Get Free 2006 CHEVROLET SILVERADO V8, 8.1L TSBs

Released 5/16/2017
Tailgate and Cargo Loop Capacity

Released 2/3/2017
Normal Characteristic - Tailgate Cable Slack

Released 11/4/2015
Disabling Or Removing CNG (Compressed Natural Gas) Fuel Systems

Released 10/31/2015
Information on Voltmeter Gauge Fluctuation Due to Regulated Voltage Control System and Concerns About Camper/Trailer Battery Charging

Released 10/31/2015
Diagnostic Tip for Coolant Leak at Oil Cooler Inlet Pipe O-Ring After Service Engine Replacement

Released 10/31/2015
Normal Characteristic - Tailgate Cable Slack

Released 8/1/2015
Information for Identifying Non-GM ECM Calibration Use and Power-up Hardware Detection in Duramax Diesel Engines - Photograph Tech 2 Calibration IDs, Calibration Verification Numbers (CVNs) and Transmission Data Screen

Released 6/1/2015
Higher Than Expected Oil Consumption at 8600 GVW and Above

Released 6/1/2015
Pre-Formed and Pre-Flared Hydraulic Brake Pipe Kits Now Available for Service

Released 5/12/2015
Information on Higher Than Expected Oil Consumption

Released 4/4/2015
Normal Characteristic - Tailgate Cable Slack

Released 3/28/2015
Aftermarket ALDL or DLC Interface Devices Causing Multiple Issues

Released 11/13/2014
Normal Characteristic - Passenger Compartment Air Filter

Released 11/11/2014
Speedometer Needle Accuracy Information

Released 8/26/2014
Information on Identifying Duramax Diesel Overpower Engine Breakdown/Non-Function Due to Aftermarket Power-Up Devices vs Non Overpower Engine Non-Function of Pistons, Cylinders, Valvetrain Components, DTC P003A or P111D Set

Released 8/8/2014
Concerns Or Questions Regarding The Installation Of Dealer Installed Accessories

Released 8/7/2014
Inside Rear View Mirror is Loose and/or Mirror Mounting Bracket Fell Off

Released 7/16/2014
Duramax Diesel Glow Plugs Difficult to Install Due to Carbon Buildup - New Glow Plug Bore Reamer Available

Released 6/19/2014
Radio Reprogramming Using Techline/Service Programming System (SPS) - Ensuring Correct Vehicle Selection

Released 2/6/2014
Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum Wheel Bead Seat Corrosion (Clean and Resurface Wheel Bead Seat)

Released 1/22/2014
Speedometer Needle Accuracy Information

Released 1/4/2014
Proper Wheel Installation and Wheel Torque Techniques

Released 6/19/2013
Global Information for GM dexos 1 and dexos 2 Engine Oil Specifications, Licensed Brands, and Service Fill

Released 6/19/2013
Information on Slight Vehicle Movement in Park at Start Up After Cold Soak

Released 6/19/2013
Repair Information for Reconnection of Rear Window Defroster (Defogger) Contact or Tab

Released 6/19/2013
Dealership Service Consultant Procedure as Vehicle Comes into Service Drive for Tire Pressure Monitor (TPM) System Message, Light and Customer Information

Released 4/23/2013
Odometer Servicing When The Odometer Cannot Be Set To The Actual Mileage

Released 4/12/2013
Information on Driveline Clunk Noise

Released 3/29/2013
Vehicle Software Enhancements

Released 3/22/2013
Vibration Analysis Worksheet

Released 3/1/2013
Paint-less Dent Repair Process

Released 2/17/2013
Tailgate Cable Slack

Released 2/15/2013
Windshield Wiper Performance, Cleaning Instructions and Maintenance

Released 2/15/2013
Information for Electrical Ground Repair - Use New Replacement Fasteners with Conductive Finish

Released 2/11/2013
Prior To Any Circuit Testing

Released 2/8/2013
HYDRA-MATIC Front Wheel Drive 4T80-E (MH1) Left Front Axle Seal Leak, Transmission Slips in Gear (Replace Third Clutch Housing with Revised Service Part)

Released 1/1/2013
Various Driveability Symptoms Due to Clogged Fuel Injectors, MIL/SES DTCs P0171, P0172, P0174, P0300, P1174, P1175 (Clean Fuel Injectors and/or Perform Injector Test With AFIT CH-47976)

Released 9/4/2012
IPC Odometer Programming Method Quick Reference Guide

Released 9/4/2012
Information on Normal Maintenance or Warranty Service for 4T40, 4T45, 4T65, 4L60 Automatic Transmission Oil Pan Magnet Upgrade

Released 5/3/2012
Information on Tire Radial Force Variation (RFV)

Released 3/19/2012
Hem Flange Rust Repair

Released 1/19/2012
Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability

Released 1/13/2012
Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability

Released 1/12/2012
Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability

Released 10/24/2011
Use of Surface Conditioning Disks When Cleaning Engine Gasket Sealing Surfaces and/or Reused Engine Parts

Released 10/22/2011
Warranty Code Generated By EL-50313 Midtronics GR8 Battery Tester/Charger Required for Claim Processing On Labor Operation 4041510 and Battery Part Restriction (North America ONLY)

Released 10/17/2011
Safety Belt Locking Conditions (Normal Operating Characteristics)

Released 10/13/2011
Eliminating Unwanted Odors in Vehicles

Released 7/22/2011
Car and Truck Fix it Right the First Time Issues

Released 7/22/2011
Car and Truck Fix it Right the First Time Issues

Released 7/15/2011
Key Code Security Rules and Information on GM KeyCode Look-Up Application (Canada Only)

Released 6/10/2011
Squeak or Creak Noise from Underbody over Bumps (Replace Body Cables)

Released 6/7/2011
Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability

Released 4/13/2011
Body Colored Side Moldings Dull, Discolored, Stained (Clean and Polish Moldings)

Released 4/12/2011
Underbody Pop or Clunk Type Noise While Turning or Driving on Uneven Road Surfaces (Install Body Mount Insulator)

Released 2/21/2011
Windshield Wiper Performance, Cleaning Instructions and Maintenance

Released 2/2/2011
Seat Belt Buckle Latching Issues and/or Seat Belt Warning Lights Illuminated

Released 12/23/2010
Information on Passenger Presence Sensing System (PPS or PSS) Concerns with Custom Upholstery, Accessory Seat Heaters or Other Comfort Enhancing Devices

Released 12/21/2010
Warranty Information-Fascia Refinish Labor Operations

Released 11/19/2010
Application of Anti-Corrosion Materials

Released 10/21/2010
Safety Belt Locking Conditions (Normal Operating Characteristics)

Released 10/14/2010
Warranty Administration-Warranty Claims Submission-Outside Rearview Mirrors

Released 9/14/2010
Car and Truck Fix It Right the First Time Issues

Released 9/10/2010
Distortion in Outer Surface of Vehicle Glass

Released 9/9/2010
Minor Wrinkles, Discoloration, Cuts on Seats with Leather, Vinyl or Cloth Seat Covers

Released 6/30/2010
Information on Hem Flange Sealer for Corrosion Protection

Released 6/30/2010
Squeeze Type Resistance Spot Welding/Equipment

Released 6/22/2010
Underbody Pop or Clunk Type Noise While Turning or Driving on Uneven Road Surfaces (Install Body Mount Insulator)

Released 6/15/2010
Information on Difficult to Install Fixed Radio Antenna Mast

Released 5/27/2010
Key Code Security Rules and Information on GM KeyCode Look-Up Application (U.S. Only)

Released 5/27/2010
Key Code Security Rules and Information on GM KeyCode Look-Up Application (Canada Only)

Released 5/4/2010
Information on Instrument Panel Cluster (IPC) Odometer and Engine Hour Meter Set Up at Dealership After IPC Replacement

Released 4/28/2010
New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores

Released 4/27/2010
Interior Cleaning-Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer-Product Availability

Released 3/30/2010
Information on Proper Use of Floor Mats

Released 3/11/2010
Key Code Security Rules and Information on GM KeyCode Look-Up Application

Released 3/10/2010
Intermittent MIL/SES, DTC P2138 with Reduced Engine Power (Repair Instrument Panel (IP) to Body Harness Connector)

Released 3/8/2010
Information on Driver or Passenger Seat Head Restraint Concerns with Comfort, Custom Upholstery or Other Comfort Enhancing Devices

Released 3/4/2010
Car and Truck Fix It Right the First Time Issues

Released 2/25/2010
Information on Heated Electrochromatic Outside Rearview Mirror Performance

Released 2/24/2010
Information on Passenger Presence Sensing System (PPS or PSS) Concerns with Custom Upholstery, Accessory Seat Heaters or Other Comfort Enhancing Devices

Released 2/5/2010
Information on Voltmeter Gauge Fluctuation Due to Regulated Voltage Control System and Concerns About Camper/Trailer Battery Charging

Released 2/4/2010
Car and Truck Fix It Right the First Time Issues

Released 11/4/2009
Safety Belt Locking Conditions (Normal Operating Characteristics)

Released 11/4/2009
Car and Truck Fix It Right the First Time Issues

Released 10/20/2009
Information on Side Door Window Glass Chipping Caused by Hanging Vehicle Key Lock Box

Released 10/6/2009
Information on Passenger Presence System (PPS or PSS) Concerns with Custom Upholstery, Accessory Seat Heaters or Other Comfort Enhancing Devices

Released 9/25/2009
Information on Discoloration, Blistering, Peeling or Erosion of Various Exterior Emblems Including Chevy Bowtie (Bulletin Canceled)

Released 9/18/2009
Clear Stain or Film on Inside Perimeter of Windshield Glass (Clean/Polish Glass)

Released 8/27/2009
Minor Wrinkles/Creases, Discoloration, Cigarette Burns and Customer Induced Cuts and Stains on Front and Rear Driver and Passenger Seats with Leather, Vinyl or Cloth Seat Covers

Released 8/13/2009
Information on Paint Stain Under Protective Shipping Film

Released 8/13/2009
Information on Body Control Module (BCM) Grounds

Released 7/29/2009
Information on Maintaining Exterior Weatherstrip Appearance

Released 7/28/2009
06-08-50-004A: Front Seat Armrest Hinge Breaking (Replace Lid) - (Jul 28, 2006)

Released 6/4/2009
Seat Belt Latch Stop Button Available for Service

Released 5/26/2009
Repair Information for Reconnection of Rear Window Defroster Contact or Tab

Released 5/18/2009
Interior Cleaning-Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl. Fabric Cleaner, Stain Remover, Restorer - Product Availability

Released 5/12/2009
Negative Impact of Dealer-Installed Cloth/Viny Roofs on XM Radio and/or OnStar Systems

Released 5/11/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 5/6/2009
Car and Truck Fix It Right the First Time Issues

Released 4/23/2009
IPC Odometer Programming Method Quick Reference

Released 3/19/2009
Marks/Stains on Windshield When Wet (Clean Windshield)

Released 3/12/2009
08-08-51-002: New Primer For TPO Fascias and Affected Cleaning Process of Painting Operation - (Mar 12, 2008)

Released 3/9/2009
Warranty Administration - Guidelines for Claiming C0034 - Windshield Replacement

Released 3/9/2009
New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores

Released 3/9/2009
Car and Truck Fix It Right the First Time Issues

Released 2/17/2009
Seat Belt Buckle Latching Issues and/or Seat Belt Warning Lights Illuminated

Released 2/16/2009
Warranty Administration - Labor Operation Z1241 - Personal Property Damage

Released 2/3/2009
Hem Flange Rust Repair

Released 1/28/2009
Non-Approval of Clipping (Sectioning of Two Vehicles) for Collision Repair

Released 1/8/2009
Preventing Damage on Dealer Lots During Longer Periods in Dealer Inventory and Maintaining High CSI Scores

Released 1/6/2009
Information on Curb Park Assist and Memory Related Issues on Outside Rearview Mirrors

Released 12/12/2008
Information on Passenger Presence Sensing System (PPS or PSS) Concerns with Custom Upholstery, Accessory Seat Heaters or Other Comfort Enhancing Devices

Released 11/26/2008
Hood Hinge Pivot Hole Too Large On Some Replacement Fenders

Released 10/16/2008
08-00-89-037: CSO Surcharges Not Allowed on Warranty Claims - (Oct 16, 2008)

Released 10/6/2008
08-00-89-036: GM Training - GM STC Training Location Changes (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-035: GM Training - Login Prompts for My I-Car Page of GM/I-CAR Web Site (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-033: GM Training - October 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-034: GM Training - Accessing Hands-On Checklists (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 9/29/2008
00-00-89-027E: Eliminating Unwanted Odors in Vehicles - (Sep 29, 2008)

Released 9/29/2008
01-07-30-032E: Transmission Oil Leaking From Transmission Vent (Replace Transmission Case Cover (Channel Plate) Gasket) - (Sep 29, 2008)

Released 9/18/2008
06-08-46-008C: Information on OnStar Dual-Mode (Analog/Digital) Systems - (Sep 18, 2008)

Released 9/15/2008
06-08-111-004A: Information on Discoloration, Blistering, Peeling or Erosion of Various Exterior Emblems Including the Chevy Bowtie - (Sep 15, 2008)

Released 9/10/2008
06-08-61-003D: Underbody Pop or Clunk Type Noise While Turning or Driving on Uneven Road Surfaces (Install Body Mount Insulator) - (Sep 10, 2008)

Released 8/27/2008
02-00-89-014E: New Labor Operation Codes for Dealer-Installed GM Accessories Replaced During Warranty Coverage Period - (Aug 27, 2008)

Released 8/25/2008
03-08-48-006E: Repair Information for Reconnection of Rear Window Defroster Contact or Tab - (Aug 25, 2008)

Released 8/14/2008
08-08-46-004: Information on Aftermarket Device Interference with OnStar Diagnostic Services - (Aug 14, 2008)

Released 6/27/2008
07-00-89-047B: Technical Assistance Center (TAC) Coverage Available for Current and Last Nine Model Year Vehicles (U.S. Only) - (Jun 27, 2008)

Released 6/24/2008
03-00-89-003A: GM Goodwrench Limited Lifetime Service Guarantee - (Jun 24, 2008)

Released 6/23/2008
08-08-64-011: Information on Heated Electrochromatic Outside Rearview Mirror Performance - (Jun 23, 2008)

Released 6/11/2008
08-00-89-022: GM Training: June 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Jun 11, 2008)

Released 6/10/2008
08-00-89-021: Servicing Medium Duty Trucks, Including Conventional and Crew Cabs, Motorhome Cutaway Cab, Commercial Cutaway Cab (Ambulance, School Bus, Shuttle Bus) and Tilt Cabs - (Jun 10, School Bus, Shuttle Bus) and Tilt Cabs - (Jun 10, 2008)

Released 6/6/2008
99-04-20-002E: Information on Driveline Clunk Noise When Shifting Between PARK and DRIVE, PARK and REVERSE or DRIVE and REVERSE - (Jun 6, 2008)

Released 6/5/2008
07-08-64-022A: Information on Curb Park Assist and Memory Related Issues on Outside Rear View Mirrors - (Jun 5, 2008)

Released 6/4/2008
08-07-30-027: No Movement When Transmission is Shifted to Drive or Third - Normal Operation When Shifted to Second, First or Reverse (Replace Forward Sprag Assembly) - (Jun 4, 2008)

Released 5/22/2008
07-08-49-020B: IPC Odometer Programming Method Quick Reference Guide - (May 22, 2008)

Released 5/12/2008
08-00-89-019: GM Training: May 2008 New Course Information (For U.S. Dealers and Aftermarket) - (May 12, 2008)

Released 5/2/2008
03-08-46-004D: Parts Restriction on Ordering OnStar Generation 6 and 7 Vehicle Communication Interface Modules (VCIM) - (May 2, 2008)

Released 5/1/2008
08-03-10-005: Use of Chrome or Chrome-Plated Steel Valve Caps on Aluminum Valve Stems - (May 1, 2008)

Released 4/30/2008
06-00-89-050B: Diagnostic Trouble Codes (DTCs) Required on Repair Orders - (Apr 30, 2008)

Released 4/29/2008
04-00-89-018C: Processing GM Accessories - Initial Quality Issues - (Apr 29, 2008)

Released 4/29/2008
07-08-49-015C: Information On Instrument Panel Cluster (IPC) Odometer and Engine Hour Meter Set Up at Dealership After IPC Replacement - (Apr 29, 2008)

Released 4/28/2008
05-08-51-001C: Information on Paint Stain Under Protective Shipping Film - (Apr 28, 2008)

Released 4/28/2008
07-00-89-031A: Warranty System Changes - Medium Duty Trucks - (Apr 28, 2008)

Released 4/24/2008
03-08-44-022E: Parts Restriction on Ordering XM Digital Radio Receiver - (Apr 24, 2008)

Released 4/21/2008
08-00-89-015: GM Training: April 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Apr 21, 2008)

Released 4/17/2008
99-00-89-011C: Key Code Information - (Apr 17, 2008)

Released 4/16/2008
05-08-44-024A: Return or Reimbursement of Customer Owned CDs, DVDs, Cassette Tapes and/or CD Magazines - (Apr 16, 2008)

Released 2/19/2008
08-00-89-006: GM Training: February 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Feb 19, 2008)

Released 2/5/2008
06-06-04-035A: Use of E85 Fuels in Vehicles Not Certified by GM as being FlexFuel Compatible/Aftermarket Conversion of Vehicles to Operate on E85 Fuels - (Feb 5, 2008)

Released 2/5/2008
04-06-01-029B: Unnecessary Engine Crankcase and Subsystems Flushing Services, Additive Recommendations and Proper Utilization of GM Simplified Maintenance Schedule to Enhance Customer Service Experience - (Feb 5, 2008)

Released 2/1/2008
00-08-48-005C: Distortion in Outer Surface of Vehicle Glass - (Feb 1, 2008)

Released 1/30/2008
99-08-52-005C: Remote Keyless Entry Operational Characteristics - (Jan 30, 2008)

Released 1/25/2008
04-08-50-006B: Minor Wrinkles/Creases, Discoloration, Cigarette Burns and Customer Induced Cuts and Stains on Front and Rear Dirver and Passenger Seats with Leather, Vinyl or Cloth Seat Covers - (Jan 25, 2008)

Released 1/18/2008
04-08-44-005C: Utilizing Tech 2 to Retrieve Part Numbers for Radios, Compact Disc (CD) Changers and Instrument Panel Clusters (IPC) - (Jan 18, 2008)

Released 1/17/2008
04-00-89-053B: Engineering Information (EI) Process - (Jan 17, 2008)

Released 1/17/2008
08-00-89-003: GM Training: January 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Jan 17, 2008)

Released 1/10/2008
06-00-89-029D: Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability - (Jan 10, 2008)

Released 1/9/2008
99-09-40-005E: Seat Belt Extender Availability - (Jan 9, 2008)

Released 1/8/2008
02-08-44-007C: Negative Impact of Dealer-Installed Cloth/Vinyl Roofs on XM Radio and/or OnStar Systems - (Jan 8, 2008)

Released 1/8/2008
02-08-46-006C: Incorrect OnStar Global Positioning System (GPS) Location Reported During OnStar Call - (Jan 8, 2008)

Released 1/8/2008
06-00-89-016A: Cataloging of Electronic Service Center Parts - (Jan 8, 2008)

Released 1/8/2008
05-08-46-004B: OnStar Phone Number Concerns (Phone Number Incorrect/Assigned to Another Vehicle/Phone) That Occur During Diagnosis of OnStar System - (Jan 8, 2008)

Released 12/17/2007
07-00-89-062: GM Training: December 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Dec 17, 2007)

Released 11/13/2007
07-00-89-056: GM Training: November 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Nov 13, 2007)

Released 11/2/2007
03-00-89-008D: Corrosion Protection for Metal Panels With Dealer Installed Accessories Fastened By Drilled Holes - (Nov 2, 2007)

Released 10/31/2007
07-09-40-002: Seat Belt Latch Stop Button Available for Service - (Oct 31, 2007)

Released 10/15/2007
07-00-89-051: GM Training: I-CAR Offers Various Resources to Help Dealers Achieve Training Goals (U.S. Dealers) - (Oct 15, 2007)

Released 10/15/2007
07-00-89-052: GM Training: October 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Oct 15, 2007)

Released 9/7/2007
07-08-42-013: Turn Signal in Camper Style Outside Rearview Mirror (RPO DPN) Does Not Illuminate Turn Signal Flash (Replace Upper Mirror Glass) - (Sep 7, 2007)

Released 9/5/2007
07-08-45-002: Service Alert: Concerns With Aftermarket Fuses in GM Vehicles - (Sep 5, 2007)

Released 8/27/2007
03-08-61-002I: Snap/Popping Type Noise Coming From Front of Vehicle (Remove Bolt-In Front Crossmember and Add Washers) - (Aug 27, 2007)

Released 8/23/2007
07-00-89-043: Warranty Admin. - Use of Parts and Components (Including Control Module Calibrations) Not Issued Through General Motors - (Aug 23, 2007)

Released 8/17/2007
07-00-89-039: GM Training: August 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Aug 17, 2007)

Released 8/13/2007
01-08-49-017A: Center Front Floor Console Compartment Lock Cylinder and Key Replacement - (Aug 13, 2007)

Released 7/25/2007
07-00-89-033: GM Training - June 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Jul 25, 2007)

Released 7/24/2007
03-08-48-005C: Compass Zone Adjustment and Calibration Procedure During Pre-Delivery Inspection - (Jul 24, 2007)

Released 7/23/2007
03-03-09-002B: Rear Leaf Spring Slap or Clunk Noise (Replace Spring Inserts) - (Jul 23, 2007)

Released 7/19/2007
05-08-44-005A: Information on Rear Seat Headphone Foam Ear Pad Replacement if Worn or Damaged - (Jul 19, 2007)

