Repaired or Replaced During Warranty Coverage Period
Released 9/4/2012 Key Cutting Procedure for Obtaining Replacement Key
Released 9/4/2012 Customer Satisfaction - Enhanced 120 Volt Charge Cord
Released 3/19/2012 Hem Flange Rust Repair
Released 3/5/2012 Warranty, SPS, Control Module Diagnostics and Configuration Information, Programming, Set-Up
Released 3/5/2012 Part Restriction and Ordering Process Information for OnStar Vehicle Communication Interface Modules (VCIM)
Released 3/1/2012 Part Restriction and Ordering Process Information for OnStar Vehicle Communication Interface Modules (VCIM)
Released 1/13/2012 Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability
Released 10/24/2011 Use of Surface Conditioning Disks When Cleaning Engine Gasket Sealing Surfaces and/or Reused Engine Parts
Released 10/22/2011 Warranty Code Generated By EL-50313 Midtronics GR8 Battery Tester/Charger Required for Claim Processing On Labor Operation 4041510 and Battery Part Restriction (North America ONLY)
Released 10/22/2011 Information for Dealers/Technicians on When and How to Submit a Field Product Report (FPR) (U.S. Dealers Only)
Released 9/26/2011 Global Diagnostic System 2 (GDS 2) General Information
Released 8/10/2011 Comeback Prevention Information and Using Customer Concern Verification Sheets (CCVS)
Released 7/22/2011 Clarification of Use - Dealer Empowerment Labor Operations and Customer Enthusiasm
Released 7/22/2011 Enhancing Field Product Reports with Digital Pictures
Released 7/11/2011 Key Cutting Procedure for Obtaining Replacement Key
Released 6/17/2011 Improperly Formatted SI Screen Characters
Released 6/9/2011 Warranty Administration-Revised Customer Concern Not Duplicated (CCND)/Verified Labor Operation Numbers/How to Submit CCND Transactions in GWM / Elimination of E9995, J9993, J9994 and J9995
Released 5/23/2011 Global Warranty Management (GWM) Warranty Parts Center (WPC) Parts Return Program Information
Released 5/19/2011 IPC Odometer Programming Method Quick Reference Guide
Released 5/9/2011 Information for Dealers on How to Submit a Product Information Report (PIR) (Canada Only)
Released 5/5/2011 Change in Product Field Action Customer Reimbursement Procedure (U.S. Dealers Only)
Released 4/18/2011 Warranty Administration - Courtesy Transportation and Roadside Assistance Programs
Released 4/13/2011 Warranty Parts Center (WPC) Special Part Request Enhancement - New Expedited Overnight Shipping Process and Form Information
Released 4/7/2011 Expediting Warranty Parts

Released 3/7/2018
New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores

Released 2/27/2018
Warranty Administration - Updated - Dealer Empowerment Labor Operations and Customer Enthusiasm (U.S. Only)

Get all TSBs for 5 vehicles for only $25

TSB Description
Released 6/16/2017 Properly Maintaining Vehicles in Dealer Inventory
Released 10/7/2016 Properly Maintaining Vehicles in Dealer Inventory
Released 3/2/2016 New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores
Released 3/2/2016 Properly Maintaining Vehicles in Dealer Inventory
Released 7/18/2015 New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores
Released 6/6/2015 Properly Maintaining Vehicles in Dealer Inventory
Released 2/15/2013 Windshield Wiper Performance, Cleaning Instructions and Maintenance
Released 1/19/2012 Properly Maintaining Vehicles in Dealer Inventory
Released 1/13/2012 Properly Maintaining Vehicles in Dealer Inventory

Get Free 2012 CHEVROLET VOLT L4, 1.4L; DOHC; 16V; MPFI; Hybrid TSBs

Technical Service Bulletins

TSB – Footer – Root – 16

LP Standard Footer mailinglist B

LP Standard footer