Released 7/19/2007
06-08-50-009B: Information on Passenger Presence Sensing System (PPS or PSS) Concerns with Custom Upholstery, Accessory Seat Heaters or Other Comfort Enhancing Devices) - (Jul 19, 2007)

Released 6/27/2007
07-00-89-028: GM Training: May 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Jun 27, 2007)

Released 6/26/2007
07-00-89-025: GM Training: April 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Jun 26, 2007)

Released 6/26/2007
07-00-89-024: GM Training: Service Training Standard (STS) Effective Date for Two Required Technology Close-ups (TCUs) was 04/14/07 (U.S. Dealers) - (Jun 26, 2007)

Released 6/26/2007
07-00-89-011: GM Training: Course Information (For U.S. Dealers and Aftermarket) - (Jun 26, 2007)

Released 6/22/2007
99-08-64-016B: Use of Silicone for Weatherstrip Maintenance - (Jun 22, 2007)

Released 6/21/2007
07-06-04-019: Intermittent MIL/SES, DTC P2138 with Reduced Engine Power (Repair Instrument Panel (IP) to Body Harness Connector) - (Jun 21, 2007)

Released 6/18/2007
03-08-64-010C: Outside Rearview Mirrors May Blow in at Highway Speeds or Power Folding Feature Appears Inoperative (Synchronize Mirrors) - (Jun 18, 2007)

Released 6/14/2007
05-00-89-067B: Communication Strategy of Service Information/Strategy Based Diagnostics - (Jun 14, 2007)

Released 6/13/2007
05-09-40-002B: Safety Belt Locking Conditions (Normal Operating Characteristic) - (Jun 13, 2007)

Released 5/21/2007
01-07-30-042E: Information on 2-3 Upshift or 3-2 Downshift Clunk Noise - (May 21, 2007)

Released 4/23/2007
05-08-51-008B: Bumps or Rust Colored Spots in Paint Due to Rail or Iron Dust (Remove Rail Dust) - (Apr 23, 2007)

Released 4/17/2007
07-08-63-001: Information on Repair of Polypropylene Energy Absorbers - (Apr 17, 2007)

Released 4/2/2007
07-08-98-001: Info - Non-approval of Clipping (Sectioning of Two Vehicles) for Collision Repair - (Apr 2, 2007)

Released 3/7/2007
07-06-01-003: LBZ LB7 LLY 6.6L Duramax Diesel Engine Accessory Drive Belt Chirp, Squeal or Squeak Type Noise at Cold Start Idle (Replace Accessory Drive Belt) - (Mar 7, 2007)

Released 2/15/2007
07-00-89-003: Info - New Bulletin Category: Technical Training (U.S. Only) - (Feb 15, 2007)

Released 1/24/2007
06-08-51-001C: Information on Protective Coating Removal - Apply Remover - (Jan 24, 2007)

Released 1/17/2007
02-08-98-002B: Info - Hem Flange Rust Repair - (Jan 17, 2007)

Released 1/12/2007
06-03-06-005A: Vehicle Lean - Left Front Sits Low or Right Rear High (Add Spacer Between Left Rear Spring Pack and Axle) - (Jan 12, 2007)

Released 1/10/2007
07-08-64-001: Warranty Admin. - Labor Time Revision for C0182 and C0183 Labor Operations - (Jan 10, 2007)

Released 1/4/2007
01-03-10-012C: Info - Guidelines for Using E2020-Wheel Alignments, E2000-Toe Adjust and E0200, E0201, E0203, E0204-Wheel Balance - (Jan 4, 2007)

Released 11/6/2006
04-08-49-015A: Noise Coming From Instrument Panel Cluster (Replace Instrument Panel Cluster (IPC)) - (Nov 6, 2006)

Released 10/9/2006
02-08-98-001C: Info - Metal Panel Bonding - (Oct 9, 2006)

Released 9/22/2006
03-00-89-006D: Info - New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores - (Sep 22, 2006)

Released 8/11/2006
06-08-110-006: Headliner Sags in Center of Roof (Install Retainer) - (Aug 11, 2006)

Released 8/7/2006
06-00-89-038: Information on Radio and Instrument Panel Cluster (IPC) Part Restrictions (U.S. Only) - (Aug 7, 2006)

Released 7/24/2006
05-08-50-012A: Unwanted/Loose Seat Movement (Apply Adhesive and Install New Bolts in Seat Mounting Rails) - (Jul 24, 2006)

Released 6/26/2006
07-01-38-001: GM Training: HVAC Systems and Operation Stage 2 WBT and IDL (11044.03) (For U.S. Dealers Only) - (Jun 26, 2007)

Released 6/21/2006
06-00-89-036: Owner Manual and Warranty Information in Service Information (SI) Website/Distributed on CD - (Jul 21, 2006)

Released 5/4/2006
04-08-50-011A: Info - Repairing Napped Seat Fabric - (May 4, 2006)

Released 5/2/2006
06-08-45-004: Info - Instrument Panel (I/P), Body and General Wiring Harness Repair - (May 2, 2006)

Released 4/3/2006
05-08-64-002B: Door Latch Freezing in Cold Temperatures (Apply Super Lube) - (Apr 3, 2006)

Released 4/3/2006
06-08-48-001: SMU - Revised Hinged Body Side Window Replacement - (Apr 3, 2006)

Released 3/29/2006
02-08-48-001B: Info - Urethane Adhesives for Stationary Glass and Other Applications - (Mar 29, 2006)

Released 3/24/2006
99-00-89-015F: Info - Light Service Support Vehicle LSSV and Enhanced Mobility Package EMP - RPO EM7 Vehicle (Formerly Commercial Utility Cargo Vehicle - CUCCV II and III) Service (U.S. ONLY) - (Mar 24, 2006)

Released 2/16/2006
05-08-64-029B: Info - Power Window Regulator Now Available Separately From Motor - (Feb 16, 2006)

Released 2/13/2006
05-08-44-029A: Info - Radio Knobs Available for Service - (Feb 13, 2006)

Released 2/1/2006
06-08-64-006: Wide Load Outside Rear View Mirror (RPO DPN) Glass Cracked, Broken or Fell Out of Mirror Housing (Replace Mirror Glass) - (Feb 1, 2006)

Released 1/30/2006
06-06-04-006: Info - Elimination of Fuel Filler Tube Flapper Door - (Jan 30, 2006)

Released 1/20/2006
03-08-50-014A: No Communication with Any Modules, Memory Seat May Not Recall, Multiple U-DTCs Set or Instrument Panel Cluster (IPC) Warning Indicators, Crank No Start (Inspect/Repair Affected Wiring Harness) - (Jan 20, 2006)

Released 12/14/2005
Power Front Seat (RPO AN3) Switch Knobs Loose or Missing (Replace Switch Knobs)

Released 11/23/2005
05-00-89-082: Info - Elimination of Front License Plate Bracket (Canada Only) - (Nov 23, 2005)

Released 11/21/2005
99-08-51-001A: Info - Paint-less Dent Repair Process - (Nov 21, 2005)

Released 11/2/2005
05-00-89-075: Warranty Admin. - Servicing Medium Duty Trucks, Including Conventional and Crew Cabs, Motorhome Cutaway Cab, Commercial Cutaway Cab (Ambulance, School Bus, Shuttle Bus), and Tilt Cabs - (Nov 2, 2005)

Released 6/28/2005
04-08-48-001B: Info - Rear Window Defogger - Broken Heating Grid Detection Method - (Jun 28, 2005)

Released 6/14/2004
04-08-48-003: Windrush Around Windshield (Install New Windshield Reveal Moldings) - (Jun 14, 2004)

Released 1/17/1997
Car and Truck Fix it Right the First Time Issues

Released 6/1/2015
Pre-Formed and Pre-Flared Hydraulic Brake Pipe Kits Now Available for Service

Released 6/1/2015
Pre-Formed and Pre-Flared Hydraulic Brake Pipe Kits Now Available for Service

Released 11/29/2013
Pre-Formed and Pre-Flared Hydraulic Brake Pipe Kits Now Available for Service

Released 3/22/2013
Aftermarket ALDL or DLC Interface Devices Causing Multiple Issues

Released 7/22/2011
Car and Truck Fix it Right the First Time Issues

Released 4/19/2011
Disc Brake Warranty Service and Procedures

Released 5/11/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 5/6/2009
Car and Truck Fix It Right the First Time Issues

Released 5/1/2009
Antilock Brake (ABS) Activation at Low Speeds (Clean Wheel Speed Sensor Mounting Surface)

Released 3/26/2009
Disc Brake Warranty Service and Procedures

Released 3/11/2009
ABS Light On, DTCs C0265, C0201, U1041 Set and/or Loss of Communication with Brake Module (Reground EBCM Ground)

Released 3/9/2009
Car and Truck Fix It Right the First Time Issues

Released 1/8/2009
Preventing Damage on Dealer Lots During Longer Periods in Dealer Inventory and Maintaining High CSI Scores

Released 10/6/2008
08-00-89-036: GM Training - GM STC Training Location Changes (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-033: GM Training - October 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-034: GM Training - Accessing Hands-On Checklists (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 9/10/2008
06-08-61-003D: Underbody Pop or Clunk Type Noise While Turning or Driving on Uneven Road Surfaces (Install Body Mount Insulator) - (Sep 10, 2008)

Released 6/27/2008
07-00-89-047B: Technical Assistance Center (TAC) Coverage Available for Current and Last Nine Model Year Vehicles (U.S. Only) - (Jun 27, 2008)

Released 6/24/2008
03-00-89-003A: GM Goodwrench Limited Lifetime Service Guarantee - (Jun 24, 2008)

Released 5/6/2008
00-05-22-002K: Disc Brake Warranty Service and Procedures - (May 6, 2008)

Released 5/1/2008
99-07-30-030F: Grinding and/or Growling Noise in Park on Incline - (May 1, 2008)

Released 4/21/2008
08-00-89-015: GM Training: April 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Apr 21, 2008)

Released 3/6/2008
08-06-04-016: Diagnostic Information on MIL/SES with DTC P0171 (Fuel Trim System Lean Bank 1) and/or P0174 (Fuel Trim System Lean Bank 2) After Brake Master Cylinder Replacement - (Mar 6, 2008)

Released 1/9/2008
06-08-46-002B: Availability of GM OnStar Vehicle Diagnostics and GM Goodwrench Remote Diagnostic Services - (Jan 9, 2008)

Released 10/31/2007
06-03-09-004A: Squeak Noise From Rear of Vehicle (Lubricant Rear Leaf Springs) - (Oct 31, 2007)

Released 8/23/2007
07-00-89-043: Warranty Admin. - Use of Parts and Components (Including Control Module Calibrations) Not Issued Through General Motors - (Aug 23, 2007)

Released 8/17/2007
07-00-89-039: GM Training: August 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Aug 17, 2007)

Released 7/25/2007
07-00-89-033: GM Training - June 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Jul 25, 2007)

Released 6/26/2007
07-00-89-011: GM Training: Course Information (For U.S. Dealers and Aftermarket) - (Jun 26, 2007)

Released 6/14/2007
04-05-25-002D: ABS Light On, DTCs C0265, C0201, U1041 Set and/or Loss of Communication with Brake Module (Reground EBCM Ground) - (Jun 14, 2007)

Released 11/30/2006
06-05-22-007: Warranty Admin. - Brake Rotor/Drum Refinishing Labor Operations - (Nov 30, 2006)

Released 5/16/2006
03-05-25-007C: Antilock Brake (ABS) Activation at Low Speeds (Clean Wheel Speed Sensor Mounting Surface) - (May 16, 2006)

Released 11/2/2005
05-00-89-075: Warranty Admin. - Servicing Medium Duty Trucks, Including Conventional and Crew Cabs, Motorhome Cutaway Cab, Commercial Cutaway Cab (Ambulance, School Bus, Shuttle Bus), and Tilt Cabs - (Nov 2, 2005)

Released 10/17/2005
04-00-89-020B: Info - Pre-Delivery and Service Guide - Parallel Hybrid Truck (PHT) (RPO HP2) - (Oct 17, 2005)

Released 6/8/2005
05-05-22-001: Info - On-Car Brake Lathe Specifications and Maintenance Requirements - (Jun 8, 2005)

Released 1/17/1997
Car and Truck Fix it Right the First Time Issues

Released 6/22/2011
Malfunction Indicator Lamp (MIL) Illuminated at Very Cold Ambient Temperatures when Using Engine Coolant Heater, DTC P0116 and/or P1400 Set (Relocate ECT Sensor and Engine Coolant Heater Cord)

Released 4/19/2011
Transmission Fluid Cooler Line Leak (Replace Affected Cooler Line)

Released 4/18/2011
New Tool Availability - EN-48974 - EGR Cooler Pressure Tester Adapter Set to Diagnose Duramax Diesel Engine EGR Cooler Engine Coolant Leaks into Combustion Chamber

Released 3/2/2011
Automatic Transmission Oil Cooler Flush and Flow Test Essential Tool J-45096 TransFlow

Released 1/24/2011
MIL Illuminated at Very Cold Temperatures When Using Engine Coolant Heater, DTC P0116 and/or P1400 Set (Relocate Engine Coolant Temperature (ECT) Sensor and Engine Coolant Heater Cord)

Released 4/29/2010
Unnecessary Flushing Services, Additive Recommendations and Proper Utilization of GM Simplified Maintenance Schedule to Enhance Customer Service Experience

Released 9/9/2009
Automatic Transmission Oil Cooler Flush and Flow Test Essential Tool J 45096 TransFlow

Released 5/11/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 5/5/2009
Engine Oil Leaks from Charge Air Cooler and Turbocharger Air Inlet Adapter (Replace Clamp and/or Turbo Inlet Duct/Pipe)

Released 3/20/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 3/18/2009
Transmission Oil Cooler Line Leak (Replace Affected Cooler Line)

Released 10/6/2008
08-00-89-036: GM Training - GM STC Training Location Changes (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-033: GM Training - October 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-034: GM Training - Accessing Hands-On Checklists (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 6/27/2008
07-00-89-047B: Technical Assistance Center (TAC) Coverage Available for Current and Last Nine Model Year Vehicles (U.S. Only) - (Jun 27, 2008)

Released 6/24/2008
03-00-89-003A: GM Goodwrench Limited Lifetime Service Guarantee - (Jun 24, 2008)

Released 4/21/2008
08-00-89-015: GM Training: April 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Apr 21, 2008)

Released 2/22/2008
02-07-30-052E: Automatic Transmission Oil Cooler Flush and Flow Test Essential Tool J 45096 TransFlow - (Feb 22, 2008)

Released 1/31/2008
08-07-30-004: 4L60-E, 4L65-E, 4L70-E HYDRAMATIC Automatic Transmission RPOs M30, M70, M32, M33, MK2, MD6 Oil Cooler Fitting Change - (Jan 31, 2008)

Released 1/18/2008
05-06-02-002B: DEX-COOL Coolant - New Leak Detection Dye J 46366 Replaces J 29545-6 - (Jan 18, 2008)

Released 1/10/2008
08-06-04-003: New Tool Availability - EN-48974 - EGR Cooler Pressure Tester Adapter Set to Diagnose Duramax Diesel Engine EGR Cooler Leaks into Combustion Chamber - (Jan 10, 2008)

Released 8/17/2007
07-00-89-039: GM Training: August 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Aug 17, 2007)

Released 6/12/2007
06-06-01-019B: Information on Gradual Coolant Loss Over Time with No Evidence of Leak Found - (Jun 12, 2007)

Released 10/6/2006
06-01-39-005B: EI06052 - HVAC Not Cooling, A/C Not Cool (Perform A/C Performance Test Per SI) - (Oct 6, 2006)

Released 8/15/2006
00-06-02-006D: Engine Coolant Recycling and Warranty Information - (Aug 15, 2006)

Released 4/27/2006
06-06-04-027: LBZ, LB7, LLY, Service Engine Soon (SES) Light Illuminated, DTC P0116, P0181 Set with Engine Coolant Heater Usage in Ambient Temps Above -18 Degrees C (0 Degrees F) (Replace Engine Coolant Heater Cord - (Apr 27, 2006)

Released 11/2/2005
05-00-89-075: Warranty Admin. - Servicing Medium Duty Trucks, Including Conventional and Crew Cabs, Motorhome Cutaway Cab, Commercial Cutaway Cab (Ambulance, School Bus, Shuttle Bus), and Tilt Cabs - (Nov 2, 2005)

Released 10/4/2004
05-07-30-009A: Revised Essential Tool J-35944- 200-A Adapter For 9.525mm (0.375 in.) Automatic Transmission Oil Cooler Lines - (Oct 4, 2005)

Released 8/30/2016
Parallel Hybrid Truck (PHT) Part Restriction has Ended

Released 2/8/2016
No Crank With DTC P1AAB, P1AAC, P1AAD, and/or P1AAE

Released 1/20/2016
Parallel Hybrid Truck (PHT) Part Restriction

Released 10/31/2015
Information on Voltmeter Gauge Fluctuation Due to Regulated Voltage Control System and Concerns About Camper/Trailer Battery Charging

Released 3/28/2015
Aftermarket ALDL or DLC Interface Devices Causing Multiple Issues

Released 8/26/2014
Parallel Hybrid Truck (PHT) Part Restriction

Released 8/8/2014
Concerns Or Questions Regarding The Installation Of Dealer Installed Accessories

Released 6/19/2014
Radio Reprogramming Using Techline/Service Programming System (SPS) - Ensuring Correct Vehicle Selection

Released 4/7/2014
Parallel Hybrid Truck (PHT) Part Restriction

Released 1/22/2014
Speedometer Needle Accuracy Information

Released 10/5/2013
OnStar Will Not Power Up

Released 9/14/2013
OnStar Will Not Power Up

Released 6/19/2013
Global Information for GM dexos 1 and dexos 2 Engine Oil Specifications, Licensed Brands, and Service Fill

Released 6/19/2013
Information on Slight Vehicle Movement in Park at Start Up After Cold Soak

Released 6/19/2013
Repair Information for Reconnection of Rear Window Defroster (Defogger) Contact or Tab

Released 4/23/2013
Odometer Servicing When The Odometer Cannot Be Set To The Actual Mileage

Released 4/12/2013
Information on Driveline Clunk Noise

Released 3/29/2013
Vehicle Software Enhancements

Released 3/22/2013
OnStar Will Not Power Up

Released 3/22/2013
Vibration Analysis Worksheet

Released 3/22/2013
Aftermarket ALDL or DLC Interface Devices Causing Multiple Issues

Released 3/1/2013
Paint-less Dent Repair Process

Released 3/1/2013
DVD Navigation Update Program, Navigation Disc Diagnostic Aid, AVN Software Update Discs and Ordering Information

Released 2/15/2013
Windshield Wiper Performance, Cleaning Instructions and Maintenance

Released 2/15/2013
Information for Electrical Ground Repair - Use New Replacement Fasteners with Conductive Finish

Released 2/11/2013
Prior To Any Circuit Testing

Released 1/1/2013
IPC Odometer Programming Method Quick Reference Guide

Released 3/3/2012
Warranty, SPS, Control Module Diagnostics and Configuration Information, Programming, Set-Up

Released 2/10/2012
Service Programming System (SPS) Errors (E4398, E4399, E4403, E4404 E4413, E4414, E4423 or E4491, E4494)

Released 10/22/2011
Warranty Code Generated By EL-50313 Midtronics GR8 Battery Tester/Charger Required for Claim Processing On Labor Operation 4041510 and Battery Part Restriction (North America ONLY)

Released 7/22/2011
Car and Truck Fix it Right the First Time Issues

Released 6/9/2011
Information on Difficult to Install Fixed Radio Antenna Mast

Released 6/6/2011
Information for Electrical Ground Repair - Use New Replacement Fasteners with Conductive Finish

Released 5/19/2011
IPC Odometer Programming Method Quick Reference Guide

Released 5/13/2011
Headlamp, Tail Lamp or Fog/Driving Lamp Damage

Released 2/9/2011
Accsssory Drive Belt Chirp, Squeal or Squeak Type Noise at Cold idle (Replace A/C Compressor/Power Steering Pump Mounting Bracket or Enlarge Bracket Bolt Holes)

Released 2/2/2011
Seat Belt Buckle Latching Issues and/or Seat Belt Warning Lights Illuminated

Released 1/5/2011
Exterior Lamp Condensation and Replacement Guidelines

Released 12/23/2010
OnStar Phone Number Concerns (Phone Number Incorrect/Assigned to Another Vehicle/Phone) That Occur During Diagnosis of OnStar System

Released 12/8/2010
Intermittent No Crank/No Start, No Module Communication, MIL, Warning Lights, Messages or DTCs Set by Various Control Modules-Diagnosing and Repairing Fretting Corrosion

Released 12/6/2010
IPC Odometer Programming Method Quick Reference Guide

Released 10/25/2010
Information for Electrical Ground Repair - Use New Replacement Fasteners with Conductive Finish

Released 10/18/2010
Warranty Code Generated by El-50313/Charger Required for N0110, Battery Parts Rest

Released 9/14/2010
Car and Truck Fix It Right the First Time Issues

Released 6/28/2010
Intermittent Malfunction Indicator Lamp (MIL) Illuminated, DTC P2138 with Reduced Engine Power (Repair Instrument Panel (IP) to Body Harness Connector)

Released 6/11/2010
Information on Inappropriate Warranty Claims Submitted for Damaged Radios and Instrument Panel Clusters (IPCs)

Released 6/4/2010
Information for Electrical Ground Repair - Use New Replacement Fasteners with Conductive Finish

Released 4/28/2010
New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores

Released 3/10/2010
Intermittent MIL/SES, DTC P2138 with Reduced Engine Power (Repair Instrument Panel (IP) to Body Harness Connector)

Released 3/9/2010
Battery Part Restriction Program Effective March 1, 2008

Released 3/5/2010
Information for Electrical Ground Repair-Use New Replacement Fasteners with Conductive Finish

Released 3/4/2010
Car and Truck Fix It Right the First Time Issues

Released 2/11/2010
DVD Navigation Update Program, Navigation Disc Diagnostic Aid, AVN Software Update Discs and Ordering Information

Released 2/5/2010
Information on Voltmeter Gauge Fluctuation Due to Regulated Voltage Control System and Concerns About Camper/Trailer Battery Charging

Released 2/4/2010
Car and Truck Fix It Right the First Time Issues

Released 11/24/2009
Intermittent No Crank/No Start, No Module Communication, MIL, Warning Lights, Vehicle Messages or DTCs Set by Various Control Modules-Diagnosing and Repairing Fretting Corrosion

Released 11/4/2009
Car and Truck Fix It Right the First Time Issues

Released 10/6/2009
Information on Passenger Presence System (PPS or PSS) Concerns with Custom Upholstery, Accessory Seat Heaters or Other Comfort Enhancing Devices

Released 9/1/2009
Intermittent No Crank/No Start, No Module Communication, MIL, Warning Lights, Vehicle Messages or DTCs Set by Various Control Modules (Disconnect Affected Connector and Apply Dielectric Lubricant)

Released 8/27/2009
Minor Wrinkles/Creases, Discoloration, Cigarette Burns and Customer Induced Cuts and Stains on Front and Rear Driver and Passenger Seats with Leather, Vinyl or Cloth Seat Covers

Released 8/13/2009
Information on Body Control Module (BCM) Grounds

Released 7/27/2009
Diagnosing Accessory Drive Belt/Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool-Drive Belt

Released 6/11/2009
Replacement of Headlamp Assemblies Under Warranty and Use of GM vs. Non-GM Headlamp Assemblies

Released 5/12/2009
Negative Impact of Dealer-Installed Cloth/Viny Roofs on XM Radio and/or OnStar Systems

Released 5/11/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 5/6/2009
Car and Truck Fix It Right the First Time Issues

Released 5/4/2009
Exterior Lamp Condensation and Replacement Guidelines

Released 4/29/2009
Malfunction Indicator Lamp (MIL) Illuminated, Intermittent DTC P0191, Slow Fuel Rail Pressure (FRP) Decay, Wiring Harness Connections, Voltage Fluctuations/Interruptions (Follow Correction Info Below)

Released 4/23/2009
IPC Odometer Programming Method Quick Reference

Released 3/20/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 3/9/2009
New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores

Released 3/9/2009
Car and Truck Fix It Right the First Time Issues

Released 3/9/2009
Navigation Radio Diagnostic Tips

Released 2/17/2009
Seat Belt Buckle Latching Issues and/or Seat Belt Warning Lights Illuminated

Released 2/11/2009
Key Code Security Rules and Information on GM KeyCode Look-Up Application

Released 2/6/2009
GM Training - February 2009 New Course Information (For U.S. Dealers and Aftermarket)

Released 1/20/2009
Information on Verifying OnStar System Function During Pre-Delivery Inspection (PDI)

Released 1/8/2009
Preventing Damage on Dealer Lots During Longer Periods in Dealer Inventory and Maintaining High CSI Scores

Released 1/6/2009
Information on Curb Park Assist and Memory Related Issues on Outside Rearview Mirrors

Released 12/17/2008
Replacement of Headlamp Assemblies Under Warranty and Use of GM vs. Non-GM Headlamp Assemblies

Released 12/12/2008
Information on Passenger Presence Sensing System (PPS or PSS) Concerns with Custom Upholstery, Accessory Seat Heaters or Other Comfort Enhancing Devices

Released 11/26/2008
GM Training - December 2008 New Course Information (For U.S. Dealers and Aftermarket)

Released 11/6/2008
Intermittent MIL/SES, DTC P2138 with Reduced Engine Power (Repair Instrument Panel (IP) to Body Harness Connector)

Released 10/29/2008
Reducing Electrical Intermittents-Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Misc. DTCs, Intermittent Driveability Concerns, Hard/No

Released 10/6/2008
08-00-89-036: GM Training - GM STC Training Location Changes (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-033: GM Training - October 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-034: GM Training - Accessing Hands-On Checklists (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 9/25/2008
06-06-04-042A: LR4, LY2, L33, LH6, LM7, L59, LC9, LMG, LY5, LS2, LQ9, LQ4, L76, LY6 Throttle Actuator Control (TAC) Module Codes, MIL/SES DTCs P2108 P1516, U0107, Reduced Engine Power (Reprogram PCM) - (Sep 25, 2006)

Released 9/10/2008
06-08-61-003D: Underbody Pop or Clunk Type Noise While Turning or Driving on Uneven Road Surfaces (Install Body Mount Insulator) - (Sep 10, 2008)

Released 9/5/2008
02-08-42-001C: Headlamp Lens Overheating When Covered and Chemical Damage to Exterior Polycarbonate Headlamp Lenses - (Sep 5, 2008)

Released 8/28/2008
08-08-44-028: Information on Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies) - (Aug 28, 2008)

Released 8/25/2008
03-08-48-006E: Repair Information for Reconnection of Rear Window Defroster Contact or Tab - (Aug 25, 2008)

Released 8/22/2008
08-06-03-009: Reducing Electrical Intermittents - Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Miscellaneous DTCs, Intermittent Driveability Concerns - (Aug 22, 2008)

Released 8/21/2008
06-08-47-001E: Warranty, SPS, Control Module Diagnostics and Configuration Information, Programming, Set-Up - (Aug 21, 2008)

Released 7/21/2008
02-06-03-008D: Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Ilde, Low Generator Output - (Jul 21, 2008)

Released 7/21/2008
07-06-03-009A: Information on Voltmeter Gauge Fluctuation Due to Regulated Voltage Control System and Concerns About Camper/Trailer Battery Charging - (Jul 21, 2008)

Released 6/27/2008
07-00-89-047B: Technical Assistance Center (TAC) Coverage Available for Current and Last Nine Model Year Vehicles (U.S. Only) - (Jun 27, 2008)

Released 6/24/2008
03-00-89-003A: GM Goodwrench Limited Lifetime Service Guarantee - (Jun 24, 2008)

Released 6/18/2008
08-08-44-023: Information on Navigation Radio Not Displaying Accurate Vehicle Location After Radio Replacement, Power Loss or Battery Replacement - (Jun 18, 2008)

Released 6/11/2008
08-00-89-022: GM Training: June 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Jun 11, 2008)

Released 6/5/2008
07-08-64-022A: Information on Curb Park Assist and Memory Related Issues on Outside Rear View Mirrors - (Jun 5, 2008)

Released 6/2/2008
05-09-41-001B: Supplemental Inflatable Restraint (SIR) Light ON, Diagnostic Trouble Codes (Inspect/Replace IP Harness to Inflatable Restraint Module (Air Bag) Yellow 4-Way Connector C221 and/or C222) - (Jun 2, 2008)

Released 5/29/2008
08-06-03-005: GM Dealer Visits: Proper Management of Batteries in Dealer Parts Stock/Vehicle Inventory - (May 29, 2008)

Released 5/22/2008
07-08-49-020B: IPC Odometer Programming Method Quick Reference Guide - (May 22, 2008)

Released 5/12/2008
08-00-89-019: GM Training: May 2008 New Course Information (For U.S. Dealers and Aftermarket) - (May 12, 2008)

Released 5/8/2008
04-06-04-036E: Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) - (May 8, 2008)

Released 5/2/2008
05-08-46-001D: OnStar Generation 5 or 6 (DIgital) System Inoperative/Has No Power, LED Light Not On (Remove/Reinstall OnStar Fuse and Replace VCIM or Follow SI Diagnostics) - (May 2, 2008)

Released 5/2/2008
01-08-42-001F: Exterior Lamp Condensation and Replacement Guidelines - (May 2, 2008)

Released 5/2/2008
05-08-45-002D: Required Return Criteria of Complete Electrical Centers (EC) and Body Control Modules (IBCMs) with Integrated Electrical Centers to Warranty Parts Center (WPC) - (May 2, 2008)

Released 4/30/2008
03-06-03-003B: ACDelco Replacement Battery Warranty Procedures - (Apr 30, 2008)

Released 4/29/2008
07-08-49-015C: Information On Instrument Panel Cluster (IPC) Odometer and Engine Hour Meter Set Up at Dealership After IPC Replacement - (Apr 29, 2008)

Released 4/28/2008
05-08-51-001C: Information on Paint Stain Under Protective Shipping Film - (Apr 28, 2008)

Released 4/28/2008
07-00-89-031A: Warranty System Changes - Medium Duty Trucks - (Apr 28, 2008)

Released 4/21/2008
08-00-89-015: GM Training: April 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Apr 21, 2008)

Released 4/17/2008
05-06-03-002C: Battery and Charging System Electrical Diagnostics - (Apr 17, 2008)

Released 4/17/2008
99-00-89-011C: Key Code Information - (Apr 17, 2008)

Released 4/17/2008
05-00-89-045A: Electronic Exchange Program Goodwill Procedures - (Apr 17, 2008)

Released 4/15/2008
05-04-21-003C: Service 4WD Light Illuminated, DTC C0374 Set (Inspect Wiring Harness to Transfer Case Speed Sensors, Replace Wiring Harness) - (Apr 15, 2008)

Released 3/27/2008
08-06-01-008: Diagnosing Accessory Drive Belt/Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt - (Mar 27, 2008)

Released 3/26/2008
00-02-35-003N: Clunking Noise Under Hood and Can Be Felt in Steering Wheel and/or Steering Column (Replace Upper Intermediate Steering Shaft (I-Shaft) Assembly) - (Mar 26, 2008)

Released 3/14/2008
08-06-03-002A: Battery Part Restriction Program Effective March 1st, 2008 - (Mar 14, 2008)

Released 2/27/2008
08-08-52-002: Diagnostic Information for Inoperative Remote Vehicle Start - (Feb 27, 2008)

Released 2/25/2008
08-09-41-003: General Motors Position Statement on Installation of Used, Salvaged or Imitation Air Bag System Components - (Feb 25, 2008)

Released 2/19/2008
08-00-89-006: GM Training: February 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Feb 19, 2008)

Released 2/1/2008
06-08-44-015A: Information on Eliminating Noise in Audio System When Using Portable Playback Device - (Feb 1, 2008)

Released 1/30/2008
99-08-52-005C: Remote Keyless Entry Operational Characteristics - (Jan 30, 2008)

Released 1/17/2008
02-08-46-007D: Information on OnStar System - Possible Loss of GPS Signal, Hands-Free Calling Minutes Expire Prematurely and/or Inability to Add Hands-Free Calling Minutes - (Jan 17, 2008)

Released 1/17/2008
08-00-89-003: GM Training: January 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Jan 17, 2008)

Released 1/16/2008
08-07-30-001: 4L80E, MT1 and 4L85E, MN8 Simplified Valve Body Reconditioning Instructions, DTC P0741, P0742, P0751, P0752, P0756, P0757, P0894, Harsh or Delayed Shifts, Slips, No Drive, No Reverse - (Jan 16, 2008)

Released 1/9/2008
06-08-46-006A: Information on Verifying OnStar System Function During Pre-Delivery Inspection(PDI) - (Jan 9, 2008)

Released 1/9/2008
99-09-40-005E: Seat Belt Extender Availability - (Jan 9, 2008)

Released 1/8/2008
06-00-89-016A: Cataloging of Electronic Service Center Parts - (Jan 8, 2008)

Released 12/17/2007
07-00-89-062: GM Training: December 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Dec 17, 2007)

Released 11/13/2007
07-00-89-056: GM Training: November 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Nov 13, 2007)

Released 11/5/2007
02-01-39-007B: Automatic Dual Zone HVAC Battery Draw - (Nov 5, 2007)

Released 10/15/2007
07-00-89-052: GM Training: October 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Oct 15, 2007)

Released 9/7/2007
07-08-42-013: Turn Signal in Camper Style Outside Rearview Mirror (RPO DPN) Does Not Illuminate Turn Signal Flash (Replace Upper Mirror Glass) - (Sep 7, 2007)

Released 9/5/2007
07-08-45-002: Service Alert: Concerns With Aftermarket Fuses in GM Vehicles - (Sep 5, 2007)

Released 8/23/2007
07-00-89-043: Warranty Admin. - Use of Parts and Components (Including Control Module Calibrations) Not Issued Through General Motors - (Aug 23, 2007)

Released 8/17/2007
07-00-89-039: GM Training: August 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Aug 17, 2007)

Released 8/2/2007
03-06-03-001D: Starter Cranks After Key Is Released (Normal Condition) - (Aug 2, 2007)

Released 7/25/2007
07-00-89-033: GM Training - June 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Jul 25, 2007)

Released 7/19/2007
06-08-50-009B: Information on Passenger Presence Sensing System (PPS or PSS) Concerns with Custom Upholstery, Accessory Seat Heaters or Other Comfort Enhancing Devices) - (Jul 19, 2007)

Released 6/29/2007
05-08-46-009B: Language Change for OnStar System (U.S. and Canada Only) - (Jun 29, 2007)

Released 6/27/2007
07-01-38-004: Information on GM ACR2000 (J-43600) and New Refrigerant Recovery Recharging Equipment SAE J2788 - (Jun 27, 2007)

Released 6/27/2007
07-00-89-028: GM Training: May 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Jun 27, 2007)

Released 6/26/2007
07-00-89-025: GM Training: April 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Jun 26, 2007)

Released 6/21/2007
07-06-04-019: Intermittent MIL/SES, DTC P2138 with Reduced Engine Power (Repair Instrument Panel (IP) to Body Harness Connector) - (Jun 21, 2007)

Released 6/14/2007
05-00-89-067B: Communication Strategy of Service Information/Strategy Based Diagnostics - (Jun 14, 2007)

Released 6/8/2007
06-08-43-003A: Windshield Wiper Performance, Cleaning Instructions and Maintenance - (Jun 8, 2007)

Released 4/17/2007
07-08-44-007: Information on Obtaining Replacement Navigation Discs When Radios are Exchanged - Order Replacement Navigation Disc Through Navigation Disc Center - (Apr 17, 2007)

Released 3/30/2007
02-08-42-004A: Info - PRNDL Display Reduced Visibility for Approximately One Minute - (Mar 30, 2007)

Released 3/7/2007
07-06-01-003: LBZ LB7 LLY 6.6L Duramax Diesel Engine Accessory Drive Belt Chirp, Squeal or Squeak Type Noise at Cold Start Idle (Replace Accessory Drive Belt) - (Mar 7, 2007)

Released 2/20/2007
06-07-30-007A: Malfunction Indicator Lamp (MIL) On, Diagnostic Trouble Code (DTC) P0894, Harsh 1-2 Shift with 4L60-E, 4L65-E, 4L70-E Auto Transmission (Test/Replace TCC Enable Solenoid/Harness, Auto Trans Wiring) - (Feb 20, 2007)

Released 1/24/2007
06-00-89-051A: KeyCode Security Rules and Information on GM KeyCode Look-Up Application - (Jan 24, 2007)

Released 1/23/2007
06-08-42-002A: Sunshade (Visor) Vanity Mirror Bulb Inoperative (Replace Vanity Mirror Bulb Only) - (Jan 23, 2007)

Released 1/10/2007
07-08-64-001: Warranty Admin. - Labor Time Revision for C0182 and C0183 Labor Operations - (Jan 10, 2007)

Released 11/28/2006
04-06-04-001C: LB7/LBZ/LLY/LMM - Intermittent Driveability Conditions-No Crank, Crank No Start, Hard to Start, MIL/SES, HEsitation, Lack of Power, Surge, Misfire, Fuel Knock, IPC Indicates No Oil Pressure, DTCs Set - (Nov 28, 2006)

Released 9/12/2006
06-06-04-046: Information on Engine Misfire MIL/SES Light Illuminated or Flashing DTC P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307, P0308, P0420 or P0430 - (Sep 12, 2006)

Released 9/12/2006
01-07-30-038D: Diagnostic Trouble Code (DTC) P0757 Set, Malfunction Indicator Lamp (MIL) Illuminated, Poor Performance of Transmission/Slipping (Clean Transmission Valve Body and Case Oil Passages of Debris) - (Sep 12, 2006)

Released 8/4/2006
06-06-04-037: Info - Normal Characteristics of Malfunction Indicator Lamp (MIL) During On-Board Diagnostic (OBD) Inspection/Maintenance (I/M) Testing - (Aug 4, 2006)

Released 5/30/2006
06-07-30-013: Allison Transmission - Vehicle Shudder When Driving in 6th Gear Range (Reprogram Transmission Control Module (TCM)) - (May 30, 2006)

Released 5/17/2006
06-04-21-001: Info - Updated Transfer Case Connector Service Kit Now Available for Transfer Case Speed Sensor Wire Harness Connector that Comes Loose or Connector Retainer Clip Breaks - (May 17, 2006)

Released 5/2/2006
06-08-45-004: Info - Instrument Panel (I/P), Body and General Wiring Harness Repair - (May 2, 2006)

Released 4/3/2006
06-08-48-001: SMU - Revised Hinged Body Side Window Replacement - (Apr 3, 2006)

Released 3/24/2006
99-00-89-015F: Info - Light Service Support Vehicle LSSV and Enhanced Mobility Package EMP - RPO EM7 Vehicle (Formerly Commercial Utility Cargo Vehicle - CUCCV II and III) Service (U.S. ONLY) - (Mar 24, 2006)

Released 3/7/2006
02-06-04-015A: Intermittent No Crank, No Start (Clean Battery Side Terminal Stripped Threads, Replace Battery Cable Bolt) - (Mar 7, 2006)

Released 3/1/2006
02-08-46-010G: Info - Programming OnStar Module for Canadian French Voice Recognition (OnStar Generation 5 or Generation 6) -(Mar 1, 2006)

Released 2/17/2006
06-08-45-001: Information on Changes to the SI Table of Contents, Electrical Connectors, Terminal Testing/Repair and the Importance of J-38125 Terminal Repair Kit Maintenance - (Feb 17, 2006)

Released 2/14/2006
02-06-05-004B: Info - Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems - (Feb 14, 2006)

Released 1/20/2006
03-08-50-014A: No Communication with Any Modules, Memory Seat May Not Recall, Multiple U-DTCs Set or Instrument Panel Cluster (IPC) Warning Indicators, Crank No Start (Inspect/Repair Affected Wiring Harness) - (Jan 20, 2006)

Released 1/9/2006
03-08-44-018C: Rear Seat Audio (RSA) and/or Rear HVAC Inoperative (Replace RSA Module) - (Jan 9, 2006)

Released 11/2/2005
05-00-89-075: Warranty Admin. - Servicing Medium Duty Trucks, Including Conventional and Crew Cabs, Motorhome Cutaway Cab, Commercial Cutaway Cab (Ambulance, School Bus, Shuttle Bus), and Tilt Cabs - (Nov 2, 2005)

Released 10/17/2005
04-00-89-020B: Info - Pre-Delivery and Service Guide - Parallel Hybrid Truck (PHT) (RPO HP2) - (Oct 17, 2005)

Released 9/26/2005
05-07-30-024: Info - Required Torque Specification When Using Special Tool J-47275 Transmission Control Module (TCM) Breakout Harness Adapter and/or Removal/Replacement of TCM - (Sep 26, 2005)

Released 9/23/2005
01-07-30-002E: MIL On, Transmission Stuck in Second or Third Gear, IPC Inoperative, DTCs P0740, P0753, P0758, P0785, P0787, P0973, P0976, P1860, P2761, P2764 and/or P2769 Set (Verify and Repair Source of Voltage Loss - (Sep 23, 2005)

Released 9/23/2005
05-06-04-060: Powertrain Control Module (PCM), Engine Control Module (ECM), Transmission Control Module (ECM), Transmission Control Module (TCM) DTCs P0601/P0602/P0603/P0604,/P1621 Shared in Multiple Modules - (Sep 23, 2005)

Released 6/28/2005
04-08-48-001B: Info - Rear Window Defogger - Broken Heating Grid Detection Method - (Jun 28, 2005)

Released 6/14/2004
04-08-48-003: Windrush Around Windshield (Install New Windshield Reveal Moldings) - (Jun 14, 2004)

Released 1/17/1997
Car and Truck Fix it Right the First Time Issues

Released 4/4/2014
Possible Engine Oil Leak Due To PCV Freeze-Up

Released 3/25/2014
Possible Engine Oil Leak Due To PCV Freeze-Up

Released 3/22/2013
Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V6 and V8 Gasoline Engines Using Tech 2 or Global Diagnostic System 2 (GDS 2)

Released 2/1/2013
Aftermarket ALDL or DLC Interface Devices Causing Multiple Issues

Released 9/4/2012
Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V8 Gasoline Engines Using Tech 2 or Global Diagnostic System 2 (GDS 2)

Released 3/3/2012
Warranty, SPS, Control Module Diagnostics and Configuration Information, Programming, Set-Up

Released 2/10/2012
Service Programming System (SPS) Errors (E4398, E4399, E4403, E4404 E4413, E4414, E4423 or E4491, E4494)

Released 7/22/2011
Car and Truck Fix it Right the First Time Issues

Released 9/16/2010
Check Engine Light On, Fuel Tank Hard to Fill, DTCs P0442, P0446, P0455 or P0449 Set (Replace EVAP Solenoid)

Released 8/6/2010
Information on Drilling High Strength Steel Related to Collision Repair

Released 5/10/2010
Malfunction Indicator Lamp (MIL) Illuminated at Very Cold Ambient Temperatures When Using Engine Coolant Heater, DTC P0116 and/or P1400 Set (Relocate Engine Coolant Temperature (ECT) Sensor, Htr Cord)

Released 1/8/2010
DTC P0446 (Restricted/Blocked EVAP Vent Path) Set, Check Engine Light On (Replace Evaporative Emission (EVAP) Vent Valve Solenoid Assembly and Add/Relocate Filter Box Using Service Kit)

Released 10/19/2009
DTC P0446 (Restricted/Blocked EVAP Vent Path) Set, Check Engine Light On (Replace Evaporative Emission (EVAP) Vent Valve Solenoid Assembly and Add/Relocate Filter Box Using Service Kit)

Released 6/19/2009
Procedure to Take Snapshot Data with Tech 2 and Upload Data to Computer Using TIS Software

Released 5/18/2009
Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V8 Gas Engines

Released 5/11/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 5/6/2009
Car and Truck Fix It Right the First Time Issues

Released 4/29/2009
Malfunction Indicator Lamp (MIL) Illuminated, Intermittent DTC P0191, Slow Fuel Rail Pressure (FRP) Decay, Wiring Harness Connections, Voltage Fluctuations/Interruptions (Follow Correction Info Below)

Released 4/9/2009
DTC P0446 (Restricted/Blocked EVAP Vent Path) Set, Check Engine Light (Replace Evaporative Emission (EVAP) Vent Valve Solenoid Assembly and Add/Relocate Filter Box Using Service Kit)

Released 3/9/2009
Car and Truck Fix It Right the First Time Issues

Released 2/6/2009
Check Engine Light On, DTC P0403 Set (Check/Reprogram ECM and Perform EGR Valve Motor Cleaning Procedure)

Released 1/9/2009
Warranty, SPS, Control Module Diagnostics and Configuration Information, Programming, Set-Up

Released 10/30/2008
Procedure to Take Snapshot Data with a Tech 2 and Upload Data to Computer Using TIS Software

Released 10/29/2008
Information on Identifying Non-GM Calibration Usages for LBZ, LLY, LMM Duramax Diesel Engines

Released 10/6/2008
08-00-89-036: GM Training - GM STC Training Location Changes (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-033: GM Training - October 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-034: GM Training - Accessing Hands-On Checklists (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 9/25/2008
06-06-04-042A: LR4, LY2, L33, LH6, LM7, L59, LC9, LMG, LY5, LS2, LQ9, LQ4, L76, LY6 Throttle Actuator Control (TAC) Module Codes, MIL/SES DTCs P2108 P1516, U0107, Reduced Engine Power (Reprogram PCM) - (Sep 25, 2006)

Released 8/26/2008
08-06-04-033B: Identifying Aftermarket Engine and Transmission Calibrations Gas Powered Engines Only and Automatic Transmissions - (Aug 26, 2008)

Released 8/21/2008
06-08-47-001E: Warranty, SPS, Control Module Diagnostics and Configuration Information, Programming, Set-Up - (Aug 21, 2008)

Released 8/6/2008
05-06-04-022E: TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - Canada ONLY - (Aug 6, 2008)

Released 7/31/2008
06-06-04-066C: LBZ, LLY Engine MIL/SES Light On With DTC P0403 Set (Check/Reprogram ECM and Perform EGR Valve Motor Cleaning Procedure) - (Jul 31, 2008)

Released 6/27/2008
07-00-89-047B: Technical Assistance Center (TAC) Coverage Available for Current and Last Nine Model Year Vehicles (U.S. Only) - (Jun 27, 2008)

Released 6/27/2008
08-06-04-006B: Information on Identifying Non-GM Calibration Usages for LMM Duramax Diesel Engine - (Jun 27, 2008)

Released 6/24/2008
03-00-89-003A: GM Goodwrench Limited Lifetime Service Guarantee - (Jun 24, 2008)

Released 6/17/2008
05-00-89-072B: Fuel and Oil Additives - Facts and Myths/Maximizing Fuel Economy - (Jun 17, 2008)

Released 5/8/2008
04-06-04-036E: Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) - (May 8, 2008)

Released 5/1/2008
PIP4403: Control Module Ignition On Timer Performance DTC P2610 - keywords 6.6 cal calibration ECM engine LBZ LLY MIL replace replacement - (May 1, 2008)

Released 4/30/2008
06-00-89-050B: Diagnostic Trouble Codes (DTCs) Required on Repair Orders - (Apr 30, 2008)

Released 4/21/2008
08-00-89-015: GM Training: April 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Apr 21, 2008)

Released 4/16/2008
02-06-04-037D: DTC P0446 (Restricted/Blocked Evap Vent Path) Set, Check Engine Light On (Replace Evaporative Emission (EVAP) Vent Valve Solenoid Assembly and Add/Relocate Filter Box Using Service Kit) - (Apr 16, 2008)

Released 3/6/2008
08-06-04-016: Diagnostic Information on MIL/SES with DTC P0171 (Fuel Trim System Lean Bank 1) and/or P0174 (Fuel Trim System Lean Bank 2) After Brake Master Cylinder Replacement - (Mar 6, 2008)

Released 2/27/2008
08-07-30-010: 4L60E Automatic Transmission (RPO M30) - Shudder or Slip in Reverse Under Hard Acceleration (Reprogram PCM) - (Feb 27, 2008)

Released 2/19/2008
08-00-89-006: GM Training: February 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Feb 19, 2008)

Released 1/17/2008
04-00-89-053B: Engineering Information (EI) Process - (Jan 17, 2008)

Released 1/10/2008
08-06-04-003: New Tool Availability - EN-48974 - EGR Cooler Pressure Tester Adapter Set to Diagnose Duramax Diesel Engine EGR Cooler Leaks into Combustion Chamber - (Jan 10, 2008)

Released 12/17/2007
07-00-89-062: GM Training: December 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Dec 17, 2007)

Released 10/22/2007
06-06-04-063C: 6.6L Duramax LBZ, LLY, LMM Diesel Engine EGR Valve Motor is Now Serviceable Separately from EGR Valve Assembly - (Oct 22, 2007)

Released 10/15/2007
07-00-89-052: GM Training: October 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Oct 15, 2007)

Released 8/23/2007
07-00-89-043: Warranty Admin. - Use of Parts and Components (Including Control Module Calibrations) Not Issued Through General Motors - (Aug 23, 2007)

Released 8/17/2007
07-00-89-039: GM Training: August 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Aug 17, 2007)

Released 7/25/2007
06-06-04-010E: Information on 3.5L (VIN K - RPO LZE), 3.9L (VIN W - RPO LGD) and 5.3L (VINS Z, 0, 3 - RPOs L59, LMG, LC9) E85 Fuel Compatible Vehicles - Alcohol Content, Switching Between Gasoline and E85 Fuel - (Jul 25, 2007)

Released 6/26/2007
07-00-89-025: GM Training: April 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Jun 26, 2007)

Released 6/26/2007
07-00-89-024: GM Training: Service Training Standard (STS) Effective Date for Two Required Technology Close-ups (TCUs) was 04/14/07 (U.S. Dealers) - (Jun 26, 2007)

Released 6/26/2007
07-00-89-011: GM Training: Course Information (For U.S. Dealers and Aftermarket) - (Jun 26, 2007)

Released 6/14/2007
05-00-89-067B: Communication Strategy of Service Information/Strategy Based Diagnostics - (Jun 14, 2007)

Released 5/3/2007
07-07-30-010: Procedure to Take Snapshot Data with a Tech 2 and Upload Data to Computer Using TIS Software - (May 3, 2007)

Released 3/23/2007
06-06-04-005A: Malfunction Indicator Lamp (MIL) On, Lean and/or Rich Fuel System DTC(s) P0171, P0172, P0174, P0175 Set on E85 Flexible Fuel 5.3L VIN Z - RPO L59 Engine (Reprogram PCM) - (Mar 23, 2007)

Released 10/24/2006
06-06-04-057: Warranty Admin. - Revised Mass Air Flow Core Return Requirements - (Oct 24, 2006)

Released 10/10/2006
00-06-04-033B: Info - I/M Readiness as Part of Emission Inspection and Maintenance Program for OBD II Vehicles - (Oct 10, 2006)

Released 8/4/2006
06-06-04-037: Info - Normal Characteristics of Malfunction Indicator Lamp (MIL) During On-Board Diagnostic (OBD) Inspection/Maintenance (I/M) Testing - (Aug 4, 2006)

Released 2/14/2006
02-06-05-004B: Info - Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems - (Feb 14, 2006)

Released 11/2/2005
05-00-89-075: Warranty Admin. - Servicing Medium Duty Trucks, Including Conventional and Crew Cabs, Motorhome Cutaway Cab, Commercial Cutaway Cab (Ambulance, School Bus, Shuttle Bus), and Tilt Cabs - (Nov 2, 2005)

Released 10/17/2005
04-00-89-020B: Info - Pre-Delivery and Service Guide - Parallel Hybrid Truck (PHT) (RPO HP2) - (Oct 17, 2005)

Released 9/23/2005
05-06-04-060: Powertrain Control Module (PCM), Engine Control Module (ECM), Transmission Control Module (ECM), Transmission Control Module (TCM) DTCs P0601/P0602/P0603/P0604,/P1621 Shared in Multiple Modules - (Sep 23, 2005)

Released 1/17/1997
Car and Truck Fix it Right the First Time Issues

Released 6/24/2013
Catalytic Converter Break-In Information To Prevent DTCs P0420 And/Or P0430

Released 2/1/2013
Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V6 and V8 Gasoline Engines Using Tech 2 or Global Diagnostic System 2 (GDS 2)

Released 1/1/2013
Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V8 Gasoline Engines Using Tech 2 or Global Diagnostic System 2 (GDS 2)

Released 2/16/2011
Exhaust Moan/Vibration Noise (Install Exhaust System Flex Pipe Kit)

Released 9/14/2010
Car and Truck Fix It Right the First Time Issues

Released 2/4/2010
Exhaust Moan/Vibration Noise (Install Exhaust System Flex Pipe Kit)

Released 10/28/2009
Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V8 Gas Engines

Released 5/11/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 5/6/2009
Car and Truck Fix It Right the First Time Issues

Released 3/20/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 10/6/2008
08-00-89-036: GM Training - GM STC Training Location Changes (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-033: GM Training - October 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-034: GM Training - Accessing Hands-On Checklists (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 6/27/2008
07-00-89-047B: Technical Assistance Center (TAC) Coverage Available for Current and Last Nine Model Year Vehicles (U.S. Only) - (Jun 27, 2008)

Released 6/24/2008
03-00-89-003A: GM Goodwrench Limited Lifetime Service Guarantee - (Jun 24, 2008)

Released 4/21/2008
08-00-89-015: GM Training: April 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Apr 21, 2008)

Released 2/5/2008
02-06-05-003G: Exhaust Moan/Vibration Noise (Install Exhaust System Flex Pipe Kit and Exhaust Dampeners, If Necessary) - (Feb 5, 2008)

Released 2/4/2008
06-06-01-010A: Info on Close-Coupled Converter, Engine Breakdown or Non-Function Due to Severe Overheat/Lack of Oil Causing Pistons, Rods, Crankshaft, Cylinders/Heads, Camshaft, Intake/Exhaust Valves, Bearing Damage - (Feb 4, 2008)

Released 8/17/2007
07-00-89-039: GM Training: August 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Aug 17, 2007)

Released 3/5/2007
03-06-05-008D: Exhaust Popping/Snapping Noise When Vehicle is Hot, at Idle or Immediately After Vehicle is Shut Off (Replace Muffler Heat Shield) - (Mar 5, 2007)

Released 12/22/2005
02-00-89-006C: Warranty Admin. - New Add Time for Labor Operation L2300 - Converter, Oxidation Catalytic-Replace - (Dec 22, 2005)

Released 11/2/2005
05-00-89-075: Warranty Admin. - Servicing Medium Duty Trucks, Including Conventional and Crew Cabs, Motorhome Cutaway Cab, Commercial Cutaway Cab (Ambulance, School Bus, Shuttle Bus), and Tilt Cabs - (Nov 2, 2005)

Released 8/2/2016
Information on Diesel Fuel Additives

Released 1/22/2016
DTCs P003A and P2563 Setting After Turbocharger Replacement

Released 11/4/2015
Disabling Or Removing CNG (Compressed Natural Gas) Fuel Systems

Released 10/31/2015
Cleaning Diesel Engine Fuel Injectors

Released 10/31/2015
Engine Misfire on Cylinder 7 And P0300 Due To Fuel System Contamination

Released 10/31/2015
Fuel Gauge Fluctuation in Park or Neutral

Released 10/31/2015
Diesel Engine Hard Start When Hot

Released 7/16/2014
Duramax Diesel Glow Plugs Difficult to Install Due to Carbon Buildup - New Glow Plug Bore Reamer Available

Released 5/14/2014
Catalytic Converter Break-In Information To Prevent DTCs P0420 And/Or P0430

Released 1/1/2013
Various Driveability Symptoms Due to Clogged Fuel Injectors, MIL/SES DTCs P0171, P0172, P0174, P0300, P1174, P1175 (Clean Fuel Injectors and/or Perform Injector Test With AFIT CH-47976)

Released 7/22/2011
Car and Truck Fix it Right the First Time Issues

Released 7/15/2011
Key Code Security Rules and Information on GM KeyCode Look-Up Application (Canada Only)

Released 10/27/2010
TOP TIER Detergent Gasoline Information and Available Brands (Deposits, Fuel Economy, No Start, Stall Concerns) Canada Only

Released 4/29/2010
Unnecessary Flushing Services, Additive Recommendations and Proper Utilization of GM Simplified Maintenance Schedule to Enhance Customer Service Experience

Released 3/4/2010
Car and Truck Fix It Right the First Time Issues

Released 2/4/2010
Car and Truck Fix It Right the First Time Issues

Released 1/28/2010
Malfunction Indicator Lamp (MIL) Illuminated, Intermittent DTC P0191, Slow Fuel Rail Pressure (FRP) Decay, Wiring Harness Connections, Voltage Fluctuations/Interruptions (Follow Correction Information

Released 11/10/2009
Information on Servicing Duramax Diesel Fuel Injectors to Avoid and Remove Contamination

Released 8/17/2009
TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - Canada ONLY

Released 8/17/2009
TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only

Released 7/20/2009
LBZ, LLY, LMM MIL/SES Light On, DTC P0087-Fuel Rail Pressure (FRP) Too Low, Lack of Performance, No Power, Engine Runs Rough, No Start (Diagnose Fuel System Components)

Released 5/11/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 5/6/2009
Car and Truck Fix It Right the First Time Issues

Released 5/5/2009
Engine Oil Leaks from Charge Air Cooler and Turbocharger Air Inlet Adapter (Replace Clamp and/or Turbo Inlet Duct/Pipe)

Released 4/29/2009
Malfunction Indicator Lamp (MIL) Illuminated, Intermittent DTC P0191, Slow Fuel Rail Pressure (FRP) Decay, Wiring Harness Connections, Voltage Fluctuations/Interruptions (Follow Correction Info Below)

Released 4/22/2009
Various Driveability Symptoms Due to Clogged Fuel Injectors, MIL/SES DTCs P0171, P0172, P0174, P0300, P1174, P1175 (Clean Fuel Injectors and/or Perform Injector Test with AFIT CH-47976)

Released 4/3/2009
LBZ, LLY, LMM MIL/SES Light, DTC P0087 - Fuel Rail Pressure (FRP) Too Low, Lack of Performance, No Power, Engine Runs Rough, No Start (Diagnose Fuel System Components)

Released 3/25/2009
LM4, LM7, L59, LR4, LQ9, LQ4, LY6 Throttle Actuator Control (TAC) Module Codes, MIL/SES DTCs P2108, P1516, U0107, Reduced Engine Power (Reprogram PCM)

Released 3/20/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 3/9/2009
Car and Truck Fix It Right the First Time Issues

Released 3/2/2009
Information on Improved Fuel Filter for 6.6L Duramax Diesel Engine

Released 1/13/2009
Information on Diesel Fuel Additives

Released 12/3/2008
Intermittent Engine Misfire And SES Light Due To Loss Of Voltage To Ignition Coils - keywords connector miss P0300 P0301 P0302 P0303 P0304 P0305 P0306 P0307 P0308 P0351 P0352 P0353 P0354 P0355 P0356

Released 11/6/2008
GM Training - November 2008 New Course Information (For U.S. Dealers and Aftermarket)

Released 10/9/2008
03-06-93-001D: Diagnostic Information on Turbocharger Malfunction Due to Lack of Engine Oil for LBZ, LB7, LLY and LMM Duramax Diesel Engine - (Oct 9, 2008)

Released 10/6/2008
08-00-89-036: GM Training - GM STC Training Location Changes (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-033: GM Training - October 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-034: GM Training - Accessing Hands-On Checklists (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/1/2008
08-06-04-029A: LBZ, LLY, LMM MIL/SES Light On DTC P0087 - Fuel Rail Pressure (FRP) Too Low, Lack of Performance, No Power, Engine Runs Rough, No Start (Diagnose Fuel System Components) - (Oct 1, 2008)

Released 9/25/2008
06-06-04-042A: LR4, LY2, L33, LH6, LM7, L59, LC9, LMG, LY5, LS2, LQ9, LQ4, L76, LY6 Throttle Actuator Control (TAC) Module Codes, MIL/SES DTCs P2108 P1516, U0107, Reduced Engine Power (Reprogram PCM) - (Sep 25, 2006)

Released 9/4/2008
05-06-01-034F: 5.3L LC9, LS4, L33, LH6, LM4, 5.7L LS1, LS6, 6.0L LS2, L76 6.2L L92, 7.0L LS7 - Engine Oil Leak at Rear Cover Assembly Area (Engine Block Porosity RTV Repair Procedure) - (Sep 4, 2008)

Released 8/6/2008
05-06-04-022E: TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - Canada ONLY - (Aug 6, 2008)

Released 6/27/2008
07-00-89-047B: Technical Assistance Center (TAC) Coverage Available for Current and Last Nine Model Year Vehicles (U.S. Only) - (Jun 27, 2008)

Released 6/24/2008
04-06-04-047H: TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only - (Jun 24, 2008)

Released 6/24/2008
03-00-89-003A: GM Goodwrench Limited Lifetime Service Guarantee - (Jun 24, 2008)

Released 6/17/2008
05-00-89-072B: Fuel and Oil Additives - Facts and Myths/Maximizing Fuel Economy - (Jun 17, 2008)

Released 6/2/2008
05-09-41-001B: Supplemental Inflatable Restraint (SIR) Light ON, Diagnostic Trouble Codes (Inspect/Replace IP Harness to Inflatable Restraint Module (Air Bag) Yellow 4-Way Connector C221 and/or C222) - (Jun 2, 2008)

Released 5/22/2008
08-06-04-032: Information on Diesel Fuel Requirements - Service Engine Soon (SES) Indicator ON, Loss of Power, Filter Life Percentage Low as a Result of Fuel Filter Plugged/Incorrect Fuel Grade - (May 22, 2008)

Released 5/1/2008
PIP4403: Control Module Ignition On Timer Performance DTC P2610 - keywords 6.6 cal calibration ECM engine LBZ LLY MIL replace replacement - (May 1, 2008)

Released 4/30/2008
06-00-89-050B: Diagnostic Trouble Codes (DTCs) Required on Repair Orders - (Apr 30, 2008)

Released 4/21/2008
08-00-89-015: GM Training: April 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Apr 21, 2008)

Released 3/6/2008
08-06-04-016: Diagnostic Information on MIL/SES with DTC P0171 (Fuel Trim System Lean Bank 1) and/or P0174 (Fuel Trim System Lean Bank 2) After Brake Master Cylinder Replacement - (Mar 6, 2008)

Released 2/19/2008
08-00-89-006: GM Training: February 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Feb 19, 2008)

Released 2/6/2008
05-00-89-078B: GM Fuel System Treatment PLUS, Fuel Sending Unit Corrosion and Fuel System Deposits - (Feb 6, 2008)

Released 2/5/2008
06-06-04-035A: Use of E85 Fuels in Vehicles Not Certified by GM as being FlexFuel Compatible/Aftermarket Conversion of Vehicles to Operate on E85 Fuels - (Feb 5, 2008)

Released 12/17/2007
07-00-89-062: GM Training: December 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Dec 17, 2007)

Released 12/10/2007
03-06-04-030F: Various Driveability Symptoms Due to Clogged Fuel Injectors, MIL/SES DTCs P0171, P0172, P0174, P0300, P1174, P1175 (Clean Fuel Injectors and/or Perform Injector Test With AFIT - CH-47976) - (Dec 10, 2007)

Released 11/13/2007
07-00-89-056: GM Training: November 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Nov 13, 2007)

Released 8/17/2007
07-00-89-039: GM Training: August 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Aug 17, 2007)

Released 7/30/2007
05-06-04-035C: Usage of E85 Fuels in GM Vehicles - (Jul 30, 2007)

Released 7/25/2007
06-06-04-010E: Information on 3.5L (VIN K - RPO LZE), 3.9L (VIN W - RPO LGD) and 5.3L (VINS Z, 0, 3 - RPOs L59, LMG, LC9) E85 Fuel Compatible Vehicles - Alcohol Content, Switching Between Gasoline and E85 Fuel - (Jul 25, 2007)

Released 6/26/2007
07-00-89-025: GM Training: April 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Jun 26, 2007)

Released 6/26/2007
07-00-89-011: GM Training: Course Information (For U.S. Dealers and Aftermarket) - (Jun 26, 2007)

Released 6/21/2007
00-06-01-026B: Intake Manifold Inspection/Replacement After Severe Internal Engine Damage - (Jun 21, 2007)

Released 3/23/2007
06-06-04-005A: Malfunction Indicator Lamp (MIL) On, Lean and/or Rich Fuel System DTC(s) P0171, P0172, P0174, P0175 Set on E85 Flexible Fuel 5.3L VIN Z - RPO L59 Engine (Reprogram PCM) - (Mar 23, 2007)

Released 3/22/2007
06-01-39-011A: HVAC Whistle Noise/Blower Motor Stalls or Vibrates (Reattach Adhesive Foam to Recirculation Door/Air Inlet Valve) - (Mar 22, 2007)

Released 2/20/2007
03-06-04-017D: Information on Diesel Fuel Additives - (Feb 20, 2007)

Released 2/1/2007
04-07-30-013B: Info - Automatic Transmission Shift, Engine Driveability Concerns or Service Engine Soon (SES) Light On as a Result of the Use of an Excessively/Over-Oiled Aftermarket, Reusable Air Filter - (Feb 1, 2007)

Released 1/24/2007
06-00-89-051A: KeyCode Security Rules and Information on GM KeyCode Look-Up Application - (Jan 24, 2007)

Released 11/6/2006
06-06-04-060: SMU - Discontinue Use of Sealer on Fuel Injection Line Fittings - (Nov 6, 2006)

Released 10/24/2006
06-06-04-057: Warranty Admin. - Revised Mass Air Flow Core Return Requirements - (Oct 24, 2006)

Released 10/17/2006
03-06-04-036A: Information on Servicing Fuel Injectors to Avoid Contamination - (Oct 17, 2006)

Released 8/11/2006
06-06-04-041: Info on Utra Low Sulfur Diesel Fuel and Warning Labels on Fuel Station Pumps -This Info Applies to Diesel Engines w/RPOs LBZ, LB7, LH6, LLY, LMM, LL4, LQM, LQN, L49, L56, L57, L65, LG4, 1C3, 1C2, 1L5 - (Aug 11, 2006)

Released 8/4/2006
03-07-30-044C: Information on Allison Transmission Service Repairs - Full Service of Internal Components - (Aug 4, 2006)

Released 5/15/2006
06-06-04-030: Locations of E85 Refueling Stations and Expanded E85 Information - (May 15, 2006)

Released 5/4/2006
04-08-50-011A: Info - Repairing Napped Seat Fabric - (May 4, 2006)

Released 4/3/2006
05-08-64-002B: Door Latch Freezing in Cold Temperatures (Apply Super Lube) - (Apr 3, 2006)

Released 1/30/2006
06-06-04-006: Info - Elimination of Fuel Filler Tube Flapper Door - (Jan 30, 2006)

Released 1/4/2006
04-06-04-051B: Info - Maintenance Cleaning of Fuel Injectors - (Jan 4, 2006)

Released 11/2/2005
05-00-89-075: Warranty Admin. - Servicing Medium Duty Trucks, Including Conventional and Crew Cabs, Motorhome Cutaway Cab, Commercial Cutaway Cab (Ambulance, School Bus, Shuttle Bus), and Tilt Cabs - (Nov 2, 2005)

Released 10/17/2005
04-00-89-020B: Info - Pre-Delivery and Service Guide - Parallel Hybrid Truck (PHT) (RPO HP2) - (Oct 17, 2005)

Released 7/29/2005
#04-06-04-070A: Information on a Revised Fuel Filter for 6.6L LLY and LB7 Duramax Diesel Engine - (Jul 29, 2005)

Released 10/13/2011
Eliminating Unwanted Odors in Vehicles

Released 8/10/2011
Air Conditioning Odor (Install Evaporator Core Dryer Kit and Apply Cooling Coil Coating)

Released 7/22/2011
Car and Truck Fix it Right the First Time Issues

Released 12/23/2010
Information on Passenger Presence Sensing System (PPS or PSS) Concerns with Custom Upholstery, Accessory Seat Heaters or Other Comfort Enhancing Devices

Released 4/29/2010
Unnecessary Flushing Services, Additive Recommendations and Proper Utilization of GM Simplified Maintenance Schedule to Enhance Customer Service Experience

Released 3/4/2010
Car and Truck Fix It Right the First Time Issues

Released 2/25/2010
Repair Information for Reconnection of Rear Window Defroster Contact or Tab

Released 2/4/2010
Car and Truck Fix It Right the First Time Issues

Released 1/21/2010
Diagnostic Information to Accurately Diagnose A/C Low Pressure Switch Using Kent Moore Special Tool GE-47742

Released 6/12/2009
Air Conditioning Odor (Install Evaporator Core Dryer Kit and Apply Cooling Coil Coating)

Released 5/26/2009
Repair Information for Reconnection of Rear Window Defroster Contact or Tab

Released 5/11/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 5/6/2009
Car and Truck Fix It Right the First Time Issues

Released 3/20/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 10/6/2008
08-00-89-036: GM Training - GM STC Training Location Changes (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-033: GM Training - October 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-034: GM Training - Accessing Hands-On Checklists (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 9/29/2008
00-00-89-027E: Eliminating Unwanted Odors in Vehicles - (Sep 29, 2008)

Released 6/27/2008
07-00-89-047B: Technical Assistance Center (TAC) Coverage Available for Current and Last Nine Model Year Vehicles (U.S. Only) - (Jun 27, 2008)

Released 6/24/2008
03-00-89-003A: GM Goodwrench Limited Lifetime Service Guarantee - (Jun 24, 2008)

Released 5/12/2008
08-00-89-019: GM Training: May 2008 New Course Information (For U.S. Dealers and Aftermarket) - (May 12, 2008)

Released 4/30/2008
06-00-89-050B: Diagnostic Trouble Codes (DTCs) Required on Repair Orders - (Apr 30, 2008)

Released 4/21/2008
08-00-89-015: GM Training: April 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Apr 21, 2008)

Released 1/25/2008
08-01-38-001: Information on New GE-48800 CoolTech Refrigerant Recovery/Recharge Equipment - (Jan 25, 2008)

Released 1/23/2008
05-01-38-008B: 18 Digit Snapshot/Charge Summary Code No Longer Required for A/C Refrigerant System repairs Submitted for Warranty Reimbursement - (Jan 23, 2008)

Released 1/18/2008
06-01-39-002C: Blower Motor Inoperative or May Not Shut Off in Extremely Low Ambient Temperature Conditions (Replace Blower Motor Control Module) - (Jan 18, 2008)

Released 12/17/2007
07-00-89-062: GM Training: December 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Dec 17, 2007)

Released 11/12/2007
06-00-89-026A: Customer Concern Not Duplicated/Verified Labor Operations - (Nov 12, 2007)

Released 11/5/2007
02-01-39-007B: Automatic Dual Zone HVAC Battery Draw - (Nov 5, 2007)

Released 10/15/2007
07-00-89-052: GM Training: October 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Oct 15, 2007)

Released 9/11/2007
07-01-39-004A: EI07139 - HVAC Performance, A/C Not Cool, A/C Compressor Noise (Perform A/C System Diagnosis) - (Sep 11, 2007)

Released 8/23/2007
07-00-89-043: Warranty Admin. - Use of Parts and Components (Including Control Module Calibrations) Not Issued Through General Motors - (Aug 23, 2007)

Released 8/17/2007
07-00-89-039: GM Training: August 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Aug 17, 2007)

Released 6/27/2007
07-01-38-004: Information on GM ACR2000 (J-43600) and New Refrigerant Recovery Recharging Equipment SAE J2788 - (Jun 27, 2007)

Released 6/26/2007
07-00-89-011: GM Training: Course Information (For U.S. Dealers and Aftermarket) - (Jun 26, 2007)

Released 5/29/2007
99-01-39-004B: Air Conditioning Odor (Install Evaporator Core Dryer Kit and Apply Cooling Coil Coating) - (May 29, 2007)

Released 3/22/2007
06-01-39-011A: HVAC Whistle Noise/Blower Motor Stalls or Vibrates (Reattach Adhesive Foam to Recirculation Door/Air Inlet Valve) - (Mar 22, 2007)

Released 3/7/2007
05-06-01-018A: Accessory Drive Belt Chirp, Squeal or Squeak Type Noise at Cold Idle (Replace A/C Compressor/Power Steering Pump Mounting Bracket or Enlarge Bracket Bolt Holes) - (Mar 7, 2007)

Released 11/2/2006
05-01-38-012C: EI05082 - Loss of Blower Motor Speeds Except for Low Speed or Inoperative (Replace Blower Motor Resistor and Resistor Module Connector) keyword fan - (Nov 2, 2006)

Released 10/6/2006
06-01-39-005B: EI06052 - HVAC Not Cooling, A/C Not Cool (Perform A/C Performance Test Per SI) - (Oct 6, 2006)

Released 7/25/2006
06-01-39-007: Info - Contaminated R134a Refrigerant Found on Market for Automotive Air-Conditioning Systems - (Jul 25, 2006)

Released 6/26/2006
07-01-38-001: GM Training: HVAC Systems and Operation Stage 2 WBT and IDL (11044.03) (For U.S. Dealers Only) - (Jun 26, 2007)

Released 4/27/2006
06-01-38-003: Intermittent Ticking Noise from I/P, Poor A/C Performance, HVAC DTCs B0229, B0414, B0424, B3770, (Reprogram HVAC Control Module) - (Apr 27, 2006)

Released 4/27/2006
06-06-04-027: LBZ, LB7, LLY, Service Engine Soon (SES) Light Illuminated, DTC P0116, P0181 Set with Engine Coolant Heater Usage in Ambient Temps Above -18 Degrees C (0 Degrees F) (Replace Engine Coolant Heater Cord - (Apr 27, 2006)

Released 3/17/2006
06-01-38-002: A/C System Refrigerant Hiss Noise (Replace Liquid Line) - (Mar 17, 2006)

Released 3/17/2006
04-01-38-014A: ASI Resolution - High-Pitched Tone Heard Inside Vehicle When A/C Compressor is Engaged (Replace Compressor Discharge Hose Assembly) - (Mar 17, 2006)

Released 1/9/2006
03-08-44-018C: Rear Seat Audio (RSA) and/or Rear HVAC Inoperative (Replace RSA Module) - (Jan 9, 2006)

Released 11/16/2005
02-01-39-004B: Info - New PAG Oil Released - (Nov 16, 2005)

Released 11/2/2005
05-00-89-075: Warranty Admin. - Servicing Medium Duty Trucks, Including Conventional and Crew Cabs, Motorhome Cutaway Cab, Commercial Cutaway Cab (Ambulance, School Bus, Shuttle Bus), and Tilt Cabs - (Nov 2, 2005)

Released 12/19/2016
Information on Diesel Engine Ticking Noise

Released 11/16/2016
Information on Higher Than Expected Oil Consumption

Released 10/19/2016
Engine Oil Crankcase Sludge

Released 4/5/2016
Engine Knock on Cold Start

Released 12/15/2015
Supplement To Service Information For Duramax Diesel Head Gasket Replacement

Released 10/31/2015
Allison LCT1000 Clunk When Shifting Into Or Out Of Park or On Start Up In Park

Released 10/31/2015
Engine and Automatic Transmission/Transaxle Identification

Released 10/31/2015
Diesel Engine Hard Start When Hot

Released 8/1/2015
Information for Identifying Non-GM ECM Calibration Use and Power-up Hardware Detection in Duramax Diesel Engines - Photograph Tech 2 Calibration IDs, Calibration Verification Numbers (CVNs) and Transmission Data Screen

Released 6/1/2015
Higher Than Expected Oil Consumption at 8600 GVW and Above

Released 5/12/2015
Supplement To Service Information For Duramax Diesel Head Gasket Replacement

Released 5/12/2015
Information on Higher Than Expected Oil Consumption

Released 8/26/2014
Information on Identifying Duramax Diesel Overpower Engine Breakdown/Non-Function Due to Aftermarket Power-Up Devices vs Non Overpower Engine Non-Function of Pistons, Cylinders, Valvetrain Components, DTC P003A or P111D Set

Released 7/17/2014
Alleged Cylinders Out Of Round

Released 6/19/2014
Delayed Or No Drive And Or Delayed Or No Reverse With DTCs Range Inhibit

Released 5/14/2014
Catalytic Converter Break-In Information To Prevent DTCs P0420 And/Or P0430

Released 4/4/2014
Possible Engine Oil Leak Due To PCV Freeze-Up

Released 3/25/2014
Possible Engine Oil Leak Due To PCV Freeze-Up

Released 2/25/2014
Allison LCT1000 Clunk When Shifting Into Or Out Of Park Or On Start Up In Park

Released 8/5/2013
SES Light, Misfire, DTC P0300, And/or A Chirp, Squeak, Squeal, Or Tick Noise - Potential Valvetrain Concern

Released 6/24/2013
Catalytic Converter Break-In Information To Prevent DTCs P0420 And/Or P0430

Released 6/19/2013
Global Information for GM dexos 1 and dexos 2 Engine Oil Specifications, Licensed Brands, and Service Fill

Released 6/19/2013
Information on Slight Vehicle Movement in Park at Start Up After Cold Soak

Released 4/12/2013
Information on Driveline Clunk Noise

Released 3/22/2013
Vibration Analysis Worksheet

Released 3/22/2013
Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V6 and V8 Gasoline Engines Using Tech 2 or Global Diagnostic System 2 (GDS 2)

Released 3/22/2013
Aftermarket ALDL or DLC Interface Devices Causing Multiple Issues

Released 2/15/2013
Engine Surge Or Stall At Stop And Or DTC P0742 Possible TCC Applied

Released 2/8/2013
HYDRA-MATIC Front Wheel Drive 4T80-E (MH1) Left Front Axle Seal Leak, Transmission Slips in Gear (Replace Third Clutch Housing with Revised Service Part)

Released 2/1/2013
Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V6 and V8 Gasoline Engines Using Tech 2 or Global Diagnostic System 2 (GDS 2)

Released 1/1/2013
Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V8 Gasoline Engines Using Tech 2 or Global Diagnostic System 2 (GDS 2)

Released 9/4/2012
Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V8 Gasoline Engines Using Tech 2 or Global Diagnostic System 2 (GDS 2)

Released 9/4/2012
Information on Normal Maintenance or Warranty Service for 4T40, 4T45, 4T65, 4L60 Automatic Transmission Oil Pan Magnet Upgrade

Released 5/23/2012
Guidelines for Usage of Transmission K Labor Operation Recondition Add Time (Bulletin Canceled)

Released 3/27/2012
Information on Diesel Engine Ticking Noise

Released 3/5/2012
Warranty, SPS, Control Module Diagnostics and Configuration Information, Programming, Set-Up

Released 3/3/2012
Warranty, SPS, Control Module Diagnostics and Configuration Information, Programming, Set-Up

Released 10/24/2011
Use of Surface Conditioning Disks When Cleaning Engine Gasket Sealing Surfaces and/or Reused Engine Parts

Released 7/22/2011
Car and Truck Fix it Right the First Time Issues

Released 5/17/2011
Information on Slight Vehicle Movement in Park at Start Up After Cold Soak

Released 5/6/2011
Information on Driveline Clunk Noise when Shifting Between PARK and DRIVE, PARK and REVERSE or DRIVE and REVERSE

Released 4/29/2011
1-2 Shift Flare with an End Bump or Harsh 1-2 Shift at Light Throttle (Install New 1-2 Accumulator Valve Kit)

Released 4/28/2011
Information on Diesel Engine Ticking Noise

Released 4/13/2011
Fluid/Oil Leak During Cold Weather from Transmission Vent (Perform Repair as Outlined Below)

Released 4/7/2011
Release of DEXRON-VI Automatic Transmission Fluid (ATF)

Released 3/28/2011
4.8L, 6.0L Knock or Rattle Noise from Engine (Replace Flywheel / Flexplate)

Released 3/28/2011
Engine and Automatic Transmission/Transaxle Identification

Released 2/17/2011
4WD System Shift Performance in Cold Ambient Temperatures (Use Synthetic Fluid in Light Duty Front Axles with 8.5 Inch Ring Gears)

Released 2/7/2011
Fluid/Oil Leak During Cold Weather from Transmission Vent (Early Models-Replace Transmission Fluid Level Indicator and Install New Transmission Vent Assembly)

Released 2/7/2011
Identifying Non-GM ECM Calibration Usages for Duramax Diesel Engines and Power-up Hardware Detection

Released 1/24/2011
MIL Illuminated at Very Cold Temperatures When Using Engine Coolant Heater, DTC P0116 and/or P1400 Set (Relocate Engine Coolant Temperature (ECT) Sensor and Engine Coolant Heater Cord)

Released 12/15/2010
Manual Transmission Operating Characteristics

Released 11/18/2010
Information - Non-GM Parts and Accessories (Aftermarket)

Released 11/10/2010
WOT 4-5 Shift Flare or Tie Up with DTC P0733, P0777, P0735 or P2723 Stored, Intermittent Slip in Reverse (Inspect Seals, Replace Piston/Clutch Plates if Damaged)

Released 11/1/2010
Information on Water or Ethylene Glycol in Transmission Fluid

Released 9/14/2010
Car and Truck Fix It Right the First Time Issues

Released 9/9/2010
WOT 4-5 Shift Flare or Tie Up with DTC P0777 or P0735 Stored (Inspect Seals, Replace Piston/Clutch Plates if Damaged)

Released 8/6/2010
Information on Drilling High Strength Steel Related to Collision Repair

Released 7/23/2010
Information on Engine Ticking Noise

Released 7/23/2010
5.3L, 5.7L, 6.0L, 6.2L, 7.0L-Engine Oil Leak at Rear Cover Assembly Area (Engine Block Porosity RTV Repair Procedure)

Released 5/20/2010
Harsh 1-2 Shift at Light Throttle (Install New 1-2 Accumulator Valve Kit)

Released 5/12/2010
Warranty Administration - Change in Automatic Transmission Add Condition Documentation and Claim Submission

Released 5/7/2010
Identifying Aftermarket Engine and Transmission Calibrations-GasPowered Engines Only and Automatic Transmission

Released 4/29/2010
Unnecessary Flushing Services, Additive Recommendations and Proper Utilization of GM Simplified Maintenance Schedule to Enhance Customer Service Experience

Released 4/23/2010
Excessive Engine Oil Consumption (Verify Condition, Inspect Valve Stems, Replace Cylinder Heads, If Necessary)

Released 3/31/2010
Information on Identifying Duramax Diesel LB7, LLY, LMM, LBZ Overpower Engine Breakdown/Non-Function Due to Aftermarket Power-Up Devices vs Non Overpower Engine Non-Function of Pistons, Cylinders

Released 3/4/2010
Car and Truck Fix It Right the First Time Issues

Released 2/24/2010
Information on Identifying Duramax Diesel LB7, LLY, LMM, LBZ Overpower Engine Breakdown or Non-Function Due to Aftermarket Power-Up Devices vs Non-Overpower Engine Non-Function of Pistons, Cylinders

Released 2/23/2010
Current Model Year Goodwrench Transmission Replacement Assembly Program

Released 2/5/2010
Information on 2-3 Upshift or 3-2 Downshift Clunk Noise

Released 2/4/2010
Car and Truck Fix It Right the First Time Issues

Released 2/3/2010
Intake Manifold Inspection/Replacement After Severe Internal Engine Damage

Released 1/27/2010
Fluid/Oil Leak During Cold Weather from Transmission Vent (Early Models-Replace Transmission Fluid Level Indicator and Install new Transmission Vent Assembly)

Released 1/12/2010
Guidelines for Usage of Transmission K Labor Operation Recondition Add Time

Released 12/17/2009
Warranty Administration - Change in Automatic Transmission Add Condition Documentation and Claim Submission

Released 12/11/2009
Unnecessary Engine Crankcase and Subsystems Flushing Services, Additive Recommendations and Proper Utilization of GM Simplified Maintenance Schedule to Enhance Customer Service Experience

Released 12/10/2009
Excessive Engine Oil Consumption (Verify Condition, Inspect Valve Stems, Replace Cylinder Heads if Necessary)

Released 12/1/2009
Information on Water or Ethylene Glycol in Transmission Oil

Released 11/13/2009
Current Model Year Goodwrench Transmission Replacement Assembly Program

Released 11/12/2009
5.3L, 5.7L, 6.0L, 6.2L, 7.0L - Engine Oil Leak at Rear Cover Assembly Area (Engine Block Porosity RTV Repair Procedure)

Released 11/9/2009
Identifying Non-GM ECM Calibration Usages and Power-Up Hardware Detection for Duramax Diesel Engines-Photograph Tech 2 Calibration IDs and CVNs and Trans Data Screen Before Removing Engine/Trans

Released 11/6/2009
Harsh 1-2 Shift at Light Throttle (Install New 1-2 Accumulator Valve Kit)

Released 11/4/2009
Car and Truck Fix It Right the First Time Issues

Released 11/3/2009
Excessive Engine Oil Consumption (Verify Condition, Inspect Valve Stems, Replace Cylinder Heads if Necessary)

Released 11/2/2009
Information on Driveline Clunk Noise When Shifting Between PARK and DRIVE, PARK and REVERSE or DRIVE and REVERSE

Released 10/30/2009
Information on 6.6L LBZ, LB7, LLY Duramax Diesel Engine Cylinder Head Gasket Design Change-New Head Gasket Part Numbers and Head Bolt Torque Specifications

Released 10/28/2009
Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V8 Gas Engines

Released 10/6/2009
Product Quality Center (PQC) for Engine, Transmission Assembly and Transfer Case Replacement

Released 10/1/2009
Engine and Automatic Transmission/Transaxle Identification

Released 9/16/2009
4WD System Shift Performance in Cold Ambient Temperatures (Use Synthetic Fluid in Light Duty Front Axles with 8.5 Inch Ring Gears)

Released 9/14/2009
Info on Identifying Duramax Diesel LB7, LLY, LMM, LBZ Overpower Engine Breakdown or Non-Function Due to Aftermarket Power-Up Devices vs Non-Overpower Engine Non-Function of Pistons, Cylinders, Valve

Released 9/9/2009
Automatic Transmission Oil Cooler Flush and Flow Test Essential Tool J 45096 TransFlow

Released 7/29/2009
Manual Transmission Operating Characteristics

Released 7/27/2009
Information on Internal Engine Noise or Damage After Oil Filter Replacement

Released 7/22/2009
Guidelines for Usage of Transmission K Labor Operation Recondition Add Time

Released 6/15/2009
GM Training - June 2009 New Course Information (For U.S. Dealers and Aftermarket)

Released 5/18/2009
Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V8 Gas Engines

Released 5/11/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 5/6/2009
Car and Truck Fix It Right the First Time Issues

Released 5/5/2009
Information on Normal Maintenance or Warranty Service for 4T40, 4T45, 4T65, 4L60 Automatic Transmission Oil Pan Magnet Upgrade

Released 5/5/2009
Engine Oil Leaks from Charge Air Cooler and Turbocharger Air Inlet Adapter (Replace Clamp and/or Turbo Inlet Duct/Pipe)

Released 5/1/2009
Vibration Analysis Worksheet

Released 4/28/2009
Whine or Click Type Noises from Front Axle/New Design Front Axle Side Bearing Adjusters (Inspect/Replace with New Lock Rings)

Released 4/24/2009
Information on Engine Ticking Noise

Released 4/1/2009
Rear Axle Fluid Level May Appear to be Lower Than Published Specification

Released 3/25/2009
LM4, LM7, L59, LR4, LQ9, LQ4, LY6 Throttle Actuator Control (TAC) Module Codes, MIL/SES DTCs P2108, P1516, U0107, Reduced Engine Power (Reprogram PCM)

Released 3/20/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 3/18/2009
Transmission Oil Cooler Line Leak (Replace Affected Cooler Line)

Released 3/9/2009
Car and Truck Fix It Right the First Time Issues

Released 3/2/2009
Wheel Hub Changes - Gen III vs. Gen II

Released 2/18/2009
4.8L, 6.0L Knock or Rattle Noise form Engine (Replace Flywheel/Flexplate)

Released 2/6/2009
GM Training - February 2009 New Course Information (For U.S. Dealers and Aftermarket)

Released 1/29/2009
Diagnostic Tips for Automatic Transmission DTC P0756, Second, Third, Fourth Gear Start

Released 1/22/2009
Excessive Engine Oil Consumption (Verify Condition, Inspect Valve Stems, Replace Cylinder Heads if Necessary)

Released 1/13/2009
Information on Engine Oil Consumption Guidelines

Released 1/12/2009
GM Training - January 2009 New Course Information (For U.S. Dealers and Aftermarket)

Released 1/12/2009
Information on Higher Than Expected Oil Consumption

Released 1/9/2009
Information on Engine Ticking Noise

Released 1/8/2009
Preventing Damage on Dealer Lots During Longer Periods in Dealer Inventory and Maintaining High CSI Scores

Released 12/18/2008
Identifying Aftermarket Engine and Transmission Calibrations 2.0L, 2.2L, 2.4L, 2.8L, 2.9L, 3.0L, 3.1L, 3.2L, 3.4L 3.5L, 3.6L, 3.8L, 3.9L, 4.2L, 4.3L, 4.4L, 4.6L, 5.0L, 5.3L, 5.7L 6.0L, 6.2L 7.0L, 7.4L

Released 12/17/2008
Higher Than Expected Oil Consumption at 8600 GVW and Above

Released 11/26/2008
GM Training - December 2008 New Course Information (For U.S. Dealers and Aftermarket)

Released 11/25/2008
Information on 4T65-E MN7, M15, M76, MN3 Automatic Transmission Case, Cooler Fitting and Torque Converter Drain Back Check Ball Change

Released 11/25/2008
All Vortec GEN IV V8 Engines-LY2, LS4, LC9, LH6, LMG, LY5, LS2, L76, LY6, L92, LS7, Low Oil Level Indicator Lamp On and/or Engine Oil Leak (Reseal Oil Pressure Sensor)

Released 11/24/2008
Information on Difficult to Remove 8.25 and 9.25 Left Front Axle Shaft - Center C-Clip

Released 11/6/2008
GM Training - November 2008 New Course Information (For U.S. Dealers and Aftermarket)

Released 10/16/2008
06-06-01-007C: Identifying Duramax DIesel LB7, LLY, LMM, LBZ Overpower Engine Breakdown or Non-Function Due to Aftermarket Power-Up Devices vs. Non-Overpower Engine Non-Function of Pistons, Cylinders, Valvetrain Com - (Oct 16, 2008)

Released 10/9/2008
03-06-93-001D: Diagnostic Information on Turbocharger Malfunction Due to Lack of Engine Oil for LBZ, LB7, LLY and LMM Duramax Diesel Engine - (Oct 9, 2008)

Released 10/6/2008
08-00-89-036: GM Training - GM STC Training Location Changes (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-033: GM Training - October 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-034: GM Training - Accessing Hands-On Checklists (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/1/2008
08-06-04-029A: LBZ, LLY, LMM MIL/SES Light On DTC P0087 - Fuel Rail Pressure (FRP) Too Low, Lack of Performance, No Power, Engine Runs Rough, No Start (Diagnose Fuel System Components) - (Oct 1, 2008)

Released 9/29/2008
02-07-30-029L: Product Quality Center (PQC) for Engine, Transmission Assembly and Transfer Case Replacement - (Sep 29, 2008)

Released 9/29/2008
01-07-30-032E: Transmission Oil Leaking From Transmission Vent (Replace Transmission Case Cover (Channel Plate) Gasket) - (Sep 29, 2008)

Released 9/25/2008
06-06-04-042A: LR4, LY2, L33, LH6, LM7, L59, LC9, LMG, LY5, LS2, LQ9, LQ4, L76, LY6 Throttle Actuator Control (TAC) Module Codes, MIL/SES DTCs P2108 P1516, U0107, Reduced Engine Power (Reprogram PCM) - (Sep 25, 2006)

Released 9/16/2008
04-07-30-017A: Information on 4T65-E MN7, M15, M76, MN3 Automatic Transmission Case, Cooler Fitting and Torque Converter Drain Back Check Ball Change - (Sep 16, 2008)

Released 9/4/2008
05-06-01-034F: 5.3L LC9, LS4, L33, LH6, LM4, 5.7L LS1, LS6, 6.0L LS2, L76 6.2L L92, 7.0L LS7 - Engine Oil Leak at Rear Cover Assembly Area (Engine Block Porosity RTV Repair Procedure) - (Sep 4, 2008)

Released 8/26/2008
08-06-04-033B: Identifying Aftermarket Engine and Transmission Calibrations Gas Powered Engines Only and Automatic Transmissions - (Aug 26, 2008)

Released 8/21/2008
06-08-47-001E: Warranty, SPS, Control Module Diagnostics and Configuration Information, Programming, Set-Up - (Aug 21, 2008)

Released 8/18/2008
02-06-01-022H: Information on Engine Ticking Noise - (Aug 18, 2008)

Released 8/8/2008
08-07-30-035: Information on Water or Ethylene Glycol in Transmission Oil - (Aug 8, 2008)

Released 8/6/2008
05-06-04-022E: TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - Canada ONLY - (Aug 6, 2008)

Released 7/31/2008
06-06-04-066C: LBZ, LLY Engine MIL/SES Light On With DTC P0403 Set (Check/Reprogram ECM and Perform EGR Valve Motor Cleaning Procedure) - (Jul 31, 2008)

Released 7/21/2008
07-06-03-009A: Information on Voltmeter Gauge Fluctuation Due to Regulated Voltage Control System and Concerns About Camper/Trailer Battery Charging - (Jul 21, 2008)

Released 7/18/2008
07-06-01-007B: Excessive Engine Oil Consumption (Verify Condition, Inspect Valve Stems, Replace Cylinder Heads, If Necessary) - (Jul 18, 2008)

Released 6/27/2008
07-00-89-047B: Technical Assistance Center (TAC) Coverage Available for Current and Last Nine Model Year Vehicles (U.S. Only) - (Jun 27, 2008)

Released 6/27/2008
08-06-04-006B: Information on Identifying Non-GM Calibration Usages for LMM Duramax Diesel Engine - (Jun 27, 2008)

Released 6/24/2008
04-06-04-047H: TOP TIER Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only - (Jun 24, 2008)

Released 6/24/2008
03-00-89-003A: GM Goodwrench Limited Lifetime Service Guarantee - (Jun 24, 2008)

Released 6/17/2008
05-00-89-072B: Fuel and Oil Additives - Facts and Myths/Maximizing Fuel Economy - (Jun 17, 2008)

Released 6/10/2008
08-00-89-021: Servicing Medium Duty Trucks, Including Conventional and Crew Cabs, Motorhome Cutaway Cab, Commercial Cutaway Cab (Ambulance, School Bus, Shuttle Bus) and Tilt Cabs - (Jun 10, School Bus, Shuttle Bus) and Tilt Cabs - (Jun 10, 2008)

Released 6/6/2008
99-04-20-002E: Information on Driveline Clunk Noise When Shifting Between PARK and DRIVE, PARK and REVERSE or DRIVE and REVERSE - (Jun 6, 2008)

Released 6/4/2008
08-07-30-027: No Movement When Transmission is Shifted to Drive or Third - Normal Operation When Shifted to Second, First or Reverse (Replace Forward Sprag Assembly) - (Jun 4, 2008)

Released 6/3/2008
08-07-30-008B: Diagnostic Information on Diagnostic Trouble Code (DTC) P0894 and P1870 - (Jun 3, 2008)

Released 5/22/2008
08-06-04-032: Information on Diesel Fuel Requirements - Service Engine Soon (SES) Indicator ON, Loss of Power, Filter Life Percentage Low as a Result of Fuel Filter Plugged/Incorrect Fuel Grade - (May 22, 2008)

Released 5/22/2008
08-07-30-026: Information on Slight Vehicle Movement in Park at Start Up After Cold Soak - (May 22, 2008)

Released 5/12/2008
01-07-30-010C: Automatic Transmission/Transaxle Torque Converter Replacement - (May 12, 2008)

Released 5/12/2008
08-00-89-019: GM Training: May 2008 New Course Information (For U.S. Dealers and Aftermarket) - (May 12, 2008)

Released 5/12/2008
01-07-30-036G: Diagnostic Tips for Automatic Transmission DTC P0756, Second, Third, Fourth Gear Start - (May 12, 2008)

Released 5/5/2008
03-07-30-007E: Engagement Time of Electronically Controlled Transmissions in General Motors Vehicles (Garage Shifts, Park to Reverse, Neutral to Drive, Neutral to Reverse, Park to Drive, Delayed Engagement) - (May 5, 2008)

Released 5/2/2008
03-07-29-004E: Manual Transmission Operating Characteristics - (May 2, 2008)

Released 5/1/2008
99-07-30-030F: Grinding and/or Growling Noise in Park on Incline - (May 1, 2008)

Released 5/1/2008
PIP4403: Control Module Ignition On Timer Performance DTC P2610 - keywords 6.6 cal calibration ECM engine LBZ LLY MIL replace replacement - (May 1, 2008)

Released 4/30/2008
06-00-89-050B: Diagnostic Trouble Codes (DTCs) Required on Repair Orders - (Apr 30, 2008)

Released 4/29/2008
07-08-49-015C: Information On Instrument Panel Cluster (IPC) Odometer and Engine Hour Meter Set Up at Dealership After IPC Replacement - (Apr 29, 2008)

Released 4/28/2008
07-00-89-031A: Warranty System Changes - Medium Duty Trucks - (Apr 28, 2008)

Released 4/21/2008
08-00-89-015: GM Training: April 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Apr 21, 2008)

Released 4/16/2008
02-06-04-037D: DTC P0446 (Restricted/Blocked Evap Vent Path) Set, Check Engine Light On (Replace Evaporative Emission (EVAP) Vent Valve Solenoid Assembly and Add/Relocate Filter Box Using Service Kit) - (Apr 16, 2008)

Released 4/15/2008
08-07-30-016A: Diagnostic Information on MH1, MN8, MT1, M15 Transmission Slips, Will Not Shift or May Overheat, SES/MIL May Be Illuminated, DTCs P0218, P0894 Set - (Apr 15, 2008)

Released 4/15/2008
05-04-21-003C: Service 4WD Light Illuminated, DTC C0374 Set (Inspect Wiring Harness to Transfer Case Speed Sensors, Replace Wiring Harness) - (Apr 15, 2008)

Released 4/14/2008
00-06-01-012C: Use of Surface Conditioning Disks When Cleaning Engine Gasket Sealing Surfaces and/or Reused Engine Parts - (Apr 14, 2008)

Released 4/2/2008
06-06-01-006B: Information on 6.6L LBZ, LB7, LLY Duramax Diesel Engine Cylinder Head Gasket Design Change - New Head Gasket Part Numbers and Head Bolt Torque Specifications - (Apr 2, 2008)

Released 3/27/2008
08-03-08-003: Wheel Hub Changes - Gen III vs. Gen II - (Mar 27, 2008)

Released 3/27/2008
08-07-30-015: Diagnostic Information on MN8, MT1 SES/MIL Illuminated, DTC P0757, Harsh Shift, Delayed 2-3 Shift, 2-3 Shift Flare, No Third Gear, Slips in Third Gear or Reverse - (Mar 27, 2008)

Released 2/27/2008
08-07-30-010: 4L60E Automatic Transmission (RPO M30) - Shudder or Slip in Reverse Under Hard Acceleration (Reprogram PCM) - (Feb 27, 2008)

Released 2/22/2008
02-07-30-052E: Automatic Transmission Oil Cooler Flush and Flow Test Essential Tool J 45096 TransFlow - (Feb 22, 2008)

Released 2/5/2008
04-06-01-029B: Unnecessary Engine Crankcase and Subsystems Flushing Services, Additive Recommendations and Proper Utilization of GM Simplified Maintenance Schedule to Enhance Customer Service Experience - (Feb 5, 2008)

Released 2/4/2008
06-06-01-010A: Info on Close-Coupled Converter, Engine Breakdown or Non-Function Due to Severe Overheat/Lack of Oil Causing Pistons, Rods, Crankshaft, Cylinders/Heads, Camshaft, Intake/Exhaust Valves, Bearing Damage - (Feb 4, 2008)

Released 2/4/2008
01-04-18-001F: Driveline Characteristics for All-Wheel Drive (AWD) and Four-Wheel Drive (4WD) Systems - (Feb 4, 2008)

Released 1/31/2008
08-07-30-004: 4L60-E, 4L65-E, 4L70-E HYDRAMATIC Automatic Transmission RPOs M30, M70, M32, M33, MK2, MD6 Oil Cooler Fitting Change - (Jan 31, 2008)

Released 1/17/2008
04-00-89-053B: Engineering Information (EI) Process - (Jan 17, 2008)

Released 1/17/2008
08-00-89-003: GM Training: January 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Jan 17, 2008)

Released 1/16/2008
08-07-30-001: 4L80E, MT1 and 4L85E, MN8 Simplified Valve Body Reconditioning Instructions, DTC P0741, P0742, P0751, P0752, P0756, P0757, P0894, Harsh or Delayed Shifts, Slips, No Drive, No Reverse - (Jan 16, 2008)

Released 1/10/2008
08-06-04-003: New Tool Availability - EN-48974 - EGR Cooler Pressure Tester Adapter Set to Diagnose Duramax Diesel Engine EGR Cooler Leaks into Combustion Chamber - (Jan 10, 2008)

Released 12/17/2007
07-00-89-062: GM Training: December 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Dec 17, 2007)

Released 12/10/2007
03-06-04-030F: Various Driveability Symptoms Due to Clogged Fuel Injectors, MIL/SES DTCs P0171, P0172, P0174, P0300, P1174, P1175 (Clean Fuel Injectors and/or Perform Injector Test With AFIT - CH-47976) - (Dec 10, 2007)

Released 12/5/2007
07-06-01-023: 60 Degree V6 Engine Oil Leak at Crankshaft Front Oil Seal (Use New Crankshaft Front Oil Seal Installer Tool EN-48869) - (Dec 5, 2007)

Released 11/21/2007
04-07-30-037D: Release of DEXRON-VI Automatic Transmission Fluid (ATF) - (Nov 21, 2007)

Released 11/13/2007
07-00-89-056: GM Training: November 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Nov 13, 2007)

Released 11/12/2007
06-00-89-026A: Customer Concern Not Duplicated/Verified Labor Operations - (Nov 12, 2007)

Released 10/22/2007
06-06-04-063C: 6.6L Duramax LBZ, LLY, LMM Diesel Engine EGR Valve Motor is Now Serviceable Separately from EGR Valve Assembly - (Oct 22, 2007)

Released 10/15/2007
07-00-89-052: GM Training: October 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Oct 15, 2007)

Released 10/2/2007
05-06-01-019F: Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal Using Revised Rear Main Seal Installer and Remover Tools) - (Oct 2, 2007)

Released 9/28/2007
05-06-01-010B: Service Information Update on Consolidating Use of GM Liquid Gasket/Engine Sealants and New Sealant Dispenser GE-48326 Essential Tool - (Sep 28, 2007)

Released 9/27/2007
07-07-30-024: Information on 4L60-E M30 Rear Wheel Drive Automatic Transmission Valve Body Reconditioning, DTC P0741, P0756, P0894, Harsh 1-2 Shift - (Sep 27, 2007)

Released 9/17/2007
07-06-01-016A: Information on Internal Engine Noise or Damage After Oil Filter Replacement - (Sep 17, 2007)

Released 8/27/2007
07-08-44-017: Radio with Six Disc CD Changer Does Not Recognize Loaded CD/Displays An INITIALIZING Message, CD Will Not Play, CD Cannot Be Ejected or Disc Icon Does Not Illuminate (Reprogram Radio) - (Aug 27, 2007)

Released 8/23/2007
07-00-89-043: Warranty Admin. - Use of Parts and Components (Including Control Module Calibrations) Not Issued Through General Motors - (Aug 23, 2007)

Released 8/17/2007
07-00-89-039: GM Training: August 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Aug 17, 2007)

Released 8/13/2007
01-08-49-017A: Center Front Floor Console Compartment Lock Cylinder and Key Replacement - (Aug 13, 2007)

Released 8/6/2007
07-07-30-020: Guidelines for Usage of Transmission K Labor Operation Recondition Add Time - (Aug 6, 2007)

Released 7/30/2007
05-06-04-035C: Usage of E85 Fuels in GM Vehicles - (Jul 30, 2007)

Released 7/25/2007
07-00-89-033: GM Training - June 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Jul 25, 2007)

Released 6/27/2007
07-00-89-028: GM Training: May 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Jun 27, 2007)

Released 6/22/2007
99-08-64-016B: Use of Silicone for Weatherstrip Maintenance - (Jun 22, 2007)

Released 6/21/2007
00-06-01-026B: Intake Manifold Inspection/Replacement After Severe Internal Engine Damage - (Jun 21, 2007)

Released 6/5/2007
04-06-01-019A: GM Performance Parts Engine Warranty Q and A - (Jun 5, 2007)

Released 5/21/2007
01-07-30-042E: Information on 2-3 Upshift or 3-2 Downshift Clunk Noise - (May 21, 2007)

Released 5/3/2007
07-07-30-010: Procedure to Take Snapshot Data with a Tech 2 and Upload Data to Computer Using TIS Software - (May 3, 2007)

Released 5/2/2007
07-07-30-009: Unable to Complete Programming of Any Module Due to SPS Error Message - (May 2, 2007)

Released 5/1/2007
07-07-30-008: 4L60-E/4L65-E/4L70-E Automatic Transmission Product Update - (May 1, 2007)

Released 4/3/2007
01-06-01-011D: Information on Engine Oil Consumption Guidelines - (Apr 3, 2007)

Released 3/30/2007
02-08-42-004A: Info - PRNDL Display Reduced Visibility for Approximately One Minute - (Mar 30, 2007)

Released 3/23/2007
06-06-04-005A: Malfunction Indicator Lamp (MIL) On, Lean and/or Rich Fuel System DTC(s) P0171, P0172, P0174, P0175 Set on E85 Flexible Fuel 5.3L VIN Z - RPO L59 Engine (Reprogram PCM) - (Mar 23, 2007)

Released 3/16/2007
07-06-01-004: All Vortec GEN IV V8 Engines - LY2 LS4 LC9 LH6 LMG LY5 LS2 L76 LY6 L92 LS7, Low Oil Level Indicator Lamp On and/or Engine Oil Leak (Reseal Oil Pressure Sensor) - (Mar 16, 200)

Released 3/7/2007
07-06-01-003: LBZ LB7 LLY 6.6L Duramax Diesel Engine Accessory Drive Belt Chirp, Squeal or Squeak Type Noise at Cold Start Idle (Replace Accessory Drive Belt) - (Mar 7, 2007)

Released 3/5/2007
07-06-01-002: Information on Revised Connecting Rod Bolt Torque for Small Block GEN III and GEN IV Vortec V8 Engines - (Mar 5, 2007)

Released 2/20/2007
06-07-30-007A: Malfunction Indicator Lamp (MIL) On, Diagnostic Trouble Code (DTC) P0894, Harsh 1-2 Shift with 4L60-E, 4L65-E, 4L70-E Auto Transmission (Test/Replace TCC Enable Solenoid/Harness, Auto Trans Wiring) - (Feb 20, 2007)

Released 2/1/2007
04-07-30-013B: Info - Automatic Transmission Shift, Engine Driveability Concerns or Service Engine Soon (SES) Light On as a Result of the Use of an Excessively/Over-Oiled Aftermarket, Reusable Air Filter - (Feb 1, 2007)

Released 1/12/2007
06-04-17-002A: Rear Drive Axle Whine Noise (Replace Slip Yoke Assembly) - (Jan 12, 2007)

Released 1/11/2007
04-06-04-054A: Info - Non-GM Parts and Accessories (Aftermarket) - (Jan 11, 2007)

Released 12/6/2006
06-07-30-032: New Calibration Info for Allison MW7 6-Speed Automatic Transmission Overheat Condition in Cold Ambient Temperatures (Less Than -40C, -40F) on Vehicles w/Aftermarket Sump Heater, 6.6L Duramax Diesel - (Dec 6, 2006)

Released 11/28/2006
04-06-04-001C: LB7/LBZ/LLY/LMM - Intermittent Driveability Conditions-No Crank, Crank No Start, Hard to Start, MIL/SES, HEsitation, Lack of Power, Surge, Misfire, Fuel Knock, IPC Indicates No Oil Pressure, DTCs Set - (Nov 28, 2006)

Released 11/1/2006
01-07-31-002B: Info - Improved Bleeding Procedure for Hydraulic Clutch Release System - (Nov 1, 2006)

Released 10/24/2006
06-06-04-057: Warranty Admin. - Revised Mass Air Flow Core Return Requirements - (Oct 24, 2006)

Released 10/17/2006
03-06-04-036A: Information on Servicing Fuel Injectors to Avoid Contamination - (Oct 17, 2006)

Released 10/10/2006
00-07-30-009B: Info - Current Model Year Goodwrench Transmission Replacement Assembly Program - (Oct 10, 2006)

Released 9/12/2006
06-06-04-046: Information on Engine Misfire MIL/SES Light Illuminated or Flashing DTC P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307, P0308, P0420 or P0430 - (Sep 12, 2006)

Released 9/12/2006
01-07-30-038D: Diagnostic Trouble Code (DTC) P0757 Set, Malfunction Indicator Lamp (MIL) Illuminated, Poor Performance of Transmission/Slipping (Clean Transmission Valve Body and Case Oil Passages of Debris) - (Sep 12, 2006)

Released 8/16/2006
06-07-30-017A: 4L60-E, 4L65-E, 4L70-E, Automatic Transmission High Pitched Whine, Whistle, Chirp or Buzz Type Noise at 1,500-1,800 RPM (replace with Updated Torque Converter) - (Aug 16, 2006)

Released 8/15/2006
00-06-02-006D: Engine Coolant Recycling and Warranty Information - (Aug 15, 2006)

Released 8/11/2006
06-06-04-041: Info on Utra Low Sulfur Diesel Fuel and Warning Labels on Fuel Station Pumps -This Info Applies to Diesel Engines w/RPOs LBZ, LB7, LH6, LLY, LMM, LL4, LQM, LQN, L49, L56, L57, L65, LG4, 1C3, 1C2, 1L5 - (Aug 11, 2006)

Released 8/4/2006
03-07-30-044C: Information on Allison Transmission Service Repairs - Full Service of Internal Components - (Aug 4, 2006)

Released 8/4/2006
02-00-89-007A: Light and Medium Duty Truck Warranty and Crossline Warranty Eligibility and Guidelines for Chevrolet and GMC Dealers - (Aug 4, 2006)

Released 7/28/2006
00-00-89-008F: Info - Recreational (Dinghy) Towing - (Jul 28, 2006)

Released 7/18/2006
06-07-30-016: 4L60-E, 4L65-E Automatic Transmission Fluid Leak from Oil Pump or Bell Housing Area (Remove Burrs on Torque Converter Hub, Pump Drive Slots, Replace Torque Converter Hub-to-Oil Pump Seal Assem. (243)) - (Jul 18, 2006)

Released 6/12/2006
06-00-89-031: Info - Engine and Automatic Transmission/Transaxle Identification - (Jun 12, 2006)

Released 5/30/2006
06-07-30-013: Allison Transmission - Vehicle Shudder When Driving in 6th Gear Range (Reprogram Transmission Control Module (TCM)) - (May 30, 2006)

Released 5/26/2006
#05-00-90-005: SMU - Revised Maintenance and Lubrication for Automatic Transmission Service Interval/correct Filter to Replace - (May 26, 2005)

Released 5/25/2006
03-07-30-043A: Information Regarding Automatic Transmission Shift Lock Control Function - (May 25, 2006)

Released 5/17/2006
06-04-21-001: Info - Updated Transfer Case Connector Service Kit Now Available for Transfer Case Speed Sensor Wire Harness Connector that Comes Loose or Connector Retainer Clip Breaks - (May 17, 2006)

Released 4/27/2006
06-06-04-027: LBZ, LB7, LLY, Service Engine Soon (SES) Light Illuminated, DTC P0116, P0181 Set with Engine Coolant Heater Usage in Ambient Temps Above -18 Degrees C (0 Degrees F) (Replace Engine Coolant Heater Cord - (Apr 27, 2006)

Released 4/10/2006
06-06-01-009: SMU - LB7, LLY Diesel Engine Revised M12 Cylinder Head Bolt Fastener Tightening Specification - (Apr 10, 2006)

Released 3/7/2006
02-06-04-015A: Intermittent No Crank, No Start (Clean Battery Side Terminal Stripped Threads, Replace Battery Cable Bolt) - (Mar 7, 2006)

Released 2/17/2006
05-07-30-017B: 4L60-E/4L65-E/4L70-E Automatic Transmission/Torque Converter Clutch (TCC) Shudder, Water in Transmission (Repair Transmission and Seal Cowl Area) - (Feb 17, 2006)

Released 2/9/2006
06-07-30-006: Diagnostic Information for Front Wheel Drive Transaxle/Transmission Final Drive and/or Front Hub Bearing Hum and/or Grind Noise -(Feb 9, 2006)

Released 1/11/2006
05-07-30-018A: 1-2, 2-3, 3-4, 4-5 Shift and Torque Converter Clutch (TCC) Characteristics During Cold Weather Operation on 4L60-E, 4L65-E, 4L70-E, 4L80-E, 4L85-E, 5L40-E, 5L50-E, 6L50, 6L80, 6L90 or Allison Trans. - (Jan 11, 2007)

Released 12/22/2005
02-00-89-006C: Warranty Admin. - New Add Time for Labor Operation L2300 - Converter, Oxidation Catalytic-Replace - (Dec 22, 2005)

Released 12/12/2005
03-04-19-004B: Growl or Moan Noise coming from Front Axle (Replace Front Axle Differential Case) - (Dec 12, 2005)

Released 11/17/2005
05-00-90-009: Info - Vehicles Without Engine Oil Life System - (Nov 17, 2005)

Released 11/2/2005
05-00-89-075: Warranty Admin. - Servicing Medium Duty Trucks, Including Conventional and Crew Cabs, Motorhome Cutaway Cab, Commercial Cutaway Cab (Ambulance, School Bus, Shuttle Bus), and Tilt Cabs - (Nov 2, 2005)

Released 10/21/2005
05-06-04-067: Information on New Essential Tool EN-47909 Injector Bore Cleaning Kit for 6.6L Duramax Diesel Engine (RPOs LB7, LBZ, LLY) - (Oct 21, 2005)

Released 10/18/2005
01-07-30-030B: 4L60-E/4l65-E Automatic Transmission Diagnostic Information on Harsh 1-2 Upshift - (Oct 18, 2005)

Released 10/17/2005
04-00-89-020B: Info - Pre-Delivery and Service Guide - Parallel Hybrid Truck (PHT) (RPO HP2) - (Oct 17, 2005)

Released 10/7/2005
05-07-30-026: Info - New Product Announcement - 4L70-E (M70) Automatic Transmission - (Oct 7, 2005)

Released 10/6/2005
01-07-30-041B: Info - Transmission Fluid Leak Diagnosis - (Oct 6, 2005)

Released 9/26/2005
05-07-30-024: Info - Required Torque Specification When Using Special Tool J-47275 Transmission Control Module (TCM) Breakout Harness Adapter and/or Removal/Replacement of TCM - (Sep 26, 2005)

Released 9/23/2005
01-07-30-002E: MIL On, Transmission Stuck in Second or Third Gear, IPC Inoperative, DTCs P0740, P0753, P0758, P0785, P0787, P0973, P0976, P1860, P2761, P2764 and/or P2769 Set (Verify and Repair Source of Voltage Loss - (Sep 23, 2005)

Released 9/23/2005
05-06-04-060: Powertrain Control Module (PCM), Engine Control Module (ECM), Transmission Control Module (ECM), Transmission Control Module (TCM) DTCs P0601/P0602/P0603/P0604,/P1621 Shared in Multiple Modules - (Sep 23, 2005)

Released 9/16/2005
05-06-01-029: Information on 4.3L Engine Front Crankshaft Pulley Appearing to Be Out of Round (Normal Condition) - (Sep 16, 2005)

Released 8/2/2005
05-04-21-004: Info - Guidelines for Proper Use of Labor Operation Numbers when Servicing Transfer Case - (Aug 2, 2005)

Released 7/29/2005
#04-06-04-070A: Information on a Revised Fuel Filter for 6.6L LLY and LB7 Duramax Diesel Engine - (Jul 29, 2005)

Released 6/28/2005
04-08-48-001B: Info - Rear Window Defogger - Broken Heating Grid Detection Method - (Jun 28, 2005)

Released 5/17/2005
02-06-01-027A: Information on Higher Than Expected Oil Consumption - (May 17, 2005)

Released 10/4/2004
05-07-30-009A: Revised Essential Tool J-35944- 200-A Adapter For 9.525mm (0.375 in.) Automatic Transmission Oil Cooler Lines - (Oct 4, 2005)

Released 1/17/1997
Car and Truck Fix it Right the First Time Issues

Released 2/1/2017
Diagnostic Tip - Rattle Squeak Clunk Thump Bump Noise From Front Suspension

Released 7/19/2016
Squeak Noise from Rear of Vehicle (Lubricate Rear Leaf Springs)

Released 10/31/2015
Diagnostic Tips: Vehicle Body Tilt Or Lean

Released 6/27/2015
Squeak Noise from Rear of Vehicle (Lubricate Rear Leaf Springs)

Released 8/18/2014
Diagnostic Tip - Missing Alignment Dowel Pin

Released 2/6/2014
Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum Wheel Bead Seat Corrosion (Clean and Resurface Wheel Bead Seat)

Released 2/6/2014
Vibration Shortly After Tires are Mounted/Preventing Vibration from Wheel Slip (Tire Sliding on Wheel)

Released 2/6/2014
Information on Slight or Mild Tire Feathering and Recommended Practices (Normal Tire Wear Condition)

Released 1/4/2014
Proper Wheel Installation and Wheel Torque Techniques

Released 6/19/2013
Dealership Service Consultant Procedure as Vehicle Comes into Service Drive for Tire Pressure Monitor (TPM) System Message, Light and Customer Information

Released 3/22/2013
Vibration Analysis Worksheet

Released 3/22/2013
Aftermarket ALDL or DLC Interface Devices Causing Multiple Issues

Released 1/1/2013
Proper Wheel Installation and Wheel Torque Techniques

Released 5/17/2012
Information on Slight or Mild Tire Feathering and Recommended Practices (Normal Tire Wear Condition)

Released 5/3/2012
Information on Tire Radial Force Variation (RFV)

Released 3/27/2012
Hydraulic Power Steering System Leak - Required Diagnostic Actions

Released 12/3/2011
Information on Diagnosis and Replacement of Shock Absorber and Strut Due to Fluid Leak

Released 10/27/2011
Squeak Noise from Rear of Vehicle (Lubricate Rear Leaf Springs)

Released 7/22/2011
Car and Truck Fix it Right the First Time Issues

Released 6/28/2011
Rear Leaf Spring Slap or Clunk Noise (Replace Spring Inserts)

Released 4/21/2011
Chemical Staining, Pitting, Corrosion and/or Spotted Appearance of Chromed Aluminum Wheels

Released 3/28/2011
EI06002 - 670 Gear Box Power Steering Pump, P/S Performance Concerns

Released 3/17/2011
Refinishing Aluminum Wheels

Released 12/13/2010
Guidelines for Using Labor Operations E0200, E0201, E0203, E0204 - Wheel Balance

Released 12/9/2010
Wheel Alignment Specifications, Requirements and Recommendations for GM Vehicles

Released 11/11/2010
Squeak Noise from Rear of Vehicle (Lubricate Rear Leaf Springs)

Released 11/1/2010
Spare Tire is a Different Size than Other Tires

Released 10/13/2010
Information on Pitman Arm Shaft Seal Service Kit

Released 9/14/2010
Car and Truck Fix It Right the First Time Issues

Released 6/21/2010
Information on Pitman Arm Shaft Seal Service Kit

Released 6/9/2010
Information on Proper Wheel Changing Procedures and Cautions

Released 6/7/2010
Guidelines for Using Labor Operations E2020 - Wheel Alignments, E2000 - Toe Adjust and E0200, E0201, E0203, E0204 - Wheel Balance

Released 5/19/2010
Warranty Administration - Labor Operation Z1111 - Suspected Tampering or Vehicle Modifications

Released 5/4/2010
Information on Tire Radial Force Variation (RFV)

Released 4/29/2010
Unnecessary Flushing Services, Additive Recommendations and Proper Utilization of GM Simplified Maintenance Schedule to Enhance Customer Service Experience

Released 4/28/2010
New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores

Released 4/27/2010
Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant)

Released 4/27/2010
Use of Nitrogen Gas in Tires

Released 4/27/2010
Dealership Service Consultant Procedure as Vehicle Comes into Service Drive for Tire Pressure Monitor (TPM) System Message, Light and Customer Information

Released 4/27/2010
Tire Puncture Repair Procedures for All Cars and Light Duty Trucks

Released 4/27/2010
Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum Wheel Bead Seat Corrosion (Clean and Resurface Wheel Bead Seat)

Released 4/13/2010
Revised GM of Canada New Vehicle Limited Warranty Tire Program and Global Warranty Management (GWM) Submission Rollout Information

Released 3/29/2010
Revised General Motors New Vehicle Tire Warranty Program and Global Warranty Management (GWM) Submission Rollout Information (U.S. Dealers Only)

Released 3/15/2010
Chemical Staining, Pitting, Corrosion and/or Spotted Appearance of Chromed Aluminum Wheels

Released 3/4/2010
Car and Truck Fix It Right the First Time Issues

Released 2/4/2010
Car and Truck Fix It Right the First Time Issues

Released 1/14/2010
Refinishing Aluminum Wheels

Released 12/17/2009
Information on Replacement Wheel Weights

Released 12/4/2009
Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum Wheel Bead Seat Corrosion (Clean and Resurface Wheel Bead Seat)

Released 12/4/2009
Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant)

Released 12/2/2009
Release of Steering Gear Stub Shaft Bearing Kit for Service

Released 11/30/2009
GM of Canada New Vehicle Limited Warranty Tire Program

Released 11/4/2009
Car and Truck Fix It Right the First Time Issues

Released 11/4/2009
Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum Wheel Bead Seat Corrosion (Clean and Resurface Wheel Bead Seat)

Released 11/3/2009
Information on Tire Radial Force Variation (RFV)

Released 11/3/2009
Guidelines for Using Labor Operation E2020-Wheel Alignments, E2000-Toe Adjust and E0200, E0201, E0203, E0204-Wheel Balance

Released 10/30/2009
GM of Canada New Vehicle Limited Warranty Tire Program

Released 10/30/2009
Revised General Motors New Vehicle Tire Warranty Program

Released 10/16/2009
Information on Replacement of Shock Absorbers and Struts Due to Fluid Leaks

Released 10/8/2009
Statement on Tire Sealant Included in GM Inflator Kits (Supplied with New Vehicles or as GM Accessory)

Released 8/13/2009
Information on Slight or Mild Tire Feathering and Recommended Practices (Normal Tire Wear Condition)

Released 8/7/2009
Diagnostic Tips/Recommendations When Power Steering Pump Replacement Is Necessary

Released 8/5/2009
Information on Tire/Wheel Characteristics (Vibration, Balance, Shake, Flat Spotting) of GM Original Equipment Tires

Released 7/24/2009
Mounting, Balancing and Installation of Accessory Wheels and Tires Available Through GM Accessories

Released 7/22/2009
Inspection of Tire and Wheel Size Prior to Diagnosis of Transmission Shifts, Poor Performance, Speedometer, Cruise Control Concerns

Released 6/4/2009
Squeak Noise from Rear of Vehicle (Lubricate Rear Leaf Springs)

Released 6/2/2009
Rear Leaf Spring Slap or Clunk Noise (Replace Spring Inserts)

Released 5/26/2009
Release of Steering Gear Stub Shaft Bearing Kit for Service

Released 5/11/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 5/11/2009
Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant)

Released 5/4/2009
Dealership Service Consultant Procedure as Vehicle Comes Into Service Drive for Tire Pressure Monitor (TPM) System Message, Light and Customer Information

Released 4/16/2009
Guidelines for Using E2020-Wheel Alignments, E2000-Toe Adjust and E0200, E0201, E0203, E0204-Wheel Balance

Released 4/2/2009
GM Tire Warranty Program Goodwill Guidelines (U.S. Only)

Released 3/31/2009
Use of Chrome or Chrome Plated Steel Valve Caps on Aluminum Valve Stems

Released 3/26/2009
Tire Puncture Repair Procedures for All Cars and Light Duty Trucks

Released 3/17/2009
Release of Steering Gear Stub Shaft Bearing Kit for Service

Released 3/9/2009
Car and Truck Fix It Right the First Time Issues

Released 3/2/2009
Wheel Hub Changes - Gen III vs. Gen II

Released 1/28/2009
Information on Proper Tire Pressure

Released 1/22/2009
Use of Nitrogen Gas in Tires

Released 1/12/2009
Spare Tire is a Different Size Than Other Tires

Released 1/8/2009
Preventing Damage on Dealer Lots During Longer Periods in Dealer Inventory and Maintaining High CSI Scores

Released 11/26/2008
Information on Slight or Mild Tire Feathering and Recommended Practices (Normal Tire Wear Condition)

Released 11/26/2008
Information on Tire Radial Force Variation (RFV)

Released 11/24/2008
Information on Tire/Wheel Characteristics (Vibration, Balance, Shake, Flat Spotting) of GM Original Equipment Tires

Released 10/6/2008
08-00-89-036: GM Training - GM STC Training Location Changes (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-033: GM Training - October 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-034: GM Training - Accessing Hands-On Checklists (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 9/17/2008
08-03-10-012: GM Tire Warranty Program Claims Submission Changes (U.S. Only) - (Sep 17, 2008)

Released 9/11/2008
05-03-10-005D: Performance Characteristics of Vehicles with Accessory Wheel/Tire Assemblies Installed as Upsized to Original Equipment - (Sep 11, 2008)

Released 8/29/2008
07-03-10-016C: Requirements for Changing Tire and Wheel Assemblies - New Vehicle Placard (U.S. and Canada Only) - (Aug 29, 2008)

Released 8/28/2008
08-08-44-028: Information on Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies) - (Aug 28, 2008)

Released 7/25/2008
05-03-08-002B: Replacement of Shock Absorbers and Struts and Use of Labor Operations E3800, E3801, E3807, E5800, E5801, E5807, E3850, E3857, E5750, E5751 and E5757 - (Jul 25, 2008)

Released 6/27/2008
07-00-89-047B: Technical Assistance Center (TAC) Coverage Available for Current and Last Nine Model Year Vehicles (U.S. Only) - (Jun 27, 2008)

Released 6/27/2008
05-03-07-009B: Wheel Alignment Specifications, Requirements and Recommendations for GM Vehicles - (Jun 27, 2008)

Released 6/24/2008
03-00-89-003A: GM Goodwrench Limited Lifetime Service Guarantee - (Jun 24, 2008)

Released 6/11/2008
08-00-89-022: GM Training: June 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Jun 11, 2008)

Released 6/10/2008
08-00-89-021: Servicing Medium Duty Trucks, Including Conventional and Crew Cabs, Motorhome Cutaway Cab, Commercial Cutaway Cab (Ambulance, School Bus, Shuttle Bus) and Tilt Cabs - (Jun 10, School Bus, Shuttle Bus) and Tilt Cabs - (Jun 10, 2008)

Released 6/5/2008
07-08-64-022A: Information on Curb Park Assist and Memory Related Issues on Outside Rear View Mirrors - (Jun 5, 2008)

Released 5/16/2008
08-03-10-007: Minimizing Damage to Tire Pressure Monitor (TPM) Sensors During Tire Mounting/Dismounting - (May 16, 2008)

Released 5/12/2008
08-03-16-003: Warranty Reduction - Transfer of Tire Pressure Monitoring (TPM) Sensors to Replacement Wheels and Allowable TPM Sensor Replacements - (May 12, 2008)

Released 5/1/2008
08-03-10-005: Use of Chrome or Chrome-Plated Steel Valve Caps on Aluminum Valve Stems - (May 1, 2008)

Released 5/1/2008
08-03-10-006: Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum wheel Bead Seat Corrosion (Clean and Resurface Wheel Bead Seat) - (May 1, 2008)

Released 4/30/2008
06-00-89-050B: Diagnostic Trouble Codes (DTCs) Required on Repair Orders - (Apr 30, 2008)

Released 4/21/2008
08-00-89-015: GM Training: April 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Apr 21, 2008)

Released 4/7/2008
07-03-10-015A: General Motors New Vehicle Wheel Warranty Coverage - (Apr 7, 2008)

Released 3/27/2008
08-03-08-003: Wheel Hub Changes - Gen III vs. Gen II - (Mar 27, 2008)

Released 3/26/2008
00-02-35-003N: Clunking Noise Under Hood and Can Be Felt in Steering Wheel and/or Steering Column (Replace Upper Intermediate Steering Shaft (I-Shaft) Assembly) - (Mar 26, 2008)

Released 3/25/2008
08-03-10-004: Mounting, Balancing and Installation of Accessory Wheels and Tires Available Through GM Accessories - (Mar 25, 2008)

Released 2/7/2008
01-03-10-003E: GM of Canada New Vehicle Limited Warranty Tire Program - (Feb 7, 2008)

Released 2/5/2008
06-02-32-013A: Diagnostic Tips/Recommendations When Power Steering Pump Replacement is Necessary

Released 2/4/2008
01-04-18-001F: Driveline Characteristics for All-Wheel Drive (AWD) and Four-Wheel Drive (4WD) Systems - (Feb 4, 2008)

Released 2/1/2008
04-03-10-012B: Pitting and Brake Dust on Chrome Wheels - (Feb 1, 2008)

Released 1/17/2008
03-03-10-001D: Tire Slowly Goes Flat and/or Excessive Wheel Vibration Caused by Bead Splits (Replace Wheels with New Heavy Duty Rim Version) - (Jan 17, 2008)

Released 1/15/2008
05-03-10-003C: Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant) - (Jan 15, 2008)

Released 1/9/2008
00-03-10-006C: Information on Tire Radial Force Variation (RFV) - (Jan 9, 2008)

Released 1/7/2008
04-03-10-001D: Tire Puncture Repair Procedure for All Cars and Light Duty Trucks - (Jan 7, 2008)

Released 1/3/2008
05-03-10-020A: Use of Nitrogen Gas in Tires - (Jan 3, 2008)

Released 10/31/2007
06-03-09-004A: Squeak Noise From Rear of Vehicle (Lubricant Rear Leaf Springs) - (Oct 31, 2007)

Released 10/29/2007
00-03-10-003M: Revised General Motors New Vehicle Tire Warranty Program - (Oct 29, 2007)

Released 10/23/2007
00-00-90-002I: Information on Proper Tire Pressure - (Oct 23, 2007)

Released 9/21/2007
03-03-10-007C: Tire/Wheel Characteristics (Vibration, Balance, Shake, Flat Spotting) of GM Original Equipment Tires - (Sep 21, 2007)

Released 8/27/2007
03-08-61-002I: Snap/Popping Type Noise Coming From Front of Vehicle (Remove Bolt-In Front Crossmember and Add Washers) - (Aug 27, 2007)

Released 8/23/2007
07-00-89-043: Warranty Admin. - Use of Parts and Components (Including Control Module Calibrations) Not Issued Through General Motors - (Aug 23, 2007)

Released 8/17/2007
07-00-89-039: GM Training: August 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Aug 17, 2007)

Released 7/26/2007
04-02-32-001C: Release of Steering Gear Stub Shaft Bearing Kit for Service - (Jul 26, 2007)

Released 7/25/2007
07-00-89-033: GM Training - June 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Jul 25, 2007)

Released 7/23/2007
03-03-09-002B: Rear Leaf Spring Slap or Clunk Noise (Replace Spring Inserts) - (Jul 23, 2007)

Released 7/18/2007
05-02-32-008B: EI06002 - 670 Gear Box Power Steering Pump, P/S Performance Concerns - (Jul 18, 2007)

Released 6/26/2007
07-00-89-011: GM Training: Course Information (For U.S. Dealers and Aftermarket) - (Jun 26, 2007)

Released 4/17/2007
07-03-10-008: Information on Slight or Mild Tire Feathering and Recommended Practices (Normal Tire Wear Condition) - (Apr 17, 2007)

Released 3/7/2007
05-06-01-018A: Accessory Drive Belt Chirp, Squeal or Squeak Type Noise at Cold Idle (Replace A/C Compressor/Power Steering Pump Mounting Bracket or Enlarge Bracket Bolt Holes) - (Mar 7, 2007)

Released 1/12/2007
06-03-06-005A: Vehicle Lean - Left Front Sits Low or Right Rear High (Add Spacer Between Left Rear Spring Pack and Axle) - (Jan 12, 2007)

Released 1/4/2007
01-03-10-010F: Info - Inspection of Tire and Wheel Size Prior to Diagnosis of Transmission Shifts, Poor Performance, Speedometer, Cruise Control Concerns - (Jan 4, 2007)

Released 1/4/2007
01-03-10-012C: Info - Guidelines for Using E2020-Wheel Alignments, E2000-Toe Adjust and E0200, E0201, E0203, E0204-Wheel Balance - (Jan 4, 2007)

Released 9/27/2006
03-03-10-006F: Info - 20 Inch Wheels Available Through GM Accessories - (Sep 27, 2006)

Released 9/22/2006
03-00-89-006D: Info - New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores - (Sep 22, 2006)

Released 9/7/2006
06-03-10-010: Information on Proper Wheel Changing Procedures and Cautions - (Sep 7, 2006)

Released 8/28/2006
02-03-10-001C: Info - Spare Tire is a Different Size than Other Tires - (Aug 28, 2006)

Released 8/1/2006
00-03-10-002D: Info - Chemical Staining, Pitting, Corrosion and/or Spotted Appearance of Chromed Aluminum Wheels - (Aug 1, 2006)

Released 6/19/2006
99-08-51-007C: Info - Refinishing Aluminum Wheels - (Jun 19, 2006)

Released 5/16/2006
03-05-25-007C: Antilock Brake (ABS) Activation at Low Speeds (Clean Wheel Speed Sensor Mounting Surface) - (May 16, 2006)

Released 3/9/2006
06-03-08-002: SMU - Revised Upper Control Arm Replacement - (Mar 9, 2006)

Released 3/1/2006
06-03-10-004: Info - Proper Use of OEM Service Wheel Weights, Marring and/or Damage Due to Use of Non-OEM and/or Incorrect Wheel Weight Installation - (Mar 1, 2006)

Released 2/24/2006
06-03-10-003: Information on P245/75R16 Goodyear Wrangler ST Tire Usage/Identification - (Feb 24, 2006)

Released 2/9/2006
06-07-30-006: Diagnostic Information for Front Wheel Drive Transaxle/Transmission Final Drive and/or Front Hub Bearing Hum and/or Grind Noise -(Feb 9, 2006)

Released 1/27/2006
05-02-35-003B: EI05061 - Intermediate Steering Shaft Clunk Noise or Stick-Slip (Follow Strategy Based Diagnostics) - (Jan 27, 2006)

Released 11/2/2005
03-03-10-002B: Info - Use of Correct Installation Procedure for Loose Hubcap Assembly - (Nov 2, 2005)

Released 11/2/2005
05-00-89-075: Warranty Admin. - Servicing Medium Duty Trucks, Including Conventional and Crew Cabs, Motorhome Cutaway Cab, Commercial Cutaway Cab (Ambulance, School Bus, Shuttle Bus), and Tilt Cabs - (Nov 2, 2005)

Released 10/17/2005
04-00-89-020B: Info - Pre-Delivery and Service Guide - Parallel Hybrid Truck (PHT) (RPO HP2) - (Oct 17, 2005)

Released 9/16/2005
05-03-10-012: Info - Use Recommended Tire Mounting Lubricant to Prevent Tires from Slipping on Chrome Wheels - (Sep 16, 2005)

Released 1/27/2016
Light and Medium Duty Truck Warranty, Crossline Warranty Eligibility and Guidelines for Chevrolet/GMC Dealers

Released 1/21/2016
Light and Medium Duty Truck Warranty, Crossline Warranty Eligibility and Guidelines for Chevrolet/GMC Dealers

Released 12/5/2014
New Tool Availability - EN-48974 - EGR Cooler Pressure Tester Adapter Set to Diagnose Duramax Diesel Engine EGR Cooler Engine Coolant Leaks into Combustion Chamber

Released 12/5/2014
Information for Dealers on How to Submit a Product Information Report (PIR) (Canada Only)

Released 7/16/2014
Duramax Diesel Glow Plugs Difficult to Install Due to Carbon Buildup - New Glow Plug Bore Reamer Available

Released 5/22/2014
Warranty Code Generated By EL-50313 Midtronics GR8 Battery Tester/Charger Required for Claim Processing On Labor Operation 4041510, 4041520 and 250 Mile/400 Km Labor Operation Restriction (North America ONLY)

Released 2/6/2014
Information on Slight or Mild Tire Feathering and Recommended Practices (Normal Tire Wear Condition)

Released 6/7/2013
IPC Odometer Programming Method Quick Reference Guide

Released 3/22/2013
Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V6 and V8 Gasoline Engines Using Tech 2 or Global Diagnostic System 2 (GDS 2)

Released 3/1/2013
Paint-less Dent Repair Process

Released 1/1/2013
IPC Odometer Programming Method Quick Reference Guide

Released 3/19/2012
Hem Flange Rust Repair

Released 3/5/2012
Warranty, SPS, Control Module Diagnostics and Configuration Information, Programming, Set-Up

Released 1/13/2012
Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability

Released 10/24/2011
Use of Surface Conditioning Disks When Cleaning Engine Gasket Sealing Surfaces and/or Reused Engine Parts

Released 10/22/2011
Information for Dealers/Technicians on When and How to Submit a Field Product Report (FPR) (U.S. Dealers Only)

Released 10/22/2011
Warranty Code Generated By EL-50313 Midtronics GR8 Battery Tester/Charger Required for Claim Processing On Labor Operation 4041510 and Battery Part Restriction (North America ONLY)

Released 8/10/2011
Comeback Prevention Information and Using Customer Concern Verification Sheets (CCVS)

Released 7/22/2011
Clarification of Use - Dealer Empowerment Labor Operations and Customer Enthusiasm

Released 7/22/2011
Enhancing Field Product Reports with Digital Pictures

Released 6/17/2011
Improperly Formatted SI Screen Characters

Released 6/9/2011
Warranty Administration-Revised Customer Concern Not Duplicated (CCND)/Verified Labor Operation Numbers/How to Submit CCND Transactions in GWM / Elimination of E9995, J9993, J9994 and J9995

Released 5/23/2011
Global Warranty Management (GWM) Warranty Parts Center (WPC) Parts Return Program Information

Released 5/19/2011
IPC Odometer Programming Method Quick Reference Guide

Released 5/9/2011
Information for Dealers on How to Submit a Product Information Report (PIR) (Canada Only)

Released 5/5/2011
Change in Product Field Action Customer Reimbursement Procedure (U.S. Dealers Only)

Released 4/18/2011
Warranty Administration - Courtesy Transportation and Roadside Assistance Programs

Released 4/18/2011
New Tool Availability - EN-48974 - EGR Cooler Pressure Tester Adapter Set to Diagnose Duramax Diesel Engine EGR Cooler Engine Coolant Leaks into Combustion Chamber

Released 4/13/2011
Warranty Parts Center (WPC) Special Part Request Enhancement - New Expedited Overnight Shipping Process and Form Information

Released 4/7/2011
Expediting Warranty Parts

Released 3/2/2011
Automatic Transmission Oil Cooler Flush and Flow Test Essential Tool J-45096 TransFlow

Released 2/3/2011
Expanded Customer Concern Not Duplicated (CCND)/Verified Labor Operation Numbers/How to Submit CCND Transactions in Global Warranty Management

Released 11/19/2010
Application of Anti-Corrosion Materials

Released 10/18/2010
Warranty Code Generated by El-50313/Charger Required for N0110, Battery Parts Rest

Released 10/13/2010
General Motors Dealership Critical Equipment Requirements and Recommendations

Released 9/2/2010
Engineering Information (EI) Process

Released 8/6/2010
Information on Drilling High Strength Steel Related to Collision Repair

Released 7/30/2010
Electronic Exchange Program Changes

Released 7/1/2010
Out-of-Warranty Parts for Engineering Analysis

Released 6/30/2010
Squeeze Type Resistance Spot Welding/Equipment

Released 6/17/2010
Free Agent Best Practices for HUMMER, Pontiac, Saab and Saturn Customers or Those Affected by Dealership Consolidation (U.S. Only) (SB10168)

Released 6/9/2010
Warranty Admin - Expanded Customer Concern Not Duplicated (CCND)/Verified Labor Operation Numbers/How to Submit CCND Transactions in Global Warranty Management

Released 5/28/2010
Expediting Warranty Parts

Released 5/27/2010
Key Code Security Rules and Information on GM KeyCode Look-Up Application (Canada Only)

Released 5/26/2010
Warranty Admin - Warranty Claims Submission-Importance of GM Part Numbers and Parts with Date Codes

Released 5/24/2010
Technical Assistance Center (TAC) Coverage Available for Current and Last Nine Model Year Vehicles (U.S. Only)

Released 5/21/2010
Improperly Formatted SI Screen Characters

Released 5/20/2010
Global Warranty Management (GWM) Warranty Parts Center (WPC) Parts Return Program Information

Released 5/20/2010
Warranty Administration - Courtesy Transportation and Roadside Assistance Programs

Released 5/19/2010
Warranty Administration - Labor Operation Z1111 - Suspected Tampering or Vehicle Modifications

Released 5/18/2010
Information for Dealers on How to Submit a Field Product Report (FPR) (U.S. Dealers Only)

Released 5/17/2010
Information for Dealers on How to Submit a Product Information Report (PIR) (Canada Only)

Released 5/4/2010
Information on Tire Radial Force Variation (RFV)

Released 5/4/2010
Enhancing Field Product Reports with Digital Pictures

Released 4/29/2010
Unnecessary Flushing Services, Additive Recommendations and Proper Utilization of GM Simplified Maintenance Schedule to Enhance Customer Service Experience

Released 4/26/2010
Required Return Criteria of Complete Electrical Center (EC) and Body Control Module (BCM) with Integrated Electrical Center to Warranty Parts Center (WPC)

Released 3/29/2010
Revised General Motors New Vehicle Tire Warranty Program and Global Warranty Management (GWM) Submission Rollout Information (U.S. Dealers Only)

Released 3/5/2010
Information for Electrical Ground Repair-Use New Replacement Fasteners with Conductive Finish

Released 2/15/2010
Warranty, SPS, Control Module Diagnostics and Configuration Information, Programming, Set-Up

Released 2/4/2010
Car and Truck Fix It Right the First Time Issues

Released 1/21/2010
Diagnostic Information to Accurately Diagnose A/C Low Pressure Switch Using Kent Moore Special Tool GE-47742

Released 12/18/2009
New Tool Availability - EN-48974-EGR Cooler Pressure Tester Adapter Set to Diagnose Duramax Diesel Engine EGR Cooler Engine Coolant Leaks into Combustion Chamber

Released 12/11/2009
Unnecessary Engine Crankcase and Subsystems Flushing Services, Additive Recommendations and Proper Utilization of GM Simplified Maintenance Schedule to Enhance Customer Service Experience

Released 11/13/2009
Light and Medium Duty Truck Warranty, Crossline Warranty Eligibility and Guidelines for Chevrolet/GMC Dealers

Released 11/11/2009
New Labor Operation Codes for Dealer-Installed GM Accessories Replaced During Warranty Coverage Period

Released 9/24/2009
Discontinuation of Printed GM VIN Cards

Released 9/11/2009
GM Training - September 2009 New Course Information (For U.S. Dealers and Aftermarket)

Released 8/13/2009
Information on Paint Stain Under Protective Shipping Film

Released 8/10/2009
GM Training - August 2009 New Course Information (For U.S. Dealers and Aftermarket)

Released 7/22/2009
GM Training - July 2009 New Course Information (For U.S. Dealers and Aftermarket)

Released 7/16/2009
Technical Assistance Center (TAC) Coverage Available for Current and Last Nine Model Year Vehicles (U.S. Only)

Released 6/16/2009
Information Required Before Contacting GM Technical Assistance or When Ordering Replacement OnStar VCIM

Released 6/15/2009
GM Training - June 2009 New Course Information (For U.S. Dealers and Aftermarket)

Released 6/15/2009
Engineering Information (EI) Process

Released 5/18/2009
Interior Cleaning-Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl. Fabric Cleaner, Stain Remover, Restorer - Product Availability

Released 5/11/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 5/7/2009
GM Training - May 2009 New Course Information (For U.S. Dealers and Aftermarket)

Released 4/20/2009
GM Training - April 2009 New Course Information (For U.S. Dealers and Aftermarket)

Released 4/2/2009
Warranty Administration - GM Dealer Empowerment Program and Goodwill Procedures

Released 4/1/2009
Warranty Administration - Policies for Used Vehicles Purchased Through GM-Sponsored Auctions (SB 09074)

Released 3/31/2009
Warranty Administration - Labor Operation Z1111 - Suspected Tampering or Vehicle Modifications

Released 3/23/2009
Enhancing Field Product Reports with Digital Pictures

Released 3/12/2009
08-08-51-002: New Primer For TPO Fascias and Affected Cleaning Process of Painting Operation - (Mar 12, 2008)

Released 2/3/2009
Hem Flange Rust Repair

Released 12/10/2008
General Motors Dealership Critical Equipment Requirements and Recommendations

Released 10/30/2008
Procedure to Take Snapshot Data with a Tech 2 and Upload Data to Computer Using TIS Software

Released 10/29/2008
Reducing Electrical Intermittents-Recrimping Electrical Connectors and Inspection of Related Wiring Harness Connections When Diagnosing Misc. DTCs, Intermittent Driveability Concerns, Hard/No

Released 10/16/2008
08-00-89-037: CSO Surcharges Not Allowed on Warranty Claims - (Oct 16, 2008)

Released 10/6/2008
08-00-89-036: GM Training - GM STC Training Location Changes (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-033: GM Training - October 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-034: GM Training - Accessing Hands-On Checklists (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 6/24/2008
03-00-89-003A: GM Goodwrench Limited Lifetime Service Guarantee - (Jun 24, 2008)

Released 4/21/2008
08-00-89-015: GM Training: April 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Apr 21, 2008)

Released 3/27/2008
08-06-01-008: Diagnosing Accessory Drive Belt/Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt - (Mar 27, 2008)

Released 2/22/2008
02-07-30-052E: Automatic Transmission Oil Cooler Flush and Flow Test Essential Tool J 45096 TransFlow - (Feb 22, 2008)

Released 1/25/2008
08-01-38-001: Information on New GE-48800 CoolTech Refrigerant Recovery/Recharge Equipment - (Jan 25, 2008)

Released 1/18/2008
04-08-44-005C: Utilizing Tech 2 to Retrieve Part Numbers for Radios, Compact Disc (CD) Changers and Instrument Panel Clusters (IPC) - (Jan 18, 2008)

Released 1/10/2008
08-06-04-003: New Tool Availability - EN-48974 - EGR Cooler Pressure Tester Adapter Set to Diagnose Duramax Diesel Engine EGR Cooler Leaks into Combustion Chamber - (Jan 10, 2008)

Released 10/2/2007
05-06-01-019F: Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal Using Revised Rear Main Seal Installer and Remover Tools) - (Oct 2, 2007)

Released 8/17/2007
07-00-89-039: GM Training: August 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Aug 17, 2007)

Released 6/27/2007
07-01-38-004: Information on GM ACR2000 (J-43600) and New Refrigerant Recovery Recharging Equipment SAE J2788 - (Jun 27, 2007)

Released 6/26/2007
07-00-89-025: GM Training: April 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Jun 26, 2007)

Released 4/23/2007
05-08-51-008B: Bumps or Rust Colored Spots in Paint Due to Rail or Iron Dust (Remove Rail Dust) - (Apr 23, 2007)

Released 2/17/2006
06-08-45-001: Information on Changes to the SI Table of Contents, Electrical Connectors, Terminal Testing/Repair and the Importance of J-38125 Terminal Repair Kit Maintenance - (Feb 17, 2006)

Released 11/21/2005
99-08-51-001A: Info - Paint-less Dent Repair Process - (Nov 21, 2005)

Released 11/2/2005
05-00-89-075: Warranty Admin. - Servicing Medium Duty Trucks, Including Conventional and Crew Cabs, Motorhome Cutaway Cab, Commercial Cutaway Cab (Ambulance, School Bus, Shuttle Bus), and Tilt Cabs - (Nov 2, 2005)

Released 10/21/2005
05-06-04-067: Information on New Essential Tool EN-47909 Injector Bore Cleaning Kit for 6.6L Duramax Diesel Engine (RPOs LB7, LBZ, LLY) - (Oct 21, 2005)

Released 6/8/2005
05-05-22-001: Info - On-Car Brake Lathe Specifications and Maintenance Requirements - (Jun 8, 2005)

Released 9/14/2010
Car and Truck Fix It Right the First Time Issues

Released 4/28/2010
New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores

Released 5/11/2009
Warranty Administration - Customer Concern Not Duplicated/Verified Labor Operations

Released 1/8/2009
Preventing Damage on Dealer Lots During Longer Periods in Dealer Inventory and Maintaining High CSI Scores

Released 10/6/2008
08-00-89-036: GM Training - GM STC Training Location Changes (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-033: GM Training - October 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 10/6/2008
08-00-89-034: GM Training - Accessing Hands-On Checklists (For U.S. Dealers and Aftermarket) - (Oct 6, 2008)

Released 6/27/2008
07-00-89-047B: Technical Assistance Center (TAC) Coverage Available for Current and Last Nine Model Year Vehicles (U.S. Only) - (Jun 27, 2008)

Released 6/24/2008
03-00-89-003A: GM Goodwrench Limited Lifetime Service Guarantee - (Jun 24, 2008)

Released 4/21/2008
08-00-89-015: GM Training: April 2008 New Course Information (For U.S. Dealers and Aftermarket) - (Apr 21, 2008)

Released 8/27/2007
03-08-61-002I: Snap/Popping Type Noise Coming From Front of Vehicle (Remove Bolt-In Front Crossmember and Add Washers) - (Aug 27, 2007)

Released 8/17/2007
07-00-89-039: GM Training: August 2007 New Course Information (For U.S. Dealers and Aftermarket) - (Aug 17, 2007)

Released 6/8/2007
06-08-43-003A: Windshield Wiper Performance, Cleaning Instructions and Maintenance - (Jun 8, 2007)

Released 9/22/2006
03-00-89-006D: Info - New Vehicle Pre-Delivery Inspection (PDI) - Delivering Quality Vehicles and Generating Higher CSi Scores - (Sep 22, 2006)

Released 11/2/2005
05-00-89-075: Warranty Admin. - Servicing Medium Duty Trucks, Including Conventional and Crew Cabs, Motorhome Cutaway Cab, Commercial Cutaway Cab (Ambulance, School Bus, Shuttle Bus), and Tilt Cabs - (Nov 2, 2005